Aiwa FR-C200 User manual

SERVICE MANUAL
DATA
RADIO RECEIVER
FR-C200
S/M Code No. 09-012-353-8N1
YZ(B)

-2-
REF. NO PART NO. KANRI DESCRIPTION
NO.
ACCESSORIES/PACKAGE LIST-1/1
1 S0-303-401-000 IB,YZ(EDPHNCZ)C200
1 S0-303-400-000 IB,YZ(EGFSI)C200

-3-
SPECIFICATIONS
•
Design and specifications are subject to change without
notice.

-4-
REF. NO PART NO. KANRI DESCRIPTION
NO. REF. NO PART NO. KANRI DESCRIPTION NO.
ELECTRICAL MAIN PARTS LIST-1/1
IC
S2-522-426-000 IC,KA22426D
DIODE
82-135-799-010 DIODE,1N4148
MAIN C.B
C5 SC-E10-614-280 CAP,E 10UF-10V
C12 87-015-698-080 CAP,E 4.7UF-50V
C14 SC-E10-614-280 CAP,E 10UF-10V
C15 87-015-696-080 CAP,E 2.2UF-50V
C16 87-015-697-080 CAP,E 3.3UF-50V
C19 SC-E10-614-280 CAP,E 10UF-10V
C21 87-A10-189-040 CAP,E 220UF-10V
C23 87-A10-189-040 CAP,E 220UF-10V
CF1 S2-110-011-300 CER,FILTER PFS455A6
CF2 S2-310-012-400 CER,FILTER 10.7MHZ
L2 S1-010-013-500 COIL,AM W/ BAR 10-90MM
L5 S4-010-013-600 COIL,CHOKE 10UH
LED1 S7-010-012-000 LED,4-2MM(RED)
PVC S2-010-010-801 PVC,AM/FM
SP1 S1-010-033-200 SPKR,57MM 8 OHM 1W
SW1 S3-123-004-000 SW,SLD SKL-23D08-G4-NA
SW2 S3-110-014-200 SW,SLD 2P2T
T1 S1-010-012-000 IFT,AM 7.5-7.5-12.5MM
T2 S3-010-011-900 IET,FM 7.5-7.5-12.5MM(GRN)
T3 S1-110-013-800 COIL,OSC AM 7-7-12(RED)
VR1 S1-310-010-800 VR,RTRY 50KA

-5-
WIRING-1/1
123456789101112131415
A
B
C
D
E
F
G
H
I
J
K
L
M
N
O
P
Q
R
S
T
U
NOTE
MAIN C.B (PARTS SIDE)
J1
BAND
1
14
15
VR1 VOL
BATT DC 4.5V
AM (W)
AM (G)
AM (B.R)
L2 (BAR ANT)
RXXX
AM FM
POWER/NOISE
OFF ON CUT
CXXX
LED1 TUNE

-6-
SCHEMATIC DIAGRAM-1/1
MAIN C.B
T1
AM IF ADJ
TC4,L2
AM TRACKING
ADJ
SIGNAL NOTE
SP1
SPEAKER
8 OHM
AM/FM IF POWER IC
TC1,L3
FM TRACKING
ADJ
TC2,L4
FM FREQUENCY
RANGE ADJ
T3,TC3
AM FREQUENCY
RANGE ADJ
T2
FM IF
ADJ
BAND
AM
FM
PVC (TC1-4)
NOISE
J1
PHONE JACK
BATT DC
4.5V
SKL-23D08
SKL-23D08
POWER
OFF
ON
VOL
FM
SPRING
2P2T
IC1 VOLTAGE
CLEAR OFF
GL0306-8ROM
: AM
: FM
TUNE

-7-
IC BLOCK DIAGRAM-1/1
IC, KA22426D

-8-
ELECTRICAL ADJUSTMENT-1/1
< TUNER SECTION >
1. AM IF Adjustment
Settings: • Test point IC1 23PIN
• Adjustment location: T1
T1 ................................................................................ 455kHz
2. AM Frequency Range Adjustment
Settings: • Test point IC1 23PIN
• Adjustment location: TC3, T3
TC3............................................................................. 1635kHz
T3 ................................................................................ 515kHz
3. AM Tracking Adjustment
Settings: • Test point IC1 23PIN
• Adjustment location: TC4, L3
TC4............................................................................. 1400kHz
L2 ................................................................................ 600kHz
4. FM IF Adjustment
Settings: • Test point IC1 23PIN
• Adjustment location: T2
T2 .............................................................................. 10.7MHz
5. FM Frequency Range Adjustment
Settings: • Test point IC1 23PIN
• Adjustment location: TC2, L4
TC2........................................................................... 108.3MHz
L4 .............................................................................. 87.4MHz
6. FM Tracking Adjustment
Settings: • Test point IC1 23PIN
• Adjustment location: TC1, L3
TC1.............................................................................. 108MHz
L3 ................................................................................. 88MHz
L2
5
23
4
166
253
L3
IC1 TC2 TC1
TC3
TC4
23
T2
T1
T3
L4
TEST POINT
MAIN C.B

-9-
MECHANICAL EXPLODED VIEW-1/1
A
A
A
B
1
2
7
3
RIBBON
5
6
89
10
PWB
A
COIL, AM W/BAR
10 11
12
13
14
C
E
F
D
D
15
16
17
18
19
20
22
21
4

-10-
REF. NO PART NO. KANRI DESCRIPTION
NO. REF. NO PART NO. KANRI DESCRIPTION NO.
MECHANICAL PARTS LIST-1/1
1 S0-301-890-000 DOOR,BATT
2 S2-010-012-600 ANT,ROD
3 S0-100-200-000 HAND STRAP
4 S0-801-640-000 LENS,PMMA
5 S0-401-090-000 BATT,PLATE
6 S0-401-080-000 CONTACT TERMINAL
7 S0-201-780-000 CAB,REAR
8 S0-503-800-000 KNOB,VOL
9 S0-402-020-000 BATT,CONTACT(+)
10 S0-900-730-000 BAR,HOLDER P.E
11 S0-202-710-000 BATT,CONTACT(-)B
12 S0-202-700-000 BATT,CONTACT(-)
13 S0-503-780-000 VOL,ADAPTOR
14 S1-701-070-000 PVC GEAR POM
15 S1-701-120-000 TUNE GEAR POM
16 S0-901-530-000 HOLDER POINTER
17 S1-701-060-000 GEAR,POM
18 S0-202-680-000 SPRING ROLL
19 S0-503-770-000 KNOB,TUNE RTRY
20 S0-700-440-000 POINTER DIAL
21 S0-101-800-000 CABI,FRONT
22 S1-010-033-200 SPKR,57MM 8 OHM 1W
A 87-264-074-410 S-SCREW,(B)M2.6-8
B 87-261-072-410 M-SCREW,M2.6-5
C 87-267-532-310 M-SCREW,M1.7-5
D S9-P01-200-610 SCREW,SELF-TAPPING M2.0-6
E 8B-RTF-213-010 W,2.8-7-0.55
F 87-354-553-310 VT2+2-6