ACDC DCAC PI7803/3-M-RS User guide

Sur e Protection G
Installation and Operating Instruction
ACDC Surge Protectors Type - PI (780; 7100; 7125; 7200) 3/3 - M - RS
CLASS
CLASS
I+II+III
I+II+III
20
20
home
home
telecom
telecom
industry
industry
center
center
IT
IT
IP
IP
3
3
0
0
1
1
2
2
LPZ
LPZ
Type - PI (780; 7100; 7125; 7200) 3/3 - M - RS
Sur
Sur eG
MULTI-STAGE SURGE PROTECTION
Empowered by InnovationEmpowered by Innovation
NINE (9) STAGES 1/1 & 3/3SERIES PROTECTOR
Cascade bi-directional EMI-RFI filtering of phase (L), neutral (N) and ground (GND) wire
Single Phase & Three Phase CLASS I+II+III
Hard Wire Installation- Modular System
Indication for bed grounding, remote alarm
www.acdc-dcac.eu

Mounting of ACDC Surge Protectors
ACDC Surge Protectors - Series have to be installed at ENTRY POINT the Main Distribution Boards (MDB) or
internal Sub Distribution Boards (SDB) right in front of the input power to the device that should be protected The ACDC Surge Protector
could be install in series or parallel configuration depending of total load per phase (>100A<).
- If the load per phase is <100A the ACDC Surge Protector install in SERIES configuration.
- If the load per phase is >100A the ACDC Surge Protector must be installed in PARALLEL configuration.
Type-PI 3/3 - M Red before Power
or .
have to be ed
Only in SERIES configuration all nine (9) protection stages are in function.
ACDC Surge Protectors are designed to fixed to the wall .
22
1.
If the the load per phase is <100A, our RECOMMENDATION is to install the surge protector in SERIES configuration
because only in this state your electrical devices will be fully protected.
If the total load per phase is >100A and ACDC Surge Protector is installed in PARALLEL configuration our
RECOMMENDATION is to install another ACDC Surge Protector in SERIES configuration ( Sub Distribution Board),
downstream power grid where the load per phase drops bellow 100A,
before
Condition for Installations:
Mounting:
Terminal andWire size:
During the installation please check:
with screws
Each terminal is designed to accept wire sizes from 4mm to 25mm solid or stranded conductor.The wire insulation should be stripped back
8mm
The voltage of the ACDC Surge Protector matches actual system voltage.
2. All conductors are in accordance with the appropriate installation drawings.
THIS UNIT SHOULD BE INSTALLED AND SERVICED ONLY BY QUALIFIED PERSONNEL.
Before installing the ACDC Surge Protector, AC power must be OFF.
CORRECT INSTALLATION - THE LIGHTS GREEN AND YELLOW ARE LIT
TROUBLESHOOTING - IF THE RED LED IS BLINKINGTHE GROUND WIRE IS NOT CONNECTED ORTHE GROUND OF THE
POWER GRID SYSTEM IN NOT WELL PERFORMED
- rovides adequate electrical and safety protection
- Prevents the ingress of moisture and water
- Allows operating diagnostic status to be inspected
p
.
.
:
.
. ..
DANGER
CAUTION
!
!
CAUTION
!
!
CAUTION
!
!
Mounting of Protectors
Sur
Sur eG
MULTI-STAGE SURGE PROTECTION
New materials, New design, New approach to Surge Protection Industry
[email protected]

Integrated Multi-Stage Protection
Installation Instruction
Sur
Sur eG
MULTI-STAGE SURGE PROTECTION
www.acdc-dcac.eu
L3
N
PE
L2
L1 C1
C2
C3
Fuse
Fuse
Fuse
Series
ACDC SURGE PROTECTOR
Red
MULTI-STAGE
SURGE
PROTECTION
CLASS I II III++
1, 3, 7 and 8 Stage: Filter (bi-directional wave tracking);
1, 3, 7 and 8 Stage: Filter (bi-directional wave tracking);
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
2, 4 and 5 Stage: SurgeLimiter (L-N)
2, 4 and 5 Stage: SurgeLimiter (L-N)
150kA (8x20
150kA (8x20
s); 22kA (10/350
s); 22kA (10/350
s)
s)
6. Stage: MOSFET Limiter-500A (8x20
6. Stage: MOSFET Limiter-500A (8x20
s)(RT<1ns)
s)(RT<1ns)
9. Stage: Surge Limiter (N-Gnd)
9. Stage: Surge Limiter (N-Gnd)
125kA (8x20
125kA (8x20
s); 20kA (10/350
s); 20kA (10/350
s)
s)
μ μ
μ
μ μ
NP S INE ROTECTION TAGES
Load Rating: 230VAC@ 100A
Type- PI Red Series
L
N
IN
L
N
IN
ININ
C1'
PARALLEL
N
OUT
PARALLEL
N
OUT
LL
mark
PARALLEL
G
PARALLEL
G
LL
ININ
ND
G
FAULT
L
G
L
G
II
CORRECT
OUT
OUT
OUT
OUT
IV,VI
CORRECT
Series
ACDC SURGE PROTECTOR
Red
MULTI-STAGE
SURGE
PROTECTION
CLASS I II III++
N
IN
N
IN
1, 3, 7 and 8 Stage: Filter (bi-directional wave tracking);
1, 3, 7 and 8 Stage: Filter (bi-directional wave tracking);
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
2, 4 and 5 Stage: SurgeLimiter (L-N)
2, 4 and 5 Stage: SurgeLimiter (L-N)
150kA (8x20
150kA (8x20
s); 22kA (10/350
s); 22kA (10/350
s)
s)
6. Stage: MOSFET Limiter-500A (8x20
6. Stage: MOSFET Limiter-500A (8x20
s)(RT<1ns)
s)(RT<1ns)
9. Stage: Surge Limiter (N-Gnd)
9. Stage: Surge Limiter (N-Gnd)
125kA (8x20
125kA (8x20
s); 20kA (10/350
s); 20kA (10/350
s)
s)
μ μ
μ
μ μ
NP S INE ROTECTION TAGES
Load Rating: 230VAC@ 100A
Type- PI Red Series
LL
ININ
C2'
N
OUT
N
OUT
PARALLELPARALLEL
LL
PARALLELPARALLEL
mark
GG
LL
ININ
G
ND
FAULT
GG
LL
II
CORRECT
OUTOUT
IV,VI
OUTOUT
CORRECT
Series
ACDC SURGE PROTECTOR
Red
MULTI-STAGE
SURGE
PROTECTION
CLASS I II III++
1, 3, 7 and 8 Stage: Filter (bi-directional wave tracking);
1, 3, 7 and 8 Stage: Filter (bi-directional wave tracking);
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
2, 4 and 5 Stage: SurgeLimiter (L-N)
2, 4 and 5 Stage: SurgeLimiter (L-N)
150kA (8x20
150kA (8x20
s); 22kA (10/350
s); 22kA (10/350
s)
s)
6. Stage: MOSFET Limiter-500A (8x20
6. Stage: MOSFET Limiter-500A (8x20
s)(RT<1ns)
s)(RT<1ns)
9. Stage: Surge Limiter (N-Gnd)
9. Stage: Surge Limiter (N-Gnd)
125kA (8x20
125kA (8x20
s); 20kA (10/350
s); 20kA (10/350
s)
s)
μ μ
μ
μ μ
NP S INE ROTECTION TAGES
Load Rating: 230VAC@ 100A
Type- PI Red Series
L
N
IN
L
N
IN
ININ
C3'
PARALLEL
N
OUT
PARALLEL
N
OUT
LL
mark
PARALLEL
G
PARALLEL
G
LL
ININ
ND
G
FAULT
L
G
L
G
II
CORRECT
OUT
OUT
OUT
OUT
IV,VI
CORRECT
The model could be installed in series configuration with or without ground filtering or in parallel
configuration
Installation Instruction
L1L2L3
NN
ND
IV,VI
II
G
1, 3 and 7 Stage: Filter (bi-directional wave tracking);
1, 3 and 7 Stage: Filter (bi-directional wave tracking);
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
2, 4 and 5 Stage: SurgeLimiter (L-N)
2, 4 and 5 Stage: SurgeLimiter (L-N)
225kA (8x20
225kA (8x20
s); 32kA (10/350
s); 32kA (10/350
s)
s)
6. Stage: MOSFET Limiter-500A (8x20
6. Stage: MOSFET Limiter-500A (8x20
s)(RT<1ns)
s)(RT<1ns)
8. Stage: Surge Limiter (N-Gnd)
8. Stage: Surge Limiter (N-Gnd)
200kA (8x20
200kA (8x20
s); 30kA (10/350
s); 30kA (10/350
s)
s)
μ μ
μ
μ μ
mark
EP S IGHT ROTECTION TAGES
CLASS I II III++
FAULT
FAULT
CORRECT
CORRECT
CORRECT
CORRECT
Load Rating: 230VAC@ 100A
Type- PI Blue Series
ND
IV,VI
II
G
1, 3 and 7 Stage: Filter (bi-directional wave tracking);
1, 3 and 7 Stage: Filter (bi-directional wave tracking);
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
2, 4 and 5 Stage: SurgeLimiter (L-N)
2, 4 and 5 Stage: SurgeLimiter (L-N)
225kA (8x20
225kA (8x20
s); 32kA (10/350
s); 32kA (10/350
s)
s)
6. Stage: MOSFET Limiter-500A (8x20
6. Stage: MOSFET Limiter-500A (8x20
s)(RT<1ns)
s)(RT<1ns)
8. Stage: Surge Limiter (N-Gnd)
8. Stage: Surge Limiter (N-Gnd)
200kA (8x20
200kA (8x20
s); 30kA (10/350
s); 30kA (10/350
s)
s)
μ μ
μ
μ μ
mark
EP S IGHT ROTECTION TAGES
CLASS I II III++
FAULT
FAULT
CORRECT
CORRECT
CORRECT
CORRECT
Load Rating: 230VAC@ 100A
Type- PI Blue Series
ND
IV,VI
II
G
1, 3 and 7 Stage: Filter (bi-directional wave tracking);
1, 3 and 7 Stage: Filter (bi-directional wave tracking);
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
2, 4 and 5 Stage: SurgeLimiter (L-N)
2, 4 and 5 Stage: SurgeLimiter (L-N)
225kA (8x20
225kA (8x20
s); 32kA (10/350
s); 32kA (10/350
s)
s)
6. Stage: MOSFET Limiter-500A (8x20
6. Stage: MOSFET Limiter-500A (8x20
s)(RT<1ns)
s)(RT<1ns)
8. Stage: Surge Limiter (N-Gnd)
8. Stage: Surge Limiter (N-Gnd)
200kA (8x20
200kA (8x20
s); 30kA (10/350
s); 30kA (10/350
s)
s)
μ μ
μ
μ μ
mark
EP S IGHT ROTECTION TAGES
CLASS I II III++
FAULT
FAULT
CORRECT
CORRECT
CORRECT
CORRECT
Load Rating: 230VAC@ 100A
Type- PI Blue Series
NG
OUT
NG
IN
L
IN
L
PARALLEL
L
PARALLEL
L
OUT
L
IN
L
PARALLEL
L
PARALLEL
L
OUT
L
IN
L
PARALLEL
L
PARALLEL
L
OUT
Series
ACDC SURGE PROTECTOR
Red
MULTI-STAGE
SURGE
PROTECTION
Series
ACDC SURGE PROTECTOR
Red
MULTI-STAGE
SURGE
PROTECTION
Series
ACDC SURGE PROTECTOR
Red
MULTI-STAGE
SURGE
PROTECTION
Ground Rail
- PARALLEL - Three Phase Installation (for current > 100A per phase)
Ground Rail
Installation Instruction for Type - PI (780; 7100; 7125; 7200) 3/3 - M - RS
IN
OUT
NG
OUT
NG
IN
IN
OUT
NG
OUT
NG
IN
IN
OUT
L3
N
PE
L2
L1 Fuse
Fuse
Fuse
Series
ACDC SURGE PROTECTOR
Red
MULTI-STAGE
SURGE
PROTECTION
CLASS I II III++
N
IN
N
IN
1, 3, 7 and 8 Stage: Filter (bi-directional wave tracking);
1, 3, 7 and 8 Stage: Filter (bi-directional wave tracking);
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
2, 4 and 5 Stage: SurgeLimiter (L-N)
2, 4 and 5 Stage: SurgeLimiter (L-N)
150kA (8x20
150kA (8x20
s); 22kA (10/350
s); 22kA (10/350
s)
s)
6. Stage: MOSFET Limiter-500A (8x20
6. Stage: MOSFET Limiter-500A (8x20
s)(RT<1ns)
s)(RT<1ns)
9. Stage: Surge Limiter (N-Gnd)
9. Stage: Surge Limiter (N-Gnd)
125kA (8x20
125kA (8x20
s); 20kA (10/350
s); 20kA (10/350
s)
s)
μ μ
μ
μ μ
NP S INE ROTECTION TAGES
Load Rating: 230VAC@ 100A
Type- PI Red Series
LL
ININ
N
OUT
N
OUT
PARALLELPARALLEL
LL
PARALLEL
G
PARALLEL
G
mark
LL
ININ
G
ND
FAULT
L
G
L
G
II
CORRECT
OUT
OUT
OUT
OUT
IV,VI
CORRECT
Series
ACDC SURGE PROTECTOR
Red
MULTI-STAGE
SURGE
PROTECTION
CLASS I II III++
1, 3, 7 and 8 Stage: Filter (bi-directional wave tracking);
1, 3, 7 and 8 Stage: Filter (bi-directional wave tracking);
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
2, 4 and 5 Stage: SurgeLimiter (L-N)
2, 4 and 5 Stage: SurgeLimiter (L-N)
150kA (8x20
150kA (8x20
s); 22kA (10/350
s); 22kA (10/350
s)
s)
6. Stage: MOSFET Limiter-500A (8x20
6. Stage: MOSFET Limiter-500A (8x20
s)(RT<1ns)
s)(RT<1ns)
9. Stage: Surge Limiter (N-Gnd)
9. Stage: Surge Limiter (N-Gnd)
125kA (8x20
125kA (8x20
s); 20kA (10/350
s); 20kA (10/350
s)
s)
μ μ
μ
μ μ
NP S INE ROTECTION TAGES
Load Rating: 230VAC@ 100A
Type- PI Red Series
L
N
IN
L
N
IN
ININ
PARALLEL
N
OUT
PARALLEL
N
OUT
LL
mark
PARALLEL
G
PARALLEL
G
LL
ININ
G
ND
FAULT
L
G
L
G
II
CORRECT
IV,VI
OUT
OUT
OUT
OUT
CORRECT
Series
ACDC SURGE PROTECTOR
Red
MULTI-STAGE
SURGE
PROTECTION
CLASS I II III++
N
IN
N
IN
1, 3, 7 and 8 Stage: Filter (bi-directional wave tracking);
1, 3, 7 and 8 Stage: Filter (bi-directional wave tracking);
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
2, 4 and 5 Stage: SurgeLimiter (L-N)
2, 4 and 5 Stage: SurgeLimiter (L-N)
150kA (8x20
150kA (8x20
s); 22kA (10/350
s); 22kA (10/350
s)
s)
6. Stage: MOSFET Limiter-500A (8x20
6. Stage: MOSFET Limiter-500A (8x20
s)(RT<1ns)
s)(RT<1ns)
9. Stage: Surge Limiter (N-Gnd)
9. Stage: Surge Limiter (N-Gnd)
125kA (8x20
125kA (8x20
s); 20kA (10/350
s); 20kA (10/350
s)
s)
μ μ
μ
μ μ
NP S INE ROTECTION TAGES
Load Rating: 230VAC@ 100A
Type- PI Red Series
LL
ININ
PARALLEL
N
OUT
PARALLEL
N
OUT
LL
PARALLEL
G
PARALLEL
G
mark
LL
ININ
G
FAULT
ND
L
G
L
G
II
CORRECT
OUT
OUT
OUT
OUT
IV,VI
CORRECT
Installation Instruction Output Ground Rail
L1IN L1OUT L2IN L2OUT L3IN L3OUT
N
Input Ground Rail
- SERIES - Three Phase Installation with phase (L), neutral (N) and ground (GND) filtering
N
ND
IV,VI
II
G
1, 3 and 7 Stage: Filter (bi-directional wave tracking);
1, 3 and 7 Stage: Filter (bi-directional wave tracking);
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
2, 4 and 5 Stage: SurgeLimiter (L-N)
2, 4 and 5 Stage: SurgeLimiter (L-N)
225kA (8x20
225kA (8x20
s); 32kA (10/350
s); 32kA (10/350
s)
s)
6. Stage: MOSFET Limiter-500A (8x20
6. Stage: MOSFET Limiter-500A (8x20
s)(RT<1ns)
s)(RT<1ns)
8. Stage: Surge Limiter (N-Gnd)
8. Stage: Surge Limiter (N-Gnd)
200kA (8x20
200kA (8x20
s); 30kA (10/350
s); 30kA (10/350
s)
s)
μ μ
μ
μ μ
mark
EP S IGHT ROTECTION TAGES
CLASS I II III++
FAULT
FAULT
CORRECT
CORRECT
CORRECT
CORRECT
Load Rating: 230VAC@ 100A
Type- PI Blue Series
ND
IV,VI
II
G
1, 3 and 7 Stage: Filter (bi-directional wave tracking);
1, 3 and 7 Stage: Filter (bi-directional wave tracking);
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
2, 4 and 5 Stage: SurgeLimiter (L-N)
2, 4 and 5 Stage: SurgeLimiter (L-N)
225kA (8x20
225kA (8x20
s); 32kA (10/350
s); 32kA (10/350
s)
s)
6. Stage: MOSFET Limiter-500A (8x20
6. Stage: MOSFET Limiter-500A (8x20
s)(RT<1ns)
s)(RT<1ns)
8. Stage: Surge Limiter (N-Gnd)
8. Stage: Surge Limiter (N-Gnd)
200kA (8x20
200kA (8x20
s); 30kA (10/350
s); 30kA (10/350
s)
s)
μ μ
μ
μ μ
mark
EP S IGHT ROTECTION TAGES
CLASS I II III++
FAULT
FAULT
CORRECT
CORRECT
CORRECT
CORRECT
Load Rating: 230VAC@ 100A
Type- PI Blue Series
ND
IV,VI
II
G
1, 3 and 7 Stage: Filter (bi-directional wave tracking);
1, 3 and 7 Stage: Filter (bi-directional wave tracking);
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
2, 4 and 5 Stage: SurgeLimiter (L-N)
2, 4 and 5 Stage: SurgeLimiter (L-N)
225kA (8x20
225kA (8x20
s); 32kA (10/350
s); 32kA (10/350
s)
s)
6. Stage: MOSFET Limiter-500A (8x20
6. Stage: MOSFET Limiter-500A (8x20
s)(RT<1ns)
s)(RT<1ns)
8. Stage: Surge Limiter (N-Gnd)
8. Stage: Surge Limiter (N-Gnd)
200kA (8x20
200kA (8x20
s); 30kA (10/350
s); 30kA (10/350
s)
s)
μ μ
μ
μ μ
mark
EP S IGHT ROTECTION TAGES
CLASS I II III++
FAULT
FAULT
CORRECT
CORRECT
CORRECT
CORRECT
Load Rating: 230VAC@ 100A
Type- PI Blue Series
NG
OUT
NG
IN
L
IN
L
PARALLEL
L
PARALLEL
L
OUT
L
IN
L
PARALLEL
L
PARALLEL
L
OUT
L
IN
L
PARALLEL
L
PARALLEL
L
OUT
Series
ACDC SURGE PROTECTOR
Red
MULTI-STAGE
SURGE
PROTECTION
Series
ACDC SURGE PROTECTOR
Red
MULTI-STAGE
SURGE
PROTECTION
Series
ACDC SURGE PROTECTOR
Red
MULTI-STAGE
SURGE
PROTECTION
IN
OUT
NG
OUT
NG
IN
IN
OUT
NG
OUT
NG
IN
IN
OUT
L3
N
PE
L2
L1 Fuse
Fuse
Fuse
Series
ACDC SURGE PROTECTOR
Red
MULTI-STAGE
SURGE
PROTECTION
CLASS I II III++
N
IN
N
IN
1, 3, 7 and 8 Stage: Filter (bi-directional wave tracking);
1, 3, 7 and 8 Stage: Filter (bi-directional wave tracking);
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
2, 4 and 5 Stage: SurgeLimiter (L-N)
2, 4 and 5 Stage: SurgeLimiter (L-N)
150kA (8x20
150kA (8x20
s); 22kA (10/350
s); 22kA (10/350
s)
s)
6. Stage: MOSFET Limiter-500A (8x20
6. Stage: MOSFET Limiter-500A (8x20
s)(RT<1ns)
s)(RT<1ns)
9. Stage: Surge Limiter (N-Gnd)
9. Stage: Surge Limiter (N-Gnd)
125kA (8x20
125kA (8x20
s); 20kA (10/350
s); 20kA (10/350
s)
s)
μ μ
μ
μ μ
NP S INE ROTECTION TAGES
Load Rating: 230VAC@ 100A
Type- PI Red Series
LL
ININ
N
OUT
N
OUT
PARALLELPARALLEL
LL
PARALLEL
G
PARALLEL
G
mark
LL
ININ
G
FAULT
ND
L
G
L
G
II
CORRECT
OUT
OUT
OUT
OUT
IV,VI
CORRECT
Series
ACDC SURGE PROTECTOR
Red
MULTI-STAGE
SURGE
PROTECTION
CLASS I II III++
1, 3, 7 and 8 Stage: Filter (bi-directional wave tracking);
1, 3, 7 and 8 Stage: Filter (bi-directional wave tracking);
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
2, 4 and 5 Stage: SurgeLimiter (L-N)
2, 4 and 5 Stage: SurgeLimiter (L-N)
150kA (8x20
150kA (8x20
s); 22kA (10/350
s); 22kA (10/350
s)
s)
6. Stage: MOSFET Limiter-500A (8x20
6. Stage: MOSFET Limiter-500A (8x20
s)(RT<1ns)
s)(RT<1ns)
9. Stage: Surge Limiter (N-Gnd)
9. Stage: Surge Limiter (N-Gnd)
125kA (8x20
125kA (8x20
s); 20kA (10/350
s); 20kA (10/350
s)
s)
μ μ
μ
μ μ
NP S INE ROTECTION TAGES
Load Rating: 230VAC@ 100A
Type- PI Red Series
L
N
IN
L
N
IN
ININ
PARALLEL
N
OUT
PARALLEL
N
OUT
LL
mark
PARALLEL
G
PARALLEL
G
LL
ININ
G
ND
FAULT
L
G
L
G
II
CORRECT
IV,VI
OUT
OUT
OUT
OUT
CORRECT
Series
ACDC SURGE PROTECTOR
Red
MULTI-STAGE
SURGE
PROTECTION
CLASS I II III++
N
IN
N
IN
1, 3, 7 and 8 Stage: Filter (bi-directional wave tracking);
1, 3, 7 and 8 Stage: Filter (bi-directional wave tracking);
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
2, 4 and 5 Stage: SurgeLimiter (L-N)
2, 4 and 5 Stage: SurgeLimiter (L-N)
150kA (8x20
150kA (8x20
s); 22kA (10/350
s); 22kA (10/350
s)
s)
6. Stage: MOSFET Limiter-500A (8x20
6. Stage: MOSFET Limiter-500A (8x20
s)(RT<1ns)
s)(RT<1ns)
9. Stage: Surge Limiter (N-Gnd)
9. Stage: Surge Limiter (N-Gnd)
125kA (8x20
125kA (8x20
s); 20kA (10/350
s); 20kA (10/350
s)
s)
μ μ
μ
μ μ
NP S INE ROTECTION TAGES
Load Rating: 230VAC@ 100A
Type- PI Red Series
LL
ININ
PARALLEL
N
OUT
PARALLEL
N
OUT
LL
PARALLEL
G
PARALLEL
G
mark
LL
ININ
G
FAULT
ND
L
G
L
G
II
CORRECT
OUT
OUT
OUT
OUT
IV,VI
CORRECT
Installation Instruction Ground Rail
L1IN L1OUT L2IN L2OUT L3IN L3OUT
- SERIES - Three Phase Installation with phase (L) and neutral (N) and without ground filtering
Ground Rail
NN
ND
IV,VI
II
G
1, 3 and 7 Stage: Filter (bi-directional wave tracking);
1, 3 and 7 Stage: Filter (bi-directional wave tracking);
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
2, 4 and 5 Stage: SurgeLimiter (L-N)
2, 4 and 5 Stage: SurgeLimiter (L-N)
225kA (8x20
225kA (8x20
s); 32kA (10/350
s); 32kA (10/350
s)
s)
6. Stage: MOSFET Limiter-500A (8x20
6. Stage: MOSFET Limiter-500A (8x20
s)(RT<1ns)
s)(RT<1ns)
8. Stage: Surge Limiter (N-Gnd)
8. Stage: Surge Limiter (N-Gnd)
200kA (8x20
200kA (8x20
s); 30kA (10/350
s); 30kA (10/350
s)
s)
μ μ
μ
μ μ
mark
EP S IGHT ROTECTION TAGES
CLASS I II III++
FAULT
FAULT
CORRECT
CORRECT
CORRECT
CORRECT
Load Rating: 230VAC@ 100A
Type- PI Blue Series
ND
IV,VI
II
G
1, 3 and 7 Stage: Filter (bi-directional wave tracking);
1, 3 and 7 Stage: Filter (bi-directional wave tracking);
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
2, 4 and 5 Stage: SurgeLimiter (L-N)
2, 4 and 5 Stage: SurgeLimiter (L-N)
225kA (8x20
225kA (8x20
s); 32kA (10/350
s); 32kA (10/350
s)
s)
6. Stage: MOSFET Limiter-500A (8x20
6. Stage: MOSFET Limiter-500A (8x20
s)(RT<1ns)
s)(RT<1ns)
8. Stage: Surge Limiter (N-Gnd)
8. Stage: Surge Limiter (N-Gnd)
200kA (8x20
200kA (8x20
s); 30kA (10/350
s); 30kA (10/350
s)
s)
μ μ
μ
μ μ
mark
EP S IGHT ROTECTION TAGES
CLASS I II III++
FAULT
FAULT
CORRECT
CORRECT
CORRECT
CORRECT
Load Rating: 230VAC@ 100A
Type- PI Blue Series
ND
IV,VI
II
G
1, 3 and 7 Stage: Filter (bi-directional wave tracking);
1, 3 and 7 Stage: Filter (bi-directional wave tracking);
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
2, 4 and 5 Stage: SurgeLimiter (L-N)
2, 4 and 5 Stage: SurgeLimiter (L-N)
225kA (8x20
225kA (8x20
s); 32kA (10/350
s); 32kA (10/350
s)
s)
6. Stage: MOSFET Limiter-500A (8x20
6. Stage: MOSFET Limiter-500A (8x20
s)(RT<1ns)
s)(RT<1ns)
8. Stage: Surge Limiter (N-Gnd)
8. Stage: Surge Limiter (N-Gnd)
200kA (8x20
200kA (8x20
s); 30kA (10/350
s); 30kA (10/350
s)
s)
μ μ
μ
μ μ
mark
EP S IGHT ROTECTION TAGES
CLASS I II III++
FAULT
FAULT
CORRECT
CORRECT
CORRECT
CORRECT
Load Rating: 230VAC@ 100A
Type- PI Blue Series
NG
OUT
NG
IN
L
IN
L
PARALLEL
L
PARALLEL
L
OUT
L
IN
L
PARALLEL
L
PARALLEL
L
OUT
L
IN
L
PARALLEL
L
PARALLEL
L
OUT
Series
ACDC SURGE PROTECTOR
Red
MULTI-STAGE
SURGE
PROTECTION
Series
ACDC SURGE PROTECTOR
Red
MULTI-STAGE
SURGE
PROTECTION
Series
ACDC SURGE PROTECTOR
Red
MULTI-STAGE
SURGE
PROTECTION
IN
OUT
NG
OUT
NG
IN
IN
OUT
NG
OUT
NG
IN
IN
OUT

Installation Instruction
New materials, New design, New approach to Surge Protection Industry
Sur
Sur eG
MULTI-STAGE SURGE PROTECTION
[email protected]
Installation Instruction for Type - PI (780; 7100; 7125; 7200) 3/3 - M - RS
The Surge Protectors are installed in Metal Distribution board with degree of protection IP54
CAUTION
This equipment must only
be installed and serviced
by qualified electrical
personnel.
Turn off all power
supplying this equipment
before working on or inside
equipment.
During installation into an
electrical system, it must
not be energized until
completely inspection.
.
.
Failure to follow these
instructions will result in
serious injury.
HAZARD OF ELECTRIC
SHOCK, EXPLOSION, OR
ARC FLASH
DANGER

Operation
Diagnostic System
ACDC DCAC Dane Krapcev no.2/1, 1000-Skopje, Macedonia Phone: [phone]; Fax: [phone]
Sur
Sur eG
MULTI-STAGE SURGE PROTECTION
www.acdc-dcac.eu
Every ACDC Surge ProtectorType -PI (740; 780; 7125; 7200) Red Series have free contact alarm as basic option. The alarm is activate in two cases:
1.When some of the protection stages (2, 4 or 6) are damaged or burned and Red Led is ON. Alarm contacts 1-3 are permanently closed.
2. When the ground of the power grid system is not well performed (pour grounding). Alarm contacts1-3 are closing with frequency of 2Hz (0,5s)
Red led is blinking.
Free contacts are on the cover of the protector with contact no. 1 and 3. (see picture)
The contact is a optocoupler with maximum value of voltage 70VDC and current of 10mA. In normal condition it is open.
.
.
13
N.C
+
-
Free Contact Alarm
Series
ACDC SURGE PROTECTOR
Red
MULTI-STAGE
SURGE
PROTECTION
CLASS I II III++
1, 3, 7 and 8 Stage: Filter (bi-directional wave tracking);
1, 3, 7 and 8 Stage: Filter (bi-directional wave tracking);
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
2, 4 and 5 Stage: Surge Limiter (L-N)
2, 4 and 5 Stage: Surge Limiter (L-N)
150kA (8x20
150kA (8x20
s); 22kA (10/350
s); 22kA (10/350
s)
s)
6. Stage: MOSFET Limiter-500A (8x20
6. Stage: MOSFET Limiter-500A (8x20
s)(RT<1ns)
s)(RT<1ns)
9. Stage: Surge Limiter (N-Gnd)
9. Stage: Surge Limiter (N-Gnd)
125kA (8x20
125kA (8x20
s); 20kA (10/350
s); 20kA (10/350
s)
s)
μ μ
μ
μ μ
NP S INE ROTECTION TAGES
Load Rating: 230VAC@ 100A
Type - PI Red Series
L
N
IN
L
N
IN
ININ
PARALLEL
N
OUT
PARALLEL
N
OUT
LL
PARALLEL
G
PARALLEL
G
LL
ININ
ND
G
FAULT
L
G
L
G
II
CORRECT
OUT
OUT
OUT
OUT
IV,VI
CORRECT
Series
ACDC SURGE PROTECTOR
Red
MULTI-STAGE
SURGE
PROTECTION
CLASS I II III++
N
IN
N
IN
1, 3, 7 and 8 Stage: Filter (bi-directional wave tracking);
1, 3, 7 and 8 Stage: Filter (bi-directional wave tracking);
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
2, 4 and 5 Stage: Surge Limiter (L-N)
2, 4 and 5 Stage: Surge Limiter (L-N)
150kA (8x20
150kA (8x20
s); 22kA (10/350
s); 22kA (10/350
s)
s)
6. Stage: MOSFET Limiter-500A (8x20
6. Stage: MOSFET Limiter-500A (8x20
s)(RT<1ns)
s)(RT<1ns)
9. Stage: Surge Limiter (N-Gnd)
9. Stage: Surge Limiter (N-Gnd)
125kA (8x20
125kA (8x20
s); 20kA (10/350
s); 20kA (10/350
s)
s)
μ μ
μ
μ μ
NP S INE ROTECTION TAGES
Load Rating: 230VAC@ 100A
Type - PI Red Series
LL
ININ
N
OUT
N
OUT
PARALLELPARALLEL
LL
PARALLELPARALLEL
GG
LL
ININ
G
ND
FAULT
GG
LL
II
CORRECT
OUTOUT
IV,VI
OUTOUT
CORRECT
Series
ACDC SURGE PROTECTOR
Red
MULTI-STAGE
SURGE
PROTECTION
CLASS I II III++
1, 3, 7 and 8 Stage: Filter (bi-directional wave tracking);
1, 3, 7 and 8 Stage: Filter (bi-directional wave tracking);
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
3dB-3kHz,38dB-100kHz,50dB-300kHz; 50bB-500kHz
2, 4 and 5 Stage: Surge Limiter (L-N)
2, 4 and 5 Stage: Surge Limiter (L-N)
150kA (8x20
150kA (8x20
s); 22kA (10/350
s); 22kA (10/350
s)
s)
6. Stage: MOSFET Limiter-500A (8x20
6. Stage: MOSFET Limiter-500A (8x20
s)(RT<1ns)
s)(RT<1ns)
9. Stage: Surge Limiter (N-Gnd)
9. Stage: Surge Limiter (N-Gnd)
125kA (8x20
125kA (8x20
s); 20kA (10/350
s); 20kA (10/350
s)
s)
μ μ
μ
μ μ
NP S INE ROTECTION TAGES
Load Rating: 230VAC@ 100A
Type - PI Red Series
L
N
IN
L
N
IN
ININ
PARALLEL
N
OUT
PARALLEL
N
OUT
LL
PARALLEL
G
PARALLEL
G
LL
ININ
ND
G
FAULT
L
G
L
G
II
CORRECT
OUT
OUT
OUT
OUT
IV,VI
CORRECT
mark
13
+
-
mark mark
Led Indication for correct stage no. 2,4 and 6. The
.
stages no. 1,3,7 and 8 (high
garde bi-directional filtering) are always in function along with ultimate (5-th)
protection stage
Led Indication for correct stage no. 4,6 and un correct no 2. The
.
stages no. 1,3,7
and 8 (bi-directional filtering) are always in function along with ultimate (5-th)
protection stage
Only stages 1,3,7 and 8 are still in function along with ultimate (5-th) protection
stage.
Led Indication for bed grounding (Low impedance equipotential ground is not
provided)
Normal:
Fault:
Fault:
Fault:
Red Yellow Green
Continuous yellow
and green
Continuous green
Blinking red
Continuous red
Connection for ommon ontact larms c c a
Operation Diagnostic System