Blaze BLZ-3-NG User manual

Blaze Outdoor Products Instructional Book
Page | 1
Version 1.4
USE & CARE GUIDE
GAS GRILLS BLZ-3(NG/LP), BLZ-4(NG/LP), BLZ-5(NG/LP)
ATTENTION INSTALLER
PLEASE LEAVE THESE INSTRUCTIONS WITH THE CONSUMER.
ATTENTION CONSUMER
PLEASE READ & RETAIN THESE INSTRUCTIONS OR UTURE RE ERENCE AND BE ORE INSTALLING
OR OPERATING.
- CONTACT INFORMATION -
Blaze Outdoor Products: 10920 Coursey Blvd, Baton Rouge, LA 70816 USA
Phone: [phone] email: [e-mail]
BLAZEGRILLS.COM
WARNING
I) Do not store or use gasoline or other flammable
liquids or vapor in the vicinity of this or any other
appliance
2) A LP cylinder not connected for use shall not be
stored in the vicinity of this or any other appliances.
DANGER - IF YOU SMELL GAS
I) Shut off the gas supply to the appliance at its source.
2) Extinguish any open flames.
3) Open grill hood to release any accumulation of gas
vapor.
4) If a gas odor persists, Keep away from your
appliance and contact your gas supplier or fire
department immediately.

2!

Never use dented, rusty or damaged propane cylinders. NEVER store additional or empty propane cylinders
in the cabinet or in the vicinity of this or any other appliance. Do not store propane cylinders indoors or on
their sides.
Children should NEVER BE LEFT ALONE or unattended in an area where an accessory is located. Place your
accessory well away from areas where children play. Do not store items that may interest children in or
around the area of your accessory, in your accessory cart, or in the masonry enclosure.
NEVER move the accessory when hot. When in use, portions of the accessory are hot enough to cause severe
burns.
Always maintain the required clearances from combustibles as detailed. Accessories are designed for
outdoor use only. NEVER use in a garage, building, shed, breezeway, or other enclosed area. Do not use this
equipment under any overhead combustible construction.
Grill accessories are not designed or certified for and are not to be installed in or on recreational vehicles,
portable trailers, boats or any other moving installation.
ALWAYS have an ABC Fire Extinguisher accessible – never attempt to extinguish a grease fire with water or
other liquids.
STORE YOU ACCESSORY: Store your accessory in a well-ventilated area. If stored indoors, detach and leave
LP cylinder outdoors in a well-ventilated area away from heat and away from where children may tamper
with it.
Keep any electrical supply cord and the fuel supply hose away from any heated surfaces. Electrical cords
should be placed away from walkways to avoid tripping hazard.
Do not repair or replace any part of the accessory unless specifically recommended in this manual. Other
service should be performed by a qualified technician.
If the accessory is installed by a professional installer or technician, be sure that he/she shows you where
your gas supply shut-off is located. All gas lines must have a shut-off that is readily and easily accessible. I
you smell gas, check for gas leaks immediately. Check only with a soap and water solution. Never check for
gas leaks with an open flame.
Inspect the LP gas supply hose prior to each use of the accessory. If there is evidence of excessive abrasion
or wear, or the hose is cut, it must be replaced before using the accessory.
THIS MANUAL MUST REAMAIN WITH THE PRODUCT OWNER FOR FUTURE REFERENCE.
BASIC CAUTIONS & CARE
• Do not leave side burner unattended while cooking
• Keep Stainless Steel Clean with using Mild Dish detergent such as Dawn. You can also
shine up the stainless with WD40 – Exterior only & not near food prep Area. DO NOT
USE Steel Wool or wire brushes this will Scratch the surface.
• Donotspray WD---40near anopen flame

4!
123425)6789:;<):;5)$:=47:>)&:?)+8;;<@=28;?A)
•The!LP!Gas!Cylinder!must!be!in!compliance!with!the!Specifications!for!LPYGas!Cylinders
of!the!US!Department!of!Transportation!or!the!National!Standard!of!Canada,!CAN/CSAY
B339.!!The!Basic!Tank!size!is!12”!in!diameter!and!18”!High!with!a!QCCY1!Cylinder!Valve.
•Any!enclosure!for!the!Cylinder!such!as!a!bbq!island!make!sure!the!island!is!well!vented
top!and!bottom.
•All!Natural!Gas!instillations!must!conform!to!local!codes!or!in!the!absence!of!local!codes
the!national!fuel!gas!code,!ANSIZ2223.1aY1998.
•In!Canada!installation!must!comply!with!the!standard!CAN/CGAYB149.2
•Always!use!a!licensed!plumber!or!contractor!to!install!all!Gas!installations.!Ensure!that
the!side!burner!is!fitted!independently!with!a!Brass!Gas!Shut!off!valve!located!close!to
the!side!burner!and!easily!accessible.
1%&B-%$&)-B0)'%C0)*,#$0#)
•Open!the!top!Hood!or!remove!the!top!cover
•Keep!your!Face!and!Body!away!from!the!burner!and!flame
•Push!in!and!Turn!Control!Knob!to!Left!High!Position!a!Spark!will!hit!the!Burner
•Try!three!times!and!if!Gas!does!not!ignite!then!Wait!5!Minutes
•If!Spark!does!not!work!you!can!place!lit!long!match!or!Long!Nose!Lighter!next!to
Burner!holes!to!ignite.!Gas!will!ignite!but!if!this!does!not!happen!switch!gas
burner!Off!and!try!again
•If!this!does!not!light!with!Electronic!Spark!or!Match!switch!off!and!call!a
professional!to!come!test!unit!or!call!manufacturer.
•Make!sure!Knob!is!in!the!OFF!Position!at!all!times!when!not!in!use.

5!
'%C0)*,#$0#)&"')+.$$0+-%.$)!%-B)&"')**D)
*"'%+)+.$$0+-%.$)E.#)16A)F123425)6789:;<)&:?G)
•When!installing!for!Natural!Gas!make!sure!that!the!side!burner!has!its!own!Brass
shut!off!valve!so!that!it!can!be!easily!and!safely!switched!off.
•Make!sure!that!you!always!use!a!trained!professional!contractor!and/or!Plummer
to!install!all!gas!appliances.
•If!you!smell!gas!switch!of!the!gas!supply!to!the!appliances!and!call!a!professional.
'%C0)*,#$0#)+.$H0#'%.$)I%-')
All!side!burners!will!either!come!Natural!Gas!or!Liquid!Propane!(LP)!as!per!your!
manufacturer.!!There!will!be!a!complete!conversion!kit!in!each!Side!Burner!for!the!
opposite!gas.!!The!kit!will!include!one!(Single!Side!Burner!)!or!Two!(Double!side!Burner)!
orifices!to!be!replaced.!!!
•Pull!out!Side!Burner!and!look!at!where!the!Gas!Goes!into!the!Burner!!Y!(Pic!Below)
•Remove!Orifice!and!replace!with!desired!gas!Type
•If!Unsure!of!full!procedure!please!contact!manufacturer!directly
•Always!have!a!gas!professional!perform!this!procedure!for!you

BASIC SIDE BURNER TERMINOLOGY
Refer to the charts below for part information.
Single Side Burner
Double Side Burner

BASIC TROUBLESHOOTING
Smell of Gas is Present
Check for loose connections in the gas line. Perform a leak test
with soapy water or Windex. DO NOT TRY AND TEST WITH
FLAME. If you find a leak call a gas professional to fix & shut off gas
to appliances.
Burner Does Not Ignite
Check position of spark tip it should jump over to the Brass Burner.
Clean area where contact will be made from spark tip to burner.
Make sure there is a Blue spark at the electrode tip to burner.
Make sure the wire is connected correctly. Make sure the orifice is
free of any grease or dirt. ALWAYS TURN OFF GAS WHEN
TESTING
Yellow Flame
Color on flame should be mostly Blue. There should be a yellow tip
but if flame is completely yellow clean burner and substances
around burner it can be oil or matter on the burner.
Plugged Orifice
Remove Orifice and clean with a fine wire.
No Gas To Burner
Check Shut Off Valve to see if in on position. Make sure that Gas is
on to main bbq and is operating – gas may be turned off.
ALWAYS CALL MANUFACTURER IF YOU HAVE TECHNICAL QUESTIONS

Blaze Product Registration
Please take a minute to let us know what you bought. This makes sure we keep you up to date and have your
info ready if you ever need warranty help!
Name
First Last
Email
Phone
Street Address
Address Line 2
City State / Province / Region
Zip / Postal Code Country
What is the model number of the Blaze Product purchased?
What is the serial number on the Blaze product (only on grills and side burners)?
Where did you buy your Blaze product?
Mail To
Blaze Outdoor Products
Warranty Registration
10920 Coursey Blvd
Baton Rouge, LA 70816