airquee Zorb Ball Operating instructions

Page 1of 3
1x
Zorb Ball
IMPORTANT
AS OWNER/OPERATOR IT IS YOUR RESPONSIBILITY TO WRITE AND CARRY OUT
YOUR OWN RISK ASSESSMENT BEFORE ATTEMPTING TO USE THIS PRODUCT.
THIS MANUAL MUST BE READ BEFORE ATTEMPTING TO USE THE PRODUCT.
Site survey:
1. Carry out a survey of the area where the unit will be used, and check for any debris
or obstruction that could harm the product.
2. You should provide an adequate power supply to the fan, this should adhere to
your local power regulations.
3. Check wind speed: It is not allowed to use the product by a higher wind force than
force 5 on the Beaufort scale of 28 - 38 kmph (19-24 mph). Force 5 is a fresh breeze
when small trees in leaf begin to sway.
Included with your unit:
CAUTION! Precautions should be taken during handling and use of the
product to prevent electric shock. The blower requires a suitable 240v
power supply and a Ground Fault Protected Circuit (GFCI). Please
read the manufacturer’s Instruction Manual before using the blower(s).
This inflatable can be set up and packed away by 1 person.
The inflatable
in its bag
Hand Held Fan
Repair Kit

Page 2of 3
Intended use of the product:
One user enters the ball, and he/she must control the
direction and speed of the ball to get over obstacles, to
race against another users or to simply enjoy the
challenging experience of walking inside an inflated ball.
Flat surfaces to be used on:
outdoor: grass, artificial grass, (AstroTurf or similar),
PVC groundsheet
indoor: gym floors, carpet, PVC groundsheet
How not to use it:
Since the Zorb Ball is not equipped with any harness system, it should not be used on any
gradient where the user is not in complete control.
Never obstruct the entrance/exit of the ball.
Surfaces NOT to be used: asphalt, concrete, tarmac sand, gravel, or any other hard surfaces.
Operating guidelines:
Before entering the ball, CLEAR INSTRUCTIONS SHALL BE GIVEN to players on their conduct
during playtime:
- Only allow users in the ball if it is dry and clean. We advise clean the ball regularly by using
antibacterial cleaning products to reduce the risk of any bacterial contamination.
- No one with ANY PRE-EXISTING INJURIES or HEALTH CONCERNS (feel unwell,
recovering from injury/surgery, high blood pressure, epilepsy, heart condition, neck or spinal
injury, in the state of PREGNANCY or UNDER THE INFLUENCE OF PSYCHOTROPHIC
SUBSTANCES may use the unit. Another preexisting conditions would be impaired vision or
just simply acting in a rough, rowdy or aggressive manner. It is at the operator’s discretion to
decide who he/she allows to enter the ball.
- The product to be used only with the supplied fans.
- Always respect the maximum number of users. Do not allow more than 1 user in the ball at
a time.
- The operating area should always be kept clean and free from debris or obstruction.
- The operating area should always be as flat as possible. A slope of more than 5° can be
dangerous to the user.
- Ask the users the remove footwear, eye wear, cell phones, keys, neck wear and/or any sharp
items etc. It is at the operator’s discretion to decide if he/she allows users in the ball. Bear in
mind that body searches, even with the consent of the user, are questionable.
- The product should not be used unsupervised. When unattended, it should be deflated.
- No one over 16stones (approximately 100 kgs) to use the product.
- The Zorb Ball, should always be operated by a competent person.

Page 3of 3
It is recommended that safety signs should be devised and displayed in a prominent position
where users will see them before theyare allowed to use the inflatable unit. Such signage isa useful
reminder for staff too.
For information regarding Inflation/Deflation please see the supplied Sealed Inflatable Products
- User Manual, section “3. Setting up” un page 3.
Enter/exit the Zorb Ball:
Once the Zorb Ball is fully inflated the user can gain access via one of the entrances.
Storing:
Before packing it away make sure the ball is clean and dry. Always store it in a cool and dry place.
ENJOY AND HAVE FUN!
Airquee reserves the right to change the content of this manual without a prior notice to the customer.
The model of your product and the type and number of your inclusions may differ from the one presented in this
manual. All the pictures and drawings contained in this manual are for illustration purposes only.
Version 1.0