ZANIER HEAT-GX Supermax+ User manual

HEAT- GX/HOT-G X SUPERMAX+ POWERPACK
INSTRUCTION FOR USE
INTRODUCTION
Congratulations on your purchase of HEAT-GX by ZANIER, the rst
glove worldwide with adjustable, processor-controlled heating.
Please read the instructions for use carefully before rst using the
glove.
Please keep these instructions and give them to others who may use
the product.
TAB LE OF CONTENTS:
Package contents ...................................... 1
Safety precautions .................................... 1
Technical data ............................................. 2
First use and charging
the Powerpacks .......................................... 2
Description of functions ......................... 3
Important usage notes ............................. 3
Use and functions ...................................... 3
Heat levels .................................................... 3
Service, storage and care of the
Powerpacks .................................................. 4
Disposal ......................................................... 4
Accessories and spare parts .................. 4
This device conforms to EMC regulations ( EC directive 89/336/ EEC) and the low
voltage directive (73/23 EEC).

PACKAGE CONTENTS
• ZANIER Gloves
• 2 Ni-MH battery packs (Supermax+ Powerpack) – rechargeable, with integrated heat level switches
• 1 charger
SAFET Y PRECAUTIONS
• If you cannot properly distinguish heat or cold (e.g. diabetics, disabled persons etc.), please consult
your doctor before using the unit.
• Check your hands regularly for reddening of the skin. Excessive heat levels over prolonged periods
can lead to burns. Children should use the unit only under the supervision of adults.
• Powerpacks are water-resistant. They should always be connected to your ZANIER gloves when
outdoors (even if not switched on), to prevent the ingress of moisture or dirt into the socket or plug.
If water enters the Powerpack, drain the water and allow the unit to dry.
• For recharging, use the Therm-ic original power adapter. It is designed for indoor use and may not be
exposed to moisture.
• Do not insert any objects, especially metal objects, into connecting sockets or plugs to avoid
damaging the unit.
• If you notice any damage to connecting cables or other parts of the unit, do not use it. Do not make
any modications to the unit or use it for any unintended purpose. Repairs to the unit or its connec-
ting leads should only be performed by the manufacturer.
• If questions or problems arise, please get in touch with your dealer or the manufacturer.
• Dispose of used Powerpacks properly.
• Do not throw Powerpacks into an open re, as there is a risk of explosion.

TECHNICAL DATA
Charger (available accessory):
Input: 110 V-240V ~ (50/60 Hz), 400mA
Output: 2x (6V / 500 mA)
FIRST USE AND CHARGING THE POWERPACKS
Preparing the Charger:
Press the appropriate adapter into the slot on the back of the charger until it locks in with an
audible click.
Charging procedure:
Each Powerpack has an LED that shows the charge status (see table).
• LED on = charging
• LED blinking = charging complete (maintenance charging)
Important: First, connect the charger to the socket. Attach both
Powerpacks to the charging cable. The charging process begins
automatically (the corresponding LED turns on).
The Powerpacks are automatically monitored and turned o by the integrated electronics, regardless of
the charge status. After successful charging (max. 4.5 hours), the Powerpacks are automatically switched
to maintenance charging mode (the corresponding L ED will blink).
In case of an error, the charging process is automatically stopped after 5 hours.

DESCRIPTION OF FUNCTIONS
The Supermax+ Powerpacks have two operating modes: POWER OFF - IN USE
These modes are clearly indicated on the device display (red LED):
• POWER OFF: The level switch is set to level “0“. The device display (red LED) remains o.
The Powerpack is now completely switched o.
• IN USE: The Powerpack is supplying the connected ZANIER gloves with power. Each Power-
pack can be individually set to one of three dierent heat levels.
The device display (red L ED) turns on.
IMPORTANT USAGE NOTES
• When using the heating element cable, plugit into the Powerpack until it can be clearly felt to engage.
• When using the unit, do not allow level 3 to be switched on longer than a few minutes at a time.
Otherwise too much heat can be produced during operation, which could lead to burns.
• Always set Powerpacks to level 1 or 2 to maintain a comfortable level of warmth for your hands
(heating should be almost undetectable).
USE AND FUNCTIONS
The desired heat level can be individually set for each Powerpack using the level switch (levels 1, 2, 3).
HEAT LEVE LS
Level 1 up to 13hours heating period per battery charge
Level 2 5.6 hours
Level 3 2.4 hours

SERVICE, STORA GE AND CARE OF THE POWERPACKS
To provide for long product life, store the Powerpacks fully charged, turned o (level “0”) and disconnected
from gloves and the charger in a dry place at room temperature.
Clean all parts and gloves as needed with a soft, slightly damp cloth and a mild cleanser.
ATTENTION : Always remove the charger from the outlet before cleaning it.
DISPOSAL
If the device can no longer be used, please dispose of it and its packaging in an environmentally-friendly
way that is in accordance with current regulations.
Do not throw the charger or the Supermax+ Powerpacks away with normal household trash. Instead, dispose
of the parts at a collection site for electrical waste.
Packaging materials are raw materials and can be recycled. For this reason, please recycle the packaging.
Batteries must be disposed of at proper collection sites.
Please contact your local public authorities for more information.
ACCESSORIES AND SPARE PART S
When subsequently purchasing accessories or spare parts make sure to give the exact Therm-ic model
designation. Ideally, take the part to be replaced with you to your dealer.
We oer a number of accessories. All articles (accessories and spare parts) are also available individually.
Your dealer will be happy to advise you.