Williams GN1200BT Instruction manual

Page1

StainlessSteelCabinet






















Installation,Operation&MaintenanceManual


Page2

SafetyTips
zPositiononaflat,stablesurface.
zAserviceagent/qualifiedtechnicianshouldcarryout
installationandanyrepairsifrequired.Donotremove
anycomponentsorservicepanelsonthisproduct.
zConsultLocalandNationalStandardstocomplywith
Thefollowing:
·HealthandSafetyatWorkLegislation
·BSENCodesofPractice
·FirePrecautions
·IEEWiringRegulations
·BuildingRegulations
zDONOTusejet/pressurewasherstocleanthe
appliance.
zDONOTusetheapplianceoutside.
zDONOTusethisappliancetostoremedicalsupplies.
zDONOTuseelectricalappliancesinsidetheappliance.
(e.g.heaters,ice‐creammakersetc.)
zDONOTstandorsupportyourselfonthebase,
drawersordoors.
zDONOTallowoilorfattocomeintocontactwiththe
plasticcomponentsordoorseal.Cleanimmediatelyif
contactoccurs.
zBottlesthatcontainahighpercentageofalcoholmust
besealedandplacedverticallyintherefrigerator.
zAlwayscarry,storeandhandletheapplianceina
verticalpositionandmovebyholdingthebaseofthe
appliance.
zAlwaysswitchoffanddisconnectthepowersupplyto
theunitbeforecleaning.
zKeepallpackingawayfromchildren.Disposeofthe
packaginginaccordancewiththeregulationsoflocal
authorities.
zIfthepowercordisdamaged,itmustbereplacedby
anagentorarecommendedqualifiedtechnicianin
ordertoavoidahazard.
Introduction
Pleasetakeafewmomentstocarefullyreadthroughthis
manual.Correctmaintenanceandoperationofthis
machinewillprovidethebestpossibleperformancefrom
yourproduct.
PackContents
·RefrigeratororFreezer
·Shelvesx3(Single)/x6(Double)
·Keysx2
·Instructionmanual
·Shelfguidesx6(Single)/x12(Double)
·Wastewatertray

Weprideourselvesonqualityandservice,ensuringthatat
thetimeofpackingthecontentsaresuppliedfullyfunctional
andfreeofdamage.Shouldyoufindanydamageasaresultof
transit,pleasecontactyourdealerimmediately.
Installation
Note:Iftheappliancehasnotbeenstoredor
movedinanuprightposition,letitstanduprightfor
approximately12hoursbeforeoperation.Ifindoubt
allowtheappliancetostand.

1. Removetheappliancefromthepackaging.Make
surethatallprotectiveplasticfilmandcoatings
arethoroughlyremovedfromallsurfaces.


2.Maintainadistanceof20cm(7inches)between
theunitandwallsorotherobjectsforventilation.
Increasethisdistanceiftheobstacleisaheatsource.

Note:Beforeusingtheapplianceforthefirsttime,
cleantheshelvesandinteriorwithsoapywater.

3.Setthebrakesonthecastorstokeeptheappliance
inpositionORleveltheappliancebyadjustingthescrewfeet.

RemovingtheCompressorSafetyBand

Thecompressorislocatedonthetopoftheappliance,
andsitsonrubberwashers.Undernormaloperating
conditionsthecompressorisallowedtovibrate.
Toavoiddamagethroughexcessivemotionduring
transit,astainlesssteelsafetybandisplacedoverthe
compressorandscrewedintothetopoftheappliance.
Thissafetybandandthetwoscrewsfixingittothe
appliancemustberemovedbeforetheapplianceis
turnon.



























Lock/UnlocktheDoors
Alockisfittedtothedoorstoensurefoodstuffsarekept
securewithinyourappliance.
Usethekeysprovidedtolock/unlockthedoor.












Page3

FittingtheWasteWaterTray
Thewastewatertraycomesreadytofittotheundersideoftheappliance.Slidethetrayintotherunnerssitedunderthe
appliance.
FittingtheShelves
1.Placeonesetofshelfguidesoneithersideofthecabinetatthedesiredheight.
2.Slidetheshelfintoplace.
3.Repeatfortheremainingshelves.

Note:Thisisvitalforensuringcorrectdrainageofcondensation.
Operation
StoringFood
Togetthebestresultfromyourappliance,followtheseinstructions:
·Onlystorefoodstuffsintheappliancewhenithasreachedthecorrectoperatingtemperature.
·Donotplaceuncoveredhotfoodorliquidinsidetheappliance.
·Warporcoverfoodwherepossible.
·Donotobstructthefansinsidetheappliance.
·Avoidopeningthedoorsforprolongedperiodsoftime.
Turnon
1. Closethedoor(s)oftheappliance.
2. Ensurethepowerswitchissetto[O]andturnonatthesocket.
3. Switchonthepower[l].Thecurrenttemperaturewithintheapplianceisdisplayed.
ManualDefrost
Theappliancewillautomaticallyrunadefrostcycleeverysixhours.
Note:Thecyclestartsfromthetimetheapplianceisinitiallypoweredup.
Tomanuallydefrosttheappliance:
1. PressandholdtheDEFROSTbuttonfor5seconds.
2. ThedefrostcyclewillstartimmediatelyandtheDefrostLETilluminates.Thedefrostwilllastamaximumof30minutes.

Note:Startingamanualdefrostalsoresetstheautomaticdefrosttimer.Thenextautomaticdefrostwillstartsix
hoursafterthemanualdefrosthasfinished.

3. Wastewateriscollectedinthewastewatertray.
Cleaning,Care&Maintenance
·Switchoffanddisconnectfromthepowersupplybeforecleaning.
·Cleantheinterioroftheapplianceasoftenaspossible.
·Donotuseabrasivecleaningagents.Thesecanleaveharmfulresidues.
·Cleanthedoorsealwithwateronly.
·Alwayswipedryaftercleaning.
·Donotallowwaterusedincleaningtorunthroughthedrainholeintotheevaporationpan.
·Takecarewhencleaningtherearoftheappliance.Sharpedgescancut.
·Anagentorqualifiedtechnicianmustcarryoutrepairsifrequired.
CleaningtheCondenser
Periodicallycleaningthecondensercanextendthelifeoftheappliance.
Werecommendthatouragentorqualifiedtechniciancleanthecondenser.









Page4

Troubleshooting
Ifyourappliancedevelopsafault,pleasecheckthefollowingtablebeforemakingacalltoyourretailer.
FaultProbableCauseAction
Theapplianceisnotworking
TheunitisnotswitchonChecktheunitispluggedincorrectlyandswitchedon
PlugandleadaredamagedCallyouragentorqualifiedtechnician
FuseintheplughasblownReplacethefuse
PowersupplyCheckpowersupply
InternalwiringfaultCallyouragentorqualifiedtechnician
Theapplianceturnson,but
thetemperatureistoo
high/low
ToomuchiceontheevaporatorDefrosttheappliance
CondenserblockedwithdustCallyouragentorqualifiedtechnician
FaultProbableCauseAction
Theapplianceturnson,but
thetemperatureistoo
high/low
DoorsarenotshutproperlyCheckdoorsareshutandsealsarenotdamaged
Applianceislocatednearaheatsource
orairflowtothecondenserisbeing
interrupted
Movetherefrigeratortoamoresuitablelocation
AmbienttemperatureistoohighIncreaseventilationormoveappliancetoacoolerposition
Unsuitablefoodstuffsarebeingstored
intheappliance Removeanyexcessivehotfoodstuffsorblockagestothefan
ApplianceisoverloadedReducetheamountoffoodstoredintheappliance
Theapplianceisleaking
water
TheapplianceisnotproperlylevelledAdjustthescrewfeettoleveltheappliance(Ifapplicable)
ThedischargeoutsideisblockedClearthedischargeoutlet
Movementofwatertothedrainis
obstructedCleartheflooroftheappliance(ifapplicable)
ThewatercontainerisdamagedCallyouragentorqualifiedtechnician
ThedriptrayisoverflowingEmptythedriptray(ifapplicable)
Theapplianceisunusually
loud
Loosenut/screwCheckandtightenallnutsandscrews
Theappliancehasnotbeeninstalledin
alevelorstablepositionCheckinstallationpositionandchangeifnecessary
ElectricalWiring
Appliancesaresuppliedwitha3pin,moulded,BS1363plugandlead,witha13ampfuseasstandard.Theplugistobe
connectedtoasuitablemainssocket.Appliancesarewiredasfollows:
Livewire(colouredbrown)toterminalmarkedL
Neutralwire(colouredblue)toterminalmarkedN
Earthwire(colouredgreen)toterminalmarkedE
Allappliancesmustbeearthed,usingadedicatedearthingcircuit.
Ifindoubtconsultaqualifiedelectrician.
Electricalisolationpointsmustbekeptclearofanyobstructions.Intheeventofanyemergencydisconnectionbeing
requiredtheymustbereadilyaccessible.
Disposal
EUregulationsrequirerefrigerationproducttobedisposedofbyspecialistcompanieswhoremoveorrecycleallgasses,
metalandplasticcomponents.
Consultyourlocalwastecollectionauthorityregardingdisposalofyourappliance.Localauthoritiesarenotobligedto
disposeofcommercialrefrigerationequipmentbutmaybeabletoofferadviceonhowtodisposeoftheequipmentlocally.

Compliance
Partshaveundergonestrictproducttestinginordertocomplywithregulatorystandardsandspecificationsetby
international,independent,andfederalauthorities.
Productshavebeenapprovedtocarrythefollowingsymbol:
