Amico AG-1500 User manual

CONTENTS
SAFETY INFORMATION
PRE-OPERATION CHECK
STARTING THE ENGINE
STOPPING THE ENGINE
CONNECTION
PERIODIC MAINTENANCE
APPLICATION RANGE
TROUBLESHOOTING
SPECIFICATIONS
DETAIL DIAGRAM
CYLINDER AND CYLINDER HEAD AND MUFFLER ASSEMBLY
PANELAND CARBURETOR ASSEMBLY
STARTER AND IGNITION ASSEMBLY
CRANK AND CONNECTING ROD AND PISTON ASSEMBLY
FUEL TANK ASSEMBLY
ALTERNATOR ASSEMBLY
WIRING DIAGRAM
LIMITED WARRANTY
PRODUCT REGISTRATION CARD
1
3
5
7
8
10
15
16
18
19
22
24
26
28
30
31
32
33
34
35
CALIFORNIAAND FEDERAL EMISSION
CONTROL WARRANTY STATEMENT

1.SAFETY INFORMATION
EXHAUST FUMES ARE POISONOUS
Never operate engine indoors
FUEL IS HIGHLY FLAMMABLE.
Stop engine when refuelling.
No Smoking while refuelling.
Take care not to spill fuel.
Never operate in wet weather conditions.
Never place near inflammables.
Never touch with wet hands.
1

Ground (earth ) generator.
DO NOT connect to commercial
power outlet.
DO NOT connect to another
generator.
2

2.PRE-OPERATION CHECK
Fuel tank capacity:4L
Use oil-mixed petrol
Do not make fuel reach the top of fuel filter.
How to make mixed petrol:
Petrol and oil mixing
Ratio:50:1
3

Use fuel tank cap to measure as:
1.(L):0.02 (L)
2.(L):0.04 (L)
3.(L):0.06 (L)
4.(L):0.08 (L)
Shake fuel tank before starting.
4

Before starting,DO NOT connect
with any electrical appliance.
3.STARTING THE ENGINE
1.Turn fuel lever to "ON" position.
2.Turn choke lever to "1"
AC OUT
1
"ON"
5

3.Turn engine switch to "ON"
4.Pull slowy on recoil starteruntil engaged,then
pull it briskly.
5. Return choke lever.
"ON"
6

4.STOPPING THE ENGINE.
Before stopping, turn off all electrical appliance.
1.Turn engine switch to"stop"
2.Turn fuel lever to "OFF" position.
AC OUT
"OFF"
"STOP"
7

5.CONNECTION.
1.WIND LEAD 2 OR 3 TURNS AROUND
THE HANDLE
2.Start engine.
3.Plug into AC socket.
Battery charger (if equipped)
Connect red lead (provided as accessory)
To positive pole (+) ,and black to negative pole (-)
AC OUT
8

SAFETY DEVICES
Press to reset AC or DC protector.
Reduce load under the top limit of rated output.
If AC or DC protector (if equipped) turns off.
RESET
OFF
RESET
OFF
1
2
1
2
"On"
"Off"
9

6.PERIODIC MAINTENANCE
ITEM
Spark plug
Air filter
Fuel filter
Carbon Deposits
REMARKS Every 50hrs
Or
Every month
Every 150hrs
Or
Every 3 month
Remove carbon
Adjust gap.
Replace if necessary.
CLEAN
Replace if necessary.
CLEAN
Replace if necessary.
CLEAN
Replace the related
part if necessary.
10

SPARK PLUG
1.Remove spark plug.
2.Remove carbon deposits.
3.Check for discolouration.
Standard:Tan colour.
4.Check spark plug gap.
0.7~0.8mm (0.028~0.031)
11

AIR FILTER
1. Air filter
2.Wash in solvent.
3.Motor oil (SEA#20)
4.Squeeze out.
1
3
2
4
Never run engine without the filter element.
12

FUEL FILTER
1.Stop engine.
2.Turn fuel lever to "OFF"
3.Clean with solvent.
13

1.Clean in solvent.
2.Wipe off.
3.Insert.
3
2
1
14

7.APPLICATION RANGE
AG-1500
~900W
~670W
~790W
Power factor
1
0.7~0.8
0.7~0.95
Max chargeable
batterycapacity:
40A.h
Appliance
If DC output is equipped
AC
DC 12V/8.3A
15

8.TROUBLESHOOTING
ENGINE WON'T START
1.Check fuel.
(Fuel switch to "ON")
2.Engine switch to "ON"
3.Check spark plug
"ON"
"ON"
16

If engine still won't start-
Check the following:
1.Fuel cock clogging
2.Air filter clogging
Or consult with your dealer.
17

9.SPECIFICATIONS
AC Output Unit
Rated Voltage V
Frequency Hz
AC Current A
Rated Output VA
Maximum Output VA
Operation hours Hr
AG-1500
120
60
8.3
1000
1200
3
18