Blodgett KLT-12G User manual

BLODGETT OVEN CO ▪44 lakeside Ave ▪Burlington, VT 05446
Tel. [phone] ▪Fax [phone] ▪www.blodgett.com
1
PARTS LIST
GAS SELF-CONTAINED KETTLE
MODEL: KLT-12G

CROWN FOOD SERVICE EQUIPMENT LTD.
70 OAKDALE ROAD, DOWNSVIEW, (TORONTO), ONTARIO, CANADA, M3N 1V9
TELEPHONE: [phone], FAX: [phone]
PRINTED IN CANADA
2 2007-06-26
FIGURE 1
FIGURE 1

ITEM PART
NUMBER
DESCRIPTION QUANTITY
1 43495 Kettle Assembly 1
2 42545 Lid Assembly 1
3 40259 Knob 1
4 42795 Handle 1
5 42948 Acorn Nut ½ - 13 NC 1
6 41015 Bearing 1
7 42829 Actuator Collar 1
8 41824 Retaining Ring 1
9 41012 Bearing 1
10 41013 Washer 1
11 41823 Retaining Ring 1
12 42546 Leg Post 1
13 42482 Trunnion Box Side Panel 1
14 41304 Flue Assembly 1
15 40002 Bottom Cover 1
16 41226 Sight Glass Assembly 1
17 40613 Relief Valve 50 PSI 1
18 40548 Air Vent Assembly 1
** 19 41224 Operating Label, English 1
41246 Operating Label, French 1
20 41021 Side Panel 1
21 40827 Console Cover 1
22 41474 Flanged Foot 4
23 41044 Down Tube 1
24 40803 Lock Pin 1
25 40138 “O” Ring 1

ITEM PART
NUMBER
DESCRIPTION QUANTITY
26 40808 Spring 1
27 43297 Washer 2
28 40134 Ex Ring Clip 1
29 40995 Thermostat Dial 1
30 43024 Hx Set Screw 1
** SELECT AS REQUIRED.

FIGURE 2

FIGURE 2
ITEM PART NUMBER DESCRIPTION QUANTITY
1 40469 Low Water Probe 1
2 41018 Pipe, 3/8 x 7 ½ Length 1
3 41787 Elbow 3/8 1
4 41305 Burner Support Channel 1
5 40903 Burner 1
** 6 40904 Orifice Jet #57 Natural Gas 10
40905 Orifice Jet .70 mm LP Gas 10
7 41229 Electrode Assembly 1
** SELECT AS REQUIRED

FIGURE 3

FIGURE 3
ITEM PART NUMBER DESCRIPTION QUANTITY
1 43496 1/2" Gas Swivel Joint 1
2 42829 Tilt Lock, Actuator Collar 1
3 41776 Nipple, ½” x 2 ½" 1
4 40616 Union Elbow Assembly 1
5 41820 Union, ½" 1
6 42579 Nipple, ½" x 3" 1
** 7 41045 Gas Control Valve (Natural) 1
41046 Gas Control Valve (L.P.) 1
8 42580 Nipple, ½ x 5 1
9 42746 Gas Line Support 1
10 41014 3/8 Pipe Strap 1
11 41790 90EStreet Elbow, ½" 1
12 41893 Ball Valve, ½" 1
13 41812 Reducing Coupling, ½" - 3/4" 1
14 41002 Temperature Control, 120V 1
41008 Temperature Probe 1
15 40938 Micro-Switch 1
16 41118 Potentiometer 1
* 43497 Rotary Shaft Seal 1
17 41883 Power Switch 1
18 40818 Pilot Light, Temperature, Red, 125V 1
19 40823 Pilot Light, Ignition, Green, 125V 1
20 40819 Pilot Light, Low Water, Amber, 125V 1
21 42732 Component Mounting Bracket 1
* NOT SHOWN.
** SELECT AS REQUIRED.

FIGURE 3
ITEM PART NUMBER DESCRIPTION QUANTITY
22 41093 Ignition Module (DSI System) 1
23 40708 Terminal Block Section 2
24 40707 Terminal Block End 1
25 42270 Terminal Strip 1
** 26 40991 Transformer, 220/240-120, 50/60 Hz, 100VA 1
40984 Transformer, 208-120, 60 Hz, 100VA 1
27 40542 Water Level Control 1
28 40907 Pressure Gauge 1
29 40030 Pressure Switch 1
30 41225 Pressure Switch Bracket 1
** 31 41844 Fuse Holder, (208 - 240V Units) 2
** 32 41859 Fuse, 250V, 1 Amp., (208 - 240V Units) 2
** 33 41844 Fuse Holder (120V Units Only) 1
** 34 41861 Fuse, 250V, 3 Amp. (120V Units Only) 1
35 42013 Earth Ground I.D. Tag 1
36 40902 Transformer Bracket 1
* 37 42706 Cord Set, 120V, Units Only 1
* NOT SHOWN.
** SELECT AS REQUIRED.

ALTERNATE PARTS
Page Item Crown Blodgett
3 3 2-KB01 43029
19 6660-2 42910
4294-TD02
42456