Blodgett SN-3E User manual

PARTS LIST, COUNTER CONVECTION STEAMERS
MODELS SN-III, SN-IV, SN-V
PART NUMBER 10018R3 1 2006-09-22
PARTS LIST
COUNTER CONVECTION STEAMERS
BLODGETT MODELS: SN-3E
SN-4E
SN-5E
September 22, 2006

PARTS LIST, COUNTER CONVECTION STEAMERS
MODELS SN-III, SN-IV, SN-V
PART NUMBER 10018R3 2 2006-09-22
GENERAL ASSEMBLY
FIGURE 1

PARTS LIST, COUNTER CONVECTION STEAMERS
MODELS SN-III, SN-IV, SN-V
PART NUMBER 10018R3 3 2006-09-22
ITEM Part # DESCRIPTION 3 4 5
1A 42678 Door Assembly 1
42680 Door Assembly 1
42682 Door Assembly 1
1 42638 Door Frame 1
42639 Door Frame 1
42641 Door Frame 1
2 42454 Door Handle Assembly 1 1 1
* 42258 Decal 1 1 1
* 42453 Door Handle 1 1 1
* 42705 Door Handle Plate 1 1 1
* 40090 Socket Set Screw 1/4 - 20 x 1-3/4 2 2 2
* 40086 Socket Set Screw 1/4 - 20 x 3/4 1 1 1
* 40646 Spacer 2 2 2
* 40268 Lock Washer 1/4 2 2 2
* 40093 Hex Nut 1/4 - 20 2 2 2
3 41679 Latch Assembly 1 1 1
4 41699 Door Bushing 4 4 4
5 N/A Spacer 2 2 2
6 41672 Door Panel 1
41670 Door Panel 1
41671 Door Panel 1
7 41658 Door Gasket 1
41656 Door Gasket 1
41657 Door Gasket 1
8 41665 Gasket Plate 1
41663 Gasket Plate 1
41664 Gasket Plate 1
9 41698 Hinge Rod 1
41696 Hinge Rod 1
41697 Hinge Rod 1
* 10 40369 Steam Diverter 2 2 2

PARTS LIST, COUNTER CONVECTION STEAMERS
MODELS SN-III, SN-IV, SN-V
PART NUMBER 10018R3 4 2006-09-22
ITEM Part # DESCRIPTION 3 4 5
11 42285 Actuator Complete With Retaining Rings 1 1 1
* 42137 Door Switch 1 1 1
12 41631 Striker 1 1 1
* 41632 Stainless Steel Washer 1 1 1
* 40112 Lock Washer 1 1 1
* 40114 Nut 1 1 1
13 40946 Pilot Light, green 1 1 1
14 40951 Pilot Light, red 1 1 1
** 15 42456 Timer Dial - 60 Minutes, 50 Hz, Optional 1 1 1
43265 Timer Dial - 60 Minutes, 60 Hz 1 1 1
43266 Timer Dial - 120 Minutes, 60 Hz, Optional 1 1 1
16 41886 Power Switch 1 1 1
* 17 43267 Label, De-Lime (rear of unit) 1 1 1
** 18 42893 Control Decal 1
42911 Control Decal - Continuous Steam, Optional 1
42896 Control Decal 1
42912 Control Decal - Continuous Steam, Optional 1
43268 Control Decal 1
42913 Control Decal - Continuous Steam, Optional 1
19 40244 Component Mounting Board 1 1 1
** 20 40625 Level Control Board, 10K OHM 1 1 1
41064 Level Control Board, 1M OHM 2 2 2
21 41887 Thermostat-Operating 1 1 1
22 41888 High Limit Thermostat 1 1 1
23 42094 Relay-Single Pole 240V 1 1 1
24 42092 Relay-Double Pole 240V 1 1 1
** 25 40971 Timer, 60 Minutes, 240V 1 1 1
40973 Timer, 120 Minutes, 240V, Optional 1 1 1
* 41881 Rotary Shaft Seal 1 1 1
26 40852 Buzzer 240V 1 1 1
** 27 40892 Contactor - 4 Pole 1 1 1

PARTS LIST, COUNTER CONVECTION STEAMERS
MODELS SN-III, SN-IV, SN-V
PART NUMBER 10018R3 5 2006-09-22
ITEM Part # DESCRIPTION 3 4 5
40840 Contactor - 380, 415, 480, 600 Volt 1 1 1
28 41037 Cooling Solenoid 240V 1 1
40307 Cooling Solenoid 240V 1
29 41037 Fill Solenoid 240V 1 1 1
30 40602 Blow-down Solenoid 240V 1 1 1
** 31 41718 Element Assembly, 7.5 kW, 208V 1
41719 Element Assembly, 7.5 kW, 220/380V 1
41720 Element Assembly, 7.5 kW, 240/415V 1
41721 Element Assembly , 7.5 kW, 480V (287) 1
41722 Element Assembly , 7.5 kW, 600V (347) 1
41636 Element Assembly, 10 kW, 208V 1 1
41642 Element Assembly, 10 kW, 220/380V 1 1
41637 Element Assembly, 10 kW, 240/415V 1 1
41638 Element Assembly , 10 kW, 480V (287) 1 1
41722 Element Assembly , 10 kW, 600V (347) 1 1
41639 Element Assembly, 15 kW, 208V 1
41639 Element Assembly, 15 kW, 220/380V 1
41641 Element Assembly, 15 kW, 240/415V 1
41643 Element Assembly , 15 kW, 480V (287) 1
41724 Element Assembly , 15 kW, 600V (347) 1
32 41703 Element Gasket 1 1 1
33 40708 Terminal Block 4 4 4
34 40707 End Section 1 1 1
35 40840 Ground Lug 1 1 1
42013 Earth I.D. Tag
36 41297 Steam Generator Tank 1 1 1
* 36 40234 Tank Cover 1 1 1
* 42138 Tank Gasket 1 1 1
37 40469 Probe - 5" Low Level Cut Off 1 1 1
38 40468 Probe - 4.25" Low Level 1 1 1
39 40931 Probe - 3.6875" High Level 1 1 1

PARTS LIST, COUNTER CONVECTION STEAMERS
MODELS SN-III, SN-IV, SN-V
PART NUMBER 10018R3 6 2006-09-22
ITEM Part # DESCRIPTION 3 4 5
40 41633 Perforated Trough 1 1 1
41 40441 Elbow 1/4 c x 1/8 MPT 1 1 1
42 40457 Tee 3/8c x 1/8 MPT 1 1 1
43 40424 Connector 1/4 c x 1/8 MPT 1 1 1
44 40435 Connector ½ c x 3/4 MPT 1 1 1
45 40450 Elbow ½ c x 3/4 MPT 1 1 1
46 40205 Thermostat Fitting, 3/8 c x 3/8 MPT 1 1 1
47 40406 Union Coupling ½ c 1 1 1
48 41047 Right Hand Steam Jet Tube 1 1 1
* 41048 Left Hand Steam Jet Tube 1 1 1
49 40447 Elbow ½ c x 1/4 MPT 2 2 2
50 40411 Elbow ½ c 1 1 1
51 40475 Water Connection 3/8 c 1 1 1
52 40076 Screw 10-32 x ½ SS 6 6 6
53 41875 Screw (Special) 10-32 x ½ 6 8 8
* 54 41864 Continuous Steam Switch (Optional) 1 1 1
55 42905 Left Hand Side and Back 1
42906 Left Hand Side and Back 1
42907 Left Hand Side and Back 1
* 55 41856 Nut Cage, 1/4 - 20 2 2 2
56 42390 Top 1 1 1
** 57 42338 Side Panel 1
42339 Side Panel 1
42340 Side Panel 1
** 58 40199 Rack Slides 2
40200 Rack Slides 2
40201 Rack Slides 2
* 59 40843 Rack Pin Assembly 4 4 4
60 43269 Brass Nipple, ½ -14 1 1 1
61 43270 Brass Elbow, ½-14 1 1 1
62 43271 Square Head Brass Plug, ½ - 14 1 1 1

PARTS LIST, COUNTER CONVECTION STEAMERS
MODELS SN-III, SN-IV, SN-V
PART NUMBER 10018R3 7 2006-09-22
ITEM Part # DESCRIPTION 3 4 5
63 40429 Connector, 3/8 c x 1/8 MPT 1 1 1
64 43272 Connector, 3/8 c x 1/8 FPT 1 1 1
65 40445 Elbow 90E, 3/8 c x 3/8 MPT 111
66 41102 Pressure Switch 1 1 1
67 40669 Foot Leveler 4 4 4
68 43273 Adjustable Leg, Optional 4 4 4
* ** 69 41860 Fuse 2 Amp. 250V (208, 240V) 2 2 2
41860 Fuse 2 Amp. 250V (220, 220/380, 240/415) 1 1 1
41844 Fuse Holder (208, 240V) 2 2 2
41844 Fuse Holder (220, 220/380, 240/415V) 1 1 1
41766 Fuse 1 Amp, 600V (380, 415, 480) 2 2 2
41768 Fuse, 8/10 Amp, 600V (600V) 2 2 2
69 41769 Fuse Holder (380, 415, 480, 600V) 2 2 2
* ** 70 40974 Transformer, 380/220V, 50/60Hz, 100VA 1 1 1
40974 Transformer, 415/240V, 50/60Hz, 100VA 1 1 1
40980 Transformer, 480/240V, 60Hz, 100VA 1 1 1
40985 Transformer, 600/240V, 60Hz, 100VA 1 1 1
71 40097 Hex Blot 5/16-18 x 1 SS 2 2 2
72 40093 Hex Nut 1/4 - 20 SS 4 4 4
* 73 41725 “Y” Strainer, Optional 1 1 1
74 42793 Compartment Strainer 1 1 1
* 75 40683 Wire Harness 1 1 1
76 41114 Copper Tube, 3/8 1 1 1
* NOT SHOWN.
** SELECT AS REQUIRED.