B&B 1TT User manual

!
1TT!–TIMER!+!TERMOREGOLATORE!-!Reference!Manual!!-!Pag.!1!di!7!
!
!
!
!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!
!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!
!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!www.bebmilano.it!
!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!
!
!!!!!!!!!!!!!!!!!!!!1TT!–!USER!MANUAL!
!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!TIMER!!+!TEMPERATURE!CONTROLLER!!
!
!! When the device is turned-on its display shows the following text:
!
- SEL!!!!!upper!display!!!!!
- CAL!!!!lower!display!!
!
!!!!!!!!!!!!!After!a!few!seconds!the!upper!display!shows!the!!!value!of!the!measured!temperature;!
!!!!!!!!!!!!!and!the!lower!display!!the!value!of!a!time!set.!
!
!!!!!!!!!!!!!!Time!setting:!!
• Press!the!!!!S!!!!!button,!so!the!upper!display!will!show!!timE!!;!the!lower!display!the!value!of!one!time,!
• Use!the!following!buttons!!!!▲!!!
!
!!!to!set!the!requested!time!value.!!
In!order!to!memorize!it,!reset!(!7!–!5)!or!press!ON/OFF.!
!
!
!!!!!!!!!!!!!!Temperature!setting!!(After!time!setting)!
!
• Press!the!!!!S!!!!button,!so!the!upper!!display!will!show!!!°C!!!and!the!lower!display!a!temperature!value;!
Use!the
!
!▲!!
!
!!buttons!to!set!the!required!temperature!value.!
!!!!!!!!!!!!!!!!!!!!!!
!!!!!!!!!!!!!!TO!ACCES!THE!TEMPERATURE!PARAMETERS!USING!THE!PASSWORD.!
• Press!for!!5!seconds!the!!!!S!!!!button,so!the!upper!!display!!will!show!!SET!and!the!lower!!!t1!.!
Pres!the!!!!▲!!button!!so!the!upper!display!will!show!SET,!the!lower!!!timE.!!!
• Press!again!the!!!!▲!!button!and!the!lower!display!will!show!dEv.!!
• Press!again!the!!!!▲!!button!and!the!lower!display!will!show!!!PAS.!!
• Press!the!!!S!!!!!button!and!the!lower!display!!!will!show!!100;!!enter!the!password!!123.!!
• With!the!!!S!!!!!button!every!pulse!corresponds!to!a!!parameter!!(see!the!Instructions!Manual).!
!
TO!ACCESS!THE!TIMER!PARAMETERS!USING!THE!PASSWORD.!
Press!for!5!seconds!the!!!S!!!button!;!!the!upper!display!will!show!!SET,!the!lower!display!.!
t1
!the!upper!right!
!red!led!will!be!switched!on!!(1)!!
Press!the!!▲!button!!and!the!!display!will!show!timE!!,!
Press!the!!!S!!button!to!access!the!following!parameters:!
!
!!!!!!!!!!!!!!!toP!!!!!!!absolute!max!limit!block!!
MobE!!relay!function!!!
InP!!!!!!!pulse!timed!relay!!
!!!!!!!!!!!!!!!!Rit!!!!!!!!delayed!relay!!!!
dir!!!!!!!!count!!!UP!!or!!dn!!
!
TS!!!!!!!Setting!of!the!times!!scale!
0!=!!!!!!!99,99!
1!=!!!!!!!999,9!
2!=!!!!!!!9999!sec.!
3!=!!!!!!!9999!min.!
4!=!!!!!!!59!min.!59!sec.!
!
Use!the!!!▲!!and!!!
!
!!buttons!!to!select!
!
At!the!end!of!every!change!the!display!will!show!!!9!9!confirming!the!successfully!completed!programming.!
!

!
1TT!–TIMER!+!TERMOREGOLATORE!-!Reference!Manual!!-!Pag.!2!di!7!
!
!
!
!!!Inputs!and!Outputs!:!
!
The!1TT!device!has!an!input!to!show!the!temperature!(PV)!and!two!digital!outputs!(OUT!and!!ALARM).!
Timer!relay!contact!!
The!small!clamps!are!used!as!in!the!following!table:!
!
!1t!regulation!channel!(SP)!
!
Probe!input!
TC!1!!!!!!(3!-!!!4+)!
Output!
SP!!!!!!!!!!(19!-!20)!
Alarm!
AL!!!!!!!!!!(17!-!18)!
Timer!relay!contact!
Relè!!!!!!!(15!-!16)!
!
Heating control:
If!the!adjustment!channel!has!been!set!to!heat!mode,!the!temperature!control!is!obtained!by!the!complete!PID!
algorithm!or!the!ON-OFF!algorithm!with!hysteresis.!
The!Act!parameter!must!be!set!to!Hot!in!order!to!select!the!heating!action:!the!activation!of!the!control!output!causes!
an!increase!in!temperature!because!it!is!connected!to!a!heating!element!.!
The!selection!is!made!by!setting!the!proportional!band!(!PB!)!:!
•
Setting!value!0!(!zero)!will!enable!the!ON!–!OFF!adjustment!
•
Setting!any!value!other!than!0!will!enable!the!PID!adjustment!
!
The!aforementioned!settings!are!summarized!in!the!table!below:!!
!
!
Simbolo!
ON-OFF!
PID!
Proportional!Band!
PB!
!If!is!set!to!0!it!will!enable!ON-OFF!
PB!>!0!–!proportional!band!PID!
Integral!Time!
Ti!
!
Integral!Time!PID!
Derivative!Time!
Td!
!
Derivative!Time!PID!(Td=-1!automatic!Td=!Ti/4)!
Positive!Hysteresis!
HSO!
>!0.1°C!
!
Negative!Hysteresis!
HSU!
<!0.1°C!
!
Output!Time!od!Cycle!
Tc!
!
From!0!(zero)!to!999”!
!
!
!
!
!
!
!
!

!
1TT!–TIMER!+!TERMOREGOLATORE!-!Reference!Manual!!-!Pag.!3!di!7!
!
!
!
Manual modes (pulse generator)
!
The!instrument!has!two!manual!modes!that!exclude!the!control!algorithms!and!run!the!control!elements!at!constant!
power:!
•
Manual!mode!always!on!(also!with!temperature!probe);!
•
Manual!mode!only!when!there!is!an!error!with!the!temperature!probe.!
!
Select!manual!mode!(always!on)!by!selecting!the!parameter!MAN!=!1!(the!MPE!parameter!is!ignored).!
To!select!manual!mode!only!when!there!is!an!error!with!the!temperature!probe!by!selecting!the!parameter!MAN!=!0!
and!MPE!=!1.!
!
In!both!cases!the!percentage!of!activation!control!output!is!set!via!the!OUT!parameter!(percentage!of!the!cycle!time!
normally!used).!!
Table!(summary):!
!
!
MAN!
MPE!
Manual!mode!always!on!
1!
!
Manual!mode!in!case!of!error!of!probe!
0!
1!
!
!
Versions with front display
! !

!
1TT!–TIMER!+!TERMOREGOLATORE!-!Reference!Manual!!-!Pag.!4!di!7!
Alarms and indicators
The!numbers!in!the!below!table!(and!images)!are!only!shown!as!an!example!(illustrative!purpose):!!
!
!
!
Temperature!over-range!
!
!
!
!
!
Temperature!under-range!
!
!
!
!
!
AutotunE!
The!display!flashes!between!the!picture!1!and!the!picture!2!
→! !
!
!
!
ECO!mode!
The!display!flashes!between!the!picture!1!and!the!picture!2!
!→! !
!
!
!
Manual!mode!in!case!of!error!of!probe!
The!display!flashes!between!the!picture!1!and!the!picture!2!
!→! !
!

!
1TT!–TIMER!+!TERMOREGOLATORE!-!Reference!Manual!!-!Pag.!5!di!7!
parameters!
!
Description!
!
!!!!!!!!!!!!!!!!!!!!!!Values!
!
Default!
!
Note!
SP!(*)!
Setpoint!!
-!99!::![!Maximum!Setpoint]!!!!!!!
20°C!
!
!!!!!!!!!!!!!!!!!!!!!!!!!!!Disposable!!Parameters!with!the!“123”!password!only!
AL!
Alarm!
[min]!::![max]!
100°C!
!
Int!
!!!!!!!!!!!!!!Kind!of!probe!
tcJ!
Termocouple!J!
tcH!
Termocouple!K!
tcb!
Termocouple!B!
tce!
Termocouple!E!
tcn!
Termocouple!N!
tcr!
Termocouple!R!
tcs!
Termocouple!S!
tct!
Termocouple!T!
pt1!
Pt100!
p10!
Pt1000!
!
TC!J!
!
Act!
Working!method!
Hot!
Heating!
Col!
Raffreddamento!
Hot!
Setting!COL!the!
controller!!will!work!by!
ON/OFF!method!w.algor.!
Eco!
!ECO!mod!
0!(off)!::!999!
0°C!
!
BSC!
Gradient!of!ramp!
0!::!1!
1!
The!setpoint!can!
automatically!change!
nSP!
Min.!setpoint!
-!99!::!999!
-!30!°C!
!
mSP!
Max.!setopoint!
-!99!::!999!!
400°C!
!
Tc!
Time!of!Cycle!
0,1!::!999!
15!s!
!
PB!
Proportional!Band!
0!(regolazione!ON-OFF)!:!100!
2!%!
Percentage!of!the!range!
Ti!
Integral!Time!
0!::!999!
120!s!
Integral!Time!
td!
!!!!!!!!!!!!Derivative!Time!
-!1!::!999!
30!s!
Select!-1!to!work!
automatically!in!!Ti/4!
OFS!
!!!!!!!!!!!TemperatureOffset!
-!100!::!+100!
0!°C!
!
HSO!
Positive!differential!off!SET!
0!::!999!
0!°C!
Used!in!case!of!!ON-OFF!
reg.!
HSU!
Negative!differential!off!SET!
0!::!999!
1!°C!
Used!in!case!of!ON-OFF!
!
ALM!
!
Relay!Alarm!Mode!
!
Absolute!Band!Alarm!!!!!!!Relay!-!(!1!off!/!2!on!)!
Finestra!o!deviazione!!!!!!!Relay!-!(!4!off!/!3!on!)!
!
!
1!
!
ALS!
!!!!!!!!!!!!Setpoint!Alarm!
0!::!1!
0!
Solo!per!allarme!!relè!
finestra!o!deviazione!
ALH!
Absolute!High!Alarm!.!!
!0!::!999!
600!°C!
!

!
1TT!–TIMER!+!TERMOREGOLATORE!-!Reference!Manual!!-!Pag.!6!di!7!
!
!TUNe!MODE!!–!ACCESS!WITHOUT!PASSWORD!!
!
Press!for!5!second!!the!!S!!!button,!the!upper!display!will!show!SET!and!the!lower!t1;!!press!the!!▲ button and!the!!
lower!display!will!show!timE;!press!again!!▲!and!the!lower!display!will!show!dev;!press!the!!S!!button!and!the!upper!!
display!will!show!tun,!!the!lower!no!;!!
Press!the!!▲!button!and!the!lower!display!will!show!the!following!tune!options!:!
-!no!!!=!!!!!Disabled.!
-!Man!=!!!Manual!SET!UP!Output.!
-!OnE!!=!!!At!first!turning!ON.!
-!All!!!!!=!!!At!every!turning!ON.!
!
After!inserting!the!the!tune!mode,!the!confirmation!that!the!programming!has!been!successfully!completed!will!be!
shown!by!the!flashing!!9!!9!!on!the!display.!!
!
!
!
!
!
!
!
ALL!
Absolute!Low!Alarm.!
!!0!::!999!
0!°C!
!
MPe!
Pulse!generator!in!case!of!
error!of!probe!
(percentualizzatore)!
0!::!1!
1!
In!caso!di!errore!sonda!
lo!strumento!passa!alla!
modalità!
percentualizzatore!
MAN!
Manual!setup!
Percent!generator!
0!::!1!
0!
Se!impostato,!lo!
strumento!funziona!
come!un!
percentualizzatore!
OUT!
Percent!manual!value)!
0!::!100!
50!%!
La!percentuale!è!
calcolata!sul!parametro!
TMS!(tempo!di!ciclo!in!
modalità!
percentualizzatore)!
LSP!
Display!functions!
0!::!1!
0!
Se!impostato!limita!la!
visualizzazione!della!
temperatura!al!setpoint!

!
1TT!–TIMER!+!TERMOREGOLATORE!-!Reference!Manual!!-!Pag.!7!di!7!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
!