Trane XL16i Operation manual

Split System
Cooling
Product Data
XL16i
1½ – 5 Tons
PUB. NO. 22-1890-01

© 2013 Trane 2 22-1890-01
Features and
Benefits
• Climatuff®compressor
• Efciencyupto16.0SEERand
9.0HSPF
• AllaluminumSpine Fin™coil
• WeatherGuard™fasteners
• Quick-Sess™cabinet,serviceaccess
andrefrigerantconnectionswithfull
coilprotection
• DuraTuff™base,fastcompletedrain,
weatherproof
• Comfort “R”™modeapproved
• Glossycorrosionresistantnish
• Internalcompressorhigh/lowpressure
&temperatureprotection
• 018,024,030&060shipwithstartkit
• Compressorsumpheat
• Liquidlinelter-drier
• Tarpaulingraycabinetwith
anthracitegraybadgeandcap
• Highpressureswitch
• Demanddefrostcontrolwith
diagnostics
• Servicevalvecover
• R-410Arefrigerant
• S.E.E.T.designtesting
• 100%lineruntest
• Lowambientto30°FwithAY28X084
• Lowambientcoolingto55°Fas
shipped
• Extended warranties available

22-1890-01 3
Contents
Features and Benefits 2
General Data 4
ProductSpecications 4
A-weightedSoundPowerLevel[dB(A)] 4
AccessoryDescriptionandUsage 5
AHRIStandardCapacityRatingConditions 5
Model Nomenclature 6
Electrical Data 7
Dimensions 10
Mechanical Specification Options 11

 4 22-1890-01
General
Data
Product Specifications
Model No. 1 4TTX6018H1000A 4TTX6024H1000A 4TTX6030H1000A 4TTX6036H1000A
Electrical Data V/Ph/Hz 2 200/230/1/60 200/230/1/60 200/230/1/60 208/230/1/60
Min Cir Ampacity 8 11 15 22
Max Fuse Size (Amps) 15 20 25 35
Compressor CLIMATUFF®CLIMATUFF®CLIMATUFF®CLIMATUFF®- SCROLL
No. Used - No Stages 1-1 1-1 1-1 1-1
RL Amps - LR Amps 6.2 - 38.6 8.6 - 57.8 11.1 - 63 16.7 - 79
Outdoor Fan FL Amps 0.74 0.74 0.74 0.93
Fan HP 1/8 1/8 1/8 1/5
Fan Dia (inches) 27.6 27.6 27.6 26.6
Coil Spine Fin™ Spine Fin™ Spine Fin™ Spine Fin™
Refrigerant R-410A 6/09-LB/OZ 6/10-LB/OZ 6/10-LB/OZ 7/11-LB/OZ
Line Size - (in.) O.D. Gas 3 1/2 5/8 3/4 3/4
Line Size - (in.) O.D. Liquid 3 3/8 3/8 3/8 3/8
Dimensions H x W x D (Crated) 45.4 x 35.1 x 38.7 45.4 x 35.1 x 38.7 45.4 x 35.1 x 38.7 53.4 x 35.1 x 38.7
Weight - Shipping 271 275 276 283
Weight - Net 227 230 232 235
Start Components YES YES YES NO
Sound Enclosure YES YES YES YES
Compressor Sump Heat NO NO NO NO
Optional Accessories: 4
Anti-short Cycle Timer TAYASCT501A TAYASCT501A TAYASCT501A TAYASCT501A
Evaporator Defrost Control A/C AY28X079 AY28X079 AY28X079 AY28X079
Rubber Isolator Kit BAYISLT101 BAYISLT101 BAYISLT101 BAYISLT101
Crank Case Heater Kit BAYCCHT300 BAYCCHT300 BAYCCHT300 BAYCCHT301
Hard Start Kit Scroll BAYKSKT260
Extreme Condition Mounting Kit BAYECMT001 BAYECMT001 BAYECMT001 BAYECMT001
Snow Leg - Base & Cap 4" High BAYLEGS002 BAYLEGS002 BAYLEGS002 BAYLEGS002
Snow Leg - 4" Extension BAYLEGS003 BAYLEGS003 BAYLEGS003 BAYLEGS003
Seacoast Kit BAYSEAC001 BAYSEAC001 BAYSEAC001 BAYSEAC001
Refrigerant Lineset 5TAYREFLN850 TAYREFLN950 TAYREFLN7* TAYREFLN7*
1Certified in accordance with the Unitary Air-Conditioner equipment certification program which is based on AHRI Standard 210/240.
2Calculated in accordance with N.E.C. Only use HACR circuit breakers or fuses.
3Standard line lengths - 60'. Standard lift - 60' Suction and Liquid line.
For Greater lengths and lifts refer to refrigerant piping software Pub# 32-3312-0†. (†denotes latest revision)
4For accessory description and usage, see page 5.
5* = 15, 20, 25, 30, 40 and 50 foot lineset available.
Sound Power Level
Model A-Weighted Sound
Power Level [dB(A)]
Full Octave Sound Power [dB]
63 Hz 125 Hz 250 Hz 500 Hz 1000 Hz 2000 Hz 4000 Hz 8000 Hz
4TTX6018H1 73 77 74 74 71 65 65 58 53
4TTX6024H1 74 78 76 73 75 71 64 58 54
4TTX6030H1 73 81 79 73 71 67 65 59 55
4TTX6036H1 72 80 75 71 70 67 60 58 47
4TTX6042H1 73 78 72 66 70 69 64 59 49
4TTX6048H1 73 78 72 77 70 65 61 58 50
4TTX6049H1 72 70 70 65 64 62 56 49 42
4TTX6060H1 74 79 71 71 70 71 66 60 51
4TTX6061H1 73 68 70 67 68 64 56 53 48
Note:RatedinaccordancewithAHRIStandard270-2008

22-1890-01 5
General
Data
Product Specifications
Model No. 1 4TTX6042H1000A 4TTX6048H1000A 4TTX6049H1000A 4TTX6060H1000A 4TTX6061H1000A
Electrical Data V/Ph/Hz 2 208/230/1/60 208/230/1/60 208/230/1/60 208/230/1/60 230/1/60
Min Cir Ampacity 26 28 26 34 39
Max Fuse Size (Amps) 45 50 45 60 60
Compressor CLIMATUFF®- SCROLL CLIMATUFF®- SCROLL CLIMATUFF®- SCROLL CLIMATUFF®- SCROLL CLIMATUFF®- SCROLL
No. Used - No. Stages 1-1 1-1 1-1 1-1 1-2
RL Amps - LR Amps 19.9 - 109 21.8 - 117 19.9 - 109 26.4 - 134 28.8 - 152.9
Outdoor Fan FL Amps 0.93 0.93 1.00 0.93 2.8
Fan HP 1/5 1/5 1/5 1/5 1/3
Fan Dia (inches) 27.6 27.6 27.6 27.6 27.6
Coil Spine Fin™ Spine Fin™ Spine Fin™ Spine Fin™ Spine Fin™
Refrigerant R-410A 7/00-LB/OZ 11/00-LB/OZ 11/9-LB/OZ 11/00-LB/OZ 12/9-LB/OZ
Line Size - (in.) O.D. Gas 3 3/4 7/8 7/8 1-1/8 1-1/8
Line Size - (in.) O.D. Liquid 3 3/8 3/8 3/8 3/8 3/8
Dimensions H x W x D (Crated) 53.4 x 35.1 x 38.7 57.4 x 35.1 x 38.7 57.4 x 35.1 x 38.7 57.4 x 35.1 x 38.7 57.4 x 35.1 x 38.7
Weight - Shipping 305 352 324 354 332
Weight - Net 257 302 287 304 295
Start Components NO NO NO YES NO
Sound Enclosure YES YES NO YES NO
Compressor Sump Heat NO NO NO NO NO
Optional Accessories: 4
Anti-short Cycle Timer TAYASCT501A TAYASCT501A TAYASCT501A TAYASCT501A TAYASCT501A
Evaporator Defrost Control A/C AY28X079 AY28X079 AY28X079 AY28X079 AY28X079
Rubber Isolator Kit BAYISLT101 BAYISLT101 BAYISLT101 BAYISLT101 BAYISLT101
Crank Case Heater Scroll BAYCCHT301 BAYCCHT301 BAYCCHT301 BAYCCHT301 BAYCCHT301
Hard Start Kit Scroll BAYKSKT260 BAYKSKT260 BAYKSKT260
Extreme Condition Mounting Kit BAYECMT001 BAYECMT001 BAYECMT004 BAYECMT001 BAYECMT004
Snow Leg - Base & Cap 4" High BAYLEGS002 BAYLEGS002 BAYLEGS002 BAYLEGS002 BAYLEGS002
Snow Leg - 4" Extension BAYLEGS003 BAYLEGS003 BAYLEGS003 BAYLEGS003 BAYLEGS003
Seacoast Kit BAYSEAC001 BAYSEAC001 BAYSEAC001 BAYSEAC001 BAYSEAC001
Refrigerant Lineset 5 TAYREFLN7* TAYREFLN3* TAYREFLN3* TAYREFLN4* TAYREFLN*4
1Certified in accordance with the Air-Source Unitary Heat Pump Equipment certification program which is based on AHRI Standard 210/240.
2Calculated in accordance with N.E.C. Only use HACR circuit breakers or fuses.
3Standard line lengths - 60'. Standard lift - 60' Suction and Liquid line. For 061 units, Max. linear length 60 ft.; Max. lift - Suction 25 ft.; Max lift - Liquid 25 ft.
For Greater lengths and lifts refer to refrigerant piping software Pub# 32-3312-0†. (†denotes latest revision)
4For accessory description and usage, see page 5.
5* = 15, 20, 25, 30, 40 and 50 foot lineset available.

 6 22-1890-01
AHRI Standard Capacity Rating Conditions
AHRI STANDARD 210/240 RATING CONDITIONS —
(A) Cooling80°FDB,67°FWBairenteringindoorcoil,95°FDBair
enteringoutdoorcoil.
(B) HighTemperatureHeating47°FDB,43°FWBairenteringout-
doorcoil,70°FDBairenteringindoorcoil.
(C) LowTemperatureHeating17°FDB,15°FWBairenteringout-
doorcoil,70°FDBairenteringindoorcoil.
(D) Ratedindoorairowforheatingisthesameasforcooling.
AHRI STANDARD 270 RATING CONDITIONS —(Noiserating
numbersaredeterminedwiththeunitincoolingoperation.)Standard
NoiseRatingnumberisat95°Foutdoorair.
Accessory Description and Usage
Anti-Short Cycle Timer—Solidstatetimingdevicethatprevents
compressorrecyclinguntil5minuteshaveelapsedaftersatisfying
callorpowerinterruptions.Useinareawithquestionablepowerdeliv-
ery,commercialapplications,longlineset,etc.
Evaporator Defrost Control—SPSTTemperatureactuatedswitch
thatcyclesthecondenseroffasindoorcoilreachesfreeze-upcondi-
tions.Usedforlowambientcoolingto30°FwithTXV.
Rubber Isolators—5largerubberdonutstoisolatecondensingunit
fromtransmittingenergyintomountingframeorpad.Useonanyap-
plicationwheresoundtransmissionneedstobeminimized.
Hard Start kit—Startcapacitorandrelaytoassistcompressormo-
torstartup.Useinareaswithmarginalpowersupply,onlonglinesets,
lowambientconditions,etc.
Extreme Condition Mount Kit—Bracketkitstosecurelymount
condensingunittoaframeorpadwithoutremovinganypanels.Use
inareaswithhighwinds,oroncommercialrooftops,etc.
General
Data

22-1890-01 7
Model
Nomenclature
Refrigerant Type
2 = R-22
4 = R-410A
TRANE
Product Type
W = Split Heat Pump
T = Split Cooling
Product Family
Z = Leadership – Two Stage
X = Leadership
R = Replacement/Retail
B = Basic
A = Light Commercial
Family SEER
0 = 10 3 = 13 6 = 16
1 = 11 4 = 14 8 = 18
2 = 12 5 = 15 9 = 19
Split System Connections 1-6 Tons
0 = Brazed
Nominal Capacity in 000s of BTUs
Major Design Modifications
Power Supply
1 = 200-230/1/60 or 208-230/1/60
3 = 200-230/3/60
4 = 460/3/60
Secondary Function
Minor Design Modifications
Unit Parts Identifier
Outdoor Units
4T TX6036H1000AA
T U D 1 B 0 8 0 A 9 H 3 1 A A
Furnace Configuration
TU = Upflow/Horizontal
TD = Downflow/Horizontal
Type
E = 80% Induced Draft Standard
D = 80% Induced Draft Premium
C = 90% Condensing Standard
X = 90% Condensing Premium
H = 95% Condensing Premium
Number of Heating Stages
1 = Single Stage
2 = Two Stage
M= Modulating
Major Design Change
Minor Design Change
Service Digit - Not Orderable
Heating Input in 1000’s (BTUH)
080 = 80,000 BTUH
Cabinet Width
A = 14.5" Cabinet Width
B = 17.5" Cabinet Width
C = 21.0" Cabinet Width
D = 24.5" Cabinet Width
Air Capacity for Cooling
Standard PSC Variable Speed High Efficiency
24 = 2 To ns V3 = 3 To ns H3 = 3 To ns
36 = 3 To ns V4 = 4 To ns H4 = 4 To ns
42 = 3.5 To ns V5 = 5 To ns H5 = 5 To ns
45 = 4 To ns
48 = 4 To ns
54 = 5 To ns
60 = 5 To ns
72 = 6 To ns
Voltage
9 = 115 Volts / 60 Hertz / Natural Gas
A = 115 Volts / 50 Hertz / Natural Gas
C = 115 Volts / Natural Gas with Communicating System Control
F = 115 Volts / Natural Gas with Integrated Electronic Filter
D = 115 Volts / Natural Gas with Communicating System Control and
Integrated Electronic Filter
Draft Inducer Speeds
1 = Single Speed
2 = Tw o Speed
V = Variable Speed
Gas Furnaces
G A M 5 A 0 B 3 6 M 3 1 S A A
Brand
T = Better
G = Good
Product Type
A = Air Handler
Product Tier
2 = Good, Entry Level Feature Set
4 = Better, Retail Replacement Mid Effy.
5 = Better, Entry Level High Effy., Multi-Speed
7 = Best, Retail Replacement High Effy.,
Variable-Speed
8 = Best, Retail Ultimate High Effy.,
Variable-Speed
Major Design Change
Minor Design Change
Unit Parts Identifier
Airflow Type & Capability
S = Low Effy PSC, 1-5 - nom. Tonnage (cfm/ton)
M = Mid Effy Multi-Speed, 1-5 - nom. To nnage (cfm/ton)
H = High Effy Multi-Speed, 1-5 - nom. To nnage (cfm/ton)
V = High Effy Variable, 1-5 - nom. To nnage (cfm/ton)
No Descriptor
0 = Air Handler / Coil
System Control Type
S = Standard - 24 VAC
C = CLII 13.8 VDC
Size (Footprint)
A = 17.5 x 21.5
B = 21.0 x 21.5
C = 23.5 x 21.5
Cooling Size: Air Handler or Coil
0-9 = AH Coil - 1000 BTU’s (18, 24, 30, 36, 42, 48, 60)
Power Supply
1 = 208-230/1/60
Convertability
M= Multi-poise 4-way
F = Upflow Front Return, 3-way
T = 3-way
Air Handler
4 T X C B 0 3 6 A C 3 H C A A
Series
T = Premium (Heat Pump or Convertible Coil)
C = Standard (Cooling Only)
Refrigerant Type
4 = R-410A
Coil Design
X = Direct Expansion Evaporator Coil
Coil Feature
C = Cased A Coil
A = Uncased A Coil
F = Cased Horizontal Flat Coil
Coil Width (Cased/Uncased)
A = 14.5" /13.3"
B = 17.5" / 16.3"
C = 21.0" / 19.8"
D = 24.5" / 23.3"
H = 10.5"
Refrigerant Line Coupling
0 = Brazed
Nominal Capacity in 1000's (BTUH)
Major Design Change
Efficiency
C = Standard
S = Hi Efficiency (derived from 10 SEER products)
Refrigerant Control
3 = TXV - Non-Bleed
Coil Circuitry
H = Heat Pump
C = Cooling
Airflow Configuration
A = Upflow Only
U = Upflow / Downflow
H = Horizontal Only
C = Convertible - Upflow, Downflow, Left or Right Airflow
Minor Design Change
Service Digit - Not Orderable
Heat Pump/
Cooling Coils

© 2013 Trane 8 22-1890-01
4TTX6018H
Electrical
Data
Schematic Diagrams
(SEELEGEND)
PrintedfromD156722P01

22-1890-01 9
4TTX6024H
Electrical
Data
Schematic Diagrams
(SEELEGEND)
PrintedfromD156722P01

10 22-1890-01
4TTX6030H
Electrical
Data
Schematic Diagrams
(SEELEGEND)
PrintedfromD156722P01