Waeco TropiCool TC-07 User manual

TropiCool TC-07
D 3 Thermoelektrische Kühlbox
Bedienungsanleitung
GB 12 Thermoelectric cooler
Instruction Manual
F 21 Glacière thermoélectrique
Notice d’emploi
E 30 Nevera termoeléctrica
Instrucciones de uso
I 39 Frigorifero termoelettrico
Istruzioni per l’uso
NL 48 Thermo-elektrische koelbox
Gebruiksaanwijzingen
DK 57 Termoelektrisk køleboks
Betjeningsanvisning
N 66 Termoelektrisk kjøleboks
Bruksanvisning
S 75 Termoelektrisk kylbox
Bruksanvisning
FIN 84 Sähkökäyttöinen kylmälaukku
Käyttöohjeet
TC-07.book Seite 1 Mittwoch, 15. September 2010 4:37 16

TC-07
2
333 190
140
278
21 0
240
1TC-07
2
A
B
C
D
3
12V
DC
TC-07.book Seite 2 Mittwoch, 15. September 2010 4:37 16

TC-07
12
Please read this manual carefully before starting the machine. Keep it
in a safe place for future reference. If the device is resold, this manual
must be handed over to the purchaser along with the device.
Contents
1 Notes on using the instruction manual. . . . . . . . . . . . . . . . . . . . . . . 13
2 Safety instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
3 Scope of delivery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
4 Proper use . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
5 Technical description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
6 Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
7 Cleaning and care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
8 Disposal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
9 Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
10 Technical data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
TC-07.book Seite 12 Mittwoch, 15. September 2010 4:37 16

Notes on using the instruction manual TC-07
13
1 Notes on using the instruction manual
The following symbols are used in this instruction manual:
Caution!
Safety instruction, failure to observe this instruction can cause
injury or damage the device.
Caution!
Safety instruction, relating to a danger from electrical current or
voltage. Failure to observe this instruction can damage the device
and impair its function and cause injury.
Note
Supplementary information for operating the device.
➤Action: this symbol indicates that you need to do something.
The required action is described step-by-step.
✓This symbol indicates the result of an action.
Please observe the following safety instructions.
2 Safety instructions
2.1 General safety
zConnect the device as follows:
– With the mains rectifier supplied to the AC mains
– With the connecting cable supplied to the cigarette lighter in the
vehicle (see fig. 3, page 2).
zDo not pull the plug out of the cigarette lighter or the socket by the cable.
zIf the cable is damaged, it must be replaced to prevent possible electrical
hazards.
zDo not operate the device if it is visibly damaged.
TC-07.book Seite 13 Mittwoch, 15. September 2010 4:37 16

TC-07 Safety instructions
14
zThis device may only be repaired by specialist personnel. Inadequate
repairs can lead to considerable hazards.
Should your device need to be repaired, please contact WAECO
customer services.
zPull out the plug:
– Before cleaning and care
– After use
zEnsure that the ventilation slots are not covered.
zOn boats: if the device is powered by the mains, ensure that the power
supply has a ground fault interrupter circuit. Mortal danger!
zDisconnect the cooling device and other power consuming devices from
the battery before connecting the quick charging device.
zCheck that the voltage specification on the type plate corresponds to that
of the energy supply.
zThe cooling device is not suitable for transporting caustic materials or
materials containing solvents.
zFood may only be stored in its original packaging or in suitable containers.
Electronic devices are not toys.
Always keep and use the device out of the reach of children.
2.2 Operating the device safely
zBefore starting the device ensure that the power supply line and the plug
are dry.
zDo not place the device near flames or other heat sources (heating, direct
sunlight, gas ovens etc.).
zDo not fill the inner container with ice or fluid.
zDo not immerse the device in water.
zProtect the device and the cable against heat and moisture.
zDo not touch exposed cables with your bare hands. This especially
applies to when operating the device with the AC mains: mortal danger!
zWAECO cannot be held liable for damage resulting from improper usage
or incorrect operation.
TC-07.book Seite 14 Mittwoch, 15. September 2010 4:37 16

Scope of delivery TC-07
15
3 Scope of delivery
Before starting the device check if all of the parts belonging to the scope of
delivery are present.
4 Proper use
The cooling device is suitable for cooling and warming foodstuffs. The device
is also suitable for camping.
If you wish to cool medicines, please check if the cooling capacity of the
device is suitable for the medicine in question.
5 Technical description
The coolbox is suitable for mobile use. You can cool products to a maximum of
25 °C under the ambient temperature (thermostat switches off at approx. +5 °C)
or warm them to a maximum of 65 °C.
Its cooling system is a non-wearing Peltier cooling, the heat is discharged by
a fan.
Quantity Description
1 Cooling device
1 Mains rectifier for 230 Volt AC mains
1 Connection cable for cigarette lighter
TC-07.book Seite 15 Mittwoch, 15. September 2010 4:37 16

TC-07 Operation
16
6 Operation
Before starting your new cooling device for the first time, you
should clean it inside and outside with a damp cloth for hygienic
reasons (please also refer to the “Cleaning and care” chapter on
page 18).
6.1 Energy saving tips
zChoose a well ventilated installation location which is protected against
direct sunlight.
zAllow food to cool down first before placing it in the device.
zDo not open the cooling device more often than necessary.
zDo not leave the lid or door open for longer than necessary.
6.2 Switching on the cool box
➤Place the coolbox on a firm base.
The plug’s polarity cannot be reversed: it can only be inserted into
the socket in one direction (see fig. 2 A, page 2).
➤Connect the coolbox
– With the mains rectifier supplied to a socket or ...
– Using the connection cable supplied to the cigarette lighter in your
vehicle (see fig. 3, page 2).
➤Push the switch on the operating panel (see fig. 2 C, page 2) into
the “HEISS/HOT” position or the “KALT/COLD“ position to switch the
coolbox on.
✓The cool box starts cooling/heating the interior.
Operating display Operating mode
Red
(see fig. 2 B, page 2)
Heating
Green
(see fig. 2 D, page 2)
Cooling
TC-07.book Seite 16 Mittwoch, 15. September 2010 4:37 16

Operation TC-07
17
Ensure that the objects placed in the cool box are suitable for
cooling/warming to the selected temperature.
6.3 Switching between cooling and heating
➤If you wish to switch between cooling and heating, push the switch
on the operating panel (see fig. 2 C, page 2) into the “HEISS/HOT“
or “KALT/COLD“ position.
✓The red or green operating display lights up and the device begins
cooling/heating.
➤If you wish to end the cooling/heating process, push the switch on the
operating panel (see fig. 2 C, page 2) into the “AUS/OFF” position.
➤If you wish to switch off the device, pull out the connecting cable.
6.4 Connecting to a cigarette lighter
If you connect the device to the cigarette lighter of your vehicle
(see fig. 3, page 2), remember that the ignition must be turned on
to supply the device with power.
TC-07.book Seite 17 Mittwoch, 15. September 2010 4:37 16

TC-07 Cleaning and care
18
7 Cleaning and care
Caution!
Before cleaning the coolbox, pull the cable out of the socket or the
cigarette lighter.
Caution!
Do not clean the coolbox under flowing water or in dish water.
Caution!
Do not use abrasive cleaning agents or hard objects during
cleaning as these can damage the coolbox.
➤Clean the interior of the coolbox with a damp cloth from time to time.
➤Clean the exterior of the device with a damp cloth.
8 Disposal
8.1 Disposing of packaging material
Do not simply throw the packaging material away. Please observe the
following instructions:
zThe cardboard packaging material should be disposed of in the
appropriate waste bin.
zPlastic packaging should be placed in the appropriate recycling bin.
zAsk your local authority for the location of the recycling unit closest to you.
8.2 Disposing of the device
If you wish to finally dispose of the coolbox, take it to the nearest recycling
centre or return it to your specialist dealer who will be happy to take it back
for a small fee.
TC-07.book Seite 18 Mittwoch, 15. September 2010 4:37 16

Troubleshooting TC-07
19
9 Troubleshooting
Fault Possible cause Suggested remedy
Your coolbox is not
working and the fan
wheel which can be
seen from the outside
is not turning.
There is no voltage
flowing from the
cigarette lighter in
your vehicle.
The ignition must be switched on in most
vehicles for voltage to flow at the cigarette
lighter.
The ignition is on and
the coolbox is not
working.
Pull the plug out of the
socket and make the
following checks.
The cigarette lighter
socket is dirty. This
results in a poor
electrical contact.
Clean the socket of the cigarette lighter
with a non-metallic brush and a solvent,
to ensure that the middle contact pin is
clean. If the plug of your coolbox becomes
very warm in the cigarette lighter socket,
either the socket must be cleaned or the
plug has not been assembled correctly.
The fuse of the
connecting cable
has blown.
Replace the connecting cable fuse (5 A).
The vehicle fuse has
blown.
Replace the vehicle cigarette lighter
fuse (usually 15 A). Please refer to the
operating manual of your vehicle.
Your coolbox does not
cool satisfactorily and
the outer fan wheel is
not turning.
The fan motor is
defective.
This can only be repaired by an
authorised customer services unit.
The coolbox does not
cool satisfactorily and
the outer fan wheel is
turning.
The ventilator motor
for the inner motor is
defective.
This can only be repaired by an
authorised customer services unit.
The Peltier element
is defective.
Only for devices with
AC operating mode:
The integrated mains
adapter is defective.
This can only be repaired by an
authorised customer services unit.
TC-07.book Seite 19 Mittwoch, 15. September 2010 4:37 16