TW Audio WPC5 User manual

Assembly
Instructions
WPC5

Assembly Instructions WPC5
2
Introduction
The WPC5 installation cover with cable gland is an accessory for the C5 loudspeaker.
It is characterized by a subtle look, a remarkable size to weight ratio and ease of use.
Instructions in this user manual
NOTE
TIP
CAUTION
WARNING
Thank you for choosing a high-quality product “MADE IN GERMANY” from the brand
TW AUDiO.
If you lend your product to another party, inform that party of the safety-related operating pro-
cedures and hand over this assembly guide. If you require additional copies of this manual,
you can obtain them free of charge from TWAUDiO or download them from www.twaudio.de
Strictly adhere to the instructions contained in this operating manual that are marked as
follows:
This symbol in combination with the signal word “Warning” identifies a potentially hazardous
situation. Failure to comply with this safety instruction can lead to serious injury or even death.
This symbol in combination with the signal word “Caution” identifies a potentially hazardous
situation. Failure to comply with this safety instruction can lead to light or moderate injury.
This symbol in combination with the signal word “Note” identifies a potentially hazardous
situation. Failure to comply with this safety instruction can lead to product damage.
This symbol in combination with the signal word “Tip” identifies additional information or
notes that will simplify working with TWAUDiO products on the basis of practical experience.

Assembly Instructions WPC5
3
Notes on the products
Read manual
before use!
Before using the device, carefully read the assembly instructions and keep it with the
WPC5 installation cover with cable gland.
General information
Assembly instructions: OM-WPC5
Version 2.0 en, 12/2022
© by TWAMBO 2022; all rights reserved.
All information contained in this operating manual was correct to the best of our knowledge
at the time of printing.
Quality warranties or assurance of suitability for a certain type of use based on the technical
specifications, dimensions and weights are not granted by TWAMBO.
TWAMBO also shall not assume liability for any secondary damage (property damage and/or
personal injury) nor for the failure to comply with this operating manual!
TWAMBO reserves the right to update this document based on recent developments.
TWAMBO GmbH
Karl-Hofer-Str. 42
14163 Berlin
Germany
Phone : + 49 (0) 71 41-48 89 89 0
Fax: + 49 (0) 71 41-48 89 89 99
E-Mail: [email protected]
WWW: www.twaudio.de

Assembly Instructions WPC5
4
Content
1. Safety | Intended use...................................................................................................... 5
2. Overview ........................................................................................................................ 7
2.1 Components ........................................................................................................... 7
3. Technical data ................................................................................................................ 8
3.1 Data sheet............................................................................................................... 8
4. Commissioning............................................................................................................... 9
4.1 Using the WPC5 cover plate.................................................................................... 9
4.2 Installation variants ................................................................................................ 11
5. Transport and storage .................................................................................................. 12
6. CE Conformity Declaration............................................................................................ 13
7. Disposal ....................................................................................................................... 13

Assembly Instructions WPC5
5
1. Safety | Intended use
The WPC5 installation cover was developed for use in professional sound systems. The ins-
tallation cover may only be used by trained and qualified personnel.
The WPC5 installation cover may only used with the C5 loudspeaker.
This rigging manual describes how to use the WPC5 installation cover correctly. Any other
use shall be deemed improper and may result in damage or even injury.
Modifications or alterations to individual parts of the WPC5 installation cover are not permit-
ted! Danger to life!
WARNING
Before every operation, check the scope of delivery of the WPC5 installation cover for its
completeness and ensure that all parts are in perfect condition.
The scope of delivery includes specified components. Only use the recommended and cer-
tified components.
WARNING
The WPC5 installation cover is designed both for indoor and outdoor use.
CAUTION
The WPC5 installation cover may only be used by trained and qualified personnel. Personnel
must check the WPC5 installation cover for suitability before each use.
WARNING
The WPC5 installation cover must be taken out of operation immediately as soon as visible
damage to the parts can be seen.
WARNING
Please keep all elements of the WPC5 installation cover away from children! The small parts
can easily be swallowed and lead to suffocation!
WARNING
Please adhere to the following safety instructions to avoid risks when using accessories.
Note the operating modes described in this assembly instructions. Other uses are not per-
missible.
Damage caused by improper use is not covered by TWAMBO.

Assembly Instructions WPC5
6
WARNING
All screw connections should be checked when the WPC5 installation cover is installed. If
there are loose screws, tighten them. If this is no longer possible, the screws and nuts must
be replaced.

Assembly Instructions WPC5
7
2. Overview
2.1 Components
1. Cover plate - powder-coated surface ................................................................1 piece
2. Cable gland.......................................................................................................1 piece
3. Hexagon screw M10x16.................................................................................. 2 pieces
4. O-Ring9x2,5-NBR-90Shore....................................................................... 2 pieces
5. Butyl round cord................................................................................................1 piece
Figure 2.1 - Overview
1
2
3
4
5

Assembly Instructions WPC5
8
3. Technical data
Dimensions (h x w x d) 119 x 87 x 26 mm [4.68 x 3.43 x 1.02 in]
Weight 0,8 kg [1.76 lbs]
Protection class IP541
Surface Powder-coated
3.1 Data sheet
1Observe installation instructions (chapter 4.2)

Assembly Instructions WPC5
9
4.1 Using the WPC5 cover plate
NOTE
4. Commissioning
Glue the butyl round cord (see figure 4.1.1) onto the cover plate. The distance between the
butyl round cord and the metal sheet’s edge should be approximately 2 mm. A line is provi-
ded for orientation.
Figure 4.1.1 - Applying Pos.5 (figure 2.1)
Figure 4.1.2 - Applying Pos.2 (figure 2.1)
NOTE
Screw the cable gland to the cover plate as shown below.
Make sure that the O-ring attached to or enclosed with the cable gland is placed between the
cable gland and the cover plate.

Assembly Instructions WPC5
10
NOTE
Figure 4.1.3 - Mounted WPC5 installation cover
Screw the WPC5 cover plate to the C5loudspeaker using the two M10x16 hexagon bolts
and the O-rings included with the WPC5.
Make sure to place the two supplied O-rings (item 4 in figure 2.1) between the screw heads
and the cover plate.

Assembly Instructions WPC5
11
NOTE
4.2 Installation variants
To obtain class IP54 protection, mount the C5 loudspeaker with the attached
WPC5 cover plate tilted downwards at least by 5°!
Figure 4.2.1 - Installation variant 1 upright, tilded 5° downwards
5°
5°
Figure 4.2.2 - Installation variant 2 horizontal, tilded 5° downwards

Assembly Instructions WPC5
12
NOTE
5. Transport and storage
Ensure that the surface of the cover plate is not damaged during transport and storage.
Moisture may penetrate where steel surfaces are exposed by scratches and result in corro-
sion.
This is why the product should be transported in a safe, careful, dry and largely dust-free
manner.
The original packaging is unsuitable as permanent storage and transport packaging.

Assembly Instructions WPC5
13
as well as all model variants based on these, provided that they correspond to the original
factory models and have not been technically modified in any way.
Applicable directives:
• 2001/95/EG
Applicable national standards and technical specifications:
• DIN EN 18 800
• DIN EN ISO 12 100
• DGUV Vorschrift 17 und 18
Berlin, Germany, January 1st, 2021
Bernhard Wüstner
7. Disposal
Diese Erklärung betrifft folgende Komponenten
• WPC5
6. CE Conformity Declaration
If you have any question regarding the disposal of used devices, please contact us under the
following telephone number:
+49 (0) 71 41 - 48 89 89 0
In countries outside of the European Union, comply with local regulations.
Copy and translation of the original CE Conformity Declaration:
We hereby declare that the below-referenced components by virtue of their design and con-
struction, and in the configuration placed on the market by us, satisfy the safety and health
requirements of the applicable EC directives. This declaration becomes invalid in case of modi-
fications that have not been approved by us.

Assembly Instructions WPC5
14
TWAMBO GmbH
Karl-Hofer-Str. 42
14163 Berlin
Germany
Phone: + 49 (0) 71 41-48 89 89 0
Fax: + 49 (0) 71 41-48 89 89 99
E-Mail: [email protected]
WWW: www.twaudio.de