Briggs & Stratton 326400 Series Setup guide

COPYRIGHT by BRIGGS & STRATTON CORPORATION
All rights reserved. No part of this material may be reproduced or transmitted,
in any form or by any means, electronic or mechanical, including photocopying,
recording or by any information storage and retrieval system, without permission
in writing from Briggs & Stratton Corporation.
PRINTED IN U.S.A.
FORM MS6179−03/18/2009
REPLACES FORM MS6179−08/23/2007
FILE IN SECT. 2 OF SERVICE MANUAL
326400
Illustrated Parts List
Model Series
326400
TYPE NUMBERS:
0010 through 0080,
0110 through 0399,
0611, 0620,
0630 through 0799,
0801, 0802, 0803, 0804, 0805,
1160, 2520, 2521, 2522, 2526, 2527,
2528, 2529, 2530, 2550, 2560, 2561,
2562, 2563, 2580, 2581, 2582, 2583, 2596.
Not for
Reproduction

326400
6179−2Assemblies include all parts shown in frames. 03/18/2009
2
13A
9
10
383
635
6
7
5
308
11
337
645
406
342
989
307
724A
724
722
989A
13
362
322
15
8
552
14
626
871
870
415
306
1
1 395663 Cylinder Assembly
5 691712 Head−Cylinder
6 691261 Washer
(Cylinder Head)
7 692231 Gasket−Cylinder Head
8 495738 Breather Assembly
9 27803s Gasket−Breather
10 690294 Screw
(Breather Assembly)
11 691512 Tube−Breather
13 691614 Screw
(Cylinder Head)
(1 3/4” Long)
−−−−−−− Note −−−−−
691640 Screw
(Cylinder Head)
(2 1/16” Long)
13A 691441 Screw
(Cylinder Head)
(2 7/16” Long)
14 691690 Stud
(Cylinder Head)
15 692833 Plug−Oil Drain
306 299536 Shield−Cylinder
307 690294 Screw
(Cylinder Shield)
308 691731 Cover−Cylinder Head
(Used After Code Date
75060800).
−−−−−−− Note −−−−−
221953 Cover−
Cylinder Head
(Used Before Code
Date 75060900).
Used on Type No(s).
0291, 0648.
322 692198 Screw
(Cylinder Head Cover)
337 802592s Plug−Spark
342 298125s Plunger−Breaker
362 793351 Shield−Spark Plug
383 89838 Wrench−Spark Plug
406 690533 Spring−Breather Tube
415 692882 Plug
(Cylinder)
552 393666 Bushing−
Governor Crank
626 690512 Spacer−
Governor Crank
635 66538s Boot−Spark Plug
645 692880 Bushing−Plunger
722 68768 Seal−Plunger
724 93516 Retainer−Seal
724A 221873 Retainer−Seal
870 691583 Seat−Valve
(Exhaust)
871 231218 Bushing−Valve Guide
989 690578 Stop Switch−
Spark Plug
−−−−−−− Note −−−−−
293739 Stop Switch−
Spark Plug
Used on Type No(s).
0200.
298926 Stop Switch−
Spark Plug
Used on Type No(s).
0028, 0062, 0138,
0187, 0195, 0220,
0232, 0237, 0238,
0243, 0266, 0295,
0320, 0327, 0658,
0663, 0675, 0680,
0681, 0687, 0691,
0729, 0730, 0735,
2528, 2562.
390785 Stop Switch−
Spark Plug
Used on Type No(s).
0640, 0734.
989A 690633 Stop Switch−
Spark Plug
Engine Gasket Set−Reference 358
Carburetor Overhaul Kit−Reference 121
Valve Gasket Set−Reference 1095
REF. PART REF. PART REF. PART
NO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
Not for
Reproduction

326400
6179−3Assemblies include all parts shown in frames. 03/18/2009
3
45 45
35
42
40
46
27
26
27
32
31
30
33 34
36
225
553
42
40
553
742
591
900A
598
743
746
900
407
511
1144
29
28
755
1143
552
626
219
25
219A
221
25 792365 Piston Assembly
(Standard)
−−−−−−− Note −−−−−
792367 Piston
Assembly
(.020 Oversize)
26 792366 Ring Set
(Standard)
−−−−−−− Note −−−−−
792368 Ring Set
(.020 Oversize)
27 691792 Lock−Piston Pin
28 299691 Pin−Piston
29 299632 Rod−Connecting
30 691726 Dipper−
Connecting Rod
31 690396 Lock−Rod Screw
32 692345 Screw
(Connecting Rod)
33 394436 Valve−Exhaust
34 394435 Valve−Intake
35 691597 Spring−Valve
(Intake)
36 691597 Spring−Valve
(Exhaust)
40 691939 Retainer−Valve
−−−−−−− Note −−−−−
690274 Retainer−
Valve
Used on Type No(s).
0722.
42 494553 Keeper−Valve
(Used After Code Date
80111200).
−−−−−−− Note −−−−−
68283 Keeper−Valve
(Used Before Code
Date 80111300).
45 691594 Tappet−Valve
46 692855 Camshaft
219 291192 Gear−Governor
(Used Before Code
Date 78062000).
219A 393720 Gear−Governor
221 841026 Cup−Governor
225 691357 Shaft−Governor Gear
407 690810 Screw
(Camshaft Bearing)
511 690402 Washer
(Camshaft Bearing)
552 393666 Bushing−
Governor Crank
553 690269 Retainer−Valve Spring
591 691746 Plug−Camshaft
598 270516 Shim−End Play
(Camshaft Bearing)
(.009 Thick)
−−−−−−− Note −−−−−
270517 Shim−
End Play
(Camshaft Bearing)
(.007 Thick)
270518 Shim−
End Play
(Camshaft Bearing)
(.005 Thick)
626 690512 Spacer−Governor
Crank
742 691080 Retainer−E Ring
743 691153 Gear−Drive
746 691803 Gear−Idler
755 299706 Bearing−Camshaft
900 691767 Shaft−Gear
900A 691768 Shaft−Gear
1143 691081 Screw
(Drive Gear Cover)
1144 690301 Washer
(Drive Gear Cover)
Engine Gasket Set−Reference 358
Carburetor Overhaul Kit−Reference 121
Valve Gasket Set−Reference 1095
REF. PART REF. PART REF. PART
NO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
Not for
Reproduction

326400
6179−4Assemblies include all parts shown in frames. 03/18/2009
4
357
17
16
24
17
16 691797 Crankshaft
−−−−−−−Note −−−−−
690534 Crankshaft
Used on Type No(s).
0237, 0133, 0190,
0252, 0315, 0788,
2582.
261222 Crankshaft
Used on Type No(s).
0139, 0204, 0228,
0328, 0678.
690535 Crankshaft
Used on Type No(s).
0050, 0116, 0130,
0143, 0147, 0149,
0150, 0151, 0156,
0167, 0170, 0172,
0173, 0174, 0185,
0186, 0188, 0192,
0193, 0208, 0219,
0231, 0248, 0257,
0286, 0290, 0310,
0317, 0318, 0329,
0337, 0343, 0371,
0636, 0638, 0666,
0669, 0684, 0690,
0706, 0721, 0751,
2550.
690536 Crankshaft
Used on Type No(s).
0022, 0063, 0114,
0129, 0153, 0175,
0176, 0183, 0198,
0205, 0217, 0224,
0233, 0235, 0236,
0238, 0247, 0255,
0261, 0265, 0266,
0273, 0277, 0278,
0279, 0285, 0287,
0291, 0296, 0303,
0320, 0334, 0338,
0340, 0344, 0345,
0346, 0347, 0348,
0353, 0359, 0361,
0363, 0366, 0367,
0374, 0375, 0383,
0385, 0394, 0396,
0633, 0634, 0648,
0650, 0654, 0661,
0671, 0674, 0676,
0680, 0687, 0692,
0693, 0694, 0696,
0698, 0699, 0702,
0703, 0708, 0714,
0718, 0722, 0724,
0729, 0733, 0736,
0746, 0753, 0754,
0757, 0764, 0771,
0772, 0774, 0776,
0782, 0787, 2522,
2563, 2596.
Crankshaft
(NO LONGER
AVAILABLE)
Used on Type No(s).
0158, 0160, 0197,
0216, 0237.
690537 Crankshaft
Used on Type No(s).
0210, 0262, 0630.
690540 Crankshaft
Used on Type No(s).
0062, 0241, 0242,
0243, 0244, 0260,
0269, 0272, 0292,
0295, 0297, 0300,
0302, 0312, 0327,
0352, 0365, 0369,
0373, 0391, 0635,
0670, 0681, 0686,
0691, 0719, 0723,
0726, 0730, 0732,
0735, 0737, 0740,
0744, 0745, 0750,
0755, 0759, 0780,
0786, 2562.
690541 Crankshaft
Used on Type No(s).
0061, 0124, 0246,
0253, 0305, 0308,
0335, 0341, 0342,
0646, 0710, 0711,
0713, 0728, 0781,
0785, 2529, 2561.
690543 Crankshaft
Used on Type No(s).
0259, 0293, 0647,
0756.
691806 Crankshaft
(Used After Code Date
77072410).
Used on Type No(s).
0021, 0112, 0128,
0181, 0189, 0203,
0209, 0254, 0256,
0258, 0314, 0321,
0357, 0362, 0368,
0395, 0656, 0668,
0675, 0709, 0717,
0739, 0743, 0752,
0765, 0778, 0779,
0784, 0789, 0790,
0792, 0793, 0794,
0801, 0802, 0804,
2521, 2526, 2530.
Crankshaft
(Used Before Code
Date 77072510).
(NO LONGER
AVAILABLE)
Used on Type No(s).
0021, 0112, 0128,
0181, 0189, 0203,
0209, 0254, 0256,
0258, 0314, 0321,
0357, 0362, 0368,
0395, 0656, 0668,
0675, 0709, 0717,
0739, 0743, 0752,
0765, 0778, 0779,
0784, 0789, 0790,
0792, 0793, 0794,
0801, 0802, 0804,
2521, 2526, 2530.
690546 Crankshaft
Used on Type No(s).
0682, 2560.
261944 Crankshaft
Used on Type No(s).
0720, 0758, 0788.
17 691938 Bearing−Ball
24 222698s Key−Flywheel
357 691483 Key−Drive Pulley
Engine Gasket Set−Reference 358
Carburetor Overhaul Kit−Reference 121
Valve Gasket Set−Reference 1095
REF. PART REF. PART REF. PART
NO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
Not for
Reproduction

326400
6179−5Assemblies include all parts shown in frames. 03/18/2009
5
21
569
15A
568
15B
567
998
998A
15A 690946 Plug−Oil Drain
15B 691680 Plug−Oil Drain
21 281658s Cap−Oil Fill
567 691104 Screw
(Engine Base)
568 294751 Base−Engine
Used on Type No(s).
0020, 0023, 0050,
0139, 0145, 0150,
0151, 0152, 0155,
0159, 0175, 0191,
0199, 0203, 0206,
0208, 0212, 0218,
0219, 0226, 0356,
0804, 2527, 2583.
−−−−−−− Note −−−−−
291404 Base−
Engine
Used on Type No(s).
0134, 0135.
568 294751 Base−Engine
Used on Type No(s).
0062, 0120, 0121,
0123, 0126, 0127,
0133, 0135, 0136,
0140, 0144, 0149,
0157, 0158, 0162,
0163, 0164, 0165,
0169, 0170, 0172,
0173, 0174, 0178,
0180, 0182, 0183,
0184, 0185, 0186,
0190, 0192, 0198,
0201, 0204, 0205,
0210, 0215, 0222,
0223, 0227, 0228,
0230, 0234, 0235,
0240, 0246, 0248,
0252, 0253, 0254,
0255, 0259, 0262,
0283, 0284, 0291,
0293, 0306, 0308,
0310, 0311, 0312,
0315, 0316, 0326,
0328, 0331, 0333,
0341, 0351, 0354,
0360, 0384, 0392,
0630, 0638, 0647,
0648, 0649, 0659,
0660, 0669, 0673,
0678, 0679, 0686,
0705, 0712, 0723,
0724, 0725, 0726,
0732, 0735, 0737,
0740, 0744, 0750,
0755, 0756, 0759,
0780, 0781, 0786,
2562, 2581, 2582.
569 691569 Gasket−Engine Base
998 690307 Pipe−Oil
998A 690502 Pipe−Oil
Engine Gasket Set−Reference 358
Carburetor Overhaul Kit−Reference 121
Valve Gasket Set−Reference 1095
REF. PART REF. PART REF. PART
NO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
Not for
Reproduction

326400
6179−6Assemblies include all parts shown in frames. 03/18/2009
6
593A
20
593
228 228A
1141
571 571B
20A
571A
20 691948 Seal−Oil
(PTO Side)
20A 291675s Seal−Oil
(PTO Side)
228 691681 Screw
(Bearing Support)
228A 691058 Screw
(Bearing Support)
571 391062 Support−Bearing
571A 291665 Support−Bearing
Used on Type No(s).
0022, 0050, 0062,
0063, 0112, 0113,
0114, 0116, 0130,
0143, 0147, 0149,
0150, 0151, 0153,
0156, 0160, 0167,
0171, 0172, 0173,
0174, 0175, 0176,
0183, 0185, 0186,
0188, 0192, 0193,
0196, 0197, 0198,
0205, 0208, 0209,
0216, 0217, 0219,
0224, 0233, 0235,
0236, 0241, 0242,
0244, 0247, 0255,
0256, 0257, 0260,
0261, 0265, 0266,
0269, 0272, 0273,
0277, 0278, 0279,
0285, 0286, 0287,
0290, 0291, 0292,
0296, 0297, 0302,
0303, 0304, 0310,
0312, 0318, 0327,
0329, 0334, 0337,
0338, 0340, 0344,
0345, 0347, 0357,
0359, 0361, 0368,
0373, 0374, 0383,
0385, 0395, 0396,
0634, 0636, 0648,
0650, 0656, 0661,
0666, 0670, 0671,
0674, 0675, 0684,
0686, 0690, 0692,
0693, 0696, 0698,
0699, 0702, 0703,
0706, 0708, 0709,
0714, 0717, 0721,
0724, 0726, 0732,
0733, 0735, 0737,
0739, 0740, 0743,
0744, 0745, 0746,
0750, 0751, 0752,
0753, 0754, 0755,
0757, 0759, 0771,
0776, 0780, 0783,
0784, 0789, 0794,
0801, 0802, 2522,
2550, 2562, 2563,
2596.
−−−−−−− Note −−−−−
291710 Support−
Bearing
Used on Type No(s).
0647, 0668, 0682,
0713, 0717, 0755,
0772, 0782, 0788,
0790, 0792, 0793,
0801, 0804, 2521,
2530.
571B 299705 Support−Bearing
(Magneto Side)
593 691311 Gasket−
Bearing Support
593A 270513 Gasket−
Bearing Support
(.015 Thick)
−−−−−−− Note −−−−−
270514 Gasket−
Bearing Support
(.010 Thick)
270515 Gasket−
Bearing Support
(.005 Thick)
1141 690402 Washer
(Bearing Support)
Engine Gasket Set−Reference 358
Carburetor Overhaul Kit−Reference 121
Valve Gasket Set−Reference 1095
REF. PART REF. PART REF. PART
NO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
Not for
Reproduction

326400
6179−7Assemblies include all parts shown in frames. 03/18/2009
7
524
525
523
399
338
3
3
704
276
366
587
749A
749
523A
1054
399A
758 3
758 3
665A
665
3 691948 Seal−Oil
(Magneto Side)
276 690258 Washer−Sealing
338 690270 Gasket−Dipstick
366 690304 Screw
(Timing Hole Plug)
399 691310 Gasket−
Counterweight Cover
(Magneto Side)
399A 692914 Gasket−
Counterweight Cover
(PTO Side)
523 691352 Dipstick
523A 690620 Dipstick
524 281370s Seal−Dipstick Tube
525 690622 Tube−Dipstick
−−−−−−− Note −−−−−
690623 Tube−Dipstick
Used on Type No(s).
0121, 0144, 0157,
0158, 0164, 0165,
0169, 0170, 0182,
0184, 0192, 0198,
0210, 0222, 0234,
0235, 0240, 0248,
0262, 0266, 0309,
0312, 0316, 0331,
0338, 0341, 0351,
0358, 0630, 0638,
0679, 0705, 0707,
0724, 0744, 0750,
0755, 0770, 1160,
2581.
587 690389 Clamp−Cable
665 298860 Minder−Oil
665A 692939 Minder−Oil
704 691083 Screw
(Counterweight Cover)
749 391061 Cover−Counterweight
749A 391361 Cover−Counterweight
(Used on Alternator
Equipped Engines)
758 393164 Counterweight
1054 280275 Tie−Cable
Engine Gasket Set−Reference 358
Carburetor Overhaul Kit−Reference 121
Valve Gasket Set−Reference 1095
REF. PART REF. PART REF. PART
NO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
Not for
Reproduction

326400
6179−8Assemblies include all parts shown in frames. 03/18/2009
8
109
134
90
1227
SEE PAGE 9
FOR ADDITIONAL
SERVICE PART
INFORMATION
90 391065 Carburetor
−−−−−−−Note −−−−−
391068 Carburetor
Used on Type No(s).
0121, 0144, 0157,
0158, 0164, 0165,
0169, 0170, 0184,
0192, 0240, 0331.
391070 Carburetor
Used on Type No(s).
0127, 0133, 0134,
0135, 0136, 0139,
0140, 0149, 0162,
0163, 0166, 0172,
0173, 0180, 0185,
0186, 0201, 0204,
0206, 0211, 0212,
0213, 0226, 0227,
0228, 0229, 0249,
0251, 0271, 0298,
0326, 0328, 0332.
392035 Carburetor
Used on Type No(s).
0182, 0210, 0222,
0309.
393431 Carburetor
Used on Type No(s).
0262, 0630.
392235 Carburetor
Used on Type No(s).
0198, 0234, 0235,
0248, 0266, 0312,
0316, 0338, 0341,
0351, 0358, 0707,
0724, 0744, 0750,
0759, 0770.
109 691353 Shaft−Choke
−−−−−−− Note −−−−−
690617 Shaft−Choke
Used on Type No(s).
0121, 0127, 0133,
0134, 0135, 0136,
0139, 0140, 0144,
0149, 0157, 0158,
0162, 0163, 0164,
0165, 0166, 0169,
0170, 0172, 0180,
0184, 0185, 0186,
0192, 0201, 0204,
0206, 0211, 0212,
0213, 0226, 0227,
0228, 0229, 0249,
0251, 0271, 0298,
0326, 0328, 0332,
2581, 2582.
134 394681 Kit−Needle/Seat
−−−−−−− Note −−−−−
394682 Kit−Needle/
Seat
(Includes Brass Seat)
394683 Kit−Needle/
Seat
(Includes Brass Seat)
(For Use With Impulse
Pump)
1227 99525s Valve−High Speed
Engine Gasket Set−Reference 358
Carburetor Overhaul Kit−Reference 121
Valve Gasket Set−Reference 1095
REF. PART REF. PART REF. PART
NO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
Not for
Reproduction

326400
6179−9Assemblies include all parts shown in frames. 03/18/2009
9
50
51
108
109
127
102
133
104
101
150
689
95
130
231
1146
689A
267
110
971
132
97
158
800
142
54
186
51A
91
134
107 94
90
54
98
1227
50 691152 Manifold−Intake
−−−−−−−Note −−−−−
692525 Manifold−
Intake
Used on Type No(s).
0248, 0308, 0358,
0638, 0707, 0770.
51 27381 Gasket−Intake
51A 692214 Gasket−Intake
54 691681 Screw
(Intake Manifold)
90 Carburetor
(See Previous Page)
91 299687 Body−
Upper Carburetor
−−−−−−− Note −−−−−
391067 Body−
Upper Carburetor
Used on Type No(s).
0121, 0144, 0157,
0158, 0164, 0165,
0169, 0170, 0182,
0184, 0192, 0240,
0309, 0331, 0630,
0707, 0724, 0770.
94 292681 Kit−Idle Mixture
95 691437 Screw
(Throttle Valve)
97 691944 Shaft−Throttle
98 693942 Kit−Idle Speed
101 691616 Pin−Shaft
102 692215 Gasket−
Carburetor Body
104 691775 Pin−Float Hinge
107 391069 Body−
Lower Carburetor
108 690621 Valve−Choke
109 Shaft−Choke
(See Previous Page)
110 691186 Washer
(Choke Shaft)
127 690627 Plug−Welch
130 691727 Valve−Throttle
132 691708 Stop−Throttle
133 692265 Float−Carburetor
134 Kit−Needle/Seat
(See Previous Page)
142 691966 Nozzle−Carburetor
(Standard)
(Labeled B)
(Used After Code Date
81090800).
−−−−−−− Note −−−−−
390950 Nozzle−
Carburetor
(Standard)
(Labeled 40)
(Used Before Code
Date 81090900).
150 691610 Gasket−Nozzle
158 27590 Plug−
Carburetor Filter/Drain
186 691764 Connector−Hose
231 691437 Screw
(Choke Valve)
267 691082 Screw
(Casing Clamp)
689 691591 Spring−Friction
689A 691590 Spring−Friction
800 Retainer−
Carburetor Drain
(NO LONGER
AVAILABLE)
971 691090 Screw
(Air Cleaner Base
to Carburetor)
1146 691587 Screw
(Choke Shaft)
1227 Valve−High Speed
(See Previous Page)
Engine Gasket Set−Reference 358
Carburetor Overhaul Kit−Reference 121
Valve Gasket Set−Reference 1095
REF. PART REF. PART REF. PART
NO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
Not for
Reproduction

326400
6179−10 Assemblies include all parts shown in frames. 03/18/2009
10
212
208
206A
162
209 211
232
203
614
404
206
205
562
505
668
270
268
269
271
629
227
616
205A
414
201
266
162 690267 Collar−Bell Crank
201 261027 Link−Air Vane
Used on Type No(s).
0234, 0705.
203 690263 Crank−Bell
205 691681 Screw
(Bell Crank)
Used on Type No(s).
0136, 0139, 0204,
0228, 0234, 0248,
0328, 0678, 0705.
205A 690810 Screw
(Bell Crank)
206 691079 Nut−Governor
Adjusting
206A 691584 Nut−
Governor Adjusting
208 393613 Rod−Governor Control
209 691596 Spring−Governor
−−−−−−− Note −−−−−
691789 Spring−
Governor
Used on Type No(s).
0611, 0630, 0647,
0651, 0690, 0760,
0781, 0801, 2520,
2527, 2528, 2529,
2550, 2581, 2582.
211 691790 Spring−Governed Idle
Used on Type No(s).
0611, 0630, 0647,
0651, 0690, 0760,
0781, 0801, 2520,
2527, 2528, 2529,
2550, 2581, 2582.
212 691791 Link−Throttle
−−−−−−− Note −−−−−
691595 Link−Throttle
Used on Type No(s).
0248, 0308, 0358,
0638, 0707, 0770.
227 690607 Lever−
Governor Control
−−−−−−− Note −−−−−
690616 Lever−
Governor Control
Used on Type No(s).
0611, 0630, 0647,
0651, 0684, 0690,
0706, 0721, 0660,
0671, 0675, 0681,
0683, 0685, 0689,
0692, 0694, 0697,
0699, 0801, 2520,
2527, 2528, 2529,
2550, 2561, 2581,
2582.
232 690545 Spring−Governor Link
−−−−−−− Note −−−−−
692207 Spring−
Governor Link
Used on Type No(s).
0248, 0308, 0358,
0638, 0707, 0770.
266 494554 Control−Throttle
−−−−−−− Note −−−−−
Control−Throttle
(Dial Control)
(NO LONGER
AVAILABLE)
Used on Type No(s).
0640, 0652, 0653,
0665.
268 691025 Casing−Control Wire
(Cut to
Required Length)
269 691026 Wire−Control
(Cut to
Required Length)
270 691027 Nut
(Control Wire Casing)
271 691028 Lever−Control
−−−−−−− Note −−−−−
221987 Lever−Control
Used on Type No(s).
0678, 0705.
404 690264 Washer
(Governor Crank)
414 692810 Washer
(Bell Crank)
Used on Type No(s).
0136, 0139, 0204,
0228, 0234, 0248,
0328, 0678, 0705.
505 691251 Nut
(Governor
Control Lever)
562 92613 Bolt
(Governor
Control Lever)
614 691620 Pin−Cotter
616 291364 Crank−Governor
629 690538 Spring−Throttle Return
Used on Type No(s).
0234, 0631, 0632,
0637, 0641, 0642,
0705, 0803, 2580.
668 690313 Spacer
(Governor
Control Rod)
Engine Gasket Set−Reference 358
Carburetor Overhaul Kit−Reference 121
Valve Gasket Set−Reference 1095
REF. PART REF. PART REF. PART
NO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
Not for
Reproduction

326400
6179−11 Assemblies include all parts shown in frames. 03/18/2009
11
171A
968
967
445
171
643
467
166
163A
536
163
1158
163 67247 Gasket−Air Cleaner
Used on Type No(s).
0308.
163A 270987 Gasket−Air Cleaner
166 691241 Stud−Air Cleaner
(9 1/2” Long)
171 691331 Nut
(Air Cleaner)
171A 690284 Nut
(Air Cleaner)
445 393957s Filter−
Air Cleaner Cartridge
467 691668 Knob−Air Cleaner
536 391063 Cleaner−Air
643 691730 Retainer−Air Filter
967 271794s Filter−Pre Cleaner
968 691755 Cover−Air Cleaner
1158 690293 Screw
(Carburetor)
(Used to Plug Air
Cleaner Stud Hole)
Used on Type No(s).
0262, 0630.
Engine Gasket Set−Reference 358
Carburetor Overhaul Kit−Reference 121
Valve Gasket Set−Reference 1095
REF. PART REF. PART REF. PART
NO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
Not for
Reproduction

326400
6179−12 Assemblies include all parts shown in frames. 03/18/2009
12
883
823
300A
346
677
613
725
303A
300C
R
300B
298
864A
301
298 677
677
237
836A
836
944
834
264
832
300 300D
864
676
994
676A
676B
81
613A
863
301B
303
346A
677A
81 691178 Lock−Muffler Screw
237 690409 Retainer−Muffler
Guard
264 691105 Nut
(Muffler Adapter)
298 691808 Locknut−Muffler/Elbow
300 393232s Muffler
300A 498984s Muffler
300B 392989 Muffler
300C 291519 Muffler
300D 399635 Muffler
301 93734 Pipe−Exhaust
(8” Long)
301B 91416 Pipe−Exhaust
(1 1/2” Long)
Used on Type No(s).
0163, 0327.
303 690281 Elbow−Exhaust
303A 91296 Elbow−Exhaust
(1”, 90 Degree)
Used on Type No(s).
0391, 0686, 0726,
0732, 0737, 0744,
0750, 0759, 0781.
−−−−−−− Note −−−−−
91415 Elbow−Exhaust
(1”, 45 Degree)
346 794845 Screw
(Spark Arrestor)
(Metric)
346A 690661 Screw
(Spark Arrestor)
(SAE)
613 691416 Screw
(Muffler)
613A 690297 Screw
(Muffler)
(Used After Code Date
97012300).
−−−−−−− Note −−−−−
692198 Screw
(Exhaust Muffler)
(Used Before Code
Date 97012400).
676 795036 Deflector−Muffler
676A 795038 Deflector−Muffler
676B 396903 Deflector−Muffler
677 794845 Screw
(Muffler Deflector)
(Metric)
677A 690661 Screw
(Muffler Deflector)
(SAE)
725 690420 Shield−Heat
823 690810 Screw
(Muffler Adapter)
832 690648 Guard−Muffler
834 691075 Washer
(Muffler Adapter)
836 691083 Screw
(Muffler Guard)
(1” Long)
836A 690367 Screw
(Muffler Guard)
(2/3” Long)
863 694016 Bracket−Muffler
864 394584 Adapter−Muffler
864A 690637 Adapter−Muffler
883 692236 Gasket−Exhaust
944 691690 Stud
(Muffler Adapter)
994 794945 Arrestor−Spark
Engine Gasket Set−Reference 358
Carburetor Overhaul Kit−Reference 121
Valve Gasket Set−Reference 1095
REF. PART REF. PART REF. PART
NO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
Not for
Reproduction

326400
6179−13 Assemblies include all parts shown in frames. 03/18/2009
13
601
240
387
788
210
247
245
385
182
674
186
195
917
199A
179
707
861 FUEL PUMP KIT
186A
187
183
246
601
918
450
182A
186B
199
240A
670
179 690280 Screw
(Fuel Tank Strap)
182 691068 Bracket−Fuel Tank
−−−−−−− Note −−−−−
222669 Bracket−
Fuel Tank
Used on Type No(s).
0205, 0291, 0648.
182A 690262 Bracket−Fuel Tank
183 691937 Strap−Fuel Tank
−−−−−−− Note −−−−−
291367 Strap−
Fuel Tank
(4 Quart)
Used on Type No(s).
0206, 0211, 0213,
0229, 0271.
186 691764 Connector−Hose
186A 691609 Connector−Hose
186B 231238 Connector−Hose
187 841589 Line−Fuel
(Cut to
Required Length)
−−−−−−− Note −−−−−
89248 Line−Fuel
(2 1/4” Long)
Used on Type No(s).
0080, 0386, 0387,
0393, 0395, 0396,
0397, 0631, 0640,
0641, 0662, 2580.
195 91635 Nipple−Fuel
199 692302 Valve−Fuel Shut Off
199A 691940 Valve−Fuel Shut Off
210 691962 Strainer−Fuel
240 298090s Filter−Fuel
(Red)
−−−−−−− Note −−−−−
394358s Filter−Fuel
(White)
Used on Type No(s).
0630, 0705, 0707,
0724, 0744, 0750,
0755, 0759, 0770,
0774, 2581.
240A 690612 Filter−Fuel
245 692190 Gasket−Fuel Bowl
246 298683 Bowl−Fuel Filter
247 691700 Yoke−Bowl
385 692198 Screw
(Fuel Pump)
387 808656 Pump−Fuel
450 691075 Washer
(Fuel Tank Bracket)
601 791850 Clamp−Hose
670 690505 Spacer−Fuel Tank
674 690303 Screw
(Fuel Tank Bracket)
707 690279 Nut
(Fuel Tank Strap)
788 224123 Bracket−Fuel Pump
861 394462 Kit−Fuel Pump
(Walbro)
−−−−−−− Note −−−−−
791885 Kit−Fuel Pump
Used on Type No(s).
0170, 0182, 0198,
0248, 0309, 0331,
0638, 0679, 0744,
0755, 0759.
917 691737 Handle−Shut Off Valve
918 393815 Hose−Vacuum
(Cylinder To
Impulse Pump)
(Cut to
Required Length)
Engine Gasket Set−Reference 358
Carburetor Overhaul Kit−Reference 121
Valve Gasket Set−Reference 1095
REF. PART REF. PART REF. PART
NO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
Not for
Reproduction

326400
6179−14 Assemblies include all parts shown in frames. 03/18/2009
14
181
180
180 291488 Tank−Fuel
(6 Quart)
−−−−−−− Note −−−−−
290816 Tank−Fuel
(4 Quart)
292415 Tank−Fuel
(8 Quart)
Used on Type No(s).
0137, 0140, 0141,
0143, 0148, 0151,
0152, 0153, 0156,
0162, 0163, 0167,
0172, 0173, 0175,
0176, 0178, 0180,
0181, 0183, 0185,
0186, 0197, 0199,
0201, 0203, 0205,
0212, 0215, 0219,
0226, 0227, 0242,
0245, 0249, 0254,
0255, 0257, 0259,
0273, 0282, 0284,
0286, 0289, 0291,
0293, 0300, 0303,
0307, 0311, 0318,
0330, 0336, 0347,
0354, 0369, 0372,
0376, 0377, 0381,
0384, 0392, 0635,
0640, 0647, 0648,
0657, 0659, 0661,
0664, 0666, 0674,
0682, 0685, 0690,
0694, 0696, 0697,
0698, 0704, 0712,
0714, 0721, 0723,
0729, 0730, 0743,
0745, 0746, 0754,
0757, 0771, 0772.
181 791545 Cap−Fuel Tank
(Chrome)
Engine Gasket Set−Reference 358
Carburetor Overhaul Kit−Reference 121
Valve Gasket Set−Reference 1095
REF. PART REF. PART REF. PART
NO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
Not for
Reproduction

326400
6179−15 Assemblies include all parts shown in frames. 03/18/2009
15
23
726
23A
363
23 395250 Flywheel
(For Magnetron
Ignition, Identified by
Two Red Stripes)
Used on Type No(s).
0611, 0620, 0632,
0633, 0635, 0637,
0640, 0641, 0642,
0644, 0645, 0646,
0647, 0648, 0650,
0651, 0652, 0655,
0656, 0657, 0659,
0662, 0664, 0670,
0674, 0677, 0681,
0683, 0686, 0689,
0690, 0691, 0694,
0695, 0696, 0700,
0706, 0709, 0710,
0713, 0717, 0722,
0723, 0727, 0728,
0730, 0734, 0735,
0737, 0739, 0743,
0744, 0745, 0747,
0750, 0755, 0756,
0757, 0759, 0762,
0763, 0766, 0775,
0778, 0780, 0785,
0786, 0790, 0791,
0792, 0793, 0794,
0799, 0801, 0802,
0803, 0804, 2520,
2521, 2522, 2529,
2530, 2550, 2560,
2561, 2562, 2580,
2581, 2582, 2583.
23A 395251 Flywheel
(For Magnetron
Ignition, Identified by
Two Red Stripes)
−−−−−−− Note −−−−−
Flywheel
(NO LONGER
AVAILABLE)
(For Magnetron
Ignition, Identified by
Two Red Stripes)
Used on Type No(s).
0736.
391363 Flywheel
(10 Amp)
(Used With Breaker
Points and Condenser
System)
Used on Type No(s).
0027, 0028, 0063,
0115, 0123, 0126,
0135, 0143, 0148,
0149, 0162, 0163,
0164, 0165, 0167,
0168, 0170, 0171,
0172, 0174, 0178,
0180, 0182, 0184,
0185, 0188, 0189,
0192, 0193, 0198,
0201, 0209, 0210,
0211, 0213, 0215,
0217, 0221, 0222,
0224, 0229, 0230,
0231, 0234, 0235,
0236, 0238, 0240,
0248, 0249, 0250,
0251, 0252, 0257,
0261, 0262, 0265,
0271, 0273, 0274,
0275, 0276, 0277,
0278, 0279, 0281,
0282, 0283, 0284,
0285, 0286, 0287,
0288, 0296, 0298,
0303, 0304, 0306,
0307, 0309, 0310,
0311, 0315, 0316,
0317, 0318, 0319,
0320, 0321, 0322,
0323, 0324, 0325,
0326, 0328, 0330,
0331, 0332, 0333,
0334, 0337, 0338,
0340, 0343, 0347,
0348, 0349, 0350,
0351, 0353, 0355,
0358, 0359, 0360,
0363, 0364, 0367,
0370, 0371, 0372,
0374, 0375, 0376,
0377, 0378, 0379,
0381, 0382, 0383,
0388, 0389, 0392,
0394, 0399.
363 19203 Puller−Flywheel
726 391362 Gear−Ring
(Includes Mounting
Hardware)
Engine Gasket Set−Reference 358
Carburetor Overhaul Kit−Reference 121
Valve Gasket Set−Reference 1095
REF. PART REF. PART REF. PART
NO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
Not for
Reproduction

326400
6179−16 Assemblies include all parts shown in frames. 03/18/2009
16
321
773
332
73
331
440
74
321A
73A
321B
75
838
73 691171 Screen−Rotating
−−−−−−−Note −−−−−
690404 Screen−
Rotating
Used on Type No(s).
0127, 0133, 0182,
0190, 0210, 0222,
0252, 0262, 0315,
0333, 0630, 0649,
2582, 2583.
73A 690410 Screen−Rotating
74 691655 Screw
(Rotating Screen)
75 691056 Washer
(Flywheel)
321 691151 Fan−Booster
321A 690377 Fan−Booster
321B 212000 Fan−Booster
331 691075 Washer
(Booster Fan)
332 691059 Nut
(Flywheel)
440 691076 Screw
(Booster Fan)
773 690265 Retainer
838 211983 Adapter−
Blower Housing Ring
Engine Gasket Set−Reference 358
Carburetor Overhaul Kit−Reference 121
Valve Gasket Set−Reference 1095
REF. PART REF. PART REF. PART
NO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
Not for
Reproduction

326400
6179−17 Assemblies include all parts shown in frames. 03/18/2009
17
304
304A
305
304 294698 Housing−Blower
−−−−−−−Note −−−−−
297010 Housing−
Blower
Used on Type No(s).
0060, 0119, 0160,
0197, 0216, 0223,
0237.
297453 Housing−
Blower
Used on Type No(s).
0020, 0023, 0050,
0136, 0139, 0140,
0145, 0150, 0151,
0152, 0155, 0159,
0175, 0181, 0183,
0191, 0199, 0203,
0204, 0205, 0206,
0208, 0212, 0218,
0219, 0226, 0227,
0228, 0254, 0255,
0259.
391229 Housing−
Blower
Used on Type No(s).
0027, 0028, 0063,
0115, 0123, 0126,
0135, 0143, 0148,
0149, 0162, 0163,
0165, 0167, 0168,
0170, 0171, 0172,
0174, 0178, 0180,
0182, 0184, 0185,
0188, 0189, 0192,
0193, 0198, 0201,
0209, 0210, 0211,
0213, 0215, 0217,
0221, 0224, 0229,
0230, 0231, 0234,
0235, 0236, 0238,
0248, 0249, 0259,
0251, 0252, 0257,
0261, 0262, 0265,
0271, 0273, 0275,
0276, 0277, 0278,
0279, 0281, 0282,
0283, 0284, 0285,
0286, 0287, 0288,
0296, 0298, 0303,
0304, 0306, 0307,
0309, 0310, 0311,
0315, 0316, 0317,
0318, 0319, 0320,
0321, 0322, 0323,
0324, 0325, 0326,
0328, 0330, 0331,
0332, 0333, 0334,
0337, 0338, 0340,
0343, 0347, 0348,
0349, 0350, 0351,
0353, 0355, 0358,
0359, 0360, 0363,
0364, 0367, 0370,
0371, 0372, 0374,
0375, 0376, 0377,
0378, 0379, 0381,
0382, 0383, 0388,
0389, 0392, 0394,
0399, 0630, 0634,
0636, 0638, 0640,
0643, 0649, 0653,
0654, 0658, 0660,
0661, 0663, 0665,
0666, 0667, 0668,
0669, 0671, 0672,
0673, 0675, 0676,
0678, 0679, 0680,
0684, 0685, 0687,
0688, 0692, 0693,
0697, 0698, 0699,
0701, 0702, 0703,
0704, 0705, 0707,
0708, 0712, 0714,
0715, 0716, 0718,
0720, 0721, 0724,
0725, 0729, 0731,
0733, 0736, 0738,
0741, 0742, 0746,
0748, 0749, 0751,
0752, 0753, 0754,
0760, 0761, 0764,
0765, 0770, 0771,
0772, 0774, 0776,
0779, 0782, 0783,
0784, 0787, 0789,
0797, 2527, 2528,
2563, 2596.
692359 Housing−
Blower
Used on Type No(s).
0682.
395513 Housing−
Blower
Used on Type No(s).
0711, 0719, 0732,
0740, 0781, 2529.
399177 Housing−
Blower
Used on Type No(s).
0758, 0788.
304A 392343 Housing−Blower
(Low Profile)
Used on Type No(s).
0713, 0744, 0750,
0755, 0759, 0780,
0785, 0786, 2561,
2562.
305 692198 Screw
(Blower Housing)
Engine Gasket Set−Reference 358
Carburetor Overhaul Kit−Reference 121
Valve Gasket Set−Reference 1095
REF. PART REF. PART REF. PART
NO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
Not for
Reproduction

326400
6179−18 Assemblies include all parts shown in frames. 03/18/2009
18
895
215
452C
452B
316
452
197
405
384
488
736
727
732
587
685
344
729A
367
488A
588A
589
318
729
573
573A
668A
452
197
452B
316
197 90072 Screw
(Back Plate)
215 222445 Guide−Air
316 691612 Nut
(Back Plate)
318 691666 Screw
(Mounting Bracket)
344 690305 Screw
(Cable Clamp)
367 690305 Screw
(Wire Clip)
384 690371 Washer
(Back Plate)
405 690290 Screw
(Back Plate)
452 92864 Washer
(Back Plate)
452B 26404 Washer
(Back Plate)
452C 691077 Washer
(Back Plate)
488 222211 Bracket−Fuse
488A 222345 Bracket−Fuse
573 391220 Plate−Back
(Used on Engines
With Electric Start
Only)
573A 299450 Plate−Back
587 690389 Clamp−Cable
588A 690375 Bracket−Armature
(Used on Engines
With Electric Starter)
589 690300 Screw
(Armature Bracket)
668A 231065 Spacer
Used on Type No(s).
0164, 0240.
685 690661 Screw
(Rectifier)
727 692338 Cover−Starter Drive
729 690432 Clip−Wire
(Alternator)
729A 690588 Clip−Wire
732 93410 Screw
(Starter Drive Cover)
736 690302 Nut−Clip
895 692309 Switch−Rotary
Engine Gasket Set−Reference 358
Carburetor Overhaul Kit−Reference 121
Valve Gasket Set−Reference 1095
REF. PART REF. PART REF. PART
NO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
Not for
Reproduction

326400
6179−19 Assemblies include all parts shown in frames. 03/18/2009
19
289
57
64
63
58
655
61
56
65A
55
678 64A
56A
65
1140
592
608
655A
458
60
55 691355 Housing−
Rewind Starter
(Low Profile)
56 392630 Pulley−Starter
(Low Profile)
56A 295871 Pulley−Starter
(Wide Legs
Starter Housing,
Includes 63” Rope)
57 490179 Spring−Rewind Starter
58 692188 Rope−Starter
(63” Long)
(Use With
Plastic Pulley)
−−−−−−− Note −−−−−
695002 Rope−Starter
(99” Long)
(Cut to
Required Length)
(Use With
Plastic Pulley)
66564 Rope−Starter
(63” Long)
(Use With
Metal Pulley)
66574 Rope−Starter
(99” Long)
(Cut to
Required Length)
(Use With
Metal Pulley)
60 490652 Grip−Starter Rope
61 68848s Bumper−Starter Pulley
(Wide Legs
Starter Housing)
63 690547 Spring−Ratchet
64 Adapter−
Ratchet Spring
(Low Profile)
(NO LONGER
AVAILABLE)
64A 691920 Adapter−
Ratchet Spring
(Wide Legs
Starter Housing)
65 691693 Screw
(Rewind Starter)
(3/8” Long)
65A 93254 Screw
(Rewind Starter)
(7/16” Long)
289 230228s Pin−Starter Grip
458 69932s Kit−Handle/Rope
592 690276 Nut
(Rewind Starter)
608 691958 Starter−Rewind
655 691734 Anchor−Rewind Spring
655A 221014 Anchor−Rewind Spring
(Wide Legs
Starter Housing)
678 490817 Spacer−Rewind
1140 690286 Washer
(Rewind Starter)
Engine Gasket Set−Reference 358
Carburetor Overhaul Kit−Reference 121
Valve Gasket Set−Reference 1095
REF. PART REF. PART REF. PART
NO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
Not for
Reproduction

326400
6179−20 Assemblies include all parts shown in frames. 03/18/2009
20
71
68
70
69
67
68
70
69A
69B
257
66 66A
67A
69
66 393127s Clutch−Starter
66A 399671 Clutch−Starter
(Sealed)
67 690542 Housing−Clutch
67A 394897 Housing−Clutch
68 691604 Ball−Clutch
69 690271 Washer
(Starter Clutch)
69A 690260 Washer
(Starter Clutch)
69B 690277 Washer
(Starter Clutch)
70 691945 Ratchet−Clutch
71 691359 Cover−Ratchet
257 690309 Screw
(Starter Clutch)
Engine Gasket Set−Reference 358
Carburetor Overhaul Kit−Reference 121
Valve Gasket Set−Reference 1095
REF. PART REF. PART REF. PART
NO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
Not for
Reproduction