Tomberlin E-MERGE User manual
E-MERGE TM
OPERATOR’S MANUAL
Columbia ParCar Custom Carts, Inc.
OR AS A PTV AT 19 MPH.
This vehicle is not designed to be used in conjunction with child
Do not use or install child safety seat in any seat or position in
Always obey and follow laws and regulations regarding the
safety seat.
the vehicle.
transportation of children.
Children that require the use of a child safety seat in a regular type
automobile should not be transported in this vehicle.
FOREWARD
FOLLOW ALL BATTERY MANUFACTURE SAFETY ,
CARE AND MAINTENANCE GUIDENCE .
Page4 E-Merge Operator's Manual
CONTENTS
E-Merge Operator's Manual Page 5
PRECAUTIONS
Do not sit or ride
back here.
SAFETY REGULATIONS
A DANGER
A WARNING
A CAUTION
Page 6 E-Merge Operator's Manual
Inspect battery terminals, cables and batteries before each use.
Always wear a full face shield, rubber gloves and rubber apron when
working with or in close proximity to batteries.
charger and place the run/tow switch to the tow position before
Turn the ignition switch to the off position, remove the key, unplug the
inspecting or performing any type of service on the vehicle.
Connections should be tight and free of corrosion.
Utilize insulated tools only when working with electrical connections.
The tightness of the battery terminal nut should be between 95-105 inch
pounds of torque. Do not over tighten. Loose and/or over tightened
connections can cause battery failure, explosion and or fire.
Do Not Overfill the Batteries and keep batteries clean and free of
moisture.
If any high heat condition or burning smell is noticed immediately park
the vehicle in a safe location, place the ignition in the off position, move
yourself and passengers away quickly to a safe distance from the
vehicle and contact your dealer for assistance and repair. If fire or smoke
Any referance to Battery Care or maintenance is intended as general safety guidelines.
Always consult and follow the recommendations of your battery manufacturer if contrary
to those expressed herein. Never exceed your skill level by performing services you are
not trained to accomplish. When in doubt, Stop and call a professional.
is detected contact your local fire department immediately. Do not store
your vehicle inside if any of these conditions exist.
Only use recommended batteries of the correct size.
2. To carry out repair work:turn the run/tow switch to the middle position
(see Figure 1). Turn the vehicle off,remove the key and check tires.
Figure1,Run/Tow switch in middle position
AP PEAR ANCE OF THEE-MERGE CONTROLS
c
-------
Logo
' ---
cc
E-Merge Operator's Manual
Figure 2
Figure 3
wc
cc
c
c
c
Page 9
L
High /Low speed switch
Seat heated switch
Key switch
Figure 5
Page 10
OFF
Figure 6
E-Merge Operator's Manual
cover of steering stem.
two OFF/ON.
ON
The high/low speed switch is located on the
cover of steering stem
Figure 7
Low speed button
High speed button
High/low speed switch
configuration)
Figure �
8
Seat heated switch (According to the actual vehicle
(Please see figure )
7
The Switch is located on the third position from right side
of Dashboard.(Please see figure )
8
seat heated
OFF
Driver
Driver+Passenger
Direction Selector
Figure �
Headlight Switch
I
I
Figure
9
I
Figure 10
Emergency Switch
Figure Figure
Light switch of Inner Mirror
E-Merge Operator's Manual Page 11
�
12
13
right side
of steering stem.
13
14
12
11
Lock of Dash Pocket:
Figure Figure
Brake Pedal
Accelerator Pedal
Page 12
Figure
Figure 17
E-Merge Operator's Manual
16
15
14
15
When the light bar is at the top of indicator, the battery pack contains
a full charge.
When the battery discharge is down by 70%, the two remaining lights
will flicker as a warning.
miles or ilometers. To change the display simply press and hold the small
h
can be set by depressing the set buttons. This feature is especially useful
in measuring the distance between each charge cycle.
The reading of the speedometer can be programmed to read out in either
button on the left.
A CAUTION
PRE-OPERATING INSPECTION
Page 16 E-Merge Operator's Manual
the top speed of the E-merge is limited even while going
down an incline, The motor will engage to limit the top speed of the vehicle.
The motor acts as a generator, transferring some of the excess energy into
recharging the batteries.
Never drink and drive. Not only is drinking and driving un
Other manuals for E-MERGE
1
Table of contents
Other Tomberlin Utility Vehicle manuals
