Tsurumi Pump Aquascape Pro PL Series Instructions for use

1
www.graystonecreations.com
706-865-0220
Waterfall and vault
water pump
For Model:
• 3-PL (Item #29975)
• 5-PL (Item #29976)
• 9-PL (Item #29977)
INSTRUCTIONS & MAINTENANCE
PL Series
Solids Handling
Pond Pump
Made in Japan, by Tsurumi Mfg. Co. Ltd.

2
PL Series
Solids Handling Pond Pump
AQUASCAPE
Aquascape
1400
PLS i
Introduction
PLS
Submersible, Semi-Vortex, Water Feature Pump
This manual provides information and procedures to safely install, operate and maintain this TSURUMI model.
For your own safety and protection from injury, carefully read, understand and observe the safety instructions
described in this manual. THE INFORMATION CONTAINED IN THIS MANUAL WAS BASED ON MACHINES IN
PRODUCTION AT THE TIME OF PUBLICATION. TSURUMI RESERVES THE RIGHT TO CHANGE ANY
PORTION OF THIS INFORMATION WITHOUT NOTICE.
Nameplate
A nameplate listing the Model Number, Manufacture Date, and Serial Number is attached to each unit. Please record
the information found on this plate so it will be available should the nameplate become lost or damaged. When ordering
parts or requesting service information, you will always be asked to specify the model, manufacture date and
serial number of the unit.
Submersible
Pump
Distributed By:
TM
Model 3-PLS
Serial Number DOM Y/M
Performance Range
1700 gph. ~ 3000 gph.
Bore: 2” Input Watts: 357 Volts: 120
MADE IN JAPAN
AMP.: 3.1 PH.: 1 Hz.: 60 Pole: 2 Ins.: E
THERMALLY PROTECTED
INDOORS OR OUTDOORS
CSA ENCLOSURE 3
Conforms to UL Std.778
Certified to CAN/CSA Std.
C222 No. 108-M89
TSURUMI MANUFACTURING CO., LTD.
2001992
iSubmers ble
Pump
eDistribut d By:
TM
MADE I JAPANN
LTHERMAL Y PROTECTED
O R U RSINDO RS O O TDOO
C OCSA EN L SURE 3
o o m o dC nf r s t UL St .778
t tCertified o CAN/CSA S d.
MC222 No. 108- 89
T UR I MAN CTURIN C ., LTDS UM UFA G O .
19200 92
o elM d 3 L-P
Serial Nu ermb DOM Y/M
Pe m n arfor a ce R nge
1 ph ~ 0 g700 g . 300 ph.
e: 2 a ts 57 : 1 0Bor ” Input W t : 3 Volts 2
MP.: 3.1 PH : .: 6 o : 2 InsA . 1 Hz 0 P le .: E
Serial Number Manufacture Date
Model Number
WARNING
To reduce risk of electric shock, connect only to a
properly grounded, grounding-type receptacle.
Risk of electric shock - This pump has not been
investigated for use in swimming pool areas.
An acceptable motor-control switch shall be pro-
vided at the time of installation according to local
codes and regulations.
To reduce risk of electric shock, see instruction
manual for proper installation.
Attention - This pump may automatically restart.
Prior to working on the pump or control panel all
supply circuits must be disconnected.
Attention - Risk of shock - Do not remove cord and
strain relief.
Keep this manual or a copy of it with the machine. If you lose this manual or need an additional
copy, please contact TSURUMI. This machine is built with user safety in mind, however, it can
present hazards if improperly operated and serviced. Follow operating instructions carefully! If
you have questions about operating or servicing this equipment, please contact TSURUMI.
PLS
ii
TSURUMI PUMP
PL Series
Solids Handling Pond Pump
PL Series
Solids Handling Pond Pump

3
PLS i
Introduction
PLS
Submersible, Semi-Vortex, Water Feature Pump
This manual provides information and procedures to safely install, operate and maintain this TSURUMI model.
For your own safety and protection from injury, carefully read, understand and observe the safety instructions
described in this manual. THE INFORMATION CONTAINED IN THIS MANUAL WAS BASED ON MACHINES IN
PRODUCTION AT THE TIME OF PUBLICATION. TSURUMI RESERVES THE RIGHT TO CHANGE ANY
PORTION OF THIS INFORMATION WITHOUT NOTICE.
Nameplate
A nameplate listing the Model Number, Manufacture Date, and Serial Number is attached to each unit. Please record
the information found on this plate so it will be available should the nameplate become lost or damaged. When ordering
parts or requesting service information, you will always be asked to specify the model, manufacture date and
serial number of the unit.
Submersible
Pump
Distributed By:
TM
Model 3-PLS
Serial Number DOM Y/M
Performance Range
1700 gph. ~ 3000 gph.
Bore: 2” Input Watts: 357 Volts: 120
MADE IN JAPAN
AMP.: 3.1 PH.: 1 Hz.: 60 Pole: 2 Ins.: E
THERMALLY PROTECTED
INDOORS OR OUTDOORS
CSA ENCLOSURE 3
Conforms to UL Std.778
Certified to CAN/CSA Std.
C222 No. 108-M89
TSURUMI MANUFACTURING CO., LTD.
2001992
b e ib eSu m rs l
mPu p
is ribu e By:D t t d
TM
E A
MAD IN J PAN
ER LY PRO EC EDTH MAL T T
I ORS R U D RSNDO O O T OO
C A ENCLOSU 3S RE
o o m to L Std 8C nf r s U .77
C if t C CS St .ert ied o AN/ A d
222 N 10 MC o. 8- 89
ITSURUM MANUFACTURINGCO., LTD.
19200 92
Model 3-PL
Serial Number DOM Y/M
aPerformance R nge
p1700 h. ~ 3000 gph.g
5Bore: 2” Input atts: 3 7 Volts: 120W
:AMP. 3.1 PH.: 1 Hz.: 60 Pole: 2 Ins.: E
Serial Number Manufacture Date
Model Number
WARNING
To reduce risk of electric shock, connect only to a
properly grounded, grounding-type receptacle.
Risk of electric shock - This pump has not been
investigated for use in swimming pool areas.
An acceptable motor-control switch shall be pro-
vided at the time of installation according to local
codes and regulations.
To reduce risk of electric shock, see instruction
manual for proper installation.
Attention - This pump may automatically restart.
Prior to working on the pump or control panel all
supply circuits must be disconnected.
Attention - Risk of shock - Do not remove cord and
strain relief.
Keep this manual or a copy of it with the machine. If you lose this manual or need an additional
copy, please contact TSURUMI. This machine is built with user safety in mind, however, it can
present hazards if improperly operated and serviced. Follow operating instructions carefully! If
you have questions about operating or servicing this equipment, please contact TSURUMI.
PLS
ii
TSURUMI PUMP
Keep this manual or a copy of it with the machine. If you lose this manual or need an additional
copy, please visit our website at www.aquascapeinc.com. This machine is built with user safety
in mind, however, it can present hazards if improperly operated and serviced. Follow operating
instructions carefully! If you have questions about operating or servicing this equipment, please
contact Aquascape at US 1.866.877.6637 | CAN 1.866.766.3426

4
PL Series
Solids Handling Pond Pump
5
6
6
7
7
8
9
10
11
13
16
18

5
Aquascape

6
Aquascape
Aquascape

7
Aquascape

8
Aquascape

9

10

11
Aquascape

12

13
Aquascape

14
Aquascape
Aquascape

15

16
Aquascape
Aquascape

17

18
Aquascape