Ambiance Fireplaces INTIRGUE UF0110 User manual

Intrigue
Direct Vent Gas Fireplace
MODEL: UF0110
ARCHGARD FIREPLACE PRODUCTS
7116 Beatty Drive
Mission, BC V2V 6B4
Canada
200-U110-03
June 15 2016
English and French Installation Manuals available through your local dealer or visit our website at:
www.archgard.com
Les manuels d'installation en anglais et en français son disponibles chez votre détaillant local ou en visitant notre site web:
www.archgard.com
INSTALLER: LEAVE THIS MANUAL WITH THE APPLIANCE.
CONSUMER: RETAIN THIS MANUAL FOR FUTURE REFERENCE
This appliance may be installed in an aftermarket permanently located, manufactured home (USA only) or mobile home
where not prohibited by local codes.
This appliance is only for use with the type of gas indicated on the rating plate.
This appliance is not convertible for use with other gases, unless a certied kit is used.
WARNING: If the information in these instructions is not followed exactly, a re or explosion may result, causing prop-
erty damage, personal injury or loss of life.
WHAT TO DO IF YOU SMELL GAS:
• Do not light any appliance
• Do not touch any electrical switch: do not use any phone in your building.
• Immediately call your gas supplier from a neighbors phone.
• Follow the gas suppliers instructions.
• If you can not reach your gas supplier, call the re department.
Do not store or use gasoline or other ammable
vapors or liquids in the vicinity of this or any other
appliance.
Installation and service must be performed by a qual-
ied installer, service agency or the gas supplier

2
TABLE OF CONTENTS
RATING PLATE LABEL 3
SAFETY INFORMATON 4
SPECIFICATIONS 6
FIREPLACE DIMENSIONS 6
UF0110 COMPONENTS LIST 7
INSTALLATION OVERVIEW 7
PREPARE THE FIREPLACE 8
󰀨 8
 9
 9
FRAMING 10
 10
 10
 11
 11
 12
 12
TYPICAL INSTALLATION OPTIONS 13
 13
 13
 13
MANTEL REQUIREMENTS 14
 14
GRILL SET 15
 16
 16
 16
UF0110 SAFETY BARRIER 17
GAS LINE CONNECTION 18
 18
VENTING 19
 19
 19
 20
 20
 22
 22
 23
LIGHT INSTALLATION 24
REFLECTIVE PANEL KIT 25
REFRACTORY PANEL KIT 27
MEDIA INSTALLATION 29
 29
 31
WIRING SCHEMATICS 33
PRESSURE TESTING 34
 35
CONTROL SYSTEM COMPONENTS 37
SYSTEM OPERATION 38
 38
 38
 38
󰀨 38
 38
 39
 39
 39
 39
 39
 40
 40
 40
 40

41
LIGHTING AND SHUTDOWN 42
MAINTENANCE 44
 44
Fan 44
 44
 44
 45
 47
BURNER REMOVAL 48
BURNER INSTALLATION 49
 50
CONVERSION KIT INSTRUCTIONS 51
REPLACEMENT PARTS LIST 55
LIMITED WARRANTY 56
LIFETIME WARRANTY 57

3
RATING PLATE LABEL
SAMPLE

4
General Information
SAFETY INFORMATON

 
 
                                                            󰀩               


• 



• 

• 

• 



• 
• 
• 
• 
• 
• 󰀩
• 

• 
• WARNING: DO NOT OPERATE APPLIANCE WITH THE GLASS/FRAME ASSEMBLY REMOVED, CRACKED OR BROKEN.
REPLACEMENT OF THE GLASS SHOULD ONLY BE PERFORMED BY A LICENSED OR QUALIFIED SERVICE PERSON
• DO NOT SUBSTITUTE
ANY MATERIALS
• 
• 
• 
• 
• 


5
General Information
COMMONWEALTH OF MASSACHUSETTS REQUIREMENTS
NOTE:




INSTALLATION OF CARBON MONOXIDE DETECTORS











APPROVED CARBON MONOXIDE DETECTORS


SIGNAGE


GAS VENT DIRECTLY BELOW. KEEP CLEAR OF ALL OBSTRUCTIONS
INSPECTION



EXEMPTIONS




MANUFACTURER REQUIREMENTS - GAS EQUIPMENT VENTING SYSTEM PROVIDED











6
Installation
SPECIFICATIONS
FIREPLACE DIMENSIONS
DESCRIPTION   

 




󰀨

Front









Front to


FIREPLACE
DIMENSIONS INCHES       10   
MILLIMETERS 876 1038 785 493 902 676 254 410 848 210
WARNING
󰀨󰀨
󰀨






7
Installation
UF0110 COMPONENTS LIST
DESCRIPTION

󰀨









NOTE


NOTE




 
 -

 
 
 
 
 
 
 
 

 
 
 
 
PLACEMENT CLEARANCE REQUIREMENTS
• 
• 

• 
• 󰀩
• 
• 
INSTALLATION OVERVIEW

8
Installation
PREPARE THE FIREPLACE
Stand-o󰀨 Assembly & Installation
WARNING
󰀨󰀨
Non-combustible zone:󰀨Use only non-combustible material in
this area for entire width of replace. Do not use wood, sheetrock etc. in this zone.

󰀨󰀨
 󰀨󰀨
 󰀨
 󰀨󰀨󰀨


9
Installation
Horizontal Vent Heat Shield Installation
IMPORTANT


 
 

Nailing Flange Assembly & Installation
 
 󰀨

 
 󰀨
NOTE


CAUTION




10
Installation
FRAMING
Wall Enclosure Rough Opening
IMPORTANT


Non –combustible facing material
󰀨
Min. Finished Opening Dimensions

    

    
NOTE



WARNING







11
Installation
Optional Full Door Face Dimensions


NOTE




-
-

Framing





NOTE  

WARNING 

FIRE
HAZARD 
IMPORTANT 
WARNING 

12
Installation
Horizontal Terminations



MINIMUM HORIZONTAL FRAMING DIMENSIONS
 
RIGID PIPE  

FLEX PIPE  

Vertical Terminations



NOTE 
CAUTION - 

CAUTION 󰀩-

HEARTH HEIGHT
WH
B
A

13
Installation
TYPICAL INSTALLATION OPTIONS
IMPORTANT



Typical Horizontal Installation
Typical Corner Installation
Typical Vertical Installation

14
Installation
MANTEL REQUIREMENTS
WARNING 
STAND-OFF BRACKETS ARE NOT LOAD BEARING
Non-Combustible Zone:
Rigid Pipe
Flexible Venting

15
Installation
GRILL SET
Installation
 

 


 





Removal
 

 
 


16
Installation
Remove Glass Frame Assembly
 
 
 
 
PULL OUT AND DOWN TO RELEASE PULL OUT AND UP TO RELEASE
FIREPLACE BOTTOM FIREPLACE TOP
Glass Door Removal and Installation
Install Glass Frame Assembly

 
 

17
Installation
UF0110 SAFETY BARRIER
• REMOVE TOP LOUVER AND HOOD
• OPEN BOTTOM LOUVERS
• UNDO TOP & BOTTOM DOOR LATCHES
• REMOVE SCREEN
TO REINSTALL THE BARRIER SCREEN, REVERSE THE STEPS FOR REMOVAL.
NOTE:
WARNING
DOOR MUST BE INSTALLED PRIOR TO SCREEN
INSTALLATION TO AVOID POSSIBLE DAMAGE OR INJURY.

18
Installation
GAS LINE CONNECTION
Gas Conversion


Note:
Note: 
CAUTION



NOTE
󰀨


󰀨
󰀨

󰀨

󰀨



IMPORTANT 󰀩󰀩

NATURAL GAS LP GAS
  
  
  
  
 #31 #50
  
  
  

19
Installation
VENTING
WARNING  




Approved Venting
• 
• 
• 
• 
• 
• 
• 
Horizontal Terminations
HORIZONTAL VENT SYSTEM CLEARANCES
TOP BOTTOM SIDES
ALLAPPROVED VENTING   
HORIZONTAL MIN. / MAX.


IMPORTANT  

IMPORTANT




ELBOWS



NOTE 

20
Installation
NOTE 
CAUTION 
Vertical Terminations
VERTICAL VENT SYSTEM CLEARANCES
SIDES
ALLAPPROVED
VERTICAL VENTING 






RESTRICTOR SETTING

󰀨




IMPORTANT  

RECOMMENDED RESTRICTOR SETTINGS
VENTING RESTRICTOR POSITION
 FULL OPEN

 PARTIAL OPEN

 CLOSED

Horizontal Terminations