amsbio CoolCLAVE E300110 User manual

Personal Sterilizer
INTRODUCTION
CoolCLAVE™ is a unique and innovative bench top sterilizer available from AMSBIO. It uses ozone as to clean* laboratory tools, especially ones
involved in sensitive experiments or assays. It is effective in keepin sterile, or sterilizin li htly contaminated pipettes, pipette tips, loves, plates,
small instruments, and even personal items such as keys and lasses. To sterilize items, simply place them inside the CoolCLAVE Sterilizer and
press START. The anti-microbial properties of ozone provide a powerful sanitizin effect that is capable of killin more than 98% of common
patho enic or anisms (bacteria, fun us, virus, etc.) in 8 minutes*. The antimicrobial properties of ozone also eliminates the odors produced by these
or anisms providin a deodorizin effect as well. Best of all, the CoolCLAVE sterilizer is very safe and efficient, does not use any liquids, harmful UV
rays, harsh chemicals, or heat, and does not dama e any surfaces or leaves any chemical residues behind.
*Note and Disclaimer: CoolCLAVE Personal Sterilizer is not a replacement or substitute for autoclaves, under no circumstance should
it be used to sterilize equipment for use in medical or surgical applications of any kind. The CoolCLAVE sterilizing cycles can eliminate
most surface contaminants, especially bacterial and fungal, but only at lower densities that are typical in normal operating
environments, such a lab benches or general surfaces. makes no claims and does not offers guarantees of any kind that a
CoolCLAVE cycle(s) will eliminate 100% of all contaminants under all possible circumstances.
PRECAUTIONS
(a) Read all instructions before using the a liance. Use this a liance only for its intended use as described in this manual.
(b) This appliance must be used ONLY with the provided power supply; do not use any substitutes to avoid dama e to unit.
(c) Do not attempt to operate the CoolCLAVE with the door open. Do not tamper with the door seal or latch mechanism.
(d) The CoolCLAVE unit emits small amounts of O3 ases. Even thou h small ozone emissions are not considered hazardous, we recommend
users avoid inhalin the ases that emanate from the CoolCLAVE after openin the door upon completion of sterilization cycle(s).
(e) Do not operate this appliance if it has a dama ed cord or plu , if it is not workin properly, or if it has been dama ed or dropped.
(f) Do not store this appliance outdoors, or use it near water– for example near sinks or water baths.
( ) Do not immerse cord or plu in water; keep cord away from heated surfaces.
(h) Do not attempt to repair or open the unit unless you are a qualified repair technician.
SPECIFICATIONS
Electricity DC 12V / 550 mA
Dimensions (Width x Depth x Hei ht) 12 ⅝ x 14 ¾ x 9⅞ (320 x 375 x 250 mm)
Wei ht 14.1 lbs. (6.4 k .)
Technolo y Ozone as
Operatin cycle 8 minutes (repeat as needed)
Warranty 1 year
Catalog # Descri tion/Content Amount
E300110 Personal Sterilizer, 110V 1 Unit
E300220 Personal Sterilizer, 220V 1 Unit
Shi ing and
Storage:
CoolCLAVE is shipped at room temperature. Store on a
lab bench away from water and heat sources.
Related Products Catalog #
BioCooler™ Cold Box, 48 x 1.5 ml tubes E100100
BioCooler™ Cell Stora e Box, 42 x 2.0 ml cryo enic tubes E100200
Mini BioCooler™ Cold Box, 8 x 1.5 ml tubes E100300
BioCooler Midi Cold Box, 12 x 2.0 ml tubes E100500
Dr. Spin Personal Centrifu e-Blue E200100
Dr. Spin Personal Centrifu e-Teal E200200
Dr. Spin Personal Centrifu e-Purple E200300
AMSBIO

CoolCLAVE™ Personal Sterilizer, Manual
OPERATION
1. Plu power supply into wall outlet and connect it to the CoolCLAVE™ unit on the backside.
2. Open the door and put the objects you want to sterilize inside the unit. You can stack or put as many tools as you need, but do not overload
unit so sterilizin can be effective.
NOTE: because the CoolCLAVE uses ozone as, you are able to safely and effectively sterilize the surfaces of most types of materials such as
plastics, metals, paper products, pipet tip boxes, and even a ar plates. On the other hand, the CoolCLAVE is not able to sterilize liquids or
solutions.
3. Close the CoolCLAVE door and press the “Start” button on the face of the unit.
a. For each press of the Start button, the CoolCLAVE will run an 8 minute sterilizin cycle.
b. The reen li ht bar next to the Start button will visually indicate the time left for each 8 minute cycle.
c. An 8 minute cycle is typically sufficient for a few li htly contaminated items. For heavier loads or further cleanin , press the Start button
a ain to start another 8 minute cycle. It is recommended that in eneral you run the CoolCLAVE 2-3 cycles for the best cleanin
effectiveness.
d. Durin operation internal LED li hts will flash and chan e color to show that the unit is in workin mode.
e. If durin an operatin cycle you open the CoolCLAVE door, the unit will stop workin . Pressin the Start button a ain, after closin door,
will restart the 8 minute cycle from the be innin .
MAINTENANCE
(a) The CoolCLAVE has a small filter cartrid e that needs occasional cleanin every 3 months. The cartrid e is located on the inside of
the unit, towards the back ri ht side. Remove the cartrid e by slidin it out of its holdin ca e and clean it by usin air un or vacuum
cleaner to remove dust particles. Avoid dama in the cartrid e’s fabric cover by usin moderate air pressure or a soft vacuum brush
head. Alternatively, you may just shake the dust off of the filter in an outdoor area, or use a dry soft brush to remove dust and particles.
(b) Keep you CoolCLAVE unit clean at all times by wipin the interior and exterior surfaces with a moist towel. To avoid dama in the
unit, do not use any deter ents or solvents.
(c) Unplu the power supply from the wall outlet when the CoolCLAVE is in stora e or will not be used for extend periods of time.
(d) Avoid obstructin the back of the unit by leavin a space of about 2 inches between it and a wall surface.
(e) Avoid dama in the unit by puttin heavy objects on top of it.
The purchase price paid for the CoolCLAVE™ rants end users a non-transferable, non-exclusive license to use the unit in a research
laboratory setting, and for sterilizing ur oses only as described in this manual. This use license excludes and without limitation, resale,
repacka in , or modification of the unit in any way and without prior notification of and approval by Genlantis.
Under no circumstances shall the CoolCLAVE unit be used on food or drink products intended for human or animal consum tion. At all
times, care and attention should be exercised in handlin and usin the CoolCLAVE unit by followin the instructions in the manual, usin
common sense lab practices, and wearin protective lab clothin and eyewear.
Purchasers may refuse this license by returnin the CoolCLAVE unit unused and its ori inal packa in . By keepin or usin the CoolCLAVE
unit, you a ree to be bound by the terms of this license. The laws of the State of California shall overn the interpretation and enforcement of
the terms of this license.