AstroBoy Countertop Smart RO System User manual

AstroBoy
Quick install guide
Water Inlet connection
Water can be diverted to the AstroBoy by either using the tap diverter or the opella valve.
Tap diverter
From your main kitchen mixer tap unscrew the aerator at the end of the spout and screw the tap diverter
and black washer provided in its place. The diverter is supplied with male and female adaptors.
Unscrew the grip nut and push onto the ¼ “ White tube provided push the tubing firmly onto the
barbed spigot and secure by reattaching the grip nut and fully tightening.
Opella valve
using the instructions provided with the valve attached the opella to a cold water pipe. Push the ¼”
white tubing provided into the pushfit connection on the valve.
Connecting to the RO unit
Take the other end of the tube attached to either the tap diverter or opella and feed through the aperture
at the centre rear of the blue RO base. Then connect to the T push fit connection at the end of the in
line filter with the pink coloured label.
Waste Connection
Feed one end of the long orange tube provided through the smaller aperture at the rear left hand corner
cut out of the blue base unit when viewed from the front. This is deliberately a tight fit Unscrew the
white end nut from the valve connector attached to the internal orange tube. Place the nut over the long
orange tube and push the tube firmly into the connector. Secure into place by reattaching the white nut
to the connector. The waste end can then either be attached to the undersink waste pipe using the black
waste connector supplied or simply placed into the sink if you require more portability.
Overflow connector
Feed the lager diameter white pipe through the larger aperture next to the orange waste pipe aperture
and using the same method as the with the orange pipe connect to the large valve connector located to
the left of the green label filter if looking from the front. The overflow can then either be fitted to a
waste pipe or placed into a sink. (note we do not provide a connection to fit the overflow to a waste
pipe). The unit is designed to continually replenish the tank to keep the pure RO water fresh. Once the
tank is full the overflow will run unless the water inlet supply is turned off
Electrical connection
The transformer connection is located next the on off switch to the front right of the blue base unit.
Ensure that the Three-pin plug is connected to a suitable 13-amp power supply.
Start up
Having first installed the water dispenser valve to the clear tank. Using the tap diverter or opella valve
turn the water supply and then the power supply on to the unit. At this point we recommend that you
observe to ensure no water leaks within the system. Once the tank has filled, turn off the water supply
and discard the first tank of water. On initial start up the first tank may contain impurities from the
filter flushing process. Once this first tank has been discarded turn the water supply back on and within
a few moments you can start to use the water.
If you intend to remove the storage tank from the system or switch the unit off we recommend that the
container is stored away from heat and direct sunlight and the pure water consumed within 8 hours.

DRINKING WATER SYSTEM
01 ASTROBOY
Inline cartridge filters
10
11
12
14
Introduction of
02 What is reverse osmosis
03 Components & Selections
04
05 The parts of ASTROBOY
07 Microprocessor control system
08 Tubing connection diagram
09 Installation diagram
Work with smart cap
Operation regulation
Change filters and membrane
13 FAQ
Maintenance checking list
15 Memo
REVERSE OSMOSIS SYSTEM
DRINKING WATER SYSTEM
ASTROBOY Countertop Smart RO System
ABSTRO OY
AB
STRO OY
USER'S MANUAL
Type of product
Date of purchase
Name Tel
Address
Memo
ASTROBOY

Maintenance checking list
Date
Filters
1st stage 2nd stage 3rd stage 4th stage 5th stage Other items
¨ASTROBOY
As a smart countertop RO system, Astroboy is especially designed for homes,
offices, restaurants, and shops use. It is the most delightful RO system
invention of 21 century. Astroboy not only brings you 100% pure clean water,
but with a multi-function tank, you can enjoy pure clean water wherever you are
anytime you want it.
With built-in the automatic flushing and self-cleaning procedure, its membrane
always remains clean. Water never stands still for a long time to avoid bacteria
growing. You can always get the best quality of water. LCD display shows the
service life of filter, and tells you if filters need to be replaced. It even knows
which filter is expired.
Build-in Smart microprocessor control system.
Complete 5 stage reverse osmosis water filter system.
Build-in high capacity booster pump.
Extremely versatile RO system.
Easy installation, just plug & drink.
LCD display to show the service life of filters.
LCD display to tell which filter needs to be replaced.
Warning if the filter was expired or out of use.
Auto shut-off when no feed water comes in.
Self-cleaning procedure to automatic flushing membrane. (every 8hrs)
Quick-connect fitting for easy maintenance.
Versatile /Portable water storage tank fits any bottle water dispenser.
Best Travel Companion.
Wide Application: Countertop / Outdoor / Motor home / Boat
¨Specifications
¨Features:
Production
Water storage tank
Transformer
Output
Wattage
Operation pressure
Dimensions
Weight
Max. inlet water temperature
80 GPD / 300 LPD
4.5gallons / 17 liters
220Volt or 240Volt (50/60Hz)
DC24V
30W
10 -100 PSI
(cm)36 (L) x 46(H) x 25 (W)
12.5 kg
46

DRINKING WATER SYSTEMDRINKING WATER SYSTEM
ASTROBOY Countertop Smart RO System ASTROBOY Countertop Smart RO System
FAQ
Q: Why is the testing result of my TDS higher than 40ppm?
Q: Can the water tank be used for similar coolers?
Q: How does the over-flow tube function?
Q: What should I do if the water productivity is shrinking?
Q: What are the importance to change filters regularly?
We suggest you stop drinking water from the system if TDS testing result is
higher than 40ppm. And change the RO membrane right away. Do remember to
change filters regularly.
Yes, this is a multi-function tank for which you can easily use for any similar
coolers.
It acts as a protector when the over-flow ball valve is malfunction.
Please change the filters. If the problem remains the same, please contact a
nearest distributor for solutions.
1.To ensure the quality of drinking water
2.To make the best use and extend the life of systems.
3.Filters have an expired life of service and must be changed regularly.
What is reverse osmosis
Reverse Osmosis
Pressure
Membrane
Water flow
Reverse osmosis was originally designed to make sea water drinkable for the
navy. It is ideal for anyone on a low sodium diet. An R.O. membrane has a pore
size much smaller than bacteria virus, or the cryptosporidium parasite. When
functioning properly it will remove all microorganisms from tap water and produce
sterile water. Reverse osmosis is the reversal of the natural flow of osmosis. In a
water purification system, the goal is not to dilute the salt solution, but to
separate the pure water from the salt and other contaminants. When the natural
osmotic flow is reversed, water from the salt solution is forced to pass through the
membrane in the opposite direction by application of pressure-thus the term
REVERSE OSMOSIS. Through this process, we are able to produce pure water
by screening out the salts and other contaminants.

DRINKING WATER SYSTEM
ASTROBOY Countertop Smart RO System
TDS meter
T.D.S
DRINKING WATER SYSTEM
ASTROBOY Countertop Smart RO System
ABSTRO OY
AB
STRO OY
1Switch off water source
and electricity.
2Turn off system power
switch
4Remove water tank and holder. 5Take out the 4 fixed screws. Then
remove filters and connectors.
6Coil the connectors with Teflon
tape and connect to a new filter.
Then connect to its tube.
7Put back the tube joint to the tank
cap. switch on water source and
electricity.
3Take out tube joint.
Check carefully to see if there is a leaking. If so, repeat the procedures described above.
Deliver-valve Water supply connector
Components & Selections
¨Selections
¨Components
Faucet Smart cap
Transformer
8mm over-flow tube white x 1
6mm feed water tube white x 1
6mm drain out tube orange x 1
Tubes
Change filters and membrane
To ASTROBOY
Withe Teflon tape

DRINKING WATER SYSTEM
DRINKING WATER SYSTEM
Service life varies with consumption and quality of water.
DRINKING WATER SYSTEM
ASTROBOY Countertop Smart RO System
AB
STRO OY
AB
STRO OY
4The system begins to produce
water 30 seconds after filters are
being flushed.
5Microprocessor control system
functions as shown on the picture.
1Plug in electricity. 2Switch on water source.
3Turn on system power switch.
DRINKING WATER SYSTEM
6Dain out the first tank of water to
flush filters and carbon fines.
Drink from the second tank of water.
ASTROBOY Countertop Smart RO System
Query Reset
TAN K F ULL
FLUSHING
NO INLET WATER
CALL SERVICE
PUMP REMAINING CAPACITY
GAL
DAYS
12345FILTER
3000
365
When under production of water, it's normal that the drain out tube comes with drain out water.
Do not stuff the drain out tube to prevent the system from breaking down.
Inline cartridge filters
Service life
Cartridge Filters Filter Description
Stage 1
Stage3
Stage 2
Inline Activated
Carbon Filter
Stage 4
Filmtec Membrane
Stage 5
Post Carbon Filter
Inline 1 Micron
Sediment Filter
DRINKING WATER SYSTEM
CARBON
DRINKING WATER SYSTEM
1 Micron
DRINKING WATER SYSTEM
CARBON
Inline Activated
Carbon Filter
1 Year
6 Months
4 Years
6 Months
6 Months
This 1micron sediment filter is made by
Dupont Anti-Bacteria. High capacity filter
removes dusts, particles and rusts, 99.70%
anti-bacterial, comply with FDA test standard.
Use 100% pure PP fine fiber. Product series
have been passed the test in accordance with
the filtering effect test of ANSI-NSF standard
42 - particulate reduction class II-V of U.S.A.
Service Life:1500GAL
This granular activated carbon filter is
composed of high-performance activated
carbon that removes free chlorine, odor,
organic contaminants, pesticides, and
chemicals that contributed to taste and odor.
Service Life:1500GAL
This granular activated carbon filter is
composed of high-performance activated
carbon that removes free chlorine, odor,
organic contaminants, pesticides, and
chemicals that contributed to taste and odor.
Service Life:1500GAL
Filmtec (Dow Chemical)membranes, maker of
the world's most advanced reverse osmosis
membranes. High rejection membrane with the
capacity of producing 80 gallons per day.
Eliminates up to 99.9% of most chemicals,
dissolved solids, metals, bacteria, and viruses.
Service Life:10000GAL
This post carbon filter is designed to improve
taste. It removes any residual impurities and
odors and provides a finer conditioning of pure
water.
Service Life:3000GAL
Operation regulation
To ASTROBOY

ABSTRO OY
AB
STRO OY
DRINKING WATER SYSTEM
ASTROBOY Countertop Smart RO System
AB
STRO OY
AB
STRO OY
1.Fasten the smart cap clockwise together with water tank.
2.Take off the cover sticker from the smart cap. Turn the tank upside down and
hook up with any counter top drink water systems / coolers.
It's normal that a plastic stopper shall be floating after turning the water tank upside down.
Each part of main body
Tank cap
Holder
Microprocessor
control system
Multi-fuction tank
Faucet
The front
Tube joint
Over-flow / drain out hole
In the back
Power switch Transformer plug
From the side
Work with smart cap

DRINKING WATER SYSTEM
ASTROBOY Countertop Smart RO System
To ASTROBOY
Deliver valve
To faucet
To water supply pipe
DRINKING WATER SYSTEM
T
1.Pure water supply
2.Over flow protector
3.Auto shut-off switch
ube joint is the combination of :
ASTROBOY Countertop Smart RO System
Each part of main body
Tube joint
Drain out tube
Low pressure switch
Solenoid valve Booster pump
Feed water tube
Auto flushing
solenoid valve
Over-flow tube
View from the top
Drain out tube
Auto flushing
solenoid valve
Booster pump
Over-flow tube
1st stage filter
2nd stage filter
3rd stage filter
4th stage filter
5th stage filter
View from the side
Installation diagram
Connect 6mm feed water tube white
Connect 6mm drain out tube orange Connect 8mm over-flow
tube white
Input water
Connect tube joint

Check the remaining service life of each cartridge filter.
Reset this system after your have done the replacement.
Showing life of service for filters.
st 1500GAL 1499.....0
3st 3000GAL 2999.....0
4st 9999GAL 9998.....0
5st 6000GAL 5999.....0
Example : 1st 1500GAL 1499.....0
2
Flashing which filter needs to be replaced.
Showing the water drop when the system is making the water.
Showing different functions as follows :
TANK FULL !
FLUSHING : Automatic flushing membrane (per 8hrs).
NO INLET WATER : No feed water!
CALL SERVICE : Flashing when the filter needs to be replaced (filter expired).
DRINKING WATER SYSTEM
ASTROBOY Countertop Smart RO System
Query Reset
TANK FULL
FLUSHING
NO INLET WATER
CALL SERVICE
PUMP REMAINING CAPACITY
GAL
DAYS
12345FILTER
3000
365
1
2
3
4
5
07
3
5
1
4
2
6
Simply leave the drain out tube and over flow tube in the sink!
Microprocessor control system Tubing connection diagram
6mm feed water tube white
6mm drain out tube orange
8mm over-flow tube white
Kitchen sink