Viking Professional VERT530-4B User manual

Viking Installation Guide
Professional and Designer
Built-In Electric Rangetops
Viking Range Corporation
111 Front Street
Greenwood, Mississippi 38930 USA
[phone]
For product information,
call 1-888-VIKING1 (845-4641)
or visit the Viking Web site at
vikingrange.com
F20576A EN (010609J)
®

IMPORTANT
3
–Please Read and FollowTable of Contents
Warnings & Important Safety Information_______________________________________________3
Dimensions (Professional Series) _______________________________________________________4
Specifications (Professional Series) _____________________________________________________5
Dimensions (Designer Series) _________________________________________________________6
Specifications (Designer Series)________________________________________________________7
Clearance Dimensions________________________________________________________________8
Electrical Requirements _____________________________________________________________10
General Information ________________________________________________________________11
Installation_________________________________________________________________________12
Final Preparation ___________________________________________________________________13
Performance Checklist ______________________________________________________________13
Service & Registration_______________________________________________________________14
• Before beginning, please read these
instructions completely and carefully.
•DO NOT remove permanently affixed
labels, warnings, or plates from product.
This may void the warranty.
• All local and national codes and ordinances
must be observed. Installation must
conform with local codes.
Your safety and the safety of others is
very important.
We have provided many important safety
messages in this manual and on your
appliance. ALWAYS read and obey all
safety messages.
This is the safety alert symbol. This
symbol alerts you to hazards that
can kill or hurt you and others.
All safety messages will be preceded by
the safety alert symbol and the word
“DANGER,” “WARNING” or “CAUTION.”
These words mean:
Hazards or unsafe practices
which WILL result in severe personal
injury or death
DANGER
Hazards or unsafe practices
which COULD result in severe personal
injury or death
Hazards or unsafe practices which
COULD result in minor personal injury or
property damage.
All safety messages will identify the
hazard, tell you how to reduce the chance
of injury, and tell you what can happen if
the instructions are not followed.
WARNING
CAUTION
• The installer must leave these instructions
with the consumer who should retain for
local inspector’s use and for future reference.
In Canada: Installation must be in accordance
with the current CSA C22.1 Canadian
Electrical Codes Part 1 and/or local codes.
DANGER
ELECTRICAL SHOCK
HAZARD
To avoid risk of electrical shock,
personal injury or death; verify your
appliance has been properly grounded in
accordance with local codes or in absence
of codes, with the National Electrical
Code (NEC). ANSI/NFPA 70-latest edition.
WARNING
MOVING HAZARD
To avoid risk of severe personal
injury; this appliance requires
two or more personnel while handling and
moving. Possible use of appliance moving
devices is recommended.

Specifications (Professional Series)
5
Dimensions (Professional Series)
4
35-7/8”
(91.1 cm)
9-1/16”
(23.0 cm)
1”
(2.5 cm)
8-1/8”
(20.6 cm)
1-5/8”
(4.1 cm) 1” (2.5 cm)
24-5/16” (61.8 cm)
28-1/16” (71.3 cm)
7-7/8”
(20.0 cm)
28-9/16” (72.6 cm)
(from front of knob
to back of rangeto
p
)
Note: Unit shown with standard island trim.
29-7/8”
(75.9 cm)
9-1/16”
(23.0 cm)
1”
(2.5 cm)
Professional Electric Rangetops
Description
VERT530-4B VERT536-6B
Overall width 29-7/8” (75.9 cm) 35-7/8” (91.1 cm)
Overall height from bottom To top of glass frame—8-1/8” (20.6 cm)
To top of island trim—add 1” (2.5 cm)
Additions to base height To top of backguard—add 8” (20.3 cm)
To top of high-shelf—add 23-1/2” (59.7 cm)
Overall depth from rear To end of side panel—24-5/16” (61.8 cm)
To end of landing ledge—28-1/16” (71.3 cm)
To end of knobs—28-9/16” (72.6 cm)
Cutout width
Cutout height
Cutout depth
30” (76.2 cm)
7-1/2” (19.1 cm)
24” (61.0 cm)
36” (91.4 cm)
7-1/2” (19.1 cm)
24” (61.0 cm)
Electrical
requirements
3-wire, 240-208/120VAC/60Hz; 40 amp 3-wire, 240-208/120VAC/60Hz; 60 amp
Unit is equipped with No. 10 ground wire in conduit. Should be fused separately.
Maximum amp usage 240V—34.6 amps (8.3 kw)
208V—29.8 amps (6.2 kw)
240V—49.2 amps (11.8 kw)
208V—42.6 amps (8.9 kw)
Surface element rating
Left front (dual element)
Left front (single element)
Left rear (dual element)
Left rear (single element)
Center front/rear
Bridge
Right front
Right rear (dual element)
Right rear (single element)
240V 208V
N/A N/A
1,500 watts 1,125 watts
2,500/1,000 watts 1,875/750 watts
N/A N/A
N/A N/A
800 watts 600 watts
1,800 watts 1,350 watts
N/A N/A
1,800 watts 1,350 watts
240V 208V
2,500/1,000 watts 1,875/750 watts
N/A N/A
N/A N/A
1,200 watts 900 watts
1,800 watts 1,350 watts
800 watts 600 watts
1,500 watts 1,125 watts
2,200/750 watts 1,650/560 watts
N/A N/A
Approximate
shipping weight 110 lbs. (49.5 kg) 165 lbs. (74.3 kg)
Minimum clearances from adjacent combustible construction
• Cooking surface and below, i.e., 36” (91.4 cm) and below
o Sides—0”
o Rear—0” with backguard or highshelf; 0” with island trim and noncombustible rear wall; 6” (15.2 cm) with island
trim and combustible rear wall.
• Above cooking surface, i.e. above 36" (91.4 cm)
o Sides—6” (15.2 cm)
o Within 6” (15.2 cm) side clearance, wall cabinets no deeper than 13” (33.0 cm) must be minimum 18” (45.7 cm)
above cooking surface.
o Wall cabinets directly above product must be minimum 36” (91.4 cm) for open top burners above cooking surface.
Electric 30” Rangetop Electric 36” Rangetop

Specifications (Designer Series)
7
Dimensions(Designer Series)
6
Designer Electric Rangetops
Description
DERT301-4B DERT361-5B
Overall width 29-7/8” (75.9 cm) 35-7/8” (91.1 cm)
Overall height from bottom To top of glass frame—6-1/8” (15.6 cm)
To top of backguard—add 6” (15.2 cm)
Additions to base height To top of island trim—add 0” (0.0 cm)
To top of high-shelf—add 23-1/2” (59.7 cm)
Overall depth from rear To end of side panel—24-7/16” (62.1 cm)
To end of landing ledge—26-1/8” (66.4 cm)
To end of knobs—27-5/8” (70.2 cm)
Cutout width 30” (76.2 cm) 36” (91.4 cm)
Cutout height 5-3/4” (14.6 cm) 5-3/4” (14.6 cm)
Cutout depth 24-7/16” (62.1 cm) 24-7/16” (62.1 cm)
Electrical
requirements
3-wire, 240-208/120VAC/60Hz; 40 amp 3-wire, 240-208/120VAC/60Hz; 50 amp
Unit is equipped with No. 10 ground wire in conduit. Should be fused separately.
Maximum amp usage 240V—35.0 amps (8.4 kw)
208V—30.3 amps (6.3 kw)
240V—45.0 amps (10.8 kw)
208V—40.0 amps (8.3 kw)
Surface element rating
Left front
Bridge
Left rear
Center (dual element)
Right front
Right rear (dual element)
240V 208V
1,800 watts 1,350 watts
800 watts 600 watts
1,800 watts 1,350 watts
N/A N/A
1,500 watts 1,125 watts
2,500/1,000 watts 1,875/750 watts
240V 208V
1,800 watts 1,350 watts
800 watts 600 watts
1,800 watts 1,350 watts
2,700/1,700 watts 2,025/1275 watts
1,500 watts 1,125 watts
2,200/750 watts 1,650/560 watts
Approximate
shipping weight 52 lbs. (23.4 kg) 63 lbs. (28.4 kg)
Minimum clearances from adjacent combustible construction
• Cooking surface and below, i.e., 36” (91.4 cm) and below
o Sides—0”
o Rear—0” with backguard or highshelf; 0” with island trim and non-combustible rear wall; 6” (15.2 cm) with island
trim and combustible rear wall.
• Above cooking surface, i.e. above 36" (91.4 cm)
o Sides—6” (15.2 cm)
o Within 6” (15.2 cm) side clearance, wall cabinets no deeper than 13” (33.0 cm) must be minimum 18” (45.7 cm)
above cooking surface.
o Wall cabinets directly above product must be minimum 36” (91.4 cm) for open top burners above cooking surface.
Electric 30” Rangetop
35-7/8”
(91.1 cm)
12-1/8”
(30.8 cm)
6-1/8”
(15.6 cm)
24-7/16” (62.1 cm)
1-5/8” (4.1 cm)
26-1/8” (66.4 cm)
27-5/8” (70.2 cm)
(from front of knob
to back of rangetop)
Note: Unit shown with 6” (15.2 cm) backguard.
29-7/8”
(75.9 cm)
12-1/8”
(30.8 cm)
Electric 36” Rangetop

98
42” min.
(106.7 cm)
13”max.
(
33.0 cm)
6” min.
(15.2 cm)
C
18” min.
(45.7 cm)
3/8”
(0.95cm)
36”
(
91.4 cm)
A
B
VERT
A7-1/2”
(19.1 cm)
B
C
24”
(61.0 cm)
30”
(76.2 cm)
36”
(91.4 cm)
DERT
A5-3/4”
(14.6 cm)
B
C
24-7/16”
(62.1 cm)
30”
(76.2 cm)
36”
(91.4 cm)
Clearance Dimensions (Proximity to Cabinets)
• This rangetop may be installed directly
adjacent to existing 36” (91.4 cm) high
base cabinets.
IMPORTANT: The top grate support
MUST be 3/8” (.95 cm) above the
adjacent base cabinet countertop.
• The rangetop CANNOT be installed
directly adjacent to sidewalls, tall cabinets,
tall appliances, or other side vertical
surfaces above 36” (91.4 cm) high. There
must be a minimum of 6” (15.2 cm) side
clearance from the rangetop to such
combustible surfaces above the 36” (91.4
cm) counter height.
• Within the 6” (15.2 cm) side clearance to
combustible vertical surfaces above 36”
(91.4 cm), the maximum wall cabinet
depth must be 13” (33.0 cm) and wall
cabinets within this 6” (15.2 cm) side
clearance must be 18” (45.7 cm) above
the 36” (91.4 cm) high countertop.
• Wall cabinets above the rangetop must be
a minimum of 42” (106.7 cm) above the
rangetop cooking surface for the full width
of the rangetop. This minimum height
requirement does not apply if a range
hood is installed over the cooking surface.
CAUTION
BURN HAZARD
To avoid risk of personal injury;
the use of cabinets for storage
above the appliance may result
in a potential burn hazard. Combustible
items may ignite, metallic items may
become hot and cause burns. If a cabinet
storage is to be provided the risk can be
reduced by installing a rangehood that
projects horizontally a minimum 5” (12.7 cm)
beyond the bottom of cabinets.
Note: Based on 24” (61 cm) deep cabinet.
Note: Minimum clearance for back wall is 0”
with backguard or high-shelf.
Note: If a range hood is installed, wall
cabinets above the rangetop have a different
minimum clearance height.
Clearance Dimensions (Wood/Composite Overlay)
The bottom of a standard hood should be
30” (76.2 cm) min. to 36” (91.4 cm) max.
above the countertop. This would typically
result in the bottom of the hood being
66” (167.6 cm) to 72” (182.9 cm) above the
floor. Refer to the range hood installation
instructions for additional information. These
dimensions provide for safe and efficient
operation of the hood.
66”min.
(167.6cm)
to
72”max.
(182.9cm)
66”min.
(167.6 cm)
to
72”max.
(182.9cm)
24”
(61.0 cm)
or
27”
(38.6 cm)
30”
(76.2 cm)
6”
(15.2 cm)
Wood/Composite
Overlay
Wood/Composite
Overlay
30”min.
(76.2 cm)
to
36”max.
(91.4 cm)
0”
(
0cm)
30”min.
(76.2 cm)
to
36”max.
(91.4 cm)
Wall Installation
Island Installation Note: 6” (15.2 cm) min. with island trim and
combustible rear wall. 0” with island trim
and non-combustible rear wall.
Note: Minimum clearance for back wall
is 0” with backguard or high-shelf.

1110
General Information
READ AND FOLLOW ALL WARNING
AND CAUTION INFORMATION WHEN
INSTALLING THIS APPLIANCE.
• All openings in the wall behind the
appliance and in the floor under the
appliance must be sealed.
•DO NOT obstruct the flow of combustion
and ventilation air.
Moving, Handling, and Unpacking
Remove and discard all packing materials,
including cardboard and tape on the outside
of the rangetop.
Some stainless steel parts may have a plastic
protective wrap which must be peeled off.
All stainless steel body parts should be
washed with hot, soapy water and with a
liquid cleaner designed for this material. If
buildup occurs, DO NOT use steel wool,
abrasive cloths, cleaners, or powders.
Electrical Requirements
Electrical Requirements
Check your national and local codes
regarding this unit. This rangetop requires
3-wire, 240-208 VAC/60 Hz. See “Installation”
section for grounding instructions. Must be
fused seperately from any other circuit.
Electrical
connection
in this area
3/4” (1.9 cm)
minimum
Cutout for electrical
5” (12.7 cm)
2” (5 cm)
WARNING
ELECTRICAL SHOCK
HAZARD
To avoid the risk of electrical
shock, personal injury or death;
verify electrical power is turned off at the
breaker box until the rangetop is installed
and ready to operate, installation by an
authorized installer only.
Electrical
connection
in this area
3/4” (1.9 cm)
minimum Cutout for electrical
5” (12.7 cm)
2”
(5 cm)
VERT
DERT

1312
1
Note: Refer to rangetop electrical
requirements section for proper
installation information.
Connect electrical in shaded area. See the “Electrical
Requirements” section for more information.
2
Install island trim. Attach with four screws provided.
3
Slide rangetop into place.
Performance Checklist
A qualified installer should carry out the
following checks:
h
Check top surface elements—glow red
when turned on.
h Check hot surface indicator lights—glow
red when corresponding element is on.
• All stainless steel body parts should be
wiped with hot, soapy water and with a
liquid cleaner designed for this material.
If buildup occurs, DO NOT use steel wool,
abrasive cloths, cleansers, or powders.
If it is necessary to scrape stainless steel
to remove encrusted materials, soak with
hot, wet cloths to loosen the material, then
use a wool or nylon scraper. DO NOT use
a metal knife, spatula, or any other material
tool to scrape stainless steel! Scratches are
almost impossible to remove.
Installation Final Preparation

14 15
Notes
________________________________________________________________________________________________________________________________________________________
________________________________________________________________________________________________________________________________________________________
________________________________________________________________________________________________________________________________________________________
________________________________________________________________________________________________________________________________________________________
________________________________________________________________________________________________________________________________________________________
________________________________________________________________________________________________________________________________________________________
________________________________________________________________________________________________________________________________________________________
________________________________________________________________________________________________________________________________________________________
________________________________________________________________________________________________________________________________________________________
________________________________________________________________________________________________________________________________________________________
________________________________________________________________________________________________________________________________________________________
________________________________________________________________________________________________________________________________________________________
________________________________________________________________________________________________________________________________________________________
________________________________________________________________________________________________________________________________________________________
________________________________________________________________________________________________________________________________________________________
________________________________________________________________________________________________________________________________________________________
________________________________________________________________________________________________________________________________________________________
________________________________________________________________________________________________________________________________________________________
________________________________________________________________________________________________________________________________________________________
________________________________________________________________________________________________________________________________________________________
________________________________________________________________________________________________________________________________________________________
________________________________________________________________________________________________________________________________________________________
Only authorized replacement parts may be used in performing service on the appliance.
All servicing should be referred to a qualified technician.
Contact Viking Range Corporation, 1-888-VIKING1 (845-4641), for the nearest service parts
distributor in your area or write to:
VIKING RANGE CORPORATION
PREFERRED SERVICE
1803 Hwy 82W
Greenwood, Mississippi 38930 USA
Rangetop – The serial number and model number for your appliance can be found by looking
under the control panel.
Record the following information indicated below. You will need it if service is ever required.
Model number ____________________________________________________________________________________
Serial number _____________________________________________________________________________________
Date of purchase __________________________________________________________________________________
Date installed ______________________________________________________________________________________
Dealer's name _____________________________________________________________________________________
Address ___________________________________________________________________________________________
These installation instructions should remain with the unit for future reference.
Service & Registration