APURO CJ558-A User manual

Model:
CJ558-A / CJ559-A
Pie Cabinet
Instruction manual
CJ558-A_CJ559-A_A5_v1_20230621.indb 1CJ558-A_CJ559-A_A5_v1_20230621.indb 1 2023/6/21 17:372023/6/21 17:37

2
EN Telephone Helpline: 1300225960
Safety Instructions
• Position on a flat, stable surface.
• A service agent/qualified technician should carry out
installation and any repairs if required. Do not remove any
components on this product.
• Consult Local and National Standards to comply with the
following:
- Health and Safety at Work Legislation
- Fire Precautions
- IEE Wiring Regulations
- Building Regulations
• DO NOT move or carry when the appliance is switched on.
• DO NOT immerse the appliance in water.
• DO NOT clean with jet/pressure washers.
• DO NOT obstruct or cover the appliance in any way when in
use.
• Always allow the Pie Warmer to cool down before cleaning,
maintaining or moving to avoid the risk of burns.
• DO NOT use the appliance for anything other than its intended
use.
• Not suitable for outdoor use.
• Always switch off and disconnect the power supply to the
appliance before cleaning.
• This appliance must only be used in accordance with these
instructions and by persons competent to do so.
• Keep all packaging away from children. Dispose of the
packaging in accordance to the regulations of local authorities.
CJ558-A_CJ559-A_A5_v1_20230621.indb 2CJ558-A_CJ559-A_A5_v1_20230621.indb 2 2023/6/21 17:372023/6/21 17:37

3
EN
Telephone Helpline: 1300225960
• If the power cord is damaged, it must be replaced by an
Apuro agent or a recommended qualified technician in order
to avoid a hazard.
• This appliance is not intended for use by persons (including
children) with reduced physical, sensory or mental capabilities,
or lack of experience or knowledge, unless they have been
given supervision or instruction concerning the use of the
appliance by a person responsible for their safety.
• Children should be supervised to ensure that they do not play
with the appliance.
• Apuro recommend that this appliance should be periodically
tested (at least annually) by a Competent Person. Testing
should include, but not be limited to: Visual Inspection,
Polarity Test, Earth Continuity, Insulation Continuity and
Functional Testing.
Introduction
Please take a few moments to carefully read through this manual. Correct maintenance and operation of
this machine will provide the best possible performance from your Apuro product.
Pack Contents
The following is included:
• Pie Warmer
• Sliding glass door x 2
• Glass display panel
• Wire rack x 3
• Element Guard
• Water tray
• Instruction manual
Apuro prides itself on quality and service, ensuring that at the time of packaging the contents are
supplied fully functional and free of damage.
Should you find any damage as a result of transit, please contact your Apuro dealer immediately.
CJ558-A_CJ559-A_A5_v1_20230621.indb 3CJ558-A_CJ559-A_A5_v1_20230621.indb 3 2023/6/21 17:372023/6/21 17:37

4
EN Telephone Helpline: 1300225960
Installation
To install the Pie Warmer:
1. Remove the appliance from the packaging. Make sure that all protective plastic film and coatings are
thoroughly removed from its surfaces.
2. Take the glass display panel and raise it at an angle into the upper track at the rear of the unit [Fig. 1].
3. Once at the top of the track, position the bottom of the glass above the lower track [Fig. 2].
4. Carefully lower the glass into the bottom track [Fig. 3].
5. Insert the two sliding door panels in the same manner as the display panel. Ensure the handles are
located towards the outside edges of the appliance [Fig. 4].
Operation
Note:
• This appliance is for maintaining temperature only. It is NOT suitable for
cooking products or heating products from cold.
• This appliance is intended to be used for commercial applications, for
example in kitchens of restaurants, canteens, hospitals and in commercial
enterprises such as bakeries, butcheries, etc., but not for continuous mass
production of food.
1. Add water to the water tray.
2. Connect the appliance to the mains power supply and turn on the ON/OFF switch (‘I” position).
3. Set the thermostat to the desired temperature.
4. The unit will cycle on and off to maintain the set temperature.
The green indicator light and the interior lamp will turn on when the unit is switched on.
The green indicator light will turn off when the desired temperature has been reached.
Note: The appliance has a maximum temperature setting of 90°C.
CJ558-A_CJ559-A_A5_v1_20230621.indb 4CJ558-A_CJ559-A_A5_v1_20230621.indb 4 2023/6/21 17:372023/6/21 17:37

5
EN
Telephone Helpline: 1300225960
Cleaning, Care & Maintenance
Warning:
Always turn off and disconnect the appliance from the power supply before
cleaning.
Always allow the appliance to cool before cleaning.
• Clean the interior of the appliance as often as possible.
• Do not use abrasive cleaning agents. These can leave harmful residues.
• For stains on the interior walls, wipe with a cloth damped with some mild soapy solution. Ensure no
moisture enters the inside of the cabinet.
• Always wipe dry after cleaning.
Cleaning the wire racks
• After use, remove the wire racks from the appliance for cleaning.
• Clean using warm, soapy water. Rinse thoroughly and dry well.
• Re-locate into the appliance.
Water tray
• Periodically remove the water tray and empty.
• Re-locate into the appliance.
WARNING: DO NOT remove the tray during or immediately after use as it is still
hot.
Troubleshooting
A qualified technician must carry out repairs if required.
Fault Probable Cause Solution
Appliance not
working
The unit is not switched on Check the unit is plugged in correctly and switched
on
Plug or lead is damaged Replace plug or lead
Mains power supply fault Check mains power supply
Appliance heats up
but indicator light
does not come on
Indicator light is faulty Consult a qualified Technician
Unit not heating up
or heats up slowly
and the indicator
light is On
Incorrect operation Ensure:
• thermostat has been set correctly
• doors are closed
• thermostat sensor bulb has not been removed
or damaged
Thermostat failure Consult a qualified Technician
Element failure Consult a qualified Technician
CJ558-A_CJ559-A_A5_v1_20230621.indb 5CJ558-A_CJ559-A_A5_v1_20230621.indb 5 2023/6/21 17:372023/6/21 17:37

6
EN Telephone Helpline: 1300225960
Technical Specifications
Note: Due to our continuing program of research and development, the specifications herein may be
subject to change without notice.
Model Voltage Power Dimensions
H x W x D mm
Net
Weight
Approx. pie
capacity
Temperature
Range
CJ558-A 220-240V~,
50Hz
350W 465 x 470 x 370 14kg 30 30°C - 90°C
CJ559-A 700W 465 x 776 x 370 22kg 60
Electrical Wiring
The plug is to be connected to a suitable mains socket.
This appliance is wired as follows:
• Live wire (coloured brown) to terminal marked L
• Neutral wire (coloured blue) to terminal marked N
• Earth wire (coloured green/yellow) to terminal marked E
This appliance must be earthed.
If in doubt consult a qualified electrician.
Electrical isolation points must be kept clear of any obstructions. In the event of any emergency
disconnection being required they must be readily accessible.
Compliance
The product must not be disposed of as household waste. To help prevent possible harm to human
health and/or the environment, the product must be disposed of in an approved and environmentally safe
recycling process. For further information on how to dispose of this product correctly, contact the product
supplier, or the local authority responsible for waste disposal in your area.
Apuro parts have undergone strict product testing in order to comply with regulatory
standards and specifications set by international, independent, and federal authorities.
Apuro products have been approved to carry the following symbol:
All rights reserved. No part of these instructions may be produced or transmitted in any form or by any means, electronic,
mechanical, photocopying, recording or otherwise, without the prior written permission of Apuro.
Every effort is made to ensure all details are correct at the time of going to press, however, Apuro reserves the right to
change specifications without notice.
CJ558-A_CJ559-A_A5_v1_20230621.indb 6CJ558-A_CJ559-A_A5_v1_20230621.indb 6 2023/6/21 17:372023/6/21 17:37

DECLARATION OF CONFORMITY
• Conformiteitsverklaring • Déclaration de conformité • Konformitätserklärung • Dichiarazione di conformità •
• Declaración de conformidad • Declaração de conformidade
Equipment Type • Uitrustingstype • Type d'équipement • Gerätetyp
• Tipo di apparecchiatura • Tipo de equipo • Tipo de equipamento
Model • Modèle • Modell • Modello
• Modelo • Malli
Pie Cabinet - 30 pie capacity
Pie Cabinet - 60 pie capacity
CJ558-A
CJ559-A
Application of Territory Legislation &
Council Directives(s)
Toepassing van Europese Richtlijn(en)
• Application de la/des directive(s) du
Conseil • Anwendbare EU-Richtlinie(n)
• Applicazione delle Direttive
• Aplicación de la(s) directiva(s) del
consejo • Aplicação de directiva(s) do
Conselho
Electrical Safety
IEC 60335-1:2020
IEC 60335-2-49:2021
Electro-Magnetic Compatibility (EMC)
EN IEC 55014-1:2021
EN IEC 55014-2:2021
EN IEC 61000-3-2: 2019 +A1:2021
EN 61000-3-3: 2013 +A1:2019
Producer Name • Naam fabrikant • Nom du producteur • Name des Herstellers
• Nome del produttore • Nombre del fabricante • Nome do fabricante
Apuro
I, the undersigned, hereby declare that the equipment specified above conforms to the above Territory Legislation, Directive(s)
and Standard(s).
Ik, de ondergetekende, verklaar hierbij dat de hierboven gespecificeerde uitrusting goedgekeurd is volgens de bovenstaande
Richtlijn(en) en Standaard(en).
Je soussigné, confirme la conformité de l'équipement cité dans la présente à la / aux Directive(s) et Norme(s) ci-dessus
Ich, der/die Unterzeichnende, erkläre hiermit, dass das oben angegebene Gerät der/den oben angeführten Richtlinie(n) und
Norm(en) entspricht.
Il sottoscritto dichiara che l'apparecchiatura di sopra specificata è conforme alle Direttive e agli Standard sopra riportati.
El abajo firmante declara por la presente que el equipo arriba especificado está en conformidad con la(s) directiva(s) y
estándar(es) arriba mencionadas.
Eu, o abaixo-assinado, declaro que o equipamento anteriormente especificado está em conformidade com a(s) anterior(es)
Directiva(s) e Norma(s)
Date • Data • Date • Datum • Data •
Fecha • Data
10th March 2023
Signature • Handtekening • Signature
• Unterschrift Firma • Firma •
Assinatura
Full Name • Volledige naam • Nom et
prénom • Vollständiger Name • Nome
completo • Nombre completo • Nome
por extenso
Ashley Hooper
Brendan Denmeade
Position • Functie • Fonction • Position
• Qualifica • Posición • Função
Technical & Quality Manager
Commercial Manager/ Responsible
Supplier
Producer Address • Adres fabrikant •
Adresse du producteur • Anschrift des
Herstellers • Indirizzo del produttore •
Dirección del fabricante • Morada do
fabricante
Fourth Way,
Avonmouth,
Bristol,
BS11 8TB
United Kingdom
15 Bagdally Road,
Campbelltown
NSW 2560
DocuSign Envelope ID: 26A1E332-E621-4C4C-A308-0F24A7C2B7E8
CJ558-A_CJ559-A_A5_v1_20230621.indb 7CJ558-A_CJ559-A_A5_v1_20230621.indb 7 2023/6/21 17:372023/6/21 17:37

CJ558-A_CJ559-A_A5_v1_2023/06/21
CJ558-A_CJ559-A_A5_v1_20230621.indb 8CJ558-A_CJ559-A_A5_v1_20230621.indb 8 2023/6/21 17:372023/6/21 17:37