TL Elektronic Integra Efis TL-6560 Instruction sheet

Page 1
© Copyright 2013
TL elektronic
All Rights Reserved
Except as expressly provided elow, no part of this manual may e downloaded, transmitted, copied, reproduced, disseminated or stored
in any storage medium, for any purpose without the express prior written consent of the TL elektronic company. Address your questions a out
the technical information to TL elektronic. Other information a out sale, distri ution should e directed to our exclusive distri utors
(see World Distri utor list on our we site).
Producer’s address:
TL elektronic Inc.
Airport, Building 125,
503 41 Hradec Kralove, Czech Repu lic
Fax: [phone] E-mail: [email protected]
We Site Address: www.tl-elektronic.com
Please, send your e-mail address to [email protected] to receive the latest information a out software upgrade.
Send your ideas to [email protected]
We will evaluate your suggestion and provide an update.
Windows is registered trademark of Microsoft Corporation.
All trademarks and registered trademarks are acknowledged.
SchecK® is registered trademark of TL elektronic.
iFamily® is registered trademark of TL elektronic.
sModern® is registered trademark of TL elektronic.
All information in this User’s manual is su ject to change without prior notice.

Page 2
Introduction
Table of Contents
Table of Contents
TABLE OF CONTENTS........................................................................................................................................................................................................................................ 2
RECORD OF REVISION ...................................................................................................................................................................................................................................... 4
EFIS SETUP MENU............................................................................................................................................................................................................................................... 6
UNITS ......................................................................................................................................................................................................................................................................
EFIS CONFIGURATION & SENSORS............................................................................................................................................................................................................. 10
EFIS RANGE AND LIMITS ............................................................................................................................................................................................................................... 11
EFIS OTHER SETTINGS & CALIBRATION.................................................................................................................................................................................................. 15
A IRCRAFT IDENTIFICATION ................................................................................................................................................................................................................................. 15
T IME ................................................................................................................................................................................................................................................................... 16
D ATE ................................................................................................................................................................................................................................................................... 16
P ITCH S ETTING .................................................................................................................................................................................................................................................... 17
B ACKLIGHT C ONTROL ........................................................................................................................................................................................................................................ 17
AUX INPUT/OUTPUT...................................................................................................................................................................................................................................... 18
M AIN S WITCH C ONTROL ..................................................................................................................................................................................................................................... 18
EFIS EXTERNAL DEVICES.............................................................................................................................................................................................................................. 19
GPS .................................................................................................................................................................................................................................................................... 20
SL30 NAV COM ................................................................................................................................................................................................................................................... 20
R EMOTE COMPASS .............................................................................................................................................................................................................................................. 21
CO G UARDIAN .................................................................................................................................................................................................................................................... 22
EFIS DATA SHARING........................................................................................................................................................................................................................................ 23
LANGUAGE ......................................................................................................................................................................................................................................................... 24
DEMO MODE....................................................................................................................................................................................................................................................... 24
AUTOPILOT (OPTIONAL FUNCTION).......................................................................................................................................................................................................... 26
S ERVO S ETUP ...................................................................................................................................................................................................................................................... 28
S ERVO D EFLECTION C ALIBRATION ..................................................................................................................................................................................................................... 29

Page 3
Introduction
Table of Contents
E XTERNAL B UTTON ............................................................................................................................................................................................................................................ 30
R OLL A XIS S ETUP ............................................................................................................................................................................................................................................... 32
P ITCH A XIS S ETUP .............................................................................................................................................................................................................................................. 34
E NTER A CTIVATION /E NTER R EACTIVATION ....................................................................................................................................................................................................... 36

Page 4
Introduction
Record of Revision
Record of revision
Revision Revision Date Description ECO# Insertion date By
PrA 14.04.2013 Initial version Hovorka

Page 5
Introduction
Warnings, Cautions & Notes
V WARNING: If setup or cali ration data is inadvertently or improperly changed, there could e inaccurate readings that may lead to
improper operation of the aircraft or engine. This could result in engine damage and/or an emergency situation.
L CAUTION: Use the INTEGRA at your own risk. To reduce the risk of unsafe operation, carefully review and understand all aspects of
this Configuration Manual and the Flight Manual Supplement, and thoroughly practice asic operation prior to actual use.
When in actual use, carefully compare indications from the INTEGRA to all availa le navigation sources, including the
information from other NAVAIDS, visual sightings, charts, etc. For safety, always resolve any discrepancies efore
continuing navigation.
 NOTE: It is the pilot’s responsi ility for initial missed approach guidance in accordance with pu lished procedure. The unit may
not provide correct guidance until esta lished on a defined leg.
 NOTE: GPS level of service annunciations are not applica le to the external CDI (or HSI) when VLOC is active.
TL elektronic is fully committed to your satisfaction as a customer. If you have any questions regarding the INTEGRA, please contact our
customer service department.

Page 6
EFIS Setup Menu
Introduction
EFIS Setup Menu

Page 7
EFIS Setup Menu
Units
 NOTE: This manual assumes that you have read User Manual and you’ve mastered operation of the Integra.
In this menu you can set up many parameters mainly for flight settings.
Access to this menu:
Press the right-hand kno , select Enter Setup in menu. When prompt “Are you sure you want to enter to setup” appears, press “Yes”. There in
Setup mode switch screen to EFIS. Press the right-hand kno again, you should see Menu EFIS Setup now.
• Menu EFIS Setup
• Units
• Configuration & Sensors
• Range and Limits
• Other Settings & Calibration
• External Devices
• EFIS Data Sharing
• utopilot Setup
• Language
• Demo Mode
• Exit Menu

Page 8
EFIS Setup Menu
Units
UNITS
You can choose etween metric and imperial units or you can define your own unit settings.
• Menu UNITS
• Metric
• Imperial (UK)
• Imperial (US)
• Custom
Metric INTEGRA display units in metric system km/h m mBar km m/s
Imperial (UK) INTEGRA display units in metric and imperial system kts ft mBar nm ft/min
Imperial (US) INTEGRA display units in imperial system kts ft inHg nm ft/min
Custom you can choose individual units for each measure
• Menu Custom
• irspeed
• ltitude
• Baro pressure
• Distance
• VSI
You can choose etween metric and imperial units or you can define your own unit settings.
You can try changing some units. Take note EFIS screen is changed y how you modified values to metric or imperial.

Page 9
EFIS Setup Menu
Units
Availa le units for measured quantities
Quantities Selecta le units
Digital speed indicator km/h kts mph
Airspeed strip km/h kts mph
Baro pressure inHg mBar
Altitude strip feet metre
Digital altitude indicator feet metre
Vertical speed indicator ft/min kts m/s

Page 10
EFIS
Setup Menu
Configuration & Sensors
EFIS Configuration & Sensors
This menu contains settings for sensors of temperature.
• Menu Configuration & Sensors
• I T
• O T
• UXT
IAT Internal Air Temperature
OAT Outside Air Temperature
AUXT Auxiliary Temperature
After you choose option for setting(IAT, OAT or AUXT) from the menu, you’ll get list of availa le sensors. You can assign one of them to
selected temperature or disa le displaying of selected temperature y option Not Connected.

Page 11
EFIS Setup Menu
Range and imits
EFIS RANGE and LIMITS
In this menu you can set airspeed values
• Menu Range and Limits
• Airspeed
• Vne – never exceed
• Vno – maximum structural cruising
• Vfe – maximum flap extended
• Vs – stall speed
• Vso – minimum flight speed in landing configuration
 NOTE: The limits of one each Vne, Vno, Vfe,Vs or Vso can´t overlap each other. If you try decrease for example Vne and it is
impossi le so you need to decrease Vno at first and than you can set Vne to lower value.

Page 12
EFIS Setup Menu
Range and imits
Vne Never exceed speed.
Change the underlined y rotating the right-hand kno .
After you get required num er, just press the kno and the
underscore skips on to the next num er. Press “Set” to enter the
value. Press “Cancel” to skip previous menu.
Vno Maximum structural cruising speed or maximum speed for
normal operations.
Change the underlined y rotating the right-hand kno .
After you get required num er, just press the kno and the
underscore skips on to the next num er. Press “Set” to enter the
value. Press “Cancel” to skip previous menu.
Cancel
Set
P
osition
Cancel
Set
P
osition

Page 13
EFIS Setup Menu
Range and imits
Vfe Maximum flap extended speed.
Change the underlined y rotating the right-hand Kno .
After you get required num er, just press the kno and the
underscore skips on to the next num er. Press “Set” to enter the
value. Press “Cancel” to skip previous menu.
Vs Stall speed or minimum steady flight speed in which the aircraft is
still controlla le.
Change the underlined y rotating the right-hand kno .
After you get required num er, just press the kno and the
underscore skips on to the next num er. Press “Set” to enter the
value. Press “Cancel” to skip previous menu.
Cancel
Set
P
osition
Cancel
Set
P
osition
Cancel
Set
P
osition

Page 14
EFIS Setup Menu
Range and imits
Vso Minimum flight speed in landing configuration.
Change the underlined y rotating the right-hand kno .
After you get required num er, just press the kno and the
underscore skips on to the next num er. Press “Set” to enter the
value. Press “Cancel” to skip previous menu.
Cancel
Set
P
osition

Page 15
EFI
S Setup Menu
Other Setting & Calibration
EFIS OTHER SETTINGS & CALIBRATION
This menu allows you to modify settings and cali rations
• Menu OTHER SETTINGS & CALIBRATION
• ircraft Identification
• Time
• Date
• Pitch Setting
• Backlight control
• UX Input/Output
• Main Switch Control
Aircraft identification The Aircraft ID Box has Letters A-Z, num ers 0-
9 lanks and - sym ol. The ID can also e
shortened to fewer than 8 digits.
The underlined letter you can change just rotate
with the right-hand kno . If you get required
letter, just press the kno and the underscore will
skip on to the next letter. Then press “Set” to
enter the new value. Press “Cancel” to skip
previous menu.
Cancel
Set
P
osition

Page 16
EFI
S Setup Menu
Other Setting & Calibration
Time
You can set the time. The underlined num ers
you can change just rotate with the right-hand
kno . If you get required time, just press the
kno and the underscore will skip on to the next
num er. Then press “Set” to enter the new value.
Press “Cancel” to skip previous menu.

NOTE: It is necessary to set UTC (Zulu time) on the INTEGRA Clock.
Date You can set the date. The underlined num ers
you can change just rotate with the right-hand
kno . If you get required time, just press the kno
and the underscore will skip on to the next
num er. Then press “Set” to enter the date. Please
insert date in the form of DD/MM/YY or
day/month/year. Press “Cancel” to skip previous
menu.
Cancel
Set
P
osition
Cancel
Set
P
osition

Page 17
EFIS Setup Menu
Configuration & Sensors
Pitch Setting If the INTEGRA is not mounted at a right angle in relation to the pitch of the aircraft this function can e
used to compensate for this variation.
V WARNING: If you are unfamiliar with pitch cali ration please o tain qualified assistance. An incorrect cali ration of horizon may
result in death or serious injury.
Backlight Control This menu has 2 su menus – Dimmer Source Control and Button Color
• Dimmer Source Control
• Button Color
• Manual You can set rightness manually • Green You can set green acklighting
• External You can set external dimmer • Red You can set red acklighting
• Max 5V
• Max 12V
• Max 24V
• Orange
You can set orange acklighting
• Auto
You can set rightness automatically

Page 18
EFIS Setup Menu
Configuration & Sensors
• Menu Main Switch Control
• Not Connected
• Connected
AUX INPUT/OUTPUT This menu contains other external inputs and outputs.
In every menu you can choose if you want to NOT CONNECT or YES – HI or YES – LO.
CNPY Canopy status (open/close)
Gear UP Undercarriage is retracted
Gear DOWN Undercarriage is extended
These sensors can e only
NOT CONNECTED or
CONNECTED HI or LO
Main Switch Control If you have Integra connected via external main switch, set in this menu “CONNECTED”. So you can
power on or power off integra via main switch. If you have Integra connected directly to attery power,
choose “NOT CONNECTED” in this menu.

Page 19
EFIS Setup Menu
External Devices
EFIS EXTERNAL DEVICES
You can add any external device, such as GPS, SL30 nav com, Remote Compass and CO Guardian.
• Menu EXTERNAL DEVICES
• GPS
• SL30 nav com
• Remote compass
• CO Guardian
External devices
GPS: Port: COM1; Baud rate: 19200; Protocol: NMEA
S 30: Port: COM2
Remote compass: Connected
CO Guardian: Not connected