APURO CP793-A User manual

Model:
CP793-A / CT012-A
Induction
Fryer
Instruction manual
CP793-A_CT012-A_A5_v2_20211220.indb 1CP793-A_CT012-A_A5_v2_20211220.indb 1 2021/12/20 17:222021/12/20 17:22

2
AU Telephone Helpline: 1300225960
Safety Instructions
Please take a few moments to carefully read through this
manual. Correct maintenance and operation of this machine will
provide the best possible performance from your Apuro product.
• Position on a flat, stable surface.
• A service agent/qualified technician should carry out
installation and any repairs if required. Do not remove any
components on this product.
• Consult Local and National Standards to comply with the
following:
- Health and Safety at Work Legislation
- Fire Precautions
- Wiring Regulations
- Building Regulations
• Caution! Hot surface!
• DO NOT immerse the appliance in water.
• DO NOT clean with jet/pressure washers.
• DO NOT move or carry the appliance when it is switched on.
• Attended appliance and switch off after use - Fire Risk!
• Caution! Never switch on the deep fryer without oil inside.
• ALWAYS ensure oil levels are within the ‘MIN’ and ‘MAX’
levels. Failure to do so could result in fire.
• ALWAYS use a suitable cooking oil.
• ALWAYS remove excess moisture/water from food before
frying to avoid excess foaming and spitting of the oil.
• Change oil regularly. The flashpoint of oil (the point at which it
ignites) gradually reduces the more it is used.
• If oil begins to smoke or overheat then switch off
immediately.
• In case of fire, never use water to extinguish it. Never pour
water onto hot oil or fat. Use the lid to cover the fire instead.
CP793-A_CT012-A_A5_v2_20211220.indb 2CP793-A_CT012-A_A5_v2_20211220.indb 2 2021/12/20 17:222021/12/20 17:22

3
AU
Telephone Helpline: 1300225960
• During and after cooking, the unit is still hot. Never touch the
surface and switch on the drainage tap to avoid scalding.
• non-ionizing electromagnetic radiation.
• People with a pacemaker fitted should not use the appliance
and keep a minimum of 60cm from the appliance during
operation.
• Suitable for indoor use only.
• Always switch off and disconnect the power supply to the
appliance when not in use.
• This appliance must only be used in accordance with these
instructions and by persons competent to do so.
• Keep all packaging away from children. Dispose of the
packaging in accordance to the regulations of local authorities.
• This appliance is not intended for use by persons (including
children) with reduced physical, sensory or mental capabilities,
or lack of experience or knowledge, unless they have been
given supervision or instruction concerning the use of the
appliance by a person responsible for their safety.
• Children should be supervised to ensure that they do not play
with the appliance.
• Apuro recommend that this appliance should be periodically
tested (at least annually) by a Competent Person. Testing
should include, but not be limited to: Visual Inspection,
Polarity Test, Earth Continuity, Insulation Continuity and
Functional Testing.
Pack Contents
The following is included:
• Apuro induction fryer - 8L / • Lid
• Frying basket
• Batter plate
• Instruction manual
Apuro prides itself on quality and service, ensuring that at the time of packaging the contents are
supplied fully functional and free of damage.
Should you find any damage as a result of transit, please contact your Apuro dealer immediately.
CP793-A_CT012-A_A5_v2_20211220.indb 3CP793-A_CT012-A_A5_v2_20211220.indb 3 2021/12/20 17:222021/12/20 17:22

4
AU Telephone Helpline: 1300225960
Installation
1. Place the unit on a heat-resistant surface. Avoid placing it on or close to easy flammable materials.
Maintain a distance of 20cm (7 inches) between the appliance and walls or other objects for
ventilation.
2. Keep the unit away from splashing water and countertop’s edge.
Note: Before using for the first time, clean the lid, basket, batter plate and the
oil tank with warm soapy water. Let dry completely.
Operation
Control panel Frying basket
Lid
Batter plate
Drainage tap
Safety
switch
Removable
air filter
Oil tank
1. Place the batter plate into the oil tank.
2. Pour cooking oil into the oil tank between the
MIN and MAX markings.
Note: Before filling oil, ensure the
drain tap is at the OFF position.
Tap: OFF position
CP793-A_CT012-A_A5_v2_20211220.indb 4CP793-A_CT012-A_A5_v2_20211220.indb 4 2021/12/20 17:222021/12/20 17:22

5
AU
Telephone Helpline: 1300225960
Cooking
READY
indicator light
HEATING
indicator light
Thermostat POWER switch
with indicator light
1. Connect the appliance to the mains power supply.
2. Set the POWER switch to I(ON position). The power indicator light illuminates.
3. Set the thermostat to the desired temperature. The HEATING indicator light (red) turns On. The
appliance begins to heat the oil.
• Note: 170°C to 180°C is suitable for general cooking.
4. When the set temperature is reached, the HEATING indicator light (red) turns Off. Meanwhile the
READY indicator light (green) goes on.
5. Lower the basket with food into the oil.
Note: When food is lowered into the oil, the indicator light may switch from
“READY” to “HEATING”.
6. Remove the basket from the oil once the food is cooked. Shake gently above the oil tank to remove
any excess oil.
WARNING: The food and oil are very hot! Take care when removing the basket
as oil may drip.
7. After use, set the POWER switch to O(OFF position) and disconnect the appliance from the mains.
Self-protection functions
Function Descriptions
Dry-heat protection Each time the appliance starts, it performs the self-checking for 20 seconds.
If no oil is detected in the oil tank, the HEATING indicator light will flash 2
seconds repeatedly. Meanwhile a buzzer alarm is on to alert the user to fill oil.
Safety switch This appliance is fitted with a Thermal Cut-Out safety feature. Should the
temperature exceed safe levels appliance will automatically stop working.
Meanwhile, the safety switch on the rear will pop up. As a solution, call Apuro
agent or qualified Technician.
CP793-A_CT012-A_A5_v2_20211220.indb 5CP793-A_CT012-A_A5_v2_20211220.indb 5 2021/12/20 17:222021/12/20 17:22

6
AU Telephone Helpline: 1300225960
Cleaning, Care & Maintenance
• Always turn off and disconnect the appliance from the power supply before
cleaning.
• Always allow the appliance and oil to cool before cleaning.
• Check the temperature with a suitable probe thermometer; 40ºC is the MAXIMUM temperature at
which oil should be removed.
• For best performance, Apuro recommend that the appliance is cleaned after each day of operation.
• Pull the air filter out of its slot on the bottom of the appliance. Clean with a vacuum cleaner.
Note: Failure to clean the appliance regularly may result in premature activation
of the thermal cut-out switch.
Empty and clean the oil tank
• When the oil has cooled sufficiently, lift the tap lever and rotate anti-clockwise to the ON position. Let
the drained oil flow into a container.
Tap: ON positionTap: OFF position
• If the oil is to be reused then filtering it before refilling will extend the oil’s cooking life.
• Use a suitable detergent to clean the oil tank.
• Let it dry well, ensuring no moisture enters the inside of the appliance.
Cleaning all removable parts
• Use warm, soapy water and a soft brush to clean the lid, basket and batter plate.
• Dry thoroughly.
Troubleshooting
An apuro dealer or qualified technician should carry out repairs if required.
Error indications Description Probable Cause Solution
HEATING
indicator light
flashes once
continuously
IGBT on the PCB is
overheated. Buzzer
alarms.
Check ventilation
slots for dirt and
grease. Make sure
there is enough
space around the
appliance.
1. Switch the unit off and let it cool.
2. Check the filter and clean if
necessary.
3. Re-start the unit.
Note: If it occurs frequently, call Apuro
agent or qualified technician
CP793-A_CT012-A_A5_v2_20211220.indb 6CP793-A_CT012-A_A5_v2_20211220.indb 6 2021/12/20 17:222021/12/20 17:22

7
AU
Telephone Helpline: 1300225960
Troubleshooting
Error indications Description Probable Cause Solution
HEATING
indicator light
flashes twice
continuously
Temperature sensor
under the oil tank
is either shorted-
circuited or open-
circuited. Buzzer
alarms.
Temperature sensor
is defective
1. Unit overheated.
2. Let it cool.
Note: If it occurs frequently, call Apuro
agent or qualified technician
HEATING
indicator light
flashes 3 times
continuously
Input voltage
exceeds the allowed
Max/Min rating
Electrical installation
is not in order
Have a qualified electrician check it.
HEATING
indicator light
flashes 4 times
continuously
Temperature sensor
in the oil tank is
either shorted-
circuited or open-
circuited. Buzzer
alarms.
Temperature sensor
is defective
1. Unit overheated.
2. Let it cool.
Note: If it occurs frequently, call Apuro
agent or qualified technician
Fault Probable Cause Solution
Appliance not
working
The unit is not switched on Check the unit is plugged in correctly and
switched on
Plug or lead is damaged Replace plug or lead
Mains power supply fault Check mains power supply
Appliance stops
working suddenly
Safety switch is activated Please check your machine is safe with on
obvious damage and then press the re-set
switch on the rear
Appliance does
not reach set
temperature
Faulty thermostat Call Apuro agent or qualified technician
Faulty element Call Apuro agent or qualified technician
Build-up of fat on the element Clean the appliance
Appliance heats up
but indicator light
does not come on
Indicator light has expired Call Apuro agent or qualified technician
Power indicator
light comes on but
appliance does not
heat up
Faulty thermostat Call Apuro agent or qualified technician
Faulty element Call Apuro agent or qualified technician
Thermostat set incorrectly Check and re-set the thermostat
Appliance slow to
heat up
Build-up of fat in the tank Clean the appliance
Oil overheats or
starts to smoke
Thermostat damaged Switch off immediately. Call Apuro agent or
qualified technician
CP793-A_CT012-A_A5_v2_20211220.indb 7CP793-A_CT012-A_A5_v2_20211220.indb 7 2021/12/20 17:222021/12/20 17:22

8
AU Telephone Helpline: 1300225960
Technical Specifications
Model Voltage Power Current Capacity
(litres) Weight Dimensions H x W x D mm
CP793-A 220-240V~, 50Hz 3000W 13A 8L 13.5kg 414 x 288 x 485
CT012-A 220-240V~, 50Hz 3000W +
3000W
13A 8L + 8L 22.7kg 410 x 576 x 478
Electrical Wiring
The plug is to be connected to a suitable mains socket.
This appliance is wired as follows:
• Live wire (coloured brown) to terminal marked L
• Neutral wire (coloured blue) to terminal marked N
• Earth wire (coloured green/yellow) to terminal marked E
This appliance must be earthed.
If in doubt consult a qualified electrician.
Electrical isolation points must be kept clear of any obstructions. In the event of any emergency
disconnection being required they must be readily accessible.
Compliance
The product must not be disposed of as household waste. To help prevent possible harm to human
health and/or the environment, the product must be disposed of in an approved and environmentally safe
recycling process. For further information on how to dispose of this product correctly, contact the product
supplier, or the local authority responsible for waste disposal in your area.
Apuro parts have undergone strict product testing in order to comply with regulatory
standards and specifications set by international, independent, and federal authorities.
Apuro products have been approved to carry the following symbol:
All rights reserved. No part of these instructions may be produced or transmitted in any form or by any means, electronic,
mechanical, photocopying, recording or otherwise, without the prior written permission of Apuro.
Every effort is made to ensure all details are correct at the time of going to press, however, Apuro reserve the right to
change specifications without notice.
CP793-A_CT012-A_A5_v2_20211220.indb 8CP793-A_CT012-A_A5_v2_20211220.indb 8 2021/12/20 17:222021/12/20 17:22

DECLARATION OF CONFORMITY
• Conformiteitsverklaring • Déclaration de conformité • Konformitätserklärung • Dichiarazione di conformità •
• Declaración de conformidad • Declaração de conformidade
Equipment Type • Uitrustingstype • Type d'équipement • Gerätetyp
• Tipo di apparecchiatura • Tipo de equipo • Tipo de equipamento
Model • Modèle • Modell • Modello
• Modelo • Malli
Induction Fryer - 8Ltrs
Double Induction Fryer -2 x 3Kw
CP793-A
CT012-A
Application of Territory Legislation &
Council Directives(s)
Toepassing van Europese Richtlijn(en) •
Application de la/des directive(s) du
Conseil • Anwendbare EU-Richtlinie(n) •
Applicazione delle Direttive
• Aplicación de la(s) directiva(s) del
consejo • Aplicação de directiva(s) do
Conselho
Electrical safety
IEC 60335-1:2010 +A1:2013 +A2::2016
IEC 60335-2-37:2017
Electro-Magnetic Compatibility
EN 55014-1:2017
EN 55014-2:2015
EN 61000-3-2:2014
EN 61000-3-3:2013
Producer Name • Naam fabrikant • Nom du producteur • Name des Herstellers
• Nome del produttore • Nombre del fabricante • Nome do fabricante
Apuro
I, the undersigned, hereby declare that the equipment specified above conforms to the above Territory Legislation, Directive(s)
and Standard(s).
Ik, de ondergetekende, verklaar hierbij dat de hierboven gespecificeerde uitrusting goedgekeurd is volgens de bovenstaande
Richtlijn(en) en Standaard(en).
Je soussigné, confirme la conformité de l'équipement cité dans la présente à la / aux Directive(s) et Norme(s) ci-dessus
Ich, der/die Unterzeichnende, erkläre hiermit, dass das oben angegebene Gerät der/den oben angeführten Richtlinie(n) und
Norm(en) entspricht.
Il sottoscritto dichiara che l'apparecchiatura di sopra specificata è conforme alle Direttive e agli Standard sopra riportati.
El abajo firmante declara por la presente que el equipo arriba especificado está en conformidad con la(s) directiva(s) y
estándar(es) arriba mencionadas.
Eu, o abaixo-assinado, declaro que o equipamento anteriormente especificado está em conformidade com a(s) anterior(es)
Directiva(s) e Norma(s)
Date • Data • Date • Datum • Data •
Fecha • Data
14th December 2021
Signature • Handtekening • Signature
• Unterschrift Firma • Firma •
Assinatura
Full Name • Volledige naam • Nom et
prénom • Vollständiger Name • Nome
completo • Nombre completo • Nome
por extenso
Ashley Hooper
Nerida Pearse
Position • Functie • Fonction • Position
• Qualifica • Posición • Função
Technical & Quality Manager
Commercial Manager/ Responsible
Supplier
Producer Address • Adres fabrikant •
Adresse du producteur • Anschrift des
Herstellers • Indirizzo del produttore •
Dirección del fabricante • Morada do
fabricante
Fourth Way,
Avonmouth,
Bristol,
BS11 8TB
United Kingdom
15 Bagdally Road,
Campbelltown
NSW 2560
DocuSign Envelope ID: 833013A4-04F4-47FB-8E91-61E6F5570D8B
CP793-A_CT012-A_A5_v2_20211220.indb 9CP793-A_CT012-A_A5_v2_20211220.indb 9 2021/12/20 17:222021/12/20 17:22

CP793-A_CT012-A_A5_v2_20211220.indb 10CP793-A_CT012-A_A5_v2_20211220.indb 10 2021/12/20 17:222021/12/20 17:22

CP793-A_CT012-A_A5_v2_20211220.indb 11CP793-A_CT012-A_A5_v2_20211220.indb 11 2021/12/20 17:222021/12/20 17:22

CP793-A_CT012-A_A5_v2_20211220
CP793-A_CT012-A_A5_v2_20211220.indb 12CP793-A_CT012-A_A5_v2_20211220.indb 12 2021/12/20 17:222021/12/20 17:22