Bella Outdoor Living Nano Series User manual

OWNER’S MANUAL
Nano Series Wood-Fired Pizza Oven
ASSEMBLY INSTRUCTIONS and IMPORTANT
SAFEGUARDS
Nano Series Owner’s Manual v1.1 © Bella Outdoor Living 2014 1

WARNING
READ AND FOLLOW ALL SAFETY WARNINGS AND
INSTRUCTIONS IN THIS MANUAL TO AVOID
PERSONAL INJURY OR PROPERTY DAMAGE.
WE WANT YOU TO ASSEMBLE AND USE YOUR OVEN AS SAFELY AS POSSIBLE.
THE PURPOSE OF THIS SAFETY ALERT SYMBOL IS TO ATTRACT YOUR ATTENTION TO POSSIBLE HAZARDS AS
YOU ASSEMBLE AND USE YOUR OVEN.
WHEN YOU SEE THE SAFETY ALERT SYMBOL, PAY CLOSE ATTENTION TO THE INFORMATION WHICH FOLLOWS!
READ ALL SAFETY WARNINGS AND INSTRUCTIONS CAREFULLY
BEFORE ASSEMBLING AND OPERATING YOUR OVEN.
WARNING
• Only use this Oven on a hard, level, non-combustible, stable surface (concrete, stone etc.) capable of supporting the weight
of the oven. Never use on wooden or other combustible surfaces.
• Proper clearance of 3 Metres between the oven and combustible material (bushes, trees, wooden decks, fences buildings,
etc.) or construction should be maintained at all times when Oven is in use.
• Do not place Oven under a roof covering, awning, overhang or other enclosed areas.
• FOR OUTDOOR USE ONLY. Do not operate oven indoors or in an enclosed area. In windy weather, place oven in an
outdoor area that is protected from the wind.
• Do not use petrol, kerosene or alcohol for lighting charcoal. Use of any of these or similar products will cause an explosion
possibly leading to severe bodily injury.
• Never add charcoal lighting fluid to hot or even warm coals as flashback or explosion may occur causing severe burns.
• Never use charcoal that has been pre-treated with lighter fluid. Use only a high grade plain charcoal or charcoal/wood
mixture.
• When using Hardwood ensure it is untreated! Use extreme caution when adding wood during cooking.
• The Oven will be extremely hot during use. Use caution when reaching into oven. To protect yourself from burns, always
wear shoes, oven mitts or gloves and protective clothing with long sleeves while operating this oven. Avoid touching hot
surfaces and be very careful when removing the oven door.
• Place Oven in an area where children and pets cannot come into contact with unit. Close supervision is necessary when
Oven is in use. Do not leave Oven unattended when in use.
• Lock the castor wheels before use.Never move Oven when it is in use or when it contains hot coals or ashes.
• Do not store or use Oven near petrol or other flammable liquids, gases or flammable vapors may be present.
• Improper installation, amendment, service or maintenance may cause property damage, personal injury or death.
• Use caution when assembling and operating your Oven to avoid scrapes or cuts from sharp edges of metal parts.
• This appliance is not intended for use by persons (including children) with reduced physical, sensory or mental capabilities,
or lack of experience and knowledge, unless they have been given supervision or instruction concerning use of the
appliance by a person responsible for their safety.
USE CAUTION AND DUE CARE WHEN OPERATING THE
OVEN.
SAVE THIS MANUAL FOR FUTURE REFERENCE.
Nano Series Owner’s Manual v1.1 © Bella Outdoor Living 2014 2

Parts List
Item No.:
Name and quantity
1
Chimney,1pc
2
Oven body, 1pc
3
Handle, 1pc
4
Long legs, 2pc
5
Storage tray, 1pc
6
Wheels, 2pc
7
Short legs, 2pc
8
Oven door, 1pc
9
Thermometer
Accessories
Quantity
Pizza peel
1 pc
Pizza server
1 pc
Pizza wheel cutter
1 pc
Owner's Manual
1 pc
M6 Screw
36 pc
Nano Series Owner’s Manual v1.1 © Bella Outdoor Living 2014 3

Assembly Steps
Choose a flat, cleared assembly area.
This oven is best assembled with 2 people.
Unpack the parts and place them on the cardboard box to prevent scratches.
Step 1:
Attach two wheels (6) to the bottom of the
oven wood storage tray (5) using M6
screws.
Step 2:
Fasten two longer legs (4) on the side of the
tray (5) without wheels and two shorter legs
(7) on the side of the tray (5) with wheels
using M6 screws.
Nano Series Owner’s Manual v1.1 © Bella Outdoor Living 2014 4

Step 3:
Fasten the handle (3) on on the side of the
oven without wheels using M6 screws.
Step 4:
Place the oven (2) on the stand and fasten.
This is a 2 person lift and use M6 screws.
Nano Series Owner’s Manual v1.1 © Bella Outdoor Living 2014 5

Step 5:
Attach the chimney (1) to the oven (2)
using M6 screws.
View of the assembled Pizza Oven
Nano Series Owner’s Manual v1.1 © Bella Outdoor Living 2014 6

The Pizza Oven is now ready for use:
Precautionary safety messages:
•As this oven uses a naked flame, it is advisable to keep a form of fire extinguisher close
by for added safety.
•Ensure the oven is not over loaded with firewood and any burning logs cannot roll out.
•Due to the intense heat, please use due care when operating this oven.
•These units have been designed as ovens for cooking purposes, not as a general wood
fire for outdoor heater.
•The oven temperature should not exceed 800 degrees F. Exceeding this temperature
level may cause personal injury and/or damage to the Pizza Oven which is not covered
under the warranty.
•Recommended maximum cooking temperature is 750 degrees F.
When firing up your oven, it is recommended that you gradually heated the oven to the
desired temperature. Ensure the damper is fully opened on the chimney.
The efficiency of the oven depends on the quality of the fire wood used. Only dry wood should
be used as damp wood produces excessive smoke and will delay the oven reaching the
desired operating temperature.
Once the fire is burning consistently add wood as required. Always check the Oven’s
temperature gauge to ensure the oven is maintaining the desired temperature.
Let the fire burn for about 15-30 minutes or until the fire has settled with minimum smoke
output and the desired heat. Cooking should commence when the coals have formed.
Additional firewood can be added as necessary to maintain the required heat.
Chimney/flue vent adjustment function (Damper):
The vent (Damper) in the chimney is used to control the air flow through the oven. An open
vent allows additional air flow which is useful when lighting the fire or boosting the fire when
adding fire wood. Slightly closing the vent will reduce the flame size, intensity and heat
allowing for more controlled cooking temperature.
Nano Series Owner’s Manual v1.1 © Bella Outdoor Living 2014 7

Oven door function:
The oven door is used when baking. The door should be removed when cooking pizzas.
When removing the door, use a mitt to avoid contact with the hot surface, place the door on
the lower tray of the pizza oven for safe storage.
Maintenance and cleaning instructions:
•To prevent a possible burn injury, always allow the Oven to cool before cleaning.
•Do not dispose of ash residue or unburnt charcoal briquettes until they have completely
cooled.
•Use warm soapy water and a soft cloth to clean the exterior of the Oven. Do not use
oven cleaner as it will damage the surface coating.
Nano Series Owner’s Manual v1.1 © Bella Outdoor Living 2014 8

BELLA OUTDOOR LIVING LIMITED WARRANTY
Bella Outdoor Living (herein called Bella) warrants it ovens, grills and fireplaces (herein called
Product) to be free from defects in materials and workmanship for a period of (1) one year
from the date of shipment.
QUALIFICATIONS TO THE WARRANTY
The complete Product Warranty outlined above does not apply under the following
circumstances:
(1) The Product has been subjected to non-standard use, including burning fuels with
abnormal burning characteristics including treated wood and wood products using a binder
that may burn at excessive temperatures and cause damage to the Product.
(2) This Warranty does not apply to normal wear and tear.
(3) This Warranty does not apply to any problems caused by over-firing, as defined in the
Owner’s Manual.
LIMITATION ON LIABILITY
It is expressly agreed and understood that Bella’s sole obligation and purchaser's exclusive
remedy under this Warranty, under any other warranty, expressed or implied, otherwise, shall
be limited to replacement, repair, or refund, as specified above, and such liability shall not
include, and purchaser specifically renounces any rights to recover, special, incidental,
consequential or other damages of any kind whatsoever, including, but not limited to, injuries
to persons or damage to property, loss of profits or anticipated profits, or loss of use of the
product.
In no event shall Bella be responsible for any incidental or consequential damages caused by
defects in its products, whether such damage occurs or is discovered before or after
replacement or repair, and whether or not such damage is caused by Bella’s negligence.
Some states do not allow the exclusion or limitation of incidental or consequential damages,
so the above limitation or exclusion may not apply to you. The duration of any implied
warranty with respect to this Product is limited to the duration of the foregoing warranty. Some
states do not allow limitations on how long an implied warranty lasts, so the above may not
apply to you.
INVESTIGATION OF CLAIMS AGAINST WARRANTY
Bella reserves the right to investigate any and all claims against this Warranty and to decide
upon method of settlement.
Nano Series Owner’s Manual v1.1 © Bella Outdoor Living 2014 9

DEALERS HAVE NO AUTHORITY TO ALTER THIS WARRANTY
Bella’s employees and dealers have no authority to make any warranties nor to authorize any
remedies in addition to or inconsistent with those stated above.
HOW TO REGISTER A CLAIM AGAINST WARRANTY
In order for any claim under this Warranty to be valid, Bella must be notified of the claimed
defect in writing or by telephone to Bella Outdoor Living, 251 W. Market St., Salinas, CA,
93901. Claims against this Warranty in writing should include the date of installation, and a
description of the defect.
Nano Series Owner’s Manual v1.1 © Bella Outdoor Living 2014 10