Toyota AVENSIS 1999 Owner's manual

1999 TOYOTA MOTOR CORPORATION
All rights reserved. This book may not be repro-
duced or copied, in whole or in part, without the
written permission of Toyota Motor Corporation.
First Printing: Jun. 15, 1999 01–990615–00
FOREWORD
This supplement has been prepared to provide information covering general service repairs for the chassis
and body of the TOYOTA AVENSIS/CORONA which underwent changes in August, 1999.
Applicable models: AT220, 221 series
ST220 series
CT220 series
CDT220 series
Pub. No. ManualName Pub. No.
SAVENSIS/CORONA Chassis and Body Repair
Manual
RM599E S2C Engine Repair Manual Supplement RM297E
S4A–FE Engine Repair Manual RM296E S2C–T Engine Repair Manual Supplement RM494E
S7A–FE Engine Repair Manual RM325E S2C–T, 2C–TE Engine Repair Manual Supplement RM612E
S4A–FE Engine Repair Manual Supplement RM397E S1CD–FTV Engine Repair Manual RM697E
S7A–FE Engine Repair Manual Supplement RM435E SA241L, A241E Automatic Transaxle Repair Manual RM177E
S4A–FE, 7A–FE Engine Repair Manual Supplement RM611E SA245E Automatic Transaxle Repair Manual RM350E
S3S–FE Engine Repair Manual RM395E SAVENSIS/CORONA Electrical Wiring Diagram EWD330Y
S3S–FE Engine Repair Manual Supplement RM495E SAVENSIS/CORONA Electrical Wiring Diagram
Supplement
EWD373F
S3S–FE Engine Repair Manual Supplement RM609E SAVENSIS/CORONA New Car Features NCF145E
S1C, 2C, 2C–T Engine Repair Manual RM025E SAVENSIS/CORONA New Car Features Supplement NCF168E
All information in this manual is based on the latest product information at the time of publication. However,
specifications and procedures are subject to change without notice.
TOYOTA MOTOR CORPORATION
AZT220 series
ManualName
ZZT220, 221 series
For the service specifications and repair procedures of the above model other than those listed in this supple-
ment, refer to the following manuals.

CAUTION
This manual does not include all the necessary items about repair and service. This manual is made
for the purpose of the use for the persons who have special techniques and certifications. In the
cases that non–specialized or uncertified technicians perform repair or service only using this manu-
al or without proper equipment or tool, that may cause severe injury to you or other people around
and also cause damage to your customer’s vehicle.
In order to prevent dangerous operation and damages to your customer’s vehicle, be sure to follow
the instruction shown below.
SMust read this manual thoroughly. It is especially important to have good understanding all the
contents written in the PRECAUTION of ”IN” section.
SThe service method written in this manual is very effective to perform repair and service. When
performing the operations following the procedures using this manual, be sure to use tools spe-
cified and recommended. If using non–specified or recommended tools and service method,
be sure to confirm safety of the technicians and any possibility of causing personal injury or
damage to the customer’s vehicle before starting the operation.
SIf part replacement is necessary, must replace the part with the same part number or equivalent
part. Do not replace it with inferior quality.
SIt is important to note that this manual contains various ”Cautions” and ”Notices” that must be
carefully observed in order to reduce the risk of personal injury during service or repair, or the
possibility that improper service or repair may damage the vehicle or render it unsafe. It is also
important to understand that these ”Cautions” and ”Notices” are not exhaustive, because it is
important to warn of all the possible hazardous consequences that might result from failure to
follow these instructions.

INTRODUCTION
PREPARATION
SERVICE SPECIFICATIONS
DIAGNOSTICS
E251 MANUAL TRANSAXLE
SUSPENSION AND AXLE
BRAKE
STEERING
SUPPLEMENTAL RESTRAINT SYSTEM
BODY ELECTRICAL
BODY
AIR CONDITIONING
ALPHABETICAL INDEX

INTRODUCTION
HOW TO USE THIS MANUAL IN–1. . . . . . . . . . . . .
GENERAL INFORMATION IN–1. . . . . . . . . . . . . . . . . .
IDENTIFICATION INFORMATION IN–3. . . . . . . . . .
VEHICLE IDENTIFICATION AND ENGINE SERIAL
NUMBER IN–3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
REPAIR INSTRUCTIONS IN–4. . . . . . . . . . . . . . . . .
GENERAL INFORMATION IN–4. . . . . . . . . . . . . . . . . .
VEHICLE LIFT AND SUPPORT LOCATIONS IN–7. .
FOR ALL OF VEHICLES IN–9. . . . . . . . . . . . . . . . . .
PRECAUTION IN–9. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
HOW TO TROUBLESHOOT ECU CONTROLLED
SYSTEMS IN–18. . . . . . . . . . . . . . . . . . . . . . . . . . . .
GENERAL INFORMATION IN–18. . . . . . . . . . . . . . . . . .
HOW TO PROCEED
WITH TROUBLESHOOTING IN–19. . . . . . . . . . . . . .
HOW TO USE THE DIAGNOSTIC CHART AND
INSPECTION PROCEDURE IN–29. . . . . . . . . . . . . . .
TERMS IN–34. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
ABBREVIATIONS USED IN THIS MANUAL IN–34. . . .