Terramite T5D Guide

WWW.TERRAMITE.COM
Charleston, WV/USA
USA 1.800.428.3772
Intl. 1 .304.776.4231
Read Operators Manual For SafetyPARTS MANUAL
Copyright ©2007 Terramite Corporation

WWW.TERRAMITE.COM
Charleston, WV/USA
USA 1.800.428.3772
Intl. 1 .304.776.4231
Read Operators Manual For Safety PARTS MANUAL
Copyright ©2007 Terramite Corporation
Table of Contents
SECTION ONE: INTRODUCTION/INFORMATION
History of Terramite Backhoes .................................................................................. 1.1
Before You Start ......................................................................................................... 1.2
Safety Tips .................................................................................................................. 1.2
Hand Signals .............................................................................................................. 1.3
Call First ..................................................................................................................... 1.4
SECTION TWO: PARTS
Left or Right is Determined from the Operator’s Position ...................................... 2.1
View of Front Loader Bucket .................................................................................... 2.2
View of Right Side of Loader Bucket ....................................................................... 2.3
View of Underside of Arm Center .............................................................................. 2.4
View of Right Side of Arm Assembly ...................................................................... 2.5
View of FrontAxle (Bumper Not Shown) ................................................................................. 2.6
View of Front Axle (continued) ................................................................................................ 2.7
View of Front Axle - Ball Socket Style (Bumper Not Shown) ............................................ 2.8
View of Hub Assembly and Spindle ......................................................................... 2.9
View of Right Front Tire and Rim .......................................................................... 2.10
View of Right Side of Tractor ................................................................................. 2.11
View of Left Side of Tractor .................................................................................... 2.12
View form Right Side of Diesel Engine Compartment (Without Air Filter) ................ 2.13
View of Diesel Air Filter Assembly ........................................................................ 2.14
View of Muffler Assembly - Diesel ......................................................................... 2.15
View Left Side of Kubota Engine ............................................................................ 2.16
View Right Side of Kohler Engine ......................................................................... 2.17
View of Kohler Engine Leftside .............................................................................. 2.18
View of Power Steering Gear ................................................................................... 2.19
View of Front Valve w/Fittings .............................................................................. 2.20
View of Loader Valve Assembly and Battery - Perkins ......................................... 2.21
View of Front Valve Linkage System .................................................................... 2.22
View of Left Side of Diesel Dash Wiring Harness - Perkins ................................. 2.23
View of Right Side of Diesel Dash Wiring Harness -Perkins ............................... 2.24
View of Operator Position Facing Dash (Diesel) ................................................... 2.25
View of Operator Position Facing Dash (Gas) ....................................................... 2.26
View of Transmission Assembly (Diesel) .............................................................. 2.27
View of Transmission Assembly (Gas) .................................................................. 2.28
View from Right of Foot Pedal Control ................................................................. 2.29
View from Right Side of Hydraulic Tank ............................................................... 2.30
View from Left Side of Fuel Tank ........................................................................... 2.31
View of Hydraulic Filter Assembly ........................................................................ 2.32
View from Back of Seat ........................................................................................... 2.33
View from Operator Position of Rear Valve (Straight Boom) ......................................... 2.34
View from Operator Position of Rear Valve (Straight Boom) ......................................... 2.35
View from Operator Position of Rear Valve (Prior to 1-1-01) ......................................... 2.36
View from Operator Position of Rear Valve (Curved Boom Prior to 1-1-01) ................... 2.37
View from Operator Position of BackhoeValve (Curved Boom Prior to 1-1-01) ............................ 2.38
View from Operator Position of Rear Valve (Prior to 1-1-01) ..................................... 2.39
View from Operator Position of Rear Valve (180 Swing) ............................................... 2.40
View of Fitting Location for Rear Valve (180 Swing) ..................................................... 2.41
View of Hose Location for Rear Valve (180 Swing) ......................................................... 2.42
View of Right Rear Tire and Rim ............................................................................ 2.43
View from Front of Rear Axle ................................................................................. 2.44
Top View of Parking Brake Assembly .................................................................... 2.45
View from Left Side of Outrigger Assembly (Curved Boom) ........................................ 2.46
View from Left Side of Swing Assembly (Curved Boom Prior to 1-1-01) ........................ 2.47
View of Backhoe Assembly for T5D with Straight Boom .................................... 2.48
View from Right Side of Swing Assembly (Straight Boom) .......................................... 2.49
View of Left Side of Backhoe Assembly (Prior to 1-1-01) ............................................... 2.50
View of Left Side of Rear Bucket & Linkage Assembly ....................................... 2.51
T7 Backhoe Assembly 180 Degree ......................................................................... 2.52
T7 Backhoe Assembly 180 Degree (continued) ................................................................ 2.53
Tooth Caps ................................................................................................................ 2.54
Position to Check Proper Lever in Hydraulic Tank ............................................... 2.55
CONTENTS
SECTION THREE: DECALS
Decal Location - Front Arms ....................................................................................... 3.1
Decal Location - Side View ......................................................................................... 3.2
Decal Location - Dash .................................................................................................. 3.3
Decal Location - Dash (continued) ............................................................................................ 3.4
Decal Location - Right Fender .................................................................................... 3.5
Decal Location - Left Fender ....................................................................................... 3.6
Decal Location - Side View (continued) .................................................................................. 3.7
Decal Location - Rear Valve ........................................................................................ 3.8
Decal Location - Rear Valve (continued) .................................................................................. 3.9
SECTION FOUR: COMPONENTS
T5D/T7 Pin Chart (Straight Boom) ............................................................................................. 4.1
T5D/T7 Pin Chart (Straight Boom) ............................................................................................. 4.2
T7 Pin Chart (Curved Boom Prior 1-1-01) ........................................................................... 4.3
T7 Pin Chart (Curved Boom Prior 1-1-01) .................................................................................... 4.4
T7 Pin Chart (180 Degree Boom) ................................................................................................. 4.5
T7 Pin Chart (180 Degree Boom) ................................................................................................. 4.6
Wiring Diagram Kohler Command 20HP/25HP ....................................................... 4.7
Wiring Diagram Perkins Diesel 20HP ....................................................................... 4.8
Wiring Diagram Perkins Terminals ............................................................................ 4.9
Wiring Diagram for Perkins Diesel Dash Harness .................................................. 4.10
Wiring Diagram for Perkins Diesel Dash Harness (continued) ...................................... 4.11
Wiring Diagram for Perkins Diesel Dash Harness (continued) ...................................... 4.12
Wiring Diagram for Perkins Diesel Dash Harness (continued) ...................................... 4.13
Wiring Diagram Kubota ........................................................................................... 4.14
Wiring Diagram Kubota (continued) ..................................................................................... 4.15
Glow Plug Timer Relay ............................................................................................ 4.16
Hose and Fitting Location for V10 Valve (180 Degree Swing) .......................................... 4.17
View from Operator's Position for V10 Valve (180 Degree Swing) .................................. 4.18
Valve Section Service Kits V10 ............................................................................... 4.19
Valve Section Kits V10 (continued) ....................................................................................... 4.20
Valve Section Kits V10 (continued) ....................................................................................... 4.21
Valve Section Kits V10 (continued) ....................................................................................... 4.22
Valve Section Service Kits V10 (continued) ........................................................................ 4.23
Valve Section Service Kits V10 (continued) ........................................................................ 4.24
Hydrastatic Transmission ......................................................................................... 4.25
Hydrastatic Transmission (continued) .................................................................................. 4.26
Sunstrand Transmission ........................................................................................... 4.27
Sunstrand Transmission (continued) ..................................................................................... 4.28
Gear Pump Part Number 66000 Gas / 66001 Diesel ............................................... 4.29
MAB/MAE Torquemotor Exploded Assembly View ............................................ 4.30
Rear Axle Assembly .................................................................................................. 4.31
Rear Axle Assembly (continued) ............................................................................................. 4.32
Schematic View of Typical Control Valve Assembly - V20 .................................. 4.33
General Tightening Toque for Bolts, Nuts and Taperlock Studs - V20 ................. 4.34
4 Way, 3 Position Valve Section - V20 .................................................................... 4.35
Load Check Plug Assembly - V20 ........................................................................... 4.36
Model J-HP High Pressure Relief - V20 ................................................................. 4.37
SPK Monoblock Valve ............................................................................................. 4.38
Cylinder Components .............................................................................................. 4.39
T7 Loader Hydraulic Circuit Hose Lengths (in.) ............................................................. 4.40
T7 Rear Boom Hose Diagram V10 .......................................................................... 4.41
T7/T9 Sunstrand Diesel Hose Diagram with Oil Cooler ....................................... 4.42
SECTION FIVE: OPTIONS
Quick Attach Backhoe Buckets ................................................................................... 5.1
View of Clam Shell 4 in 1 Bucket (Factory Installed Option) .................................................. 5.2
View of Clam Shell 4 in 1 Bucket from Drivers Position (Factory Installed Option) .......................... 5.3
View Under the Dash for Clam Shell 4 in 1 Bucket (Only as Factory Installed Option) ......................... 5.4
SECTION SIX: TRANSLATIONS
Translations ....................................................................................................... 6.1 to 6.6
SECTION SEVEN: INDEX
Index .................................................................................................................. 7.1 to 7.5
Sample: Limited New Product Warranty ................................................................... 7.6

WWW.TERRAMITE.COM
Charleston, WV/USA
USA 1.800.428.3772
Intl. 1 .304.776.4231
Read Operators Manual For SafetyPARTS MANUAL
Copyright ©2007 Terramite Corporation
History of Terramite Backhoes
TERRAMITE was founded in 1965 by Kelly G. Cunningham. Mr. Cunningham realized that he could attach the digging
part of a tunneling machine he manufactured to the front of a tractor, producing a versatile piece of equipment with a
tremendous number of applications. He used the Gravely 7.6 tractor to power his patented backhoe, creating the Model 1,
the world’s first compact backhoe. During the years 1965 to 1972, the Model 1 was produced, and a new Model T-2 with an
endloader attachment was introduced.
In 1972, Mr. Cunningham purchased 19.5 acres in Cross Lanes, West Virginia and built the initial portion of the existing
plant. Terramite now has 56 acres with a plant four times as large. Constant improvement in safety, durability, strength, load
capacity and digging depth have resulted in the T-3, T3-15, T4, T5, T5B and T5C. In 1997 Terramite introduced the
Terramite T6, the largest and most powerful compact tractor loader backhoe ever. 1999 brought the addition of the Terramite
T5D. This newest member of the Terramite compact tractor loader backhoe family features center-mount steering, extended
reach arms, dual front curl cylinders, and much more.
1999 was also a year of new products for Terramite. The TX15 and TX25 Mini Excavators and the TSS36 and TSS38
Street Sweepers were introduced at the 1999 ARA Trade Show in Las Vegas early February.
June 2000 the Models T5D and T6 were renamed Models T7 and T9.
In addition to the Terramite backhoe lines, in 1985, Terramite created a concrete finishing product named the Roller
Screed. The Roller Screed is used for paving parking lots, entrance ramps, roads, sidewalks and airport runways.
1.1

WWW.TERRAMITE.COM
Charleston, WV/USA
USA 1.800.428.3772
Intl. 1 .304.776.4231
Read Operators Manual For Safety PARTS MANUAL
Copyright ©2007 Terramite Corporation
Safety Tips
Safety is a prime consideration in the design of this
machine. Guards, shields and other safety features are built
in wherever possible. However, accident reports show
carelessness causes the majority of accidents. You can avoid
most accidents by observing the safety rules on these pages.
Study these rules carefully and enforce them on the job:
Never allow minors to operate or be in the vicinity
of the machine while working.
Do not allow the T9 to be operated by anyone who
is intoxicated or on medication that would affect their
judgement or ability to operate the machine.
The machine is designed to be operated by adults
who are of average size and weight. Persons who are
extremely heavy, big or tall, or those who are exceedingly
short, light or weak should not run the machine.
Before Operating the Terramite T9
Read the Operator's Handbook. Never allow anyone
to operate the backhoe without reading the Operator's Manual
and Safety Instructions. This should be followed by
supervised training, if possible.
Check Your Equipment. Always make a complete
inspection of the machine before operating it that day. Check
the hydraulic system and the engine oil level. Then check
the machine for broken, missing or defective parts. Check
the tires for cuts, bulges, irregularities and abnormal wear
and proper inflation. Check the neutral position of the foot
pedal. A malfunctioning machine invites accidents.
Keep Your Machine Clean. Slippery surfaces are
hazardous. Remove oil, grease or mud from the operating
area of the tractor. Failure to keep these areas clean could
cause a serious accident.
Wear Whatever is Needed for Protection. Protect
yourself by wearing all the protective clothing and personal
safety devices issued to you or required by job conditions.
You may need a hard hat, safety shoes, safety glasses, heavy
gloves, hearing protection, reflective clothing, wet weather
gear and a respirator. Never take chances by wearing loose
clothing, watches or rings.
Look For Hazards. Walk around a new work area
and check for any hidden hazards, such as holes and hidden
abutments.
Read and Heed Safety Decals. Make sure the safety
and information decals can be easily read. To clean decals,
use soap and water only. Gasoline or solvents will destroy
the decals. If these decals are missing or illegible, call our
Parts/Service Department for replacements.
Roll-Over Protective Structure. All Terramite T9
tractor loader backhoes are equipped with a Roll-Over
Protective Structure. This is designed to protect the operator
in the event of a roll-over. If this machine has been rolled
over, the R.O.P.S. must be replaced. It is designed to be
used only once.
Driving Pivot Pins. When driving pivot pins in or
out, use care to guard against injury from particles that may
chip off the pin or object used in striking the pin. These
pins can fly out at high speed if they are not tapped lightly
just before they come out. Make sure there isn't anyone or
anything in the way, in case the pin flies out. Safety glasses
should be worn.
IMPORTANT! If this machine is used by the owner, an
employee, or is loaned or rented, make sure that the
following instructions are complied with:
1. The operator has read the Operation and the
Safety Rules sections of the Operator's
Handbook.
2. He has been given instructions on the safe
and correct use of the machine.
3. He has practiced operating the machine and
the use of all controls in a safe, clear area
before he operates the machine on a job site.
4. He has read all safety decals on the machine.
5. He has been informed to clear the area of
other persons and hidden hazards before
starting the machine.
Before You Start
READ OPERATOR'S HANDBOOK
Carefully read all WARNING! and DANGER! messages in handbook and be sure you understand their
meanings.
1.2

WWW.TERRAMITE.COM
Charleston, WV/USA
USA 1.800.428.3772
Intl. 1 .304.776.4231
Read Operators Manual For SafetyPARTS MANUAL
Copyright ©2007 Terramite Corporation
Hand Signals
Purpose and Scope
The purpose of the hand signals is to provide an easy means of communications in the interest of safety. These hand signals
are in general agreement with U.S. Army Field Manual, FM21-60, Section II, Standard Arm and Hand Signals. The standard
provides for hand signals to be used in agricultural operations especially when noise or distance precludes the use of normal
voice communications.
Fig. 1 - THIS FAR TO GO. Place palms at
ear level facing head, move laterally inward
to indicate remaining distance to go.
Fig. 2 - COME TO ME. Raise the arm
vertically overhead, palm to the front, and
rotate in large horizontal circles.
Fig. 3 - MOVE TOWARD ME. Beckon by
holding the arm horizontally to the front,
palm up, and motioning toward the body.
Fig. 4 - MOVE OUT - TAKE OFF. Face the
desired direction of movement; hold the arm
extended to the rear; then swing it overhead
and forward in the direction of desired
movement until it is horizontal, palm down.
Fig. 5 - STOP. Raise hand upward to the
full extent of the arm, palm to the front.
Hold that position until the signal is
understood.
Fig. 6 - SPEED IT UP - INCREASE SPEED.
Raise the hand to the shoulder, fist closed;
thrust the fist upward to the full extent of
the arm and back to the shoulder rapidly
several times.
Fig. 7 - SLOW IT DOWN - DECREASE
SPEED. Extend the arm horizontally
sideward, palm down, and wave arm
downward 45 deg. minimum several times,
keeping the arm straight. Do not move arm
above horizontal.
Fig. 8 - START THE ENGINE. Simulate
cranking the vehicle by moving arm in a
circular motion at waist level.
Fig. 9 - STOP THE ENGINE. Draw right
hand palm down, across the neck in a
"throat cutting" motion from left to right.
Fig. 10 - LOWER EQUIPMENT. Make
circular motion with either hand pointing
to the ground.
Fig. 11 - RAISE EQUIPMENT. Make circular
motion with either hand at head level.
1.3

WWW.TERRAMITE.COM
Charleston, WV/USA
USA 1.800.428.3772
Intl. 1 .304.776.4231
Read Operators Manual For Safety PARTS MANUAL
Copyright ©2007 Terramite Corporation
CALL FIRST
Call Your One-Call System First
Before you start any digging project, don't forget to call the
local One-Call System in your area. If you don't call, you
may have an accident or suffer injuries, cause interruption
of services, damage the environment or experience job
delays. The One-Call System will notify participating utility
companies of your proposed digging activities.
If you don't know the number for the local One-Call in
your area, dial the national One-Call referral number
toll free, 1-888-258-0808 for this information.
Utilities will then mark their underground facilities by using
the following international marking codes:
Red - Electric
Yellow - Gas, Oil or Petroleum
Orange - Communication, Telephone, TV
Blue - Potable Water
Green/Brown - Sewer
White - Proposed Excavation
Pink - Temporary Survey Markings
Always contact your local One-Call system
before starting your digging project.
One-Call Safety Labels & Placards Available From
Hazard Communication Systems, Inc. 800-748-0241
WARNING
1.4

WWW.TERRAMITE.COM
Charleston, WV/USA
USA 1.800.428.3772
Intl. 1 .304.776.4231
Read Operators Manual For SafetyPARTS MANUAL
Copyright ©2007 Terramite Corporation
Operator Position
for Endloader Use
Please Note: Left or Right is Determined from the Operator's Position
Operator Position for
Backhoe Operation
2.1

WWW.TERRAMITE.COM
Charleston, WV/USA
USA 1.800.428.3772
Intl. 1 .304.776.4231
Read Operators Manual For Safety PARTS MANUAL
Copyright ©2007 Terramite Corporation
ITEM PART NUMBER DESCRIPTION QTY.
1 18043 Assembly, ROPS, Front and Rear, T5C/T5D/T6/T7/T9 (Arm Strut Included) 1
2 77075 Light, Flood, Rectangle, T5B/T5C/T5D/T6/T7/T9 4
3 74047 Bulb, Halogen, T5C/T5D/T6/T7/T9 4
4 13357 Bucket, Loader, 56” Wide, T5D/T7 1
1 2 3 4
View of Front Loader Bucket
2.2

WWW.TERRAMITE.COM
Charleston, WV/USA
USA 1.800.428.3772
Intl. 1 .304.776.4231
Read Operators Manual For SafetyPARTS MANUAL
Copyright ©2007 Terramite Corporation
ITEM PART NUMBER DESCRIPTION QTY.
1 17176 Pin, 5 1/2”, Arm Link toArm Cylinder, T5D/T6/T7/T9 4
2 12037 Rod, Link, Loader Arm, T5D/T6/T7/T9 2
3 13200 Pin, 4 3/4”, Front Bucket to Arm, T5C/T5D/T6/T7/T9 4
4 13357 Bucket, Loader, 56” Wide, T5D/T7 1
5 13056 Edge, Cutting, 56” Loader, T5D/T7 1
612048 Arm Link Brace, Right, T5D/T6/T7/T9 2
12079 Arm Link Brace, Left, T5D/T6/T7/T9
7 17178 Pin, 5 1/2”, Arm Link to Arm, T5D/T6/T7/T9 2
View of Right Side of Loader Bucket
2 3 4
134
2
33
73
625
2.3

WWW.TERRAMITE.COM
Charleston, WV/USA
USA 1.800.428.3772
Intl. 1 .304.776.4231
Read Operators Manual For Safety PARTS MANUAL
Copyright ©2007 Terramite Corporation
ITEM PART NUMBER DESCRIPTION QTY.
1 80132 Hose, 3/8” x 70” 4
2 20063 Fitting, 3/8” MP x 3/8” 90 Swivel, Stubby, T5D/T6/T7/T9 2
3 20176 Fitting, 3/8” M x 3/8” FM, Swivel 8
4 80134 Hose, 3/8” x 28” 2
5 80133 Hose, 3/8” x 26” 2
6 88418 Hose, 1/4” x 18” 2
7 80055 Hose, 1/4” x 38” 2
8 20177 Fitting, 3/8” M x 1/4” F, Straight Swivel 4
9 22118 Fitting, 3/8” M 90 x 1/4” F, Swivel 2
10 22266 Fitting, 3/8” Tee, Weld-On 4
11 80131 Hose, 1/4” x 70” 2
12 12046 Plate 1
View of Underside of Arm Center
41 2 3 5
10
o
o
12
11 9867
2.4

WWW.TERRAMITE.COM
Charleston, WV/USA
USA 1.800.428.3772
Intl. 1 .304.776.4231
Read Operators Manual For SafetyPARTS MANUAL
Copyright ©2007 Terramite Corporation
ITEM PART NUMBER DESCRIPTION QTY.
1 12600 Pin, 5 1/4”, Arm Cylinder to Arm, T5C/T5D/T6/T7/T9 2
2 82074 Cylinder, Front Curl, Right, T5D/T6/T7/T9 1
3 82073 Rod, 22 1/4”, Front Curl, T5D/T6/T7/T9 2
4 82066 Cylinder, Front Curl, Left, T5D/T6/T7/T9 1
512074 Assembly, Arm, T5D (Includes Decals) 1
12075 Assembly, Arm, T7 (Includes Decals)
6 17179 Pin, 5 1/2”,Arm Bracket to Arm Cylinder, T5D/T6/T7/T9 2
7 12026 Cylinder, Arm Lift, T5C/T5D/T7 2
8 12301 Pin, 7 7/8”, Arm Cylinder Rod to Frame, T5B/T5C/T5D/T6/T7/T9 1
View of Right Side of Arm Assembly
2
5
3
6
7
3
8
3 4
1
2.5

WWW.TERRAMITE.COM
Charleston, WV/USA
USA 1.800.428.3772
Intl. 1 .304.776.4231
Read Operators Manual For Safety PARTS MANUAL
Copyright ©2007 Terramite Corporation
ITEM PART NUMBER DESCRIPTION QTY.
1 53091 Bearing, Thrust, F Spin, T5C/T5D/T6/T7/T9 2WD (not shown) 2
2 53212 Axle, Front, T5D/T7 (prior 1/1/01) 1
3 53107 Boss, Spindle Lock, T5D/T6/T9 2WD 2
4 28501 Screw, Set, 1/2”- 20 x 1/2” Plain 4
5 21428 Fitting, Grease 1/4” - 28 Straight 4
6 53050 Spindle, Front, Left, 9 5/8”, T5D/T7/T6/T9 2WD 1
7 53137 Hub, 5 on 4.5”, T5C/T5D/T6/T7/T9 2WD 2
8 53116 Spindle, Front, Right, 9 5/8”,T5D/T7/T6/T9 2WD 1
PIVOT PINS & BOLTS
9 15406 Pin, Front Axle Pivot, 11/4, T5C/T5D/T7 (prior 11/00) 1
10 53081 Nut, Hex, 1 1/4” - 12 Slotted Regular 2
11 15013 Bolt, 1/4” - 20 x 2 1/2” Gr8 Z 2
12 24008 Washer, 1/4” Flat USS 2
13 28504 Nut, 1/4” NC Lock Z 1
View of Front Axle (Bumper Not Shown) (Prior 1/1/01)
321 76
8
4 5
910 11
13
12
2.6

WWW.TERRAMITE.COM
Charleston, WV/USA
USA 1.800.428.3772
Intl. 1 .304.776.4231
Read Operators Manual For SafetyPARTS MANUAL
Copyright ©2007 Terramite Corporation
ITEM PART NUMBER DESCRIPTION QTY.
1 28503 Nut, Jam, 5/8” NF Z 3
2 53054 Tie Rod, T5C/T5D/T6/T7/T9 1
3 53043 Tie Rod End, w/Kit, T5C/T5D/T6/T7/T9 4
4 25803 Rod, Power Steering, T5C,T5D/T6/T7/T9 2WD 1
5 25815 Cylinder, Power Steering, T5C/T5D/T6/T7/T9 1
6 23174 Fitting, 1/4” M x 1/4”F 45° Degrees 2
7 53092 Assembly, Axle, Front, T5D/T7 (Completely Assembled) 1
8 53131 Update Kit for Axle (prior to 1/01/01) 1
9 53221 Tie Rod, Ball Socket After Ser# 2370201 1
View of Front Axle (continued)(prior 1/01/01)
321
6 5 4
7 Complete Assembly
8 Update Kit
2.7
9

WWW.TERRAMITE.COM
Charleston, WV/USA
USA 1.800.428.3772
Intl. 1 .304.776.4231
Read Operators Manual For Safety PARTS MANUAL
Copyright ©2007 Terramite Corporation
ITEM PART NUMBER DESCRIPTION QTY.
1 53201 Axle, Front, T7/T9 2W 1
2 81212 Cylinder, Power Steering, Ball Socket Style, T5C/T7/T9 2WD 1
3 24028 Pin, Clevis, 5/8x 2 1/4”1
4 53160 Pin, Cotter, 1/8x 1 3/4”1
5 25803 Rod, Power Steering, T5C/T5D/T6/T7/T9 2WD 1
6 15162 Assembly, Axle, Front, Ball Socket, T7/T9 2WD 1
1 2 3
45
View of Front Axle - Ball Socket Style (Bumper Not Shown)(After 1/1/01)
6 Complete Assembly
2.8

WWW.TERRAMITE.COM
Charleston, WV/USA
USA 1.800.428.3772
Intl. 1 .304.776.4231
Read Operators Manual For SafetyPARTS MANUAL
Copyright ©2007 Terramite Corporation
ITEM PART NUMBER DESCRIPTION QTY.
153116 Spindle, Front, Right, T5D/T7 T6/T9 2WD 1
53050 Spindle, Front, Left, T5D/T7 T6/T9 2WD
2 53111 Seal, Front, Hub, T5C/T5D/T6/T7/T9 1
3 53123 Bearing, Front, Inner, T5C/T5D/T6/T7/T9 1
4 53124 Race, 5 on 5.5, Front, Inner, T5C/T5D/T6/T7/T9 1
5 53137 Hub, 5 on 4.5, T5C/T5D/T6/T7/T9 1
6 53058 Race, Old Style, In & Out and New Style Outer, T5C/T5D/T6/T7/T9 1
7 53125 Bearing, Front, Outer, T5C 1
8 53140 Washer, 3/4”, SAE Z, Front Axle 1
9 53150 Nut, Castelated, 3/4”, Front Hub 1
10 53160 Pin, Cotter, 1/8x 13/4”1
11 53170 Cap, Dust, T3/T4/T5C/T5D/T6/T7/T9 1
12 28506 Nut, Lug, 1/2” - 20 ID x 13/16” OD, Front & Rear 5
13 53136 Assembly, Hub, 5 on 4.5 (Spindle Not Included) 1
14 53227 Bearing Kit w/no Hub 1
121110987654321
View of Hub Assembly and Spindle
13 Hub Assembly
2.9

WWW.TERRAMITE.COM
Charleston, WV/USA
USA 1.800.428.3772
Intl. 1 .304.776.4231
Read Operators Manual For Safety PARTS MANUAL
Copyright ©2007 Terramite Corporation
View of Right Front Tire and Rim
1 32
45
ITEM PART NUMBER DESCRIPTION QTY.
1 53170 Cap, Dust, T3/T5C/T5D/T6/T7/T9 1
2 28506 Nut, Lug, 1/2”- 20 ID x 13/16” OD, Front & Rear 5
3 51275 Tire, Front, 23” x 10.5” x 12”, T6/T7/T9 1
4 51273 Valve, Tire, Front 1
5 50017 Rim, Front, T5D/T6/T7/T9 1
6 51019 Assembly, Tire & Rim, Front, T6/T7/T9 1
6 Tire Assembly
2.10

WWW.TERRAMITE.COM
Charleston, WV/USA
USA 1.800.428.3772
Intl. 1 .304.776.4231
Read Operators Manual For SafetyPARTS MANUAL
Copyright ©2007 Terramite Corporation
ITEM PART NUMBER DESCRIPTION QTY.
1 15126 Hood, T5D/T7 1
2 80055 Hose, 1/4” x 38” 1
3 20174 Fitting, 1/4” MP x 1/4” FM Swivel 1
4 12301 Pin, 7 7/8”, Arm Cylinder, Rod to Frame, T5B/T5C/T5D/T6/T7/T9 1
5 80025 Wrap, Hose, 4” (Sold per Foot) 4
6 80132 Hose, 3/8x 70” 2
7 80131 Hose, 1/4” x 70” 2
8 12300 Pin, 6 7/8”, Arm to Frame, T5B/T5C/T5D/T6/T7/T9 1
View of Right Side of Tractor
1
2345678
2.11

WWW.TERRAMITE.COM
Charleston, WV/USA
USA 1.800.428.3772
Intl. 1 .304.776.4231
Read Operators Manual For Safety PARTS MANUAL
Copyright ©2007 Terramite Corporation
ITEM PART NUMBER DESCRIPTION QTY.
1 12056 Strut, Lift,Arm, Loader, T5C/T5D/T6/T7/T9 1
2 17200 Pin, Quick Release w/Ring Grip, T5C/T5D/T6/T7/T9 1
3 22109 Bolt, 1/2x 3 1/2” NC Gr8 Z 1
4 15542 Latch, Hood, T5D/T6/T7/T9 1
5 17198 Pin, 8 1/2”, Arm Lift Cylinder to Strut, T5C/T5D/T6/T7/T9 1
6 21003 Oil Filter 25HP Kubota 1
View of Left Side of Tractor
1 2
35 46
2.12

WWW.TERRAMITE.COM
Charleston, WV/USA
USA 1.800.428.3772
Intl. 1 .304.776.4231
Read Operators Manual For SafetyPARTS MANUAL
Copyright ©2007 Terramite Corporation
Right Side of Diesel Engine Compartment - Kubota (Without Air Filter)
ITEM PART NUMBER DESCRIPTION QTY.
1 15506 Filter, Fuel, 5/16”, T5C/T5D/T6/T7/T9 (not shown) 1
2 21003 Filter, Oil, 25hp., T5D/T6/T7/T9 1
3 43396 Filter, Fuel Element, 25 &32.5hp., T5D/T6/T7/T9 1
3
2.13

WWW.TERRAMITE.COM
Charleston, WV/USA
USA 1.800.428.3772
Intl. 1 .304.776.4231
Read Operators Manual For Safety PARTS MANUAL
Copyright ©2007 Terramite Corporation
ITEM PART NUMBER DESCRIPTION QTY.
1 41056 Kit, Air Cleaner Filter, 3 Cylinder, Kubota 1
2 41074 Filter, Air (Not Shown) 1
View of Diesel Air Filter Assembly
1
2.14