Cleveland Enodis 24-CDM User manual

Cleveland
™
Project ________________________________
Item __________________________________
Quantity _______________________________
FCSI Section ____________________________
Approval _______________________________
Date __________________________________
1333 East 179 St.,
Cleveland, Ohio, U.S.A. 44110
Tel: [phone]
Fax: [phone]
Web Site: www.ClevelandRange.com
Email: [e-mail]
CLASSIC CONVECTION STEAMERS
15 PSI BOILER BASE STYLE
MODEL:c24-CDM
Cleveland Standard Features
nCooking Capacity for up to six 12˝ x 20˝ x 21⁄2˝deep Cafeteria
Pans.
nPressureless cooking with forced convection steam,
permitting doors to be opened while cooking continues.
nEach compartment is equipped with a 60 minute mechanical
timer, separate bypass switch for constant steaming and a
cold water condenser for superior cooking results.
nDurable 14 Gauge Stainless Steel Construction:
For Compartment Door and Steam Cooking Cavity.
nSeparate Main Power Switch for “On/Off”
nExclusive Steam Cooking Distribution System: The
exclusive Convection Jets produce a high velocity
convection steam without fans. Coved Corner design in
cooking compartment distributes heat evenly and is easy to
keep clean. Creased top & bottom enhance drainage. Cold
Water Condenser for each compartment maintains a dry
steam. Fully insulated cooking compartment for thermal
efficiency. Removable Stainless Steel Slide Racks for easy
cleaning.
nExclusive “Cool to the Touch” Compartment Door
Design: Free floating inner door with reversible door gasket
provides an air tight seal. Stainless Steel Slam/Latch Door
Latch mechanism provides greater reliability.
nLeft Hand Door Hinging: Compartment Doors hinged left,
controls on the right.
nModular Cabinet Base with Hinged Door.
nMoisture Separator Trap for incoming steam.
nPressure Reducing Valve: For 15-50 psi incoming steam
pressure based on a 3⁄4˝ steam line. (minimum size)
nSingle Cold Water Connection
nNSF Certified 6˝ Stainless Steel Legs with adjustable
flanged feet for a one inch level adjustment.
nStandard Voltage for Controls: 115 volts, 60 Hz, single
phase.
nAll Controls are serviceable from the front.
pClean non-toxic, uncontaminated steam is required
for all “Direct Steam” steamers
Options & Accessories
pRight Hand Door Hinging, Controls on the Left (DHR)
pElectronic Timer with Compensating Load Feature (ETC)
pON/OFF Steam Switch only for compartment controls (MC)
pCafeteria pans in depths of 1˝, 21⁄2˝, 4˝ and 6˝
pVoltages for controls other than standard
pCompartment Door Steam Shut Off Switch (SCS)
pStainless Steel Base Frame (FSS)
pSecond Pressure Reducing Valve for 50-120 psi steam pres-
sure (PRV)
pCorrectional Packages
4
Shall be Two Compartments, CLEVELAND Convection Steamer, Model 24-
CDM, Direct Steam, 115 volts, single phase. For each cooking compartment:
60 minute Mechanical Timer, Manual Operation Mode and Cold Water
Condenser. Type 304 Stainless Steel cooking compartment.
Short Form Specifications
Cleveland Classic Series
TWO COMPARTMENT, PRESSURELESS
DIRECT STEAM
24” WIDE CABINET BASE DESIGN
CONVECTION
STEAMERS
SECT. III PAGE 7
0707

(NOT TO SCALE)
SECT.III PAGE 8
0707
Litho in U.S.A.
Right - 3”, Left - 3”, Rear - 3”
(12” on control side if adjoin-
ing wall or equipment is over
30” high for service acess)
Contact factory for
variances to clearances.
1 1/2” IPS common drain.
Do not connect other units
to this drain.
Do not use PVC pipe for
•Each compartment has capacity for:
Three, 12˝ x 20˝ x 21⁄2˝or six, 12˝ x 20˝ x 1˝ deep
Cafeteria Pans.
WATER QUALITY REQUIREMENT
The recommended minimum water quality standards
whether untreated or pre-treated, based upon 10 hours
of use per day, and a Daily Blowdown, are as follows:
TOTAL DISSOLVED SOLIDS less than 60 parts per million
TOTAL ALKALINITY less than 20 parts per million
SILICA less than 13 parts per million
pH FACTOR greater than 7.5
CHLORINE less than 30 parts per million
Consult a local water treatment specialist for an on site
water analysis for recommendations concerning steam
generator feed water treatment (if required), in order to
remove or reduce harmful concentrations of minerals.
The use of highly mineralized water will mean that more
frequent servicing of the steam generator will be
necessary. The fact that a water supply is potable is not
proof that it will be suitable for the generator.
NOTES:
Cleveland Range reserves right of design improvement or modification, as warranted.
Many regional, state and local codes exist and it is the responsibility of the owner and installer to comply with the codes.
Cleveland Range equipment is built to comply with applicable standards for manufacturers. Included among those approval agencies are UL, NSF and CSA.