Briggs & Stratton 44P700 Series Setup guide

COPYRIGHT by BRIGGS & STRATTON CORPORATION
All rights reserved. No part of this material may be reproduced or transmitted,
in any form or by any means, electronic or mechanical, including photocopying,
recording or by any information storage and retrieval system, without permission
in writing from Briggs & Stratton Corporation.
PRINTED IN U.S.A.
FORM MS−3581−04/26/2007
REPLACES FORM MS−3581−02/19/2007
FILE IN SECT. 2 OF SERVICE MANUAL
44P700
Illustrated Parts List
Model Series
44P700
TYPE NUMBERS
0016 through 0884.
TABLE OF CONTENTS
Air Cleaner 6. . . . . . . . . . . . . . . . . . . . . . . . .
Alternators 8. . . . . . . . . . . . . . . . . . . . . . . . .
Blower Housing/Shrouds 6. . . . . . . . . . . .
Camshaft 3. . . . . . . . . . . . . . . . . . . . . . . . . . .
Carburetor 5. . . . . . . . . . . . . . . . . . . . . . . . . .
Controls 7. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Crankshaft 3. . . . . . . . . . . . . . . . . . . . . . . . .
Cylinder 2. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cylinder Head 4. . . . . . . . . . . . . . . . . . . . . .
Electric Starter 7. . . . . . . . . . . . . . . . . . . . . .
Engine Sump 2. . . . . . . . . . . . . . . . . . . . . . .
Exhaust System 5. . . . . . . . . . . . . . . . . . . .
Flywheel 7. . . . . . . . . . . . . . . . . . . . . . . . . . .
Ignition 8. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Gasket Set −Engine 2. . . . . . . . . . . . . . . . .
Gasket Set −Valve 4. . . . . . . . . . . . . . . . . .
Lubrication 3. . . . . . . . . . . . . . . . . . . . . . . . .
Kit−Carburetor Overhaul 5. . . . . . . . . . . . .
Piston, Rings, Connecting Rod 3. . . . . . .
Valves 4. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

44P700
Illustrations cover a range of engines. Parts shown without corresponding text may not be used on your specific engine.
3581−2Assemblies include all parts shown in frames. 04/26/2007
2
8
20
1013
691 552
1017
12
252
10
9
11
718
31058 OPERATOR’S MANUAL
2
1
250
239 22
4
ÚÚ
ÚÚ
ÚÚ
ÚÚ
Ú
Ú
Ú
943
750
1035
1024
965
1027
15
718
1330 REPAIR MANUAL
883
943
1022
12
9
7
3
358A ENGINE GASKET SET
868
842
691
524
20
163
415
51A
1024A

44P700
Illustrations cover a range of engines. Parts shown without corresponding text may not be used on your specific engine.
3581−3Assemblies include all parts shown in frames. 04/26/2007
3
24
26
28
25
27
27
741
146
16
32
29
287
842
524
523
525
847
45
46
27

44P700
Illustrations cover a range of engines. Parts shown without corresponding text may not be used on your specific engine.
3581−4Assemblies include all parts shown in frames. 04/26/2007
4
53
654
337
635
383
13
798
42
192
1022
1100
1029
7
36
35
33
34
868
798
5A
883
1022
1100
1029
7
36 35
33
34
868
5
42
192
1023A
1023
1022
1022
868
1095 VALVE GASKET SET
7
163
883
883
1022
1026
45
1026A
54
929
212
163
50
914
415
617
918
51A
617
617

44P700
Illustrations cover a range of engines. Parts shown without corresponding text may not be used on your specific engine.
3581−5Assemblies include all parts shown in frames. 04/26/2007
5
387
628
788
240
385
276
1127
137
104
987
95
150
1128
105
1126
1124
1123
276
633
108
672
418
163
135
231
130
98
947
141
125
975
133
131
142
1169
601601
187
601
187A
601601601
187B
121 CARBURETOR OVERHAUL KIT
104
276
1124
150
987 633
672
105
1123
137
300
613
613A
883883
187C
601
51A
117
117A
118
118A
788A

44P700
Illustrations cover a range of engines. Parts shown without corresponding text may not be used on your specific engine.
3581−6Assemblies include all parts shown in frames. 04/26/2007
6
447
865
573
163
304
967
445
865A
447A
865B
447A
405A
703
729
1036 EMISSIONS LABEL
431
305
1040
305B
467A
968
467A

44P700
Illustrations cover a range of engines. Parts shown without corresponding text may not be used on your specific engine.
3581−7Assemblies include all parts shown in frames. 04/26/2007
7
363
1070
75
332
668
74
73
742
552
616
213
216
220
615
209
211 267
265
188
222
219
265
552A
404
552A
691
267A
280
1090
797
311
579
802
310
801
1051
783
513
309
510
697
267
23
165
726
1005
695
544
803
562
505
227
278

44P700
Illustrations cover a range of engines. Parts shown without corresponding text may not be used on your specific engine.
3581−8Assemblies include all parts shown in frames. 04/26/2007
8
729
1119
1054
851
334
635 333
501B
526B
877B
10 −16 AMP
474B
789A
789B
1059
578A
NOTE: All stators use a No. mounting screw.
1119
NOTE: The proper flywheel part number and/or the alternator magnet size will
determine the alternator type or output. See repair instruction manual
for additional information.
789E
789D
878C
474C
877C
DUAL
CIRCUIT
1059

REF. PART REF. PART REF. PART
NO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
44P700
KIncluded in Engine Gasket Set−Ref. No.358.
DIncluded in Carburetor Overhaul Kit−Ref. No. 121.
ΔIncluded in Valve Gasket Set−Ref. No 1095.
Illustrations cover a range of engines. Parts shown without corresponding text may not be used on your specific engine.
3581−9Assemblies include all parts shown in frames. 04/26/2007
9
1 793564 Cylinder Assembly
2 499585 Kit−Bushing/Seal
(Magneto Side)
3K391086s Seal−Oil
(Magneto Side)
4 699747 Sump−Engine
5 793558 Head−Cylinder
(Cylinder 1)
5A 793559 Head−Cylinder
(Cylinder 2)
7KΔ693997 Gasket−Cylinder Head
8 792185 Breather Assembly
9K690937 Gasket−Breather
10 691108 Screw
(Breather Assembly)
11 792184 Tube−Breather
12 K697227 Gasket−Crankcase
13 791130 Screw
(Cylinder Head)
15 690946 Plug−Oil Drain
16 699700 Crankshaft
−−−−−− Note −−−−−−
790136 Crankshaft
Used on Type No(s).
0025.
790132 Crankshaft
Used on Type No(s).
0016, 0026, 0110,
0111, 0115, 0120,
0412.
20 K791892 Seal−Oil
(PTO Side)
22 694966 Screw
(Crankcase
Cover/Sump)
23 691053 Flywheel
24 222698s Key−Flywheel
25 793560 Piston Assembly
(Standard)
−−−−−− Note −−−−−−
793563 Piston
Assembly
(.020” Oversize)
26 793561 Ring Set
(Standard)
−−−−−− Note −−−−−−
792073 Ring Set
(.020” Oversize)
27 690975 Lock−Piston Pin
28 690229 Pin−Piston
(Standard)
29 699699 Rod−Connecting
(Standard)
32 690976 Screw
(Connecting Rod)
33 793557 Valve−Exhaust
34 793556 Valve−Intake
35 694865 Spring−Valve
(Intake)
36 694865 Spring−Valve
(Exhaust)
42 499586 Keeper−Valve
45 690977 Tappet−Valve
46 793663 Camshaft
50 695241 Manifold−Intake
51A K791677 Gasket−Intake
53 690951 Stud
(Carburetor)
54 699816 Screw
(Intake Manifold)
73 494439 Screen−Rotating
74 698425 Screw
(Rotating Screen)
75 691056 Washer
(Flywheel)
95 690718 Screw
(Throttle Valve)
98 699721 Kit−Idle Speed
104 D694918 Pin−Float Hinge
105 D698537 Valve−Float Needle
108 699723 Valve−Choke
117 792296 Jet−Main
(Standard)
(Left)(Nikki)
117A 842627 Jet−Main
(Standard)
(Right)(Nikki)
118 699457 Jet−Main
(High Altitude)
(Left)(Nikki)
118A 699733 Jet−Main
(High Altitude)
(Right)(Nikki)
121 792455 Kit−Carburetor
Overhaul
125 792295 Carburetor
130 690993 Valve−Throttle
131 499805 Kit−Throttle Shaft
133 699724 Float−Carburetor
135 699729 Tube−Fuel Transfer
137 D690994 Gasket−Float Bowl
141 699722 Kit−Choke Shaft
142 699726 Nozzle−Carburetor
(Standard)
146 690979 Key−Timing
150 D690995 Gasket−Nozzle
163 KΔ691001 Gasket−Air Cleaner
165 693148 Nut
(Ring Gear)
187 791881 Line−Fuel
(Molded)
187A 791801 Line−Fuel
(Molded)
187B 791766 Line−Fuel
(15” Long)(Cut to
Required Length)
187C 791744 Line−Fuel
(Formed)(Cut to
Required Length)
188 691108 Screw
(Control Bracket)

REF. PART REF. PART REF. PART
NO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
44P700
KIncluded in Engine Gasket Set−Ref. No.358.
DIncluded in Carburetor Overhaul Kit−Ref. No. 121.
ΔIncluded in Valve Gasket Set−Ref. No 1095.
Illustrations cover a range of engines. Parts shown without corresponding text may not be used on your specific engine.
3581−10 Assemblies include all parts shown in frames. 04/26/2007
10
192 690083 Adjuster−Rocker Arm
209 793340 Spring−Governor
(Orange)
(Used After Code Date
06081400).
Used on Type No(s).
0025, 0026, 0027,
0412.
−−−−−− Note −−−−−−
697674
Spring−Governor
(Brown)
(Used Before Code
Date 06081500).
Used on Type No(s).
0025, 0026, 0027,
0412.
793343
Spring−Governor
(Used After Code Date
06081400).
Used on Type No(s).
0110, 0111, 0112,
0113, 0115, 0116,
0117, 0120.
698071 Spring−
Governor
(White)
(Used Before Code
Date 06081500).
Used on Type No(s).
0110, 0111, 0112,
0113.
791606
Spring−Governor
(Medium Green)
(Used Before Code
Date 06081500).
Used on Type No(s).
0115, 0117.
793340
Spring−Governor
(Orange)
Used on Type No(s).
0016, 0119, 0884.
211 691019 Spring−Governed Idle
212 695238 Link−Throttle
213 691021 Bracket−Choke
Control
216 691022 Link−Choke
219 793338 Gear−Governor
(Used After Code Date
06081400).
−−−−−− Note −−−−−−
698231
Gear−Governor
(Used Before Code
Date 0608100).
220 690412 Washer
(Governor Gear)
222 698761 Bracket−Control
−−−−−− Note −−−−−−
698757
Bracket−Control
Used on Type No(s).
0884.
227 792492 Lever−Governor
Control
231 690718 Screw
(Choke Valve)
239 792028 Switch−Oil Pressure
−−−−−− Note −−−−−−
697049 Switch−Oil
Pressure
Used on Type No(s).
0115, 0119.
240 695666 Filter−Fuel
250 690957 Retainer−Breather
252 690956 Collector−Oil
265 691024 Clamp−Casing
267 691044 Screw
(Casing Clamp)
Used on Type No(s).
0025, 0027, 0113,
0115, 0116, 0117,
0119, 0120.
267A 695134 Screw
(Casing Clamp)
Used on Type No(s).
0016, 0026, 0100,
0110, 0111, 0112,
0412, 0884.
276 D695410 Washer−Sealing
278 792651 Washer
(Governor Control
Lever)
280 691526 Bracket−Rod
287 691108 Screw
(Dipstick Tube)
300 626226 Muffler
304 792301 Housing−Blower
305 691005 Screw
(Blower Housing)
305B 790690 Screw
(Blower Housing to
Intake Elbow)
309 499521 Motor−Starter
310 691263 Screw
(Starter Motor)
311 497608 Brush Set
332 691059 Nut
(Flywheel)
333 691060 Armature−Magneto
334 691061 Screw
(Magneto Armature)
337 491055s Plug−Spark
−−−−−− Note −−−−−−
691043 Plug−Spark
Used on Type No(s).
0884.
358A 694012 Gasket Set−Engine
363 19203 Puller−Flywheel
383 19374s Wrench−Spark Plug
385 691108 Screw
(Fuel Pump)
387 808656 Pump−Fuel
404 690442 Washer
(Governor Crank)
405A 697820 Screw
(Backplate)
415 690283 Plug
418 690999 Plate−Carburetor
431 792297 Elbow−Intake
445 792105 Filter−Air Cleaner
Cartridge
447 691003 Screw
(Air Guide Cover)
447A 691108 Screw
(Air Guide Cover)
467A 790697 Knob−Air Cleaner
474B 696458 Alternator
(10−16 Amp
Regulated)
474C 696459 Alternator
(Dual Circuit)
501B 691185 Regulator
(10−16 Amp
Regulated)