BigBlue ETFE Series User manual

User Manual
SolarPowa 150
ETFE-Solar Panel Series
CONTENTS
IMPORTANT SAFETY INSTRUCTION
Product Disclaimer:
Actual products may vary. reserves the right to the final interpretation of the contents
in this manual and all documents associated with this product. We also reserve the
right to update, change or terminate this manual without prior notice.
Read all the instructions.
Keep these instructions.
Heed all warnings.
Follow all instructions.
Failure to operate the product correctly may result in damage to the product or
personal property, and cause serious injury.
will not be held liable for damages caused by fire, earthquake, accidents, intentional
misconduct on the part of the customer abuse or other abnormal conditions.
reserves the right to the final interpretation of the contents of this user manual.
WARNING: This product can expose you to chemicals such as Di (2-ethylhexyl)
phthalate (DEHP), which is known to the State of California to cause cancer and birth
defects or other reproductive harm. For more information go to www.P65Warnings.ca.gov
Product Use:
The actual output of the solar panel depends on the light intensity and tilt angle of the
panel. The charging power of a solar panel may fluctuate due to weather conditions,
seasonal changes, and location. This product should be installed and connected
strictly in accordance with instructions found in the user manual.
The main body of this product is waterproof; however, the junction box and
connection points must not be immersed in water.
To avoid damaging the solar cells of the panel:
• DO NOT use sharp objects on the surface. Do not knock or bend the solar panel.
• DO NOT apply pressure to the solar panel or allow it to be dropped on any of its
corners, sides, or faces.
WARNING: This product should not come into contact with highly corrosive substances
or be immersed in corrosive liquids.
DO NOT repair any damage to the product. Refer servicing to qualified personnel.
SolarPowa 150-ETFE-Solar Panel Series
INTRODUCTION
SYSTEM OPERATIONS
SYSTEM SPECIFICATIONS
FREQUENTLY ASKED QUESTIONS
IMPORTANT SAFETY INSTRUCTION
Product Warranty:
Our company provides customers with a warranty of 24 months from the date of
purchase.
No dealer nor distributor may vary the terms of this warranty which is personal to the
original purchaser and is not transferable.
Please retain the sales receipt as proof of purchase.
Warranty claims must wherever possible be made through the dealer from whom the
product was purchased.
This warranty excludes:
• Damage caused through neglect, accident, misuse, wear, and tear, or incorrect
installation, adjustment, or repair by unauthorized personnel. Any unauthorized
servicing will result in the loss of warranty.
• The above conditions do not affect your statutory rights as a consumer.
IMPORTANT SAFETY INSTRUCTION
DO NOT disassemble or attempt to repurpose or modify in any manner.
Connect your device and solar charger with the included, or other certified power
cable to start charging.
Overheating will cause damage. Stop using and contact the manufacturer if the product Is
excessively hot, is emitting odor, is deformed, or showing other abnormalities.
Do not clean with harmful chemicals or detergents.
The surface temperature of the solar panel will increase during operation. Please do
not directly touch the front of the battery to avoid burns.
Do not use the panel when the panel front or back sheet is broken or damaged. It can
expose personnel to hazardous voltages.
Product Storage:
Recommended to fold and keep the solar panel vertically when being moved or stored.
The panel must not be knocked, exposed to heavy pressure, or bent during the
transportation and installation.
The product should be well folded or covered by something to protect it from sunlight.
Store in a cool, dry place. Recommend storage temperature: -4°F to 140°F / -20°C to 60°C.
Do not expose to moisture or submerge in liquid.
Store the solar panel in a dry environment when not in use.
Always ensure the junction box (if any) is not exposed to sunlight.
Product Disposal:
Unwanted solar panels must be disposed of in accordance with local legal requirements.
WARNING: Attention should be drawn to the environmental aspects of battery (if
included) disposal. Dispose of the product in specific recycling boxes only after a
complete discharge. Strictly follow the local regulations on battery disposal and
recycling.
Product Certifications:
06
07
09
10
01 02
03 04 05

FREQUENTLY ASKED QUESTIONS
1. Why the connected device cannot be charged?
Please check if your device is well connected to the solar charger or if the connecting
cable works normally. Re-plug the cable or try with another cable.
2. Why the connected device is charged slowly?
Ensure that the input current and voltage of the connected device are within the
accepted range. The amount of sunlight, weather, or shady may cause fluctuations
in the current output that prevent your devices from charging. In this event, try
placing the solar charger in more direct sunlight or wait for the weather to clear. In
order to get the maximum solar energy, please adjust the solar charger toward the
sun.
3. What is the difference between the nominal / rated output from the
actual output of the solar charger?
The maximum nominal / rated output of the SolarPowa 150 solar charger is rated
based on the Standard Test Conditions (STC) – the industry-wide standard for the
conditions under which a solar panel is tested. The test conditions are defined as
irradiation 1000 W/m², temperature 25°C, and air mass 1.5.
The nominal / rated power refers to the power of the solar charger, which is not
equal to the actual output of the solar charger. In fact, the actual power is less than
the nominal / rated power, since there will be some power loss in the form of heat
during the solar energy conversion, and a few other environmental factors such as
the weather conditions, seasonal changes, and location.
NOTE: Refer to page 09 to optimize the efficiency of the solar charger.
SYSTEM OPERATIONS 6. Solar charger, in most cases, does not deliver the full rated power. Here are a few
recommendations to optimize the efficiency of the ETFE-SolarPowa 150 solar
charger:
•
Perfect the Sunlight Orientation
The amount of sunlight shining on the panel fluctuates the output power. A solar
charger's performance can be maximized by orienting the panel so that it faces
directly toward the sun. The ideal angle of inclination for a solar panel is 90 degrees
from horizontal.
• Eliminate the Shade
The surface of the solar charger should not be shaded during use. Shading caused
by weather, coverings, or other obstructions can greatly reduce power output.
• Offset Surface Temperature Increase
The amount of power generated by a solar charger depends on its surface
temperature. Lower temperature leads to a higher generation. This effect is greater
compared to winter time than summer. During the summer day, particularly, the
surface of the solar charger may reach 131°F / 55°C , which reduces the rated
power over 10% efficiency.
• Keep it Clean
Dust or dirt can gradually accumulate on your solar panel, reducing the amount of
sunlight reaching the solar cells. Cleaning your panels a few times a year allows them
to convert more solar energy.
1. ETFE-SolarPowa built-in MC4 cable included.
2. Unfold the ETFE-SolarPowa 150.
3. Please use approved cables for charging.
4. Position the ETFE-SolarPowa 150 where the entire surface area is at an angle of 90°
facing direct sunlight. Prop up with the kickstand where necessary.
5. Avoid any shaded areas to optimize energy production.
INTRODUCTION
SolarPowa 150-ETFE-Solar Panel Series
Thank you for your purchase of the SolarPowa 150. The ETFE-SolarPowa 150 solar
panel combines industry-leading solar panel technology with ergonomic design to
optimize your satisfaction. It has an adjustable kickstand, which enables you to position
the solar charger in a good direction or orientation, facing the ideal angle for maximum
yield. With its seamless one-piece design and industrial-strength fabric-wrapped
exterior rear layer; this stellar solar charger has high-grade water resistance and dust
protection.
Please read this manual carefully to obtain the best performance from your SolarPowa 150.
Unpacking The Equipment
The carton should contain:
• The ETFE-SolarPowa 150 solar panel
• One user manual
SYSTEM SPECIFICATIONS
SPECIFICATIONS
General Information
Model
Rated Power
Working Voltage
Working Current
Open Circuit Voltage
Short Circuit Current
Folded size
Expanded Size
Net Weight
SolarPowa 150
150±5%
23.94V
6.26A
28.80V
6.58A
608 x 776 x 31mm / 23.9 x 30.6 x 1.2inch
1,217 x 776 x 25mm / 47.9 x 30.6 x 0.98inch
About5.59kg
06 07 08
09 10