AVIVA Iceberg Climbing Wall Product manual

Instructions & Warnings
For proper use of
ICEBERG ClIMBING WALL
AVIVA Inflatable Products
AVIVA Sports, Inc.
4059 State Road A
Montreal, MO 65591
Phone: [phone] Fax: [phone]
[e-mail]
www.goaviva.com
WARNING!
Read these materials prior to assembling and using your AVIVA Product.
Failure to follow these instructions could result in serious injury or death.
AVIVA Inflatables are not life saving devices. Never leave children near
water unattended and be sure they are supervised by a mature and
knowledgeable adult. AVIVA highly recommends the use of U.S. Coast
Guard approved personal flotation devices (life jackets) by those near or in
the water.
Inflation, set up and supervision must be done by a mature and
knowledgeable adult!
Inspect product for any unsafe conditions before use! Do not use if repair
is needed!
Instruct children on proper use of this product.
Over-inflation is the major cause of leaks. Do not inflate with an air
compressor or other high pressure pump.
Read the instructions and warnings printed in this manual for proper
inflation and safe use.
Keep away from fire and other heat sources. Keep out of direct sunlight
when not in use.
Before using, AVIVA recommends that you check local laws and
regulations and also, local water conditions for dangerous conditions.

•PRODUCTS
• 6’ THE ROCK . . . . . . . . . . . . . . . . . . . . . . 3
• 7’ SPACE MOUNTAIN. . . . . . . . . . . . . . . . .4
• 14’ ICEBERG . . . . . . . . . . . . . . . . . . . . . . . 5
• INFLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6
• ANCHORING . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
• EZ UP QUICK CONNECT . . . . . . . . . . . . . . . . . . .8
• DEFLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
• MAINTENANCE . . . . . . . . . . . . . . . . . . . . . . . . . . 9
• CLEANING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
• STORAGE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
• REPAIRS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
• WARNINGS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
• WARRANTY . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Table of Contents
DO NOT OVER-INFLATE!! Product should not be firm! There should
be a depression when pushed on with your hand.
Please Note: Keep in mind the temperature of the air going into the product
and the outside air. If your inflator is hot and sending warm air into the product,
when it cools, it will seem like your Product is loosing air. This is normal.
Weather and temperature variations will also cause the air inside the unit to
expand and condense. This is normal. If you are experiencing a cool span
you may want to add additional air. Be careful when the temperature rises that
the unit does not become over-inflated. Damage due to over-inflation voids the
warranty.
Proper inflation should be checked often if the product is left inflated for
consecutive days.
All inflatable's are sensitive to cold, therefore never unfold or inflate in
temperatures below 50° F.
Always remove your inflatable from the water when not in use. To extend the life
of you’re inflatable – keep out of sunlight when not in use. For additional
protection, we recommend using U.V. protectant.

6’ The Rock
Item 18015
INFLATION: The Rock is inflated using any of the recommended types
of inflators. Foot / Hand pumps are not recommended for the main
chamber due to the size of the product.
PARTS: The Rock includes:
3 – Halkey Roberts Valves
1 – Big Black Valve
1 – EZ Up w/ quick connect
4 – Anchor Plates
1 - Repair Kit consisting of: 4 oz of Glue, 2 – 8” square, patch of
each in White and Blue, 1 extra Handle and 1 extra Anchor Plate.
POSITION: Make sure water depth is a minimum of 8 feet deep.
There should also be a minimum of 16 feet clearance all around the
unit.
RECOMMENDED MAXIMUM WEIGHT: 400 lbs.
RECOMMENDED NO. OF PEOPLE: 1 - 3
RECOMMENDED WATER DEPTH: 8 Feet
RECOMMENDED AGES: 6 +
HandlesStabilizing Tube
PATENT NO. - 6,322,454 & D451,567
3

Handles
Stabilizing Tube EZ Up Platform
PATENT NO. - 6,322,454 & D451,567
4
7’ Space Mountain
Item 18016
INFLATION: The Space Mountain is inflated using any of the
recommendedtypes of inflators. Foot / Hand pumps are not
recommendedfor the main chamber due to the size of the product.
PARTS: The Space Mountain includes:
2 – Halkey Roberts Valves
1 – Big Black Valve
4 – Anchor Plates
1 – EZ Up Platform (already attached)
1 - Repair Kit consisting of: 4 oz of Glue, 2 – 8” square, patch of
each in White and Blue , 1 extra Handle and 1 extra Anchor Plate.
POSITION: Make sure water depth is a minimum of 8 feet deep.
There should also be a minimum of 16 feet clearance all around the
unit.
RECOMMENDED MAXIMUM WEIGHT: 500 lbs.
RECOMMENDED NO. OF PEOPLE: 1 - 4
RECOMMENDED WATER DEPTH: 8 Feet
RECOMMENDED AGES: 6 +

Handles Stabilizing Tube
PATENT NO. - 6,322,454 & D451,567
5
14’ Iceberg
Item 18002
INFLATION: The Iceberg is inflated using any of the recommended
types of inflators. Foot / Hand pumps are not recommended for the
main chamber due to the size of the product.
PARTS: The Iceberg includes:
3 – Halkey Roberts Valve
1 – Big Black Valve
12 – Anchor Plates
1 - Repair Kit consisting of: 4 oz of Glue, 2 – 8” square, patch of
each in White and Blue, 1 extra handle and 1 extra Anchor Plate.
POSITION: Make sure water depth is a minimum of 12 feet deep.
There should also be a minimum of 16 feet clearance all around the
unit.
RECOMMENDED MAXIMUM WEIGHT: 1,500 lbs
RECOMMENDED NO. OF PEOPLE: 1 - 8
RECOMMENDED WATER DEPTH: 12 Feet
RECOMMENDED AGES: 14 +

INFLATION
SET UP AND SUPERVISION MUST BE DONE BY A MATURE AND KNOWLEDGEABLE ADULT!
You can use the following devices to inflate the Product:
- Electric Inflator/Deflator (household current)
- Inflator/Deflator that plugs into a DC outlet in your vehicle
- Any other inflator designed for inflatable boats, rafts, pool floats, air beds,
camping mattresses, and other low pressure inflatables.
- Shop Vac or Leaf Blower.
CAUTION:Use extreme care when using an electric inflator anywhere near
water. Beware of the dangers of electrocution when using electric powered
inflators. Precautions should be observed during use and handling to prevent
shock.
DO NOT inflate with an air compressor or other high pressure pump!! This
unit is designed to be inflated with a high volume of air but at a low pressure.
DO NOT allow children to play with the product until it is fully inflated!!
6
Air Valve Stem
CAP
Halkey Roberts Valve – Unscrew the cap by twisting counterclockwise to
expose the air valve stem. Open the air valve by pushing in the stem and
rotating clockwise. Inflate with your inflation device until firm. Pushing on the
stem and rotating counterclockwise will seal the valve. Replace cap making
sure it is tightened securely. Air Valve Stem
Big Black Valve - For faster inflation if your product has a Big Black Valve
you may use it to do the bulk of your inflating. Just unscrew the cap and
hold your inflator up against it. You will need to top off using the Halkey
Roberts valve.

ANCHORING
Due to extreme varieties of conditions, anchor line and anchors are
not included with the product and must be purchased separately.
Attach the anchor line (not included) securely to the Anchor Plate
of the product. The number of anchor attachment points will vary
per model.
Please Note: There are many ways to anchor your products.
Before moving forward, it is best to consult your local regulations
regarding what types of anchors can be used in your area. Every
location has different conditions and demands, so you will have to
determine what will work best for your situation. Here are a few
anchoring tips to get you started.
Anchor Rope: Nylon rope holds up the best in water and sun.
The anchor line must be a length of at least 1 ½ times to the depth
of the water. Lines do eventually wear out, so it’s important to
check on them periodically.
A forsheda (amortisator) or a bungee harness can be used to
decrease the stress on the anchor rope, anchor plates and the
product.
Mark line by attaching a buoy or other float to the end of your
anchor line when not in use. You’ll find it easier to identify the
location of your anchor.
Anchoring a stainless steel snap hook to the buoy simplifies the
process of removing your product from the water for cleaning or
repair. It also makes it simple to return your product to its previous
location.
7
Forsheda

DEFLATION
PRIOR TO DEFLATION, REMOVE ALL CHILDREN FROM THE UNIT!
Use one of the Inflator/Deflator devices recommended in the “Inflation”
Section for faster deflation.
Halkey Roberts Valve - Unscrew the cap by twisting counterclockwise to
expose the air valve stem. Open the air valve by pushing in the stem and
rotating clockwise. Allow air to escape. Pushing on the stem and rotating
counterclockwise will seal the valve. Replace cap making sure it is tightened
securely.
Big Black Valve – Unscrew the cap by twisting counter clockwise. Press the
Red Button on the Flap and allow air to escape. Replace cap making sure it is
tightened securely.
Completely Dry Unit. Wipe the product off with a terry cloth towel and allow
to dry completely. Store for next use. See Storage Section for details.
8
EZ Up Quick Connect
Line up the EZ Up to the Rock by placing both units against each
other and lining up the loops on each side. Unit must be on level
ground to attach. It may be easier to attach to the unit before
inflating.
Thread the tube through the loops. Then thread the included string
through the PVC tube and caps. Attach tube caps and tie the string
on either end of the tube cap leaving approximately 3” to 4” of
excess on both sides. Cut off any remaining excess.
Note: Pipe will
thread through
loops easier if wet.

CLEANING
If your inflatable is used intensively, then it should be cleaned on a weekly basis. It is
also important to clean and dry the product before it is packed away.
When cleaning your product never use strong detergents or silicone-based products.
Also never use high pressure cleaning equipment such as a “pressure washer”. This
will result in damage to your product.
Clean the outside surface only.
Clean your inflatable with mild soap and fresh water and check that the valves are
clean and not damaged.
AVIVA recommends the use of U.V. protectant for prolonging the life of your inflatable.
To remove algae and other hazards from the ocean, you can use a special cleaning
agent from your local marina. Following the directions carefully.
All hardware (O-rings, springs, and such) should be rinsed with fresh water weekly.
Although normal wear and tear is unavoidable, this will increase the life of your
product.
STORAGE
When storing your inflatable, keep it in a clean and dry place that is not affected by
major variations in temperatures and other damaging factors. You can store your
inflatable deflated and rolled up or lightly inflated. Be careful never to stack anything
on top of inflatable. It is recommended that you allow the unit to completely dry and
lubricate the rubber on the valves with a petroleum based product t before storage.
Please note: rodents, such as mice, chew on fabric, including inflatable material. As a
precaution you can place moth balls or fabric softener sheets around the products
during storage to deter them.
9
MAINTENANCE
Maintenance is essential to increase the life of your product. Please follow all
maintenance and repairs according to this manual. If you are unsure please contact
your local dealer, service center or AVIVA Sports directly.
•Inspect product regularly for potentially unsafe conditions, particularly after
storms, and suspected misuse of product.
•Do not use product if repair is needed!
•Clean product regularly per the Cleaning section of manual.
•Check storage area. Make sure it is rodent free and dry.
•Black rubber portion of Valves and Plugs should be lightly coated with a
petroleum based product before storage to prevent drying and cracking.
•When disposing of product do so in such a manner that no hazardous conditions
exist at the time the product is discarded.

REPAIRS
All of the inflatable products include a repair kit. You can easily repair minor
punctures and cuts and even anchor plates or handles.
Conditions necessary for a successful repair are:
Relative humidity less than 65%.
Temperature Range between 62° - 77° F.
Avoid performing repairs in direct sunlight or rain.
Step 1 -Locate the damaged area. The easiest way is to fully inflate the product
and listen for the leak, or to spray with soapy water and look for bubbles. Mark the
damaged area with a crayon or wax pencil and deflate the product.
Step 2 – Cut out a patch approximately 2 inches larger than the leak. Clean
the damaged part of the product and patch and allow to dry thoroughly.
TIP –It is a good idea to always use a circle or rectangle patch with rounded corners. Pointed
corners tend to pull off.
Step 3 – Next clean the area and the patch with alcohol, grease remover, or
fingernail polish remover and allow to dry thoroughly.
Step 4 -Apply glue in a very thin layer to the patch and then to the area of the
leak. Let the glue stand until tacky, usually 30 seconds – 1 minute.
TIP – Place glue on the dull side of the patch and to the shinny side of the unit. Then when you
apply the patch it will match.
TIP –Use a short brush (just cut the length off) as this digs into the material better to spread the
glue. Also try to use a brush with real hair instead of synthetic.
Step 5 – Place the patch over the leak
Step 6 – Press out the air pockets which may have formed under the patch.
You can use any round object, such as a spoon, starting in the center and then
working outwards toward the edges. You can keep the repair “tight” by clamping
together with spring pliers.
Step 7 – Allow repair to cure for 24 hours before re-inflating.
Step 8 –Inflate the repaired product.
TIP –It is a good idea to check again for leaks. If you have multiple leaks, the air will rush out of a
larger hole before a smaller one.
CAUTION: When using glue, remove unused glue from threads of tube and cap
and carefully replace the cap on the tube. If properly sealed it will keep perfectly.
Do not leave the tube in the sun or next to heat sources or direct flames.
•Check that the room is properly ventilated, avoid inhaling or ingesting the glue
and avoid contact with skin.
•For major repairs, take your product to your local dealer or manufacturer.
10

WARNINGS
THIS IS NOT A LIFESAVING OR PERSONAL FLOTATION DEVICE. DO NOT
LEAVE CHILD UNATTENDED WHILE IN USE!
ALWAYS USE A U.S. COAST GUARD APPROVED (PERSONAL FLOATATION
DEVICE) VEST FOR CHILDREN AND ADULTS!
ALWAYS ANCHOR THE INFLATABLE SECURELY BEFORE USE!
ALWAYS INSPECT AREA FOR RECOMMENDED WATER DEPTH BEFORE USE!
ALWAYS KEEP A MINIMUM OF 16 FEET (4.88 METERS) DISTANCE FROM ALL
OTHER OBJECTS INCLUDING DOCKS, PLATFORMS, BOATS AND PIER!
ALWAYS KEEP A MINIMUM WATER DEPTH (SEE PRODUCT PAGE FOR DEPTH)
UNDER UNIT WHILE IN USE!
THIS PRODUCT IS ONLY FOR THE USE IN THE WATER! NEVER LEAVE IN OR
NEAR WATER WHEN NOT IN USE!
THIS PRODUCT SHOULD ONLY BE USED UNDER MATURE, AND
KNOWLEDGEABLE ADULT SUPERVISION AT ALL TIMES!
ALWAYS RETAIN INSTRUCTIONS WITH INFLATABLE!
ALWAYS INSPECT PRODUCT AND AREA FOR PROPER INFLATION ANY UNSAFE
CONDITIONS BEFORE USE! DO NOT USE IF REPAIR IS NEEDED!
ALWAYS INSTRUCT CHILDREN IN PROPER USE!
ALWAYS STAY IN CONTROL AND NO WILD PLAYING WHILE USING THE
INFLATABLE!
ALWAYS REMOVE ANY SHARP OBJECTS SUCH AS A WATCH OR CHAIN
BEFORE USING!
DO NOT USE IN BAD WEATHER, STRONG CURRENTS, OR DARKNESS!
DO NOT MODIFY PRODUCT UNLESS INSTRUCTED BY MANUFACTURER!
DO NOT DIVE OFF THE INFLATABLE!
DO NOT ALLOW SWIMMING UNDER THE UNIT WHILE IN USE!
DO NOT USE ON SNOW OR TOW BEHIND A VEHICLE!
DO NOT ATTEMPT TO ATTACH A MOTOR TO UNIT!
DO NOT USE WHILE UNDER THE INFLUENCE OF ALCOHOL OR DRUGS!
DO NOT USE NEAR FIRE!
DO NOT ALLOW ROUGH PLAY!
DO NOT PUT HANDS, ARMS, LEGS OR FEET THROUGH THE GAPS BETWEEN
INFLATED CHAMBERS OR HANDLES!
DO NOT ATTACH OR STRAP ANY PERSON OR ANIMAL TO THE INFLATABLE!
WE CANNOT GUARANTEE FREEDOM FROM INJURY. THE USER ASSUMES ALL
RISK OF INJURY DUE TO USE. ALL MERCHANDISE IS SOLD ON THIS CONDITION,
WHICH NO REPRESENTATIVE OF THE COMPANY CAN WAIVER OR CHANGE.
IT IS THE RESPONSIBILITY OF THE OWNER OF THE PRODUCT TO MAKE SURE
SUBSEQUENT USERS ARE INSTRUCTED IN THE SAFE USE OF THIS PRODUCT!
IMPORTANT: PLEASE READ OWNERS MANUAL COMPLETELY BEFORE USE.
READ AND MAKE SURE YOU FOLLOW ALL WARNINGS BEFORE USE!
11

LIMITED WARRANTY
Aviva Sports, Inc. warrants to the original purchaser only and warrants only when products are
used for normal recreational purposes.Aviva Sports, Inc. warrants that products are free from
defects in material and workmanship for a period of 1 Year under Commercial Use and 5 Years
under Residential use from the date of purchase from an Authorized AVIVA Dealer. All claims must
be made in writing in the form of email, fax, or mail.A legible copy of dated sales receipt and the
part and/or item to be warranted are required for all claims.
Aviva Sports shall inspect all warranty claims and in the event of a defect will repair or replace the
defective part or entire product. All requests for cash refund must be requested through original
place of purchase. Please Note: Postage, handling and return shipping charges are not refundable
and not included in this warranty.
The purchaser must obtain from Aviva Sports a return merchandise authorization number before
returning any item.All items shipped to AVIVA without an RMA # will be refused.
To file a Warranty Claim:
By Mail - please call [phone] or fax [phone] and request an RMA Form to be mailed
/ Fax to you to start your claim.
By Email - Please go to www.goaviva.com on the internet, click the link for Contact Us and follow
the instructions. Or, email [e-mail] for instructions. Please include when and where you
purchased your unit, along with what the problem is.
All warranty claims must be made in writing.
Once an authorization number has been obtained, the purchaser must ship the product,
POSTAGE PREPAID, with a legible copy of the purchasing receipt to:
Aviva Sports, Inc.
Attn: RMA#(to be provided)
4059 State Road A
Montreal, MO 65591
This warranty does NOT cover:
•Products used under circumstances not considered normal recreational purposes.
• Punctures, cuts, and abrasions sustained in normal use.
• Items involved in accidents.
• Items damaged in white water mishaps.
• Other unreasonable uses or improper storage.
• Damaged caused by over inflation.
Aviva Sports, Inc. shall within thirty (30) days from receipt of an authorized return from purchaser,
perform its responsibilities in conformance with this warranty.
THERE ARE NO WARRANTIES WHICH EXTEND BEYOND THE DESCRIPTION OF THE FACE
HEREOF.AVIVA SPORTS INC SHALL NOT BE HELD LIABLE FOR INCIDENTAL AND
CONSEQUENTIAL DAMAGES.THIS WARRANTY IS INCLUSIVE IN LIEU OF ALL OTHER
WARRANTIES.
This warranty gives you specific legal rights, and you may also have other rights which vary from
state to state.
12