Vaportek RESTORATOR User manual

Odor Neutralizing System
Odor Neutralizing SystemOdor Neutralizing System
Odor Neutralizing System
Five-Year Limited Warranty
Vaportek warrants this unit to be free from defects in
workmanship or materials under normal use and service,
for a period of five years from the date of purchase by the
original purchaser. If at any time during the warranty
period the product is found to be defective or
malfunctions, Vaportek will repair or replace the defective
part (at its option) and provide the shop labor to repair
the product. This warranty shall not apply if it is shown by
Vaportek that the defect or malfunction was caused by
neglect or abuse by the consumer. This warranty does not
cover any other charges incurred by the consumer. The
sole responsibility of Vaportek shall be to repair or replace
product within the terms stated above.
Vaportek shall not be liable for any consequential
damages resulting from any breach of warranty, e press
or implied, applicable to this product. Some states do not
allow the e clusion or limitation of consequential
damages, so this limitation may not apply to you.
This warranty is in lieu of all other warranties,
e pressed or implied, and the warranties of
merchantability and fitness for a particular purpose are
hereby e cluded beyond the five-year duration of this
warranty. Some states do not allow limitation on how long
an implied warranty lasts, so the above limitation may not
apply to you. This warranty gives you specific legal rights,
and you may also have other rights which can vary from
state to state. This warranty applies only to products sold
and used in the United States and Canada. Goods
submitted for repair under this warranty must be sent,
freight prepaid, to Vaportek, Inc.
As with any electrical device, certain precautions for
safe and efficient use apply. Please follow these simple
rules and recommendations whenever using the
Restorator:
1. Do not alter the plug or change the electrical wiring
of the unit.
2. Always unplug the unit prior to installing or
removing the odor neutralizer cartridge.
3. Do not use near or around water.
4. Always use in plain view, to assure proper
operation.
5. If the unit ever appears to malfunction, unplug it
immediately and contact your dealer or Vaportek
for service advice.
6. The membrane cartridge is sealed. Do not puncture
or open the internal membrane.
7. For best results, store cartridge in cool, dry place
and replace after 270 hours of use.
8. To e tend cartridge life, re-cap when not in use.
9. Keep Restorator cartridges away from e treme heat
and from any sources of ignition.
•
Simple to Use
Simple to UseSimple to Use
Simple to Use — Just uncap the cartridge,
insert in machine and turn on!
• Works Fast
Works FastWorks Fast
Works Fast — Odor neutralizer delivery is
immediate and permanent!
• Sa e & Environmentally Pre erable
Sa e & Environmentally Pre erableSa e & Environmentally Pre erable
Sa e & Environmentally Pre erable —
No chemicals or harm ul ozone!
USE AND OPERATING
INSTRUCTIONS
CAUTION
#90-5000 110V
#90-5012 12V
W226 N6339 Village Drive
Susse , WI 53089
800-237-6367 ▪ www.vaportek.com ▪ [e-mail]
www.johnson-wholesale.com

Thank you for purchasing the Restorator by
Vaportek. This innovative appliance restores areas
up to 20,000 cubic feet from odor contamination
quickly, safely and economically.
With proper care, your Restorator will provide years
of trouble-free service. Please read this short
manual carefully before operating your Restorator,
and keep it for future reference.
The Restorator is a simple-to-use, portable electric system
that quickly, safely and effectively neutralizes odors in
interior spaces up to 20,000 cubic feet.
As this unit does not have any “fine” output control, it is
primarily intended for fast odor-neutralizing treatment at
high intensity. The characteristic neutralizer fragrance,
therefore, will be very noticeable in operation, as the
essential oils circulate throughout the treatment area at
full output from the machine.
For initial treatment, it is suggested that the #90-5150
(3X Industrial) or #90-5150-85 (S.O.S./Smoke Odor
Solution) cartridge be used. The High-Output (#90-4120)
cartridge may also be used and is available in several
fragrances for follow-up treatment, if desired.
Place the unit where air flow at both ends is unblocked,
preferably in a relatively high location. Locate on a hard,
stable surface. Be sure the replaceable cartridge is
properly installed (see instructions below), with the plastic
cap removed from the cartridge prior to installation. To
preserve cartridge life, always store with the cap on when
not in use.
Turn the unit on and allow it to deliver odor-neutralizing
dry vapor for a few minutes. In many cases, deodorization
will be complete in 30-60 minutes. For more severe
contamination, treatment may take several hours or even
days.
Dry vapor output will be affected by humidity and
temperature, with vapor release significantly reduced in
e cess humidity conditions (90-100%). Normal interior
conditions allow the unit to work well. Ideal temperature
range for best dry vapor release is 60°-110° F.
Finished surfaces may be damaged by direct contact with
cartridge oils. The essential oils used in the membrane are
non-to ic; however, if the oils should leak, wash affected
skin, clothes or surfaces with soapy water.
The Restorator is designed for use only with Vaportek-
approved replacement cartridges. Use of non-approved
replacement cartridges will void warranty coverage and
may cause risk of injury. For best results, replace
cartridge after 270 hours of use.
CONTAMINATED HOTEL ROOMS — Place the
Restorator relatively high in the treatment area
(i.e., on a table/off the floor). Let run 15-30 minutes
to penetrate all porous surfaces.
FIRE SMOKE DAMAGE — Close air vents and doors
in room. Let Restorator run overnight or longer,
depending on severity of damage. Residual
deodorizer vapor will dissipate in a few hours after
treatment and imbedded malodors will be eliminated.
AUTO BOAT RESTORATION — The Restorator is
ideal for removing cigarette, food, mustiness and
other biological odors in cars, recreational vehicles,
boats, etc. Run in closed treatment area for 15-30
minutes (light malodor problem) to 2-3 hours or
more (for severe odor problems).
ALSO IDEAL FOR REAL ESTATE, CLEANING
AND CRIME SCENE SERVICES; FACILITIES
MAINTENANCE; MORTUARIES; MEETING
ROOMS; AUTO RENTAL AGENCIES; USED CAR
DEALERS, DETAIL SHOPS...AND COUNTLESS
OTHER APPLICATIONS WHERE PROBLEM
ODORS EXIST!
THANK YOU!
SOME SUGGESTED USES
INSTRUCTIONS
Place cartridge into back of
machine with open end of
cartridge inserted first. (If
substantial oil leakage
[dripping] is evident, do not
use. Re-cap and contact
dealer or aportek.)
Be sure cartridge is
positioned properly
in the internal
cradle, with open
end resting against
the black gasket.
Fig. 1 Fig. 2 Fig. 3
Fig. 4 Fig. 5
Lift off lid and discard clear
film liner. (Slight wetness
under cap is normal.)
To operate, plug cord into
appropriate power outlet. Always
unplug Restorator before removing
cartridge. To prolong cartridge life,
remove from machine, re-cap and
store cartridge upright in a cool, dry
place. The Restorator cord can be
coiled for storage in the back of the
rear cover plate.
When machine is in use,
the plastic lid can be
stored at the back end of
the cartridge inside the
machine.
Replace spring-
loaded rear cover
plate by pressing it
against the cartridge
while turning, until it
locks into place.
Fig. 6
www.johnson-wholesale.com