VonHaus 3500059 User manual

20L ASH VACUUM
3500059 - Instruction Manual
01 0818

CONTENTS
Safety Instructions 1
Specification 2
Wheel Assembly, Vacuuming 3
Blow Function, Emptying the Ash Vac 3
Removing the Filters, Cleaning the Filters 4
Troubleshooting 5
Warranty 6

WARNING
PLEASE READ THESE INSTRUCTIONS CAREFULLY AND KEEP FOR FUTURE REFERENCE
INTENDED USE.
This appliance is intended for domestic use only. It is not
intended for use in commercial or industrial environments
and is not suitable for use outdoors or on wet surfaces.
This appliance is not intended for use by persons
(including children) with reduced physical, sensory or
mental capabilities, or lack of experience and knowledge,
unless they have been given supervision or instruction
concerning the use of the appliance by a person
responsible for their safety.
GENERAL PRECAUTIONS.
Do not allow to be used as a toy. Close attention is
necessary when used near children.
If the appliance is not functioning properly, has been
dropped, damaged, left outdoors or immersed in liquid,
do not use, contact DOMU Brands Customer Services.
Do not use the appliance if any parts appear to be faulty,
missing or damaged.
Ensure all parts are securely attached before using the
appliance.
CABLES AND PLUGS.
Check to ensure your electricity supply matches that
shown on the rating plate. The appliance must only be
used as rated.
The use of an extension cable is not recommended.
Do not handle the plug or the appliance with wet hands.
Keep the cord away from heated surfaces.
Do not pull the cable around sharp edges or corners.
Do not run the Ash Vacuum over the cord.
Do not unplug by pulling on the cable. To unplug, grasp
the plug, not the cable.
Do not use with a damaged cable or plug. If the supply
cable is damaged, it must be replaced by a qualified
engineer or authorised service agent in order to avoid a
hazard.
RISK OF PERSONAL INJURY.
Never use the Ash Vacuum without both the Fabric Filter
and HEPA Filter correctly and securely in place.
Do not use any filter other than those supplied with the
Ash Vacuum.
Do not use the appliance in areas where flammable or
combustible liquids may be present.
When using this appliance for the first time, a smell or
vapour may be given off. This will dissipate after a few
uses.
Only use the appliance to vacuum the following
substances:
• Ashes from admissible fuels
• Cold ashes from fireplaces, wood/coal stoves,
ashtrays or grills
NOTE: The term “cold ash” refers to ash that has been
left to cool down for a sufficient time and is free of any
embers. This can be confirmed by scouring the ash for
pockets of embers using metal tools before using the
appliance. Cold ash does not emit any recognisable heat.
In order to prevent damage to the appliance and
reduce risk of fire and/or personal injury, the following
objects are strictly prohibited from being sucked up:
• Anything that is burning or smoking such as
cigarettes, matches or hot ashes
• Any hot, burning or glowing objects
• Any objects that are hotter than 40°C
• Ashes or other objects within the fire that are not
completely extinguished
• Soot
• Reactive liquids (solvent, corrosive, detergent).
• Flammable or explosive substances such as alcohol,
thinners etc.
• Large or broken objects such as glass
WARNING! Do not use for the separation of health-
hazardous dusts (dust classes M).
Keep hair, loose clothing, fingers and all parts of the body
away from openings and moving parts.
Do not insert any objects into openings or cover the
appliance.
Do not leave the appliance unattended when plugged
in. Unplug from the outlet when not in use, and
before performing user maintenance, connecting or
disconnecting attachments or changing accessories.
Use only as described in this manual and with DOMU
Brands recommended attachments only.
CLEANING, STORAGE AND MAINTENANCE.
Empty and clean the appliance before and after use to
avoid the collection of materials that could pose a fire
hazard.
In order to maintain performance, it is essential that the
appliance is cleaned regularly and that any blockages are
prevented or cleared immediately.
Store the appliance indoors in a cool, dry place.
Do not carry out any maintenance or repair work other
than that shown in this manual, or as advised by the
DOMU Brands Customer Care Helpline.
Use only the accessories and spare parts supplied by, or
authorised by, DOMU Brands.
THERMAL CUT-OUT.
This appliance is fitted with a safety thermal cut-out
which will switch off the appliance automatically should it
overheat.
The appliance may overheat if the Filters are clogged, the
Flexible Hose is blocked or the tank is full.
Empty the tank, remove any blockages and/or clean the
Filter before next use.
The appliance will become operational again after
allowing 30-60 minutes to cool down.

SPECIFICATION
W L M
V
220-240
Hz
1200 20 HEPA 4
50
VOLTAGE POWER CAPACITY FILTER
TYPE
HOSE
LENGTH
FREQUENCY
5
2
1
2
3
3
4
5
6
7
8
9
10
11
7. Metal Tube
8. Crevice Tool
9. Flexible Hose
10. HEPA Filter
11. Debris Filter
12. Fabric Filter
1. Blow Outlet
2. On/Off Switch
3. Locking Clips
4. Vacuum Inlet
5. Wheel Base
6. Wheels
12

WHEEL ASSEMBLY
To attach the Wheels (6) to the Wheel Base (5) turn
the Wheel Base upside down.
Insert the Wheels into the hole and push to secure
into place.
Turn the Wheels Base upright and place the Container
into the recess.
To assemble the Ash Vacuum, insert either end of the
Flexible Hose (9) into the Vacuum Inlet (4). To insert,
align the notches and twist to secure into place.
Fig 1.
NOTE: If the area you are to vacuum contains large
pieces of debris it is advised you attach the Debris
Filter (11) to avoid clogging up the Vacuum.
To use the Debris Filter, loosen the screw and slide
the Debris Filter over the Metal Tube (7), re-tighten
screw to secure into place. Fig 2.
NOTE: Leave a small distance between the end of the
Debris Filter and Metal Tube.
To power on the Ash Vacuum, press the ON/OFF
Switch (2) located on the top of the Ash Vac.
To power off, press the ON/OFF Switch to the off
position.
CAUTION: Always ensure that both the Fabric
Filter (4) and the HEPA Filter (5) are in place before
operating the Ash Vacuum.
WARNING! Never vacuum hot embers. Always
ensure that the ashes have been left too cool for
approximately four days. Always use metal fireplace
tools to sift the ash to check for embers.
CAUTION: Ensure the outside of the Flexible Hose
does not come into contact with any hot surfaces.
Although the centre is lined with a metal lining, the
outer is plastic and this could cause damage.
VACUUMING
Loosen
Tighten
Fig 1.
Fig 2.

To use the Blow Function, insert the Flexible Hose (9)
into the Blow Outlet (1).
Twist to secure into place.
4
EMPTYING THE ASH VAC
BLOW FUNCTION
To remove Lid, lift the bottom of the Clasp to release
the top section. Un-hook the top of the Clasp to
release.
Lift away the Lid, empty the Ash Vac into a suitable
container.
1.LIFT
2.UN-CLASP
WARNING! Ensure you have switched off and unplugged from the mains supply before performing
any maintenance or cleaning of the appliance.

CLEANING THE FILTERS
To gain access to the Fabric Filter and HEPA Filter you
will need to remove the Motor Unit.
Follow the steps shown in “ Emptying the Ash
Vacuum ” on page 4.
Remove the Fabric Filter lift away from the Container,
rinse under clean running water.
CAUTION: Do not use the Ash Vacuum without the
HEPA Filter in place.
CAUTION: Do not use the Ash Vacuum with wet
Filters in place this will damage the product.
Leave to completly dry for 24hrs.
Locate the HEPA Filter on the underside of the Motor
Unit.
Gently pull and twist to remove the Filter.
Clean the HEPA Filter from the inside outwards; this
will ensure effecient removal of debris.
Use clean running water to clean the filter, do not use
any harsh abrasives or detergents to clean the filter.
Leave to completly dry for 24hrs.
CAUTION: Do not use the Ash Vacuum without the
HEPA Filter in place.
CAUTION: Do not use the Ash Vacuum with wet
Filters in place this will damage the product.
WARNING! Ensure you have switched off and unplugged from the mains supply before performing
any maintenance or cleaning of the appliance.

TROUBLESHOOTING
PROBLEM SOLUTION
Remove the plug from the mains and reinsert.
Check that all components are securely connected.
Check that the HEPA Filter is securely in place. Ensure
that it is pressed against the small white button and that
it is fully pressed inwards.
VACUUM WILL NOT START.
LOSS OF SUCTION.
CAUTION: Before attempting troubleshooting, power off the appliance and disconnect from the plug socket.
VACUUM IS DIFFICULT TO MOVE.
If you are having difficulty using your product and require support, please contact
[email protected]
6
Check the Flexible Hose, Metal Tube, Metal Nozzle
Attachment, Fabric and HEPA Filters and openings for
any obstructions and remove.
Remove and empty the Fabric Filter.
Clean the Fabric and HEPA Filter (see the ‘ Cleaning the
Filters ’section on the previous page).
Check that all components are securely connected.
There is an obstruction. Power off and check all
attachments for blockages.
VACUUM CUTS OUT.
Thermal cut-out has activated. Empty the tank, remove
any blockages and/or clean the Filters. The appliance will
become operational again after allowing 30-60 minutes
for it to cool down.

DISPOSAL INFORMATION
COPYRIGHT
WARRANTY
Please recycle where facilities exist. Check with your local authority for recycling advice.
All material in this instruction manual are copyrighted
by DOMU Brands Ltd.
Any unauthorised use may violate worldwide
copyright, trademark, and other laws.
To register your product and find out if you qualify
for a free extended warranty, go to:
www.VonHaus.com/warranty
Please retain a proof of purchase receipt or
statement as proof of the purchase date.
The warranty only applies if the product is used
solely in the manner indicated in the Warnings page
of this manual, and all other instructions have been
followed accurately. Any abuse of the product or
the manner in which it is used will invalidate the
warranty.
Returned goods will not be accepted unless re-
packaged in its original colour box and accompanied
by a relevant and completed returns form. This does
not affect your statutory rights.
No rights are given under this warranty to a
person acquiring the appliance second-hand or for
commercial or communal use.

VonHaus is a registered trademark of DOMU Brands Ltd
Made in China for DOMU Brands Ltd M24 2RW.
Thank you for purchasing the 20L Ash Vacuum.