Blodgett ZEPHAIRE-G PLUS User manual

BLODGETT OVEN COMPANY
www.blodgett.com
44 Lakeside Avenue, Burlington, VT 05401 • Phone: [phone] • Fax: [phone]
BCX-14G and
ZEPHAIRE-G PLUS
BCX Series Combi Stacked on a
Full-Size Gas Convection Oven
BCX-14G STACKED ON A ZEPHAIRE-G PLUS
Project
Item No.
Quantity
Requires Blodgett stacking kit SK-88FS.
Shown with optional casters
SHORT FORM SPECIFICATIONS Provide Blodgett model
BCX-14G Combi stacked on a model DFG-200 bakety depth gas
convection oven.
BCX-14G Combi - Shall have the ability to cook with pressureless
steam (212F), hot air, or combination of steam and hot air (with an
operating range 140F to 500F), vario-steaming (operating range
140F to 212F), low temperature cooking and holding, rethermaliz-
ing, cool down mode and our Exclusive Steam on Demand steam
injection system. Oven capacity to accept 7ea 18x26 bake pans
or 14ea 12x20x2.5” full size steam table pans with 3-1/4” spac-
ing. Front access service user interface control panel and service
diagnosis system. Unit shall be constructed with a fully welded
stainless steel frame. Cooking chamber shall be constructed with
304 series with bright-annealed stainless steel finish and coved
corners. Oven cavity shall be open to the atmosphere with a ther-
mostatically controlled quench box with a flow rate of less than 8
gallons per hour (total water consumption not to exceed 15 gal-
lons per hour). Unit shall include a four speed, bi-directional fan
with vent switch to control humidity in the cooking chamber. Dual
pane thermal glass window with 180 degree door swing, two-step
safety door-latch with adjustable door hinges, door mounted drip
pan. Unit to include a detachable 4” core temperature probe,
halogen lights and external hose with spray nozzle. Supply with
exclusive time to delime indicator with adjustable settings of 30, 60
or 90 hours of run time, semi-automatic deliming system. Where
applicable, quantities in this spec are doubled for stacked units.
A start-up inspection service will be performed by our factory-
authorized agent at no cost to the operator. One-year parts and
labor warranty
Zephaire G Plus - Shall mal glass windows with single porcelain
handle and simultaneous operation. Unit shall be gas heated with
electronic spark ignition and shall cook by means of a dual-flow
system combining direct and indirect heat. Air in baking chamber
distributed by dual inlet blower wheel powered by a two speed,
1/3 HP motor with thermal overload protection. Each chamber
shall be fitted with five chrome-plated removable racks. Control
panel shall be recessed with Cook/Cool Down mode selector,
solid state manual infinite thermostat (200 - 500°F), and 60-min-
ute timer. 2 year parts and 1 year labor warranty.
This model consists of a standard BCX-14G stacked on a Zephaire
G Plus. For more information on each oven refer to the the BCX-14G
and Zephaire G Plus specications sheets.
BCX-14G Approvals
Zephaire G Plus Approvals

BCX-14G STACKED ON A ZEPHAIRE-G PLUS
Printed in U.S.A. NOTE: FOR COMMERCIAL USE ONLY
NOTE: The company reserves the right to make substitutions of components without prior notice
APPROVAL/STAMP
P/N 50455 Rev S (3/12)
DIMENSIONS:
Product clearance 6” from combustible and non-combustible
construction. 12” on left side if not on casters.
Additional Height:
6” adjustable legs 6-7/8” - 8” (174.6-203.2mm)
GAS SUPPLY: BCX-14G Zephaire G Plus
Connection: 3/4” NPT 3/4” NPT
Inlet Pressure:
Natural 7.0” W.C. 7.0” W.C. minimum
10.5” W.C. maximum
Propane 14.0” W.C. 10.05” W.C. minimum
13.0” W.C. maximum
Manifold Pressure:
Natural 3.5 W.C. 3.5 W.C.
Propane 10.0 W.C. 10.0 W.C.
Maximum Input: 115,000 BTU/hr 60,000 BTU/hr
WATER SUPPLY (BCX-14G only):
TDS: < 100 ppm Hardness: 80-120 ppm pH: 7.0 - 8.0
Chlorides: < 30 ppm Chlorine: 0 ppm 30(min)-50(max) PSI
140°F (60°C) avg. drain temp.
2” drain connection 3/4” garden hose cold water
Appliance is to be installed with backflow protection in accordance
with Federal, State or Local codes.
POWER SUPPLY:
BCX-14G: 120VAC, 20 amp, Nema 5-20R dedicated receptacle
Zephaire G Plus: 115 VAC, 6 amp, 1 phase, 60 Hz., 2-wire with ground
6’ (1.8m) electric cord set furnished.
Both units: Each unit requires a dedicated circuit.
Blodgett recommends a Pass & Seymour, model 2095, GFCI
for these ovens.
MINIMUM ENTRY CLEARANCE:
BCX-14G Zephaire G Plus
Uncrated 33” (838mm)* 32-1/16” (814mm)
Crated 42” (1066.8mm) 37-1/2” (953mm)
* after adjustment of flue brackets
SHIPPING INFORMATION:
Approx. Weight:
BCX-14G 645 lbs. (293 kg)
Zephaire G Plus 640 lbs. (290 kg)
Crate sizes (per section):
BCX-14G 44.5” H x 42” W x 54.25” D (1130 x 1067 x 1378mm)
Zephaire G Plus 37-1/2” (952mm) x 43-1/2” (1105mm) x 52” (1321mm)
DIMENSIONS ARE IN INCHES (MM)
69.03 (1753)
65 (165)
41.19” (1021)
0(0)
32 (813)
38.25 (972)
0 (0)
3 (76)
39.88 (1013)
46.87* (1190)
Customer Supplied Drain
*76.06 (1932) overall depth
with combi door open 90°
UTILITY CONNECTIONS
0 (0)
2.91 (74)
5.65 (144)
1.56 (40)
3.34 (85)
5.84(148)
23.59 (599)
F
U
D
F
U
F
UUnfiltered Water -
Condensate, cold only
Filtered Water -
Boiler, hot or cold
D
BLODGETT OVEN COMPANY
www.blodgett.com
44 Lakeside Avenue, Burlington, VT 05401 • Phone: [phone] • Fax: [phone]