Briggs & Stratton 83100 User manual
en
English
bg ru
Ðóññêèé
cs hr slet hu
Èeština
lt lv pl ro
eesti keel Hrvatski Latviešu Polski Românã
Áúëãàðñêè LietuviMagyar Slovenšèina
en Operator’s Manual
bg Èíñòðóêöèè çà åêñïëîàòàöèÿ
cs Návod k obsluze
et Kasutusjuhend
hr Priruènik za operatora
hu Kezelési útmutató
lt Naudojimo instrukcija
lv Operatora rokasgrmata
pl Instrukcja obs³ugi
ro Manual de utilizare
ru Ðóêîâîäñòâî ïî ýêñïëóàòàöèè
sl Priroènik za uporabo
Form No. 278916EST
Revision: A
E2009 Briggs & Stratton Corporation,
Milwaukee, WI, USA. All rights reserved.
Briggs & Stratton is a registered trademark
of Briggs & Stratton Corporation
Model 83100 550 Series
I/C®550 Series
Intek Pro 550 Series
2BRIGGSandSTRATTON.COM
I
K
L
G
C
D
FJ
1I
L
B
C
EH
A
N
M
A
2AB
A
B
C
C
A
B
3
D
C
4
B
A
E
3
A
B
A
5A
6
B
7
A
8
DE
B
C
D
F
D
E
9A
B
FA
B
C
D
10
G
D
E
D
C
C
11
A
B
4BRIGGSandSTRATTON.COM
General Information
This manual contains safety information to make you aware of the hazards and risks
associated with engines and how to avoid them. It also contains instructions for the
proper use and care of the engine. Because Briggs & Stratton Corporation does not
necessarily know what equipment this engine will power, it is important that you read and
understand these instructions and the instructions for the equipment. Save these
instructions for future reference.
For replacement parts or technical assistance, record below the engine model, type, and
code numbers along with the date of purchase. These numbers are located on your
engine (see the Features and Controls page).
Date of purchase:
Engine model:
MM/DD/YYYY
Model: Code:Type:
Engine Power Rating Information
The gross power rating for individual gas engine models is labeled in accordance with
SAE (Society of Automotive Engineers) code J1940 (Small Engine Power & Torque
Rating Procedure), and rating performance has been obtained and corrected in
accordance with SAE J1995 (Revision 2002-05). Torque values are derived at 3060
RPM; horsepower values are derived at 3600 RPM. Actual gross engine power will be
lower and is affected by, among other things, ambient operating conditions and
engine-to-engine variability. Given both the wide array of products on which engines are
placed and the variety of environmental issues applicable to operating the equipment,
the gas engine will not develop the rated gross power when used in a given piece of
power equipment (actual “on-site” or net power). This difference is due to a variety of
factors including, but not limited to, accessories (air cleaner, exhaust, charging, cooling,
carburetor, fuel pump, etc.), application limitations, ambient operating conditions
(temperature, humidity, altitude), and engine-to-engine variability. Due to manufacturing
and capacity limitations, Briggs & Stratton may substitute an engine of higher rated
power for this Series engine.
Operator Safety
Explosion
Toxic Fumes
Moving Parts
Shock
Hot Surface
Kickback
Fire
Fuel Shutoff
Read Manual
Choke
Oil
Fuel
On Off
Stop
Wear Eye
Protection
Slow
Fast
SAFETY AND CONTROL SYMBOLS
Hazardous
Chemical Frostbite
The safety alert symbol is used to identify safety information about hazards that can
result in personal injury. A signal word (DANGER, WARNING, or CAUTION) is used with the
alert symbol to indicate the likelihood and the potential severity of injury. In addition, a hazard
symbol may be used to represent the type of hazard.
DANGER indicates a hazard which, if not avoided, will result in death or
serious injury.
WARNING indicates a hazard which, if not avoided, could result in death or
serious injury.
CAUTION indicates a hazard which, if not avoided, could result in minor or
moderate injury.
NOTICE indicates a situation that could result in damage to the product.
WARNING
Certain components in this product and its related accessories contain chemicals
known to the State of California to cause cancer, birth defects, or other reproductive
harm. Wash hands after handling.
WARNING
The engine exhaust from this product contains chemicals known to the State of
California to cause cancer, birth defects, or other reproductive harm.
WARNING
Briggs & Stratton does not approve or authorize the use of these engines on 3-wheel
All Terrain Vehicles (ATVs), motor bikes, fun/recreational go-karts, aircraft products,
or vehicles intended for use in competitive events. Use of these engines in such
applications could result in property damage, serious injury (including paralysis), or
even death.
NOTICE: This engine was shipped from Briggs & Stratton without oil. Before you start
the engine, make sure you add oil according to the instructions in this manual. If you
start the engine without oil, it will be damaged beyond repair and will not be covered
under warranty.
WARNING
Fuel and its vapors are extremely flammable and explosive.
Fire or explosion can cause severe burns or death.
When Adding Fuel
‚Turn engine off and let engine cool at least 2 minutes before removing the fuel
cap.
‚Fill fuel tank outdoors or in well-ventilated area.
‚Do not overfill fuel tank. To allow for expansion of the fuel, do not fill above the
bottom of the fuel tank neck.
‚Keep fuel away from sparks, open flames, pilot lights, heat, and other ignition
sources.
‚Check fuel lines, tank, cap, and fittings frequently for cracks or leaks.
Replace if necessary
‚If fuel spills, wait until it evaporates before starting engine.
When Starting Engine
‚Ensure that spark plug, muffler, fuel cap and air cleaner (if equipped) are in
place and secured.
‚Do not crank engine with spark plug removed.
‚If engine floods, set choke (if equipped) to OPEN/RUN position, move throttle
(if equipped) to FAST position and crank until engine starts.
When Operating Equipment
‚Do not tip engine or equipment at angle which causes fuel to spill.
‚Do not choke the carburetor to stop engine.
‚Never start or run the engine with the air cleaner assembly (if equipped) or the
air filter (if equipped) removed.
When Changing Oil
‚If you drain the oil from the top oil fill tube, the fuel tank must be empty or fuel
can leak out and result in a fire or explosion.
When Transporting Equipment
‚Transport with fuel tank EMPTY or with fuel shut-off valve OFF.
When Storing Fuel Or Equipment With Fuel In Tank
‚Store away from furnaces, stoves, water heaters or other appliances that have
pilot lights or other ignition sources because they can ignite fuel vapors.
Starting engine creates sparking.
Sparking can ignite nearby flammable gases.
Explosion and fire could result.
WARNING
‚If there is natural or LP gas leakage in area, do not start engine.
‚Do not use pressurized starting fluids because vapors are flammable.
Engines give off carbon monoxide, an odorless, colorless, poison gas.
Breathing carbon monoxide can cause nausea, fainting or death.
WARNING
‚Start and run engine outdoors.
‚Do not start or run engine in enclosed area, even if doors or windows are open.
5
en
Rapid retraction of starter cord (kickback) will pull hand and arm
toward engine faster than you can let go.
Broken bones, fractures, bruises or sprains could result.
WARNING
‚When starting engine, pull the starter cord slowly until resistance is felt and then
pull rapidly to avoid kickback.
‚Remove all external equipment/engine loads before starting engine.
‚Direct-coupled equipment components such as, but not limited to, blades,
impellers, pulleys, sprockets, etc., must be securely attached.
Rotating parts can contact or entangle hands, feet, hair, clothing, or
accessories.
Traumatic amputation or severe laceration can result.
WARNING
‚Operate equipment with guards in place.
‚Keep hands and feet away from rotating parts.
‚Tie up long hair and remove jewelry.
‚Do not wear loose-fitting clothing, dangling drawstrings or items that could
become caught.
Running engines produce heat. Engine parts, especially muffler,
become extremely hot.
Severe thermal burns can occur on contact.
Combustible debris, such as leaves, grass, brush, etc. can catch fire.
WARNING
‚Allow muffler, engine cylinder and fins to cool before touching.
‚Remove accumulated debris from muffler area and cylinder area.
‚It is a violation of California Public Resource Code, Section 4442, to use or
operate the engine on any forest-covered, brush-covered, or grass-covered land
unless the exhaust system is equipped with a spark arrester, as defined in
Section 4442, maintained in effective working order. Other states or federal
jurisdictions may have similar laws. Contact the original equipment
manufacturer, retailer, or dealer to obtain a spark arrester designed for the
exhaust system installed on this engine.
Unintentional sparking can result in fire or electric shock.
Unintentional start-up can result in entanglement, traumatic
amputation, or laceration.
Fire hazard
WARNING
Before performing adjustments or repairs:
‚Disconnect the spark plug wire and keep it away from the spark plug.
‚Disconnect battery at negative terminal (only engines with electric start.)
‚Use only correct tools.
‚Do not tamper with governor spring, links or other parts to increase engine
speed.
‚Replacement parts must be of the same design and installed in the same
position as the original parts. Other parts may not perform as well, may damage
the unit, and may result in injury.
‚Do not strike the flywheel with a hammer or hard object because the flywheel
may later shatter during operation.
When testing for spark:
‚Use approved spark plug tester.
‚Do not check for spark with spark plug removed.
6BRIGGSandSTRATTON.COM
Features and Controls
Compare the illustration 1with your engine to familiarize yourself with the location of
various features and controls.
A. Engine Identification
Model Type Code
B. Spark Plug
C. Air Cleaner
D. Choke
E. Starter Cord Handle
F. Finger Guard
G. Throttle Control (optional)
H. Stop Switch (optional)
I. Fuel Tank and Cap
J. Oil Drain Plug
K. Oil Fill
L. Muffler
Muffler Guard (optional)
Spark Arrester (optional)
M. Gear Reduction Unit (optional)
N. Fuel Shutoff
Operation
Oil capacity (see the Specifications section)
Oil Recommendations
We recommend the use of Briggs & Stratton Warranty Certified oils for best
performance. Other high-quality detergent oils are acceptable if classified for service SF,
SG, SH, SJ or higher. Do not use special additives.
Outdoor temperatures determine the proper oil viscosity for the engine. Use the chart to
select the best viscosity for the outdoor temperature range expected.
*Below 40°F(4°C) the use of SAE 30 will result in hard starting.
** Above 80°F(27°C) the use of 10W-30 may cause increased oil consumption. Check
oil level more frequently.
How To Check/Add Oil - Figure 2
Before adding or checking the oil
‚Place engine level.
‚Clean the oil fill area of any debris.
1. Remove the dipstick (A) and wipe with a clean cloth.
2. Insert the dipstick but do not screw in. Oil level should be at the FULL mark (B)on
the dipstick.
3. To add oil, pour the oil slowly into the engine oil fill (C). Fill to point of overflowing.
4. Replace and tighten the dipstick.
Fuel Recommendations
Fuel must meet these requirements:
‚Clean, fresh, unleaded gasoline.
‚A minimum of 87 octane/87 AKI (91 RON). High altitude use, see below.
‚Gasoline with up to 10% ethanol (gasohol) or up to 15% MTBE (methyl tertiary
butyl ether) is acceptable.
CAUTION: Do not use unapproved gasolines, such as E85. Do not mix oil in gasoline or
modify the engine to run on alternate fuels. This will damage the engine components and
void the engine warranty.
To protect the fuel system from gum formation, mix a fuel stabilizer into the fuel. See
Storage. All fuel is not the same. If starting or performance problems occur, change fuel
providers or change brands. This engine is certified to operate on gasoline. The
emissions control system for this engine is EM (Engine Modifications).
High Altitude
At altitudes over 5,000 feet (1524 meters), a minimum 85 octane/85 AKI (89 RON)
gasoline is acceptable. To remain emissions compliant, high altitude adjustment is
required. Operation without this adjustment will cause decreased performance,
increased fuel consumption, and increased emissions. See a Briggs & Stratton
Authorized Dealer for high altitude adjustment information.
Operation of the engine at altitudes below 2,500 feet (762 meters) with the high altitude
kit is not recommended.
How To Add Fuel - Figure 3
WARNING
Fuel and its vapors are extremely flammable and explosive.
Fire or explosion can cause severe burns or death.
When Adding Fuel
‚Turn engine off and let engine cool at least 2 minutes before removing the fuel
cap.
‚Fill fuel tank outdoors or in well-ventilated area.
‚Do not overfill fuel tank. To allow for expansion of the fuel, do not fill above the
bottom of the fuel tank neck.
‚Keep fuel away from sparks, open flames, pilot lights, heat, and other ignition
sources.
‚Check fuel lines, tank, cap, and fittings frequently for cracks or leaks.
Replace if necessary
‚If fuel spills, wait until it evaporates before starting engine.
1. Clean the fuel cap area of dirt and debris. Remove the fuel cap (A) (Figure 3).
2. Fill the fuel tank (B) with fuel. To allow for expansion of the fuel, do not fill above the
bottom of the fuel tank neck (C).
3. Reinstall the fuel cap.
How To Start The Engine - Figure 4
Rapid retraction of starter cord (kickback) will pull hand and arm
toward engine faster than you can let go.
Broken bones, fractures, bruises or sprains could result.
WARNING
‚When starting engine, pull the starter cord slowly until resistance is felt and then
pull rapidly to avoid kickback.
WARNING
Fuel and its vapors are extremely flammable and explosive.
Fire or explosion can cause severe burns or death.
When Starting Engine
‚Ensure that spark plug, muffler, fuel cap and air cleaner (if equipped) are in
place and secured.
‚Do not crank engine with spark plug removed.
‚If engine floods, set choke (if equipped) to OPEN/RUN position, move throttle
(if equipped) to FAST position and crank until engine starts.
Engines give off carbon monoxide, an odorless, colorless, poison gas.
Breathing carbon monoxide can cause nausea, fainting or death.
WARNING
‚Start and run engine outdoors.
‚Do not start or run engine in enclosed area, even if doors or windows are open.
NOTICE: This engine was shipped from Briggs & Stratton without oil. Before you start
the engine, make sure you add oil according to the instructions in this manual. If you
start the engine without oil, it will be damaged beyond repair and will not be covered
under warranty.
Note: Equipment may have remote controls. See the equipment manual for location and
operation of remote controls.
1. Check the oil level. See the How To Check/Add Oil section.
2. Make sure equipment drive controls, if equipped, are disengaged.
7
en
3. Move the fuel shutoff (E) to the on position.
4. Move the choke control lever (A) to the choke position (Figure 4).
Note: Choke is usually unnecessary when restarting a warm engine.
5. Move the throttle control lever (B), if equipped, to the fast position. Operate
the engine with the throttle control lever in the fast position.
6. On engines equipped with a stop switch (C), move the switch to the on position.
7. Firmly hold the starter cord handle (D). Pull the starter cord handle slowly until
resistance is felt, then pull rapidly.
Note: If the engine does not start after repeated attempts, go to
BRIGGSandSTRATTON.COM or call 1-800-233-3723 (in USA).
WARNING: Rapid retraction of the starter cord (kickback) will pull your
hand and arm toward the engine faster than you can let go. Broken bones, fractures,
bruises or sprains could result. When starting engine, pull the starter cord slowly until
resistance is felt and then pull rapidly to avoid kickback.
8. As the engine warms up, move the choke control (A)totherun position.
How To Stop The Engine - Figure 4
WARNING
Fuel and its vapors are extremely flammable and explosive.
Fire or explosion can cause severe burns or death.
‚Do not choke the carburetor to stop engine.
1. Move the stop switch (C) to the stop position.
or
Move the throttle control lever (B), if equipped, to slow and then to the stop
position.
2. Move the fuel shutoff (E) to the off position.
Maintenance
We recommend that you see any Briggs & Stratton Authorized Dealer for all
maintenance and service of the engine and engine parts.
NOTICE: All the components used to build this engine must remain in place for proper
operation.
Emissions Control
Maintenance, replacement, or repair of the emissions control devices and systems
may be performed by any non-road engine repair establishment or individual.
However, to obtain “no charge” emissions control service, the work must be performed
by a factory authorized dealer. See the Emissions Warranty.
Unintentional sparking can result in fire or electric shock.
Unintentional start-up can result in entanglement, traumatic
amputation, or laceration.
Fire hazard
WARNING
Before performing adjustments or repairs:
‚Disconnect the spark plug wire and keep it away from the spark plug.
‚Disconnect battery at negative terminal (only engines with electric start.)
‚Use only correct tools.
‚Do not tamper with governor spring, links or other parts to increase engine
speed.
‚Replacement parts must be of the same design and installed in the same
position as the original parts. Other parts may not perform as well, may damage
the unit, and may result in injury.
‚Do not strike the flywheel with a hammer or hard object because the flywheel
may later shatter during operation.
When testing for spark:
‚Use approved spark plug tester.
‚Do not check for spark with spark plug removed.
Maintenance Chart
First 5 Hours
‚Change oil
Every8HoursorDaily
‚Check engine oil level
‚Clean area around muffler and controls
‚Clean finger guard
Every 25 Hours or Annually
‚Clean air filter *
‚Clean pre-cleaner *
Every 50 Hours or Annually
‚Change engine oil
‚Inspect muffler and spark arrester
Every 100 Hours
‚Change gear reduction oil (if equipped)
Annually
‚Replace air filter
‚Replace pre-cleaner
‚Replace spark plug
‚Clean air cooling system *
*In dusty conditions or when airborne debris is present, clean more often.
Carburetor Adjustment
Never make adjustments to the carburetor. The carburetor was set at the factory to
operate efficiently under most conditions. However, if adjustments are required, see any
Briggs & Stratton Authorized Dealer for service.
NOTICE: The manufacturer of the equipment on which this engine is installed specifies
the top speed at which the engine will be operated. Do not exceed this speed.
How To Replace The Spark Plug - Figure 5
Check the gap (A, Figure 5) with a wire gauge (B). If necessary, reset the gap. Install
and tighten the spark plug to the recommended torque. For gap setting or torque, see the
Specifications section.
Note: In some areas, local law requires using a resistor spark plug to suppress ignition
signals. If this engine was originally equipped with a resistor spark plug, use the same
type for replacement.
Inspect Muffler And Spark Arrester - Figure 6
Running engines produce heat. Engine parts, especially muffler,
become extremely hot.
Severe thermal burns can occur on contact.
Combustible debris, such as leaves, grass, brush, etc. can catch fire.
WARNING
‚Allow muffler, engine cylinder and fins to cool before touching.
‚Remove accumulated debris from muffler area and cylinder area.
‚It is a violation of California Public Resource Code, Section 4442, to use or
operate the engine on any forest-covered, brush-covered, or grass-covered land
unless the exhaust system is equipped with a spark arrester, as defined in
Section 4442, maintained in effective working order. Other states or federal
jurisdictions may have similar laws. Contact the original equipment
manufacturer, retailer, or dealer to obtain a spark arrester designed for the
exhaust system installed on this engine.
Remove accumulated debris from muffler area and cylinder area. Inspect the muffler (A,
Figure 6) for cracks, corrosion, or other damage. Remove the spark arrester (B), if
equipped, and inspect for damage or carbon blockage. If damage is found, install
replacement parts before operating.
WARNING: Replacement parts must be of the same design and installed
in the same position as the original parts. Other parts may not perform as well, may
damage the unit, and may result in injury.
8BRIGGSandSTRATTON.COM
How To Change The Oil - Figure 7 8
Used oil is a hazardous waste product and must be disposed of properly. Do not discard
with household waste. Check with your local authorities, service center, or dealer for safe
disposal/recycling facilities.
Remove Oil
1. With engine off but still warm, disconnect the spark plug wire (A) and keep it away
from the spark plug (Figure 7).
2. Remove the oil drain plug (B, Figure 8). Drain the oil into an approved receptacle.
Note: Any of the oil drain plugs (C) shown may be installed in the engine.
3. After the oil has drained, install and tighten the oil drain plug.
Add oil
‚Place engine level.
‚Clean the oil fill area of any debris.
‚See the Specifications section for oil capacity.
1. Remove the dipstick (D) and wipe with a clean cloth.
2. Pour the oil slowly into the engine oil fill (E). Fill to point of overflowing.
3. Install the dipstick but do not screw in. Remove and check the oil level. Oil level
should be at the FULL mark (F) on the dipstick.
4. Install and tighten the dipstick.
How To Service The Air Filter - Figure 9
WARNING
Fuel and its vapors are extremely flammable and explosive.
Fire or explosion can cause severe burns or death.
‚Never start or run the engine with the air cleaner assembly (if equipped) or the
air filter (if equipped) removed.
NOTICE: Do not use pressurized air or solvents to clean the filter. Pressurized air can
damage the filter and solvents will dissolve the filter.
The air cleaner system uses a pleated filter with an optional pre-cleaner. The pre-cleaner
can be washed and reused.
1. Remove the fastener (A) and the cover (B).
2. Remove the fastener (C) and the filter (D).
3. Remove the pre-cleaner (E), if equipped, from the filter. To loosen debris, gently tap
the filter on a hard surface. If the filter is excessively dirty, replace with a new filter.
4. Wash the pre-cleaner in liquid detergent and water. Then allow it to thoroughly air
dry. Do not oil the pre-cleaner.
5. Assemble the dry pre-cleaner to the filter.
6. Install the filter and pre-cleaner into the base (F) and onto stud (G). Make sure filter
fits securely into the base. Secure the filter with the fastener (C).
7. Install the cover and secure with the fastener (A). Make sure the fastener is tight.
How To Change The Gear Reduction Oil - Figure 10
If your engine is equipped with a gear reduction unit, service as follows.
1. Remove the oil fill plug (B) and the oil level plug (C).
2. Remove the oil drain plug (A, Figure 10) and drain the oil into an appropriate
receptacle.
3. Install and tighten the oil drain plug.
4. To refill, slowly pour gear lube into the oil fill hole (see Specifications section).
Continue to pour until the oil runs out of the oil level hole.
5. Install and tighten the oil level plug.
6. Install and tighten the oil fill plug.
Important: The oil fill plug has a vent hole (D) and must be installed on the top of the
gear case cover as shown.
How To Clean The Air Cooling System - Figure 11
Running engines produce heat. Engine parts, especially muffler,
become extremely hot.
Severe thermal burns can occur on contact.
Combustible debris, such as leaves, grass, brush, etc. can catch fire.
WARNING
‚Allow muffler, engine cylinder and fins to cool before touching.
‚Remove accumulated debris from muffler area and cylinder area.
NOTICE: Do not use water to clean the engine. Water could contaminate the fuel
system. Use a brush or dry cloth to clean the engine.
This is an air cooled engine. Dirt or debris can restrict air flow and cause the engine to
overheat, resulting in poor performance and reduced engine life.
Use a brush or dry cloth to remove debris from the finger guard (A) (Figure 11). Keep
linkage, springs and controls (B) clean. Keep the area around and behind the muffler (C)
free of any combustible debris.
Storage
WARNING
Fuel and its vapors are extremely flammable and explosive.
Fire or explosion can cause severe burns or death.
When Storing Fuel Or Equipment With Fuel In Tank
‚Store away from furnaces, stoves, water heaters or other appliances that have
pilot light or other ignition source because they can ignite fuel vapors.
Fuel System
Fuel can become stale when stored over 30 days. Stale fuel causes acid and gum
deposits to form in the fuel system or on essential carburetor parts. To keep fuel fresh,
use Briggs & Stratton FRESH START®fuel stabilizer, available as a liquid additive or a
drip concentrate cartridge.
There is no need to drain gasoline from the engine if a fuel stabilizer is added according
to instructions. Run the engine for 2 minutes to circulate the stabilizer throughout the fuel
system. The engine and fuel can then be stored up to 24 months.
If gasoline in the engine has not been treated with a fuel stabilizer, it must be drained into
an approved container. Run the engine until it stops from lack of fuel. The use of a fuel
stabilizer in the storage container is recommended to maintain freshness.
Engine Oil
While the engine is still warm, change the engine oil.
Troubleshooting
Need Assistance? Go to BRIGGSandSTRATTON.COM or call 1-800-233-3723.
Specifications
Engine Specifications
Model 83100
Displacement 7.74 ci (127 cc)
Bore 2.441 in (62 mm)
Stroke 1.654 in (42 mm)
Engine Oil Capacity 18 -- 20 oz (0.54 -- 0.59 L)
Gear Reduction Specifications
Gear Reduction Oil Type 80W-90
Gear Reduction Oil Capacity 4 oz (0.12 L)
Tune-up Specifications *
Model 83100
Spark Plug Gap 0.030 in (0.76 mm)
Spark Plug Torque 180 lb-in (20 Nm)
Armature Air Gap 0.006 - 0.010 in (0.15 - 0.25 mm)
Intake Valve Clearance 0.005 - 0.007 in (0.13 - 0.18 mm)
Exhaust Valve Clearance 0.005 - 0.007 in (0.13 - 0.18 mm)
*Engine power will decrease 3.5% for each 1,000 feet (300 meters) above sea level and
1% for each 10flF(5.6flC) above 77flF(25flC). The engine will operate satisfactorily at
an angle up to 15fl. Refer to the equipment operator’s manual for safe allowable
operating limits on slopes.
Common Service Parts
Service Part Part Number
Oval Air Filter 797258
Fuel Additive 5041, 5058
Spark Plug 797235
Spark Plug Wrench 89838, 5023
Spark Tester 19368
nWe recommend that you see any Briggs & Stratton Authorized Dealer for all
maintenance and service of the engine and engine parts.
9
en
BRIGGS & STRATTON ENGINE OWNER WARRANTY POLICY September 2009
Briggs & Stratton Corporation will repair or replace, free of charge, any part(s) of the engine that is defective in material or workmanship or both. Transportation charges on
product submitted for repair or replacement under this warranty must be borne by purchaser. This warranty is effective for and is subject to the time periods and conditions
stated below. For warranty service, find the nearest Authorized Service Dealer in our dealer locator map at BRIGGSandSTRATTON.COM, or by calling
1-800-233-3723, or as listed in the ‘Yellow Pages’.
There is no other expressed warranty. Implied warranties, including those of merchantability and fitness for a particular purpose, are limited to one year from
purchase, or to the extent permitted by law. All other implied warranties are excluded. Liability for incidental or consequential damages are excluded to the
extent exclusion is permitted by law. Some states or countries do not allow limitations on how long an implied warranty lasts, and some states or countries do not allow
the exclusion or limitation of incidental or consequential damages, so the above limitation and exclusion may not apply to you. This warranty gives you specific legal rights
and you may also have other rights which vary from state to state and country to country.
LIMITED WARRANTY
STANDARD WARRANTY TERMS *
Brand/Product Type Consumer Use Commercial Use
Vanguardt2 years 2 years
Extended Life Seriest; I/C®; IntektI/C®; IntektPro;
Professional Seriestwith Dura-BoretCast Iron Sleeve;
850 Seriestwith Dura-BoretCast Iron Sleeve;
Snow Series MAXtwith Dura-BoretCast Iron Sleeve
All Other Briggs & Stratton Engines Featuring Dura-BoretCast Iron Sleeve
2 years 1 year
All Other Briggs & Stratton Engines 2 years 90 days
*These are our standard warranty terms, but occasionally there may be additional warranty coverage that was not determined at time of publication. For a listing of
current warranty terms for your engine, go to BRIGGSandSTRATTON.COM or contact your Authorized Briggs & Stratton Service Dealer.
Engines used on Home Standby Generator applications are warranted under consumer use only. This warranty does not apply to engines on equipment used for
prime power in place of a utility. Engines used in competitive racing or on commercial or rental tracks are not warranted.
The warranty period begins on the date of purchase by the first retail consumer or commercial end user, and continues for the period of time stated in the table above. “Consumer
use” means personal residential household use by a retail consumer. “Commercial use” means all other uses, including use for commercial, income producing or rental purposes.
Once an engine has experienced commercial use, it shall thereafter be considered as a commercial use engine for purposes of this warranty.
No warranty registration is necessary to obtain warranty on Briggs & Stratton Products. Save your proof of purchase receipt. If you do not provide proof of the initial
purchase date at the time warranty service is requested, the manufacturing date of the product will be used to determine the warranty period.
About Your Warranty
Briggs & Stratton welcomes warranty repair and apologizes to you for being
inconvenienced. Any Authorized Service Dealer may perform warranty repairs. Most
warranty repairs are handled routinely, but sometimes requests for warranty service may
not be appropriate.
If a customer differs with the decision of the Service Dealer, an investigation will be made
to determine whether the warranty applies. Ask the Service Dealer to submit all
supporting facts to his Distributor or the Factory for review. If the Distributor or the
Factory decides that the claim is justified, the customer will be fully reimbursed for those
items that are defective. To avoid misunderstanding which might occur between the
customer and the Dealer, listed below are some of the causes of engine failure that the
warranty does not cover.
Normal wear: Engines, like all mechanical devices, need periodic parts service and
replacement to perform well. Warranty will not cover repair when normal use has
exhausted the life of a part or an engine. Warranty would not apply if engine damage
occurred because of misuse, lack of routine maintenance, shipping, handling,
warehousing or improper installation. Similarly, warranty is void if the serial number of the
engine has been removed or the engine has been altered or modified.
Improper maintenance: The life of an engine depends upon the conditions under which
it operates, and the care it receives. Some applications, such as tillers, pumps and rotary
mowers, are very often used in dusty or dirty conditions, which can cause what appears
to be premature wear. Such wear, when caused by dirt, dust, spark plug cleaning grit, or
other abrasive material that has entered the engine because of improper maintenance, is
not covered by warranty.
This warranty covers engine related defective material and/or workmanship only,
and not replacement or refund of the equipment to which the engine may be
mounted. Nor does the warranty extend to repairs required because of:
1Problems caused by parts that are not original Briggs & Stratton parts.
2 Equipment controls or installations that prevent starting, cause unsatisfactory engine
performance, or shorten engine life. (Contact equipment manufacturer.)
3 Leaking carburetors, clogged fuel pipes, sticking valves, or other damage, caused
by using contaminated or stale fuel.
4 Parts which are scored or broken because an engine was operated with insufficient
or contaminated lubricating oil, or an incorrect grade of lubricating oil (check and
refill when necessary, and change at recommended intervals). OIL GARD may not
shut down running engine. Engine damage may occur if oil level is not properly
maintained.
5 Repair or adjustment of associated parts or assemblies such as clutches,
transmissions, remote controls, etc., which are not manufactured by Briggs &
Stratton.
6 Damage or wear to parts caused by dirt, which entered the engine because of
improper air cleaner maintenance, re-assembly, or use of a non-original air cleaner
element or cartridge. At recommended intervals, clean and/or replace the filter as
stated in the Operator’s Manual.
7 Parts damaged by over-speeding, or overheating caused by grass, debris, or dirt,
which plugs or clogs the cooling fins, or flywheel area, or damage caused by
operating the engine in a confined area without sufficient ventilation. Clean engine
debris at recommended intervals as stated in the Operator’s Manual.
8 Engine or equipment parts broken by excessive vibration caused by a loose engine
mounting, loose cutter blades, unbalanced blades or loose or unbalanced impellers,
improper attachment of equipment to engine crankshaft, over-speeding or other
abuse in operation.
9 A bent or broken crankshaft, caused by striking a solid object with the cutter blade of
a rotary lawn mower, or excessive v-belt tightness.
10 Routine tune-up or adjustment of the engine.
11 Engine or engine component failure, i.e., combustion chamber, valves, valve seats,
valve guides, or burned starter motor windings, caused by the use of alternate fuels
such as, liquified petroleum, natural gas, altered gasolines, etc.
Warranty service is available only through authorized service dealers by Briggs &
Stratton Corporation. Locate your nearest Authorized Service Dealer in our dealer
locator map on BRIGGSandSTRATTON.COM or by calling 1-800-233-3723, or as
listed in the ‘Yellow Pages’.
10 BRIGGSandSTRATTON.COM
California, U.S. EPA, and Briggs & Stratton Corporation Emissions Control Warranty Statement
Your Warranty Rights And Obligations
February 2009
The California Air Resources Board, U.S. EPA, and Briggs & Stratton (B&S) are pleased
to explain the emissions control system warranty on your Model Year 2009 and later
engine/equipment. In California, new small off-road engines and large spark ignited
engines less than or equal to 1.0 liter must be designed, built, and equipped to meet the
State’s stringent anti-smog standards. B&S must warrant the emissions control system
on your engine/equipment for the periods of time listed below provided there has been
no abuse, neglect, or improper maintenance of your engine or equipment.
Your emissions control system may include parts such as the carburetor or fuel injection
system, fuel tank, ignition system, and catalytic converter. Also included may be hoses,
belts, connectors, sensors, and other emissions-related assemblies.
Where a warrantable condition exists, B&S will repair your engine/equipment at no cost
to you including diagnosis, parts, and labor.
Manufacturer’s Warranty Coverage:
Small off-road engines and large spark ignited engines less than or equal to 1.0 liter are
warranted for two years. If any emissions-related part on your engine/equipment is
defective, the part will be repaired or replaced by B&S.
Owner’s Warranty Responsibilities:
‚As the engine/equipment owner, you are responsible for the performance of the
required maintenance listed in your owner’s manual. B&S recommends that you
retain all receipts covering maintenance on your engine/equipment, but B&S cannot
deny warranty solely for the lack of receipts or your failure to ensure the performance
of all scheduled maintenance.
‚As the engine/equipment owner, you should however be aware that B&S may deny
you warranty coverage if your engine/equipment or a part has failed due to abuse,
neglect, improper maintenance, or unapproved modifications.
‚You are responsible for presenting your engine/equipment to a B&S distribution
center, servicing dealer, or other equivalent entity, as applicable, as soon as a
problem exists. The warranty repairs should be completed in a reasonable amount of
time, not to exceed 30 days. If you have any questions regarding your warranty
rights and responsibilities, you should contact B&S at (414) 259-5262.
Briggs & Stratton Emissions Control Warranty Provisions
The following are specific provisions relative to your Emissions Control Warranty Coverage. It is in addition to the B&S engine warranty for non-regulated engines found in the
Operator’s Manual.
1. Warranted Emissions Parts
Coverage under this warranty extends only to the parts listed below (the emissions
control systems parts) to the extent these parts were present on the engine
purchased.
a. Fuel Metering System
‚Cold start enrichment system (soft choke)
‚Carburetor and internal parts
‚Fuel pump
‚Fuel line, fuel line fittings, clamps
‚Fuel tank, cap and tether
‚Carbon canister
b. Air Induction System
‚Air cleaner
‚Intake manifold
‚Purge and vent line
c. Ignition System
‚Spark plug(s)
‚Magneto ignition system
d. Catalyst System
‚Catalytic converter
‚Exhaust manifold
‚Air injection system or pulse valve
e. Miscellaneous Items Used in Above Systems
‚Vacuum, temperature, position, time sensitive valves and switches
‚Connectors and assemblies
2. Length of Coverage
For a period of two years from date of original purchase, B&S warrants to the original
purchaser and each subsequent purchaser that the engine is designed, built, and
equipped so as to conform with all applicable regulations adopted by the Air
Resources Board; that it is free from defects in material and workmanship that could
cause the failure of a warranted part; and that it is identical in all material respects to
the engine described in the manufacturer’s application for certification. The warranty
period begins on the date the engine is originally purchased.
The warranty on emissions-related parts is as follows:
‚Any warranted part that is not scheduled for replacement as required
maintenance in the owner’s manual supplied, is warranted for the warranty
period stated above. If any such part fails during the period of warranty
coverage, the part will be repaired or replaced by B&S at no charge to the
owner. Any such part repaired or replaced under the warranty will be warranted
for the remaining warranty period.
‚Any warranted part that is scheduled only for regular inspection in the owner’s
manual supplied, is warranted for the warranty period stated above. Any such
part repaired or replaced under warranty will be warranted for the remaining
warranty period.
‚Any warranted part that is scheduled for replacement as required maintenance
in the owner’s manual supplied, is warranted for the period of time prior to the
first scheduled replacement point for that part. If the part fails prior to the first
scheduled replacement, the part will be repaired or replaced by B&S at no
charge to the owner. Any such part repaired or replaced under warranty will be
warranted for the remainder of the period prior to the first scheduled
replacement point for the part.
‚Add on or modified parts that are not exempted by the Air Resources Board
may not be used. The use of any non exempted add on or modified parts by the
owner will be grounds for disallowing a warranty claim. The manufacturer will
not be liable to warrant failures of warranted parts caused by the use of a non
exempted add on or modified part.
3. Consequential Coverage
Coverage shall extend to the failure of any engine components caused by the
failure of any warranted emissions parts.
4. Claims and Coverage Exclusions
Warranty claims shall be filed according to the provisions of the B&S engine
warranty policy. Warranty coverage does not apply to failures of emissions parts
that are not original equipment B&S parts or to parts that fail due to abuse, neglect,
or improper maintenance as set forth in the B&S engine warranty policy. B&S is not
liable for warranty coverage of failures of emissions parts caused by the use of
add-on or modified parts.
Look For Relevant Emissions Durability Period and Air Index Information
On Your Small Off-Road Engine Emissions Label
Engines that are certified to meet the California Air Resources Board (CARB) small
off-road Emissions Standard must display information regarding the Emissions Durability
Period and the Air Index. Briggs & Stratton makes this information available to the
consumer on our emissions labels. The engine emissions label will indicate certification
information.
The Emissions Durability Period describes the number of hours of actual running time
for which the engine is certified to be emissions compliant, assuming proper
maintenance in accordance with the Operating & Maintenance Instructions. The
following categories are used:
Moderate:
Engine is certified to be emissions compliant for 125 hours of actual engine running time.
Intermediate:
Engine is certified to be emissions compliant for 250 hours of actual engine running time.
Extended:
Engine is certified to be emissions compliant for 500 hours of actual engine running time.
For example, a typical walk-behind lawn mower is used 20 to 25 hours per year.
Therefore, the Emissions Durability Period of an engine with an intermediate rating
would equate to 10 to 12 years.
Briggs & Stratton engines are certified to meet the United States Environmental
Protection Agency (USEPA) Phase 2 emissions standards. For Phase 2 certified
engines, the Emissions Compliance Period referred to on the Emissions Compliance
label indicates the number of operating hours for which the engine has been shown to
meet Federal emissions requirements.
For engines less than 225 cc displacement.
Category C = 125 hours , Category B = 250 hours , Category A = 500 hours
For engines of 225 cc or more displacement.
Category C = 250 hours , Category B = 500 hours , Category A = 1000 hours
11
bg
Îáùà èíôîðìàöèÿ
‚îâà ˜úêîâîäñòâî ñúäú˜¥à ñâåäåíèÉçà áåçîïàñíà ˜àáîòà, çà äà ñòå íàÉñíî ñ
àâà˜èèòå è îïàñíîñòèòå, ñâú˜çàíè ñ òåçè äâèãàòåëè è êàê äà ãè èçáÉãâàòå. ‚î
ñúäú˜¥à è èíñò˜óêöèè çà ï˜àâèëíàòà èì óïîò˜åáà è ïîää˜ú¥êà. ‚úé êàòî â
ÿî˜ïî˜àöèÉBriggs & Stratton íå áèõà ìîãëè äà çíàÉò êàêâà ìàèíà ùå ñå
çàäâè¥âà ñ òîçè äâèãàòåë, âà¥íî å äà ï˜î…åòåòå è ˜àçáå˜åòå òåçè èíñò˜óêöèè u
èíñò˜óêöèèòå çà çàäâè¥âàíàòà ìàèíà. Çàïèåòå òåçè èíñò˜óêöèè çà áúäåùè
ñï˜àâêè.
Çà ˜åçå˜âíè …àñòè èëè òåõíè…åñêà ïîìîù çàïèåòå îòäîëó ìîäåëà íà äâèãàòåëÉ,
òèïà è êîäîâèòå íîìå˜à ñ äàòàòà íà êóïóâàíåòî ìó. ‚åçè íîìå˜à ñå íàìè˜àò âú˜õó
äâèãàòåëÉâè. (íàï˜àâåòå ñï˜àâêà íà ñò˜àíèöàòà ñ ˜àçäåë Åëåìåíòè è
Óïðàâëåíèÿ).
Äàòà íà êóïóâàíå:
Ìîäåë íà äâèãàòåëÿ:
MM/ÄÄ/øøøø
flîäåë: ÿîä:‚èï:
Èíôîðìàöèÿ çà íîìèíàëíàòà ìîùíîñò íà äâèãàòåëèòå
fiúëíàòà ìîùíîñò âú˜õó îòäåëíèòå ìîäåëè áåíçèíîâè äâèãàòåëè å îòáåëÉçàíà â
ñúîòâåòñòâèå ñúñ ñúçäàäåíèÉîò SAE (Ęó¥åñòâî íà èí¥åíå˜èòå îò
àâòîìîáèëíàòà ï˜îìèëåíîñò è ò˜àíñïî˜òà) fi˜àâèëíèê çà òåõíè…åñêà
åêñïëîàòàöèÉJ1940 (flåòîäèêà çà îï˜åäåëÉíå íà íîìèíàëíàòà ìîùíîñò è
âú˜òÉùèÉìîìåíò íà ìàëêè äâèãàòåëè), à íîìèíàëíàòà èì ìîùíîñò áå ïîëó…åíà è
êî˜èãè˜àíà â ñúîòâåòñòâèå ñ âå˜ñèÉòà íà fi˜àâèëíèêà çà òåõíè…åñêà
åêñïëîàòàöèÉJ1995 íà SAE (ˆåäàêöèÉîò 2002-05 ã.). Ñòîéíîñòèòå íà âú˜òÉùèÉ
ìîìåíò ñà èçâåäåíè ï˜è 3060 îá/ìèí.; ñòîéíîñòèòå íà ìîùíîñòòà Áï˜è 3600
îá/ìèí. Äåéñòâèòåëíàòà ïúëíà ìîùíîñò íà äâèãàòåëèòå ùå áúäå ïî-íèñêà è ñå
âëèÉå, ìå¥äó ä˜óãîòî, îò îêîëíàòà ñ˜åäà, â êîÉòî îáî˜óäâàíåòî ñå åêñïëîàòè˜à è
îò õà˜àêòå˜èñòèêèòå íà âñåêè îòäåëåí äâèãàòåë. fi˜è è˜îêèÉíàáî˜ îò ìàèíè,
âú˜õó êîèòî ñå ïîñòàâÉò äâèãàòåëèòå è ï˜è ˜àçíîîá˜àçèåòî íà åêîëîãè…íèòå
èçèñêâàíèÉ,âêîÉòî îáî˜óäâàíåòî ˜àáîòè, áåíçèíîâèÉò äâèãàòåë íÉìà äà ˜àçâèå
óêàçàíàòà îò ï˜îèçâîäèòåëÉïúëíà ìîùíîñò, êîãàòî å ìîíòè˜àí íà äàäåíî
åíå˜ãèéíî îáî˜óäâàíå (äåéñòâèòåëíàòà ìîùíîñò Äíà îáåêòàÄèëè åôåêòèâíàòà
ìîùíîñò). ‚àçè ˜àçëèêà ñå äúë¥è íà ãîëÉì á˜îé ôàêòî˜è, âêë˚…èòåëíî íà
àêñåñîà˜èòå êúì äâèãàòåëÉ(âúçäóåí ôèëòú˜, àóñïóõ, ñèñòåìà çà çà˜å¥äàíå,
ñèñòåìà çà îõëà¥äàíå, êà˜áó˜àòî˜, ãî˜èâíà ïîìïà è ò. í.), íà õà˜àêòå˜íèòå
îã˜àíè…åíèÉçà èçïîëçâàíåòî ìó, íà óñëîâèÉòà â îêîëíàòà ñ˜åäà, â êîÉòî
äâèãàòåëÉò ˜àáîòè (òåìïå˜àòó˜à, âëà¥íîñò, íàäìî˜ñêà âèñî…èíà), íà ˜àçëè…èÉòà
âúâ âñåêè îòäåëåí äâèãàòåë. fiî˜àäè òåõíîëîãè…íè è ï˜îèçâîäñòâåíè îã˜àíè…åíèÉ
ôè˜ìàòà Briggs & Stratton ìî¥å äà çàìåñòè äàäåí äâèãàòåë ñ ïî-âèñîêà
íîìèíàëíà ìîùíîñò ñ äâèãàòåë îò òåçè ñå˜èè.
Òåõíèêà çà áåçîïàñíîñò íà îïåðàòîðà
Âçðèâîîïàñíî
Îòðîâíè
ãàçîâå
Äâèæåùè
ñå ÷àñòè
Îïàñíîñò çà ïîðàæåíèÿ
îò åëåêòðè÷åñêè òîê
Ãîðåùà
ïîâúðõíîñò
Îáðàòåí
óäàð
Îãíåîïàñíî
Ïðåêðàòÿâàíå
ïîäàâàíåòî íà ãîðèâî
Ïðî÷åòåòå
Ðúêîâîäñòâîòî
Ñìóêà÷
Ìàñëî
Ãîðèâî
Âêë. Èçêë.
Ñòîï
Äà ñå íîñÿò
ïðåäïàçíè î÷èëà
Áúðçè
îáîðîòè Áàâíè
îáîðîòè
ÑÈÌÂÎËÈ ÇÀ ÁÅÇÎÏÀÑÍÎÑÒ È ÓÏÐÀÂËÅÍÈÅ
Îïàñíè
õèìèêàëè Îïàñíîñò îò
èçìðúçâàíå
fi˜åäóï˜åäèòåëíèÉò ñèìâîë çà îïàñíîñò îï˜åäåëÉï˜åäîõ˜àíèòåëíà
èíôî˜ìàöèÉçà ˜èñêîâå, êîèòî ìîãàò äà äîâåäàò äî íà˜àíÉâàíå íà ïå˜ñîíàëà.
Ñèãíàëèçè˜àùà äóìà (›fiæÑ‹›, fiˆÅćfiˆÅŒÄÅ‹¤Å èëè Ö‹¤fl拤Å) ñå ïîñòàâÉ
çàåäíî ñ ï˜åäóï˜åäèòåëåí ñèìâîë, çà äà ïîñî…è âå˜îÉòíîñòòà è ïîòåíöèàëíàòà
ñå˜èîçíîñò íà íà˜àíÉâàíåòî. Äîïúëíèòåëíî, åäèí ñèìâîë çà îïàñíîñò ìî¥å äà
ïîêàçâà âèäà íà îïàñíîñòòà.
ÎÏÀÑÍÎ ïîñî…âà îïàñíîñò, êîÉòî, àêî íå áúäå èçáåãíàòà, ùå äîâåäå
äî ñìúðò èëè ñåðèîçíî íàðàíÿâàíå.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ ïîñî…âà îïàñíîñò, êîÉòî, àêî íå áúäå
èçáåãíàòà, ìîæå äà äîâåäå äî ñìúðò èëè ñåðèîçíî íàðàíÿâàíå.
ÂÍÈÌÀÍÈÅ ïîñî…âà îïàñíîñò, êîÉòî, àêî íå áúäå èçáåãíàòà, ìîæå äà
äîâåäå äî ìàëêà èëè ñðåäíà ñòåïåí íà íàðàíÿâàíå.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ ïîñî…âà ñèòóàöèÉ,êîÉòî áèìîãëàäàäîâåäå
äî ïîâðåæäàíå íà ïðîäóêòà.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
‹Éêîè îò ñúñòàâíèòå åëåìåíòè íà òîçè ï˜îäóêò è ñâú˜çàíèòå ñ òÉõ
ï˜èñïîñîáëåíèÉñúäú˜¥àò õèìè…íè âåùåñòâà, èçâåñòíè â ùàòà ÿàëèôî˜íèÉ
êàòî ï˜è…èíèòåëè íà ˜àê, óâ˜åäà íà íîâî˜îäåíèòå èëè ä˜óãè óâ˜åäè íà
˜åï˜îäóêòèâíàòà ñïîñîáíîñò. Ñëåä ˜àáîòà ñ òÉõ, èçìèâàéòå ˜úöåòå ñè.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
¤çãî˜åëèòå ãàçîâå îò òîçè äâèãàòåë ñúäú˜¥àò õèìè…åñêè ñúåäèíåíèÉ,
èçâåñòíè íà ùàòà ÿàëèôî˜íèÉêàòî ï˜è…èíèòåëè íà ˜àê, óâ˜å¥äàíèÉï˜è
˜à¥äàíå, èëè ä˜óãè óâ˜å¥äàíèÉ, ñâú˜çàíè ñ ˜åï˜îäóêòèâíîñòòà.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
ÿî˜ïî˜àöèÉBriggs & Stratton íå îäîá˜ÉâàèíåïîçâîëÉâà èçïîëçâàíåòî íà
òåçè äâèãàòåëè âú˜õó âñúäåõîäè íà 3 êîëåëà, ìîòîöèêëåòè, óâåñåëèòåëíè
êîëè…êè/êà˜òèíã, ëåòàòåëíè àïà˜àòè èëè ò˜àíñïî˜òíè ñ˜åäñòâà çà ó…àñòèå â
ñúñòåçàòåëíè ìå˜îï˜èÉòèÉ. ¤çïîëçâàíåòî íà òåçè äâèãàòåëè íà òàêèâà
ìàèíè ìî¥å äà äîâåäå äî ìàòå˜èàëíè ùåòè, ñå˜èîçíè íà˜àíÉâàíèÉ
(âêë˚…èòåëíî ïà˜àëèçà) è äî˜è äî ñìú˜ò.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ: ‹àñòîÉùèÉò äâèãàòåë ñå äîñòàâÉîò Briggs & Stratton áåç
ìàñëî. fi˜åäè äà ñòà˜òè˜àòå äâèãàòåëÉñå óâå˜åòå, …å ñòå íàëåëè ìàñëî â íåãî
ñïî˜åä èíñò˜óêöèèòå â òîâà ˜úêîâîäñòâî. æêî ãî ñòà˜òè˜àòå áåç ìàñëî, òîé ùå ñå
ïîâ˜åäè, áåç äà áúäå âúçìî¥íî äà ñå ˜åìîíòè˜à è áåç ïîê˜èòèå îò ãà˜àíöèÉòà.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
Ãîðèâîòî è íåãîâèòå ïàðè ñà èçêëþ÷èòåëíî îãíåîïàñíè è
èçáóõëèâè.
Ïîæàð èëè âçðèâ ìîãàò äà ïðè÷èíÿò ñåðèîçíè îáãàðÿíèÿ èëè
ñìúðò.
Ïðè äîëèâàíå íà ãîðèâî
‚¤çêë˚…åòå äâèãàòåëÉè ãî îñòàâåòå äà ñå îõëàäè íàé-ìàëêî 2 ìèíóòè,
ï˜åäè äà ñâàëèòå êàïà…êàòà íà ˜åçå˜âîà˜à çà ãî˜èâî.
‚fiúëíåòå ˜åçå˜âîà˜à çà ãî˜èâî íà îòê˜èòî èëè â äîá˜å âåíòèëè˜àíî
ïîìåùåíèå.
‚íå ï˜åïúëâàéòå ˜åçå˜âîà˜à çà ãî˜èâî. Çà äà ïîçâîëèòå ˜àçè˜åíèå íà
áåíçèíà, íå ïúëíåòå íàä äîëíàòà îñíîâà íà ãú˜ëîâèíàòà çà íàëèâàíå íà
ãî˜èâî.
‚Ęú¥òå ãî˜èâîòî äàëå… îò èñê˜è, îòê˜èòè ïëàìúöè, ñèãíàëíè ëàìïè,
òîïëèíà è ä˜óãè çàïàëèòåëíè èçòî…íèöè.
‚fi˜îâå˜Éâàéòå …åñòî ãî˜èâîï˜îâîäèòå, ˜åçå˜âîà˜à, êàïà…êàòà è
ñúåäèíåíèÉòà çà ïóêíàòèíè èëè òå…îâå. Çàìåíåòå ãè, àêî å íåîáõîäèìî.
‚æêî ãî˜èâîòî ñå ˜àçëåå, èç…àêàéòå äîêàòî òî ñå èçïà˜è, ï˜åäè äà
ñòà˜òè˜àòå äâèãàòåëÉ.
Ïðè ñòàðòèðàíå íà äâèãàòåëÿ
‚‡âå˜åòå ñå, …å çàïàëèòåëíàòà ñâåù, óìîçàãëóèòåëÉ, êàïà…êàòà íà
˜åçå˜âîà˜à çà ãî˜èâî è âúçäóíèÉôèëòú˜ (àêî èìà òàêèâà) ñà íà
ìÉñòîòî ñè è ñà îáåçîïàñåíè.
‚‹å ˜àçâú˜òàéòå äâèãàòåëÉñ èçâàäåíà çàïàëèòåëíà ñâåù.
‚æêî äâèãàòåëÉò ñå çàäàâè, ïîñòàâåòå ñìóêà…à (àêî èìà òàêúâ) íà ïîçèöèÉ
OPEN/RUN, ï˜èäâè¥åòå ˜ú…íàòà ãàç (àêî èìà òàêàâà) íà ïîçèöèÉFAST è
˜àçâú˜òàéòå, äîêàòî äâèãàòåëÉò ñòà˜òè˜à.
Ïðè ðàáîòåùà ìàøèíà
‚‹å íàêëîíÉâàéòå äâèãàòåëÉèëè ìàèíàòà ïîä úãúë, êîéòî âîäè äî
˜àçëèâàíå íà ãî˜èâîòî.
‚‹å çàïóâàéòå êàìå˜àòà íà êà˜áó˜àòî˜à, çà äà ñï˜åòå äâèãàòåëÉ.
‚‹èêîãà íå ñòà˜òè˜àéòå è íå ˜àáîòåòå ñ äâèãàòåëÉï˜è îòñò˜àíåí êîìïëåêò
íà âúçäóíèÉôèëòú˜ (àêî èìà òàêúâ) èëè ï˜è îòñò˜àíåí âúçäóåí
ôèëòú˜ (àêî èìà òàêúâ).
Ïðè ñìÿíà íà ìàñëîòî
‚æêî èçòî…âàòå ìàñëîòî îò ãî˜íàòà ò˜úáà çà ïúëíåíå ñ ìàñëî,
˜åçå˜âîà˜úò çà ãî˜èâî ò˜Éáâà äà áúäå ï˜àçåí, èëè òî ìî¥å äà ïîòå…å è
äà ï˜è…èíè ïî¥à˜ èëè åêñïëîçèÉ.
Ïðè òðàíñïîðòèðàíå íà ìàøèíàòà
‚‚˜àíñïî˜òè˜àéòå ñ fiˆæÇÅ‹ ˜åçå˜âîà˜, èëè ñ ê˜àí çà ïîäàâàíå íà ãî˜èâî
íà ïîçèöèÉOFF.
Ïðè ñêëàäèðàíå íà ãîðèâî èëè íà ìàøèíà ñ ãîðèâî â ðåçåðâîàðà
‚Ñêëàäè˜àéòå äàëå… îò ïåùè, ïå…êè, âîäîíàã˜åâàòåëè èëè ä˜óãè
åëåêò˜è…åñêè ï˜èáî˜è, êîèòî èìàò ñèãíàëíè ëàìïè èëè ä˜óãè çàïàëèòåëíè
èçòî…íèöè, çàùîòî òå ìîãàò äà âúçïëàìåíÉò èçïà˜åíèÉòà îò ãî˜èâîòî.
12 BRIGGSandSTRATTON.COM
Ïóñêàíåòî íà äâèãàòåëÿ ñúçäàâà èñêðåíå.
Èñêðåíåòî ìîæå äà âúçïëàìåíè íàìèðàùèòå ñå íàîêîëî
çàïàëèìè ãàçîâå.
Òîâà ìîæå äà äîâåäå äî åêñïëîçèÿ è ïîæàð.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
‚æêî èìà èçòè…àíå íà ï˜è˜îäåí èëè âòå…íåí ãàç ï˜îïàí â ïîìåùåíèåòî, íå
ñòà˜òè˜àéòå äâèãàòåëÉ.
‚‹å èçïîëçâàéòå ãî˜èâà çà íà…àëíî çàïàëâàíå ïîä íàëÉãàíå, çàùîòî
ïà˜èòå èì ñà çàïàëèòåëíè.
Äâèãàòåëèòå èçïóñêàò âúãëåðîäåí îêèñ, êîéòî å îòðîâåí ãàç, áåç
ìèðèñ è öâÿò.
Âäèøâàíåòî íà âúãëåðîäåí îêèñ ìîæå äà ïðè÷èíè ãàäåíå,
ïðèïàäúê èëè ñìúðò.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
‚Ñòà˜òè˜àéòå è ˜àáîòåòå ñ äâèãàòåëÉíàâúí.
‚‹å ñòà˜òè˜àéòå è íå ˜àáîòåòå ñ äâèãàòåëÉâ çàòâî˜åíî ïîìåùåíèå, äî˜è è
ï˜è îòâî˜åíè â˜àòè èëè ï˜îçî˜öè.
Áúðçîòî ïðèòåãëÿíå íà ïóñêîâîòî âúæå (îáðàòåí óäàð)
ïðèäúðïâà ðúêàòà êúì äâèãàòåëÿ ïî-áúðçî, îòêîëêîòî âèå
ìîæåòå äà ÿ îòäðúïíåòå.
Òîâà ìîæå äà ïðè÷èíè ñ÷óïåíè êîñòè, ôðàêòóðè, êîíòóçèè è
íàâÿõâàíèÿ.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
‚fi˜è ñòà˜òè˜àíå íà äâèãàòåëÉ, èçòåãëåòå âíèìàòåëíî âú¥åòî íà ˜ú…íèÉ
ñòà˜òå˜, äîêàòî óñåòèòå ñúï˜îòèâëåíèå, à ñëåä òîâà ä˜úïíåòå ˜Éçêî, çà
äà èçáåãíåòå îá˜àòíèÉóäà˜.
‚¤çêë˚…åòå âñÉêî âúííî îáî˜óäâàíå/çàäâè¥âàíî îò äâèãàòåëÉ, ï˜åäè äà
ãî ñòà˜òè˜àòå.
‚Äè˜åêòíî ï˜èêà…åíèòå êúì äâèãàòåëÉìàèííè åëåìåíòè êàòî íî¥îâå,
ïå˜êè, ëåáåäêè, çúáíè êîëåëà, çàäâè¥âàùè âå˜èãè è ä˜óãè, ò˜Éáâà äà
áúäàò ñèãó˜íî ï˜èê˜åïåíè.
Âúðòÿùèòå ñå ÷àñòè ìîãàò äà äîïðàò èëè çàõâàíàò ðúöå, êðàêà,
êîñà, îáëåêëî èëè ïðèíàäëåæíîñòè.
Ìîæå äà ñå äîñòèãíå äî òðàâìàòè÷íà àìïóòàöèÿ èëè ñåðèîçíî
íàðàíÿâàíå.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
‚ˆàáîòåòå ñ äâèãàòåëÉï˜è ïîñòàâåíè çàùèòíè êàïàöè.
‚Ęú¥òå ˜úöåòå è ê˜àêàòà ñè äàëå… îò âú˜òÉùè ñå …àñòè.
‚fi˜èâú˜çâàéòå äúëãèòå êîñè è ñâàëÉéòå óê˜àåíèÉòà.
‚‹å íîñåòå ïî ñåáå ñè è˜îêî îáëåêëî, âèñÉùè íó˜îâå èëè âåùè, êîèòî
ìîãàò äà áúäàò çàõâàíàòè.
Ðàáîòåùèòå äâèãàòåëè îòäåëÿò òîïëèíà. ×àñòèòå íà äâèãàòåëèòå,
îñîáåíî øóìîçàãëóøèòåëÿ, ñòàâàò èçêëþ÷èòåëíî ãîðåùè.
Ïðè äîïèð ìîæå äà ïîëó÷èòå ñåðèîçíî èçãàðÿíå.
Ãîðèìèòå îòïàäúöè, êàòî ëèñòà, òðåâè, õðàñòàëàê è äðóãè, ìîãàò
äà ñå çàïàëÿò.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
‚›ñòàâåòå óìîçàãëóèòåëÉ,öèëèíäú˜àíàäâèãàòåëÉè ˜åá˜àòà äà ñå
îõëàäÉò, ï˜åäè äà ãè äîêîñâàòå.
‚›òñò˜àíåòå íàò˜óïàíèòå îòëîìêè îêîëî óìîçàãëóèòåëÉè öèëèíäú˜à.
‚¤çïîëçâàíåòî èëè ˜àáîòàòà ñ äâèãàòåëÉ, ïî çàëåñåíè ñ ãî˜è, õ˜àñòè èëè ñ
ò˜åâè ïëîùè, ñïî˜åä fi˜àâèëíèêà íà ÿàëèôî˜íèÉçà îáùåñòâåíèòå
˜åñó˜ñè, ˆàçäåë 4442, ï˜åäñòàâëÉâà íà˜óåíèå, îñâåí àêî äâèãàòåëÉò
íå å ñíàáäåí ñ èñê˜îãàñèòåë, ïîääú˜¥àí â åôèêàñíî ˜àáîòíî ñúñòîÉíèå,
êàêòî å îï˜åäåëåíî â ˆàçäåë 4442. Öä˜óãèòåùàòèèôåäå˜àëíè
˚˜èñäèêöèè ìî¥å äà èìà ïîäîáíè çàêîíè. Ñâú˜¥åòå ñå ñ ï˜îèçâîäèòåëÉ,
ï˜îäàâà…à íà ä˜åáíî èëè äèñò˜èáóòî˜à íà î˜èãèíàëíîòî ñúî˜ú¥åíèå, çà
äà ïîëó…èòå èñê˜îãàñèòåë, ï˜îåêòè˜àí çà ìîíòè˜àíàòà íà òîçè äâèãàòåë
èçïóñêàòåëíà ñèñòåìà.
Ñëó÷àéíî èñêðåíå ìîæå äà äîâåäå äî ïîæàð èëè ïîðàçÿâàíå îò
åëåêòðè÷åñêè òîê.
Íåâîëíî ñòàðòèðàíå ìîæå äà äîâåäå äî çàõâàùàíå, òðàâìàòè÷íà
àìïóòàöèÿ èëè äî ðàíÿâàíå.
Îïàñíîñò îò ïîæàð
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
Ïðåäè èçâúðøâàíå íà ðåãóëèðîâêè è ïîïðàâêè:
‚›òêà…åòå êàáåëà íà çàïàëèòåëíàòà ñâåù è ãî ä˜ú¥òå äàëå… îò íåÉ.
‚›òêà…åòå ìèíóñ-êëåìàòà íà àêóìóëàòî˜à (ñàìî ï˜è äâèãàòåëè ñ
åëåêò˜è…åñêè ñòà˜òå˜).
‚¤çïîëçâàéòå ñàìî ïîäõîäÉùè èíñò˜óìåíòè.
‚‹å çàñòîïî˜Éâàéòå ñ ˜åãóëè˜àùàòà ï˜ó¥èíà, ëîñòîâèòå ñèñòåìè èëè ñ
ä˜óãè…àñòè,çàäàïîâèèòå îáî˜îòèòå íà äâèãàòåëÉ.
‚ˆåçå˜âíèòå …àñòè ò˜Éáâà äà áúäàò ñúñ ñúùàòà êîíñò˜óêöèÉèäàñå
ìîíòè˜àò â ñúùîòî ïîëî¥åíèå, êàêòî î˜èãèíàëíèòå …àñòè. ˝àñòè îò ä˜óã
ï˜îèçâîäèòåë ìî¥å äà íå ˜àáîòÉò äîá˜å, ìî¥å äà ïîâ˜åäÉòàã˜åãàòàèëè
äà äîâåäàò äî íà˜àíÉâàíå.
‚‹å óä˜Ééòå ìàõîâèêà ñ …óê èëè òâú˜ä ï˜åäìåò, çàùîòî òîé ìî¥å äà ñå
ñò˜îè ïî â˜åìå íà ˜àáîòà.
Ïðè èçïðîáâàíå çà èñêðà:
‚¤çïîëçâàéòå îäîá˜åí òèï òåñòå˜ çà ñâåùè.
‚‹å ï˜àâåòå ï˜îâå˜êà çà èñê˜à ï˜è èçâàäåíà çàïàëèòåëíà ñâåù.
13
bg
Åëåìåíòè è óïðàâëåíèÿ
јàâíåòå èë˚ñò˜àöèÉòà 1ñâàèÉäâèãàòåë, çà äà ñå çàïîçíàåòå ñ
˜àçïîëî¥åíèåòî íà ˜àçëè…íèòå åëåìåíòè è óï˜àâëåíèÉ.
A. flà˜êè˜îâêà íà äâèãàòåëÉ
Ìîäåë Òèï Êîä
B. Çàïàëèòåëíà ñâåù
C. Öúçäóåí ôèëòú˜
D. Ñìóêà…
E. ˆúêîõâàòêà íà âú¥åòî çà ˜ú…íèÉñòà˜òå˜
F. fi˜åäïàçèòåë çà ï˜úñòèòå
G. ˆú…íà ãàç (ïî îïöèÉ)
H. Ñòîï-êë˚… (ïî îïöèÉ)
I. ˆåçå˜âîà˜ çà ãî˜èâî è êàïà…êà
J. fi˜îáêà çà èçòî…âàíå íà ìàñëîòî
K. ›òâî˜ çà íàëèâàíå íà ìàñëî
L. Æóìîçàãëóèòåë
ÿî¥óõ íà óìîçàãëóèòåëÉ(ïî îïöèÉ)
¤ñê˜îãàñèòåë (ïî îïöèÉ)
M. Çúáíà ˜åäóêòî˜íà êóòèÉ(ïî îïöèÉ)
N. fi˜åê˜àòÉâàíå ïîäàâàíåòî íà ãî˜èâî
Ðàáîòà
Öìåñòèìîñò çà ìàñëî (íàï˜àâåòå ñï˜àâêà â ˜àçäåë Òåõíè÷åñêè äàííè)
Ïðåïîðúêè çà ìàñëîòî
Çà ïîëó…àâàíå íà íàé-äîá˜è òåõíè…åñêè ïîêàçàòåëè ï˜åïî˜ú…âàìå èçïîëçâàíåòî
íà ìàñëàòà íà Briggs & Stratton ñ ãà˜àíöèÉè ñå˜òèôèêàò çà êà…åñòâî. Ęóãè
âèñîêîêà…åñòâåíè ìàñëà ñ ìèåùè ï˜èñàäêè ñà ï˜èåìëèâè, àêî ñà êëàñèôèöè˜àíè
çà ˜àáîòíè ˜å¥èìè SF, SG, SH, SJ èëè ïî-âèñîêè. Äà íå ñå èçïîëçâàò ñïåöèàëíè
äîáàâêè.
Öúííèòå òåìïå˜àòó˜è îï˜åäåëÉò ï˜àâèëíèÉâèñêîçèòåò íà ìàñëîòî çà
äâèãàòåëÉ. ¤çïîëçâàéòå òàáëèöàòà, çà äà èçáå˜åòå íàé-äîá˜èÉâèñêîçèòåò çà
î…àêâàíèÉäèàïàçîí íà âúííèòå òåìïå˜àòó˜è.
SAE 30.
10W-30
Ñèíòåòè÷íî 5W-30
5W-30
°F°C
*æêî ï˜è òåìïå˜àòó˜è ïîä 40°F(4°C) ñå èçïîëçâà ìàñëî SAE 30, òîâà ùå
äîâåäå äî ò˜óäíî ñòà˜òè˜àíå íà äâèãàòåëÉ.
** fi˜è òåìïå˜àòó˜è íàä 80°F(27°C) èçïîëçâàíåòî íà ìàñëî 10 W-30 ìî¥å äà
ïîâèè êîíñóìàöèÉòà íà ìàñëî. fi˜îâå˜Éâàéòå ïî …åñòî íèâîòî ìó.
Êàê ñå ïðîâåðÿâà/íàëèâà ìàñëî - Ôèãóðà 2
Ïðåäè íàëèâàíå èëè ïðîâåðÿâàíå íà ìàñëîòî
‚ˆàçïîëî¥åòå õî˜èçîíòàëíî äâèãàòåëÉ.
‚fiî…èñòåòå ìÉñòîòî îêîëî îòâî˜à çà íàëèâàíå íà ìàñëî îò âñè…êè îòëîìêè.
1. Ñâàëåòå íèâîïîêàçàòåëÉ(A) è ãî èçáú˜åòå ñ …èñò ïëàò.
2. fiîñòàâåòå íèâîïîêàçàòåëÉ,íîíå ãî çàòÉãàéòå. íèâîòî íà ìàñëîòî ò˜Éáâà äà
áúäå äî ìà˜êè˜îâêàòà FULL (B) íà íèâîïîêààçàòåëÉ.
3. fi˜è íàëèâàíå íà ìàñëî, îòëèâàéòå âíèìàòåëíî ï˜åç îòâî˜à çà ïúëíåíå ñ
ìàñëî (C). ‹àïúëíåòå äî òî…êàòà íà ï˜åïúëâàíå.
4. fiîñòàâåòå îòíîâî íèâîïîêàçàòåëÉè ãî çàòåãíåòå.
Ïðåïîðúêè çà ãîðèâîòî
Ãîðèâîòî òðÿáâà äà îòãîâàðÿ íà ñëåäíèòå èçèñêâàíèÿ:
‚˝èñò, ï˜åñåí, áåçîëîâåí áåíçèí.
‚flèíèìàëíî îêòàíîâî …èñëî îò 87/87 AKI (91 RON). Çà ãîëÉìà íàäìî˜ñêà
âèñî…èíà, âè¥òå ïî-äîëó.
‚Ÿåíçèí ñúñ ñúäú˜¥àíèå íà íå ïîâå…å îò 10% åòàíîë (áåíçîñïè˜ò) èëè äî
15% MTBE (ò˜è-ìåòèë áóòèëîâ åòå˜) å ï˜èåìëèâ.
ÂÍÈÌÀÍÈÅ: ‹å èçïîëçâàéòå íå îäîá˜åíè áåíçèíè êàòî E85. ‹å ñìåñâàéòå
áåíçèíà ñ ìàñëî, íå ãî ìîäèôèöè˜àéòå çà ˜àáîòà ñ àëòå˜íàòèâíè ãî˜èâà. ‚îâà ùå
ïîâ˜åäè êîìïîíåíòèòå íà äâèãàòåëÉèùå àíóëèðà ãàðàíöèÿòà ìó.
Çà äà ï˜åäïàçèòå ãî˜èâíàòà ñèñòåìà îò îá˜àçóâàíå íà ñìîëè, äîáàâåòå
ñòàáèëèçàòî˜ â ãî˜èâîòî. ‹àï˜àâåòå ñï˜àâêà â Ñêëàäèðàíå. øî˜èâàòà íå ñà åäíè
ñúùè. æêî íàñòúïè ï˜îáëåì ñúñ ñòà˜òè˜àíåòî èëè òåõíè…åñêèòå ïîêàçàòåëè,
ñìåíåòå äîñòàâ…èöèòå èëè ìà˜êèòå íà ãî˜èâîòî. ‹àñòîÉùèÉòäâèãàòåëèìà
ñå˜òèôèêàò çà ˜àáîòà ñ áåíçèí. Ñèñòåìàòà çà áî˜áà ñ â˜åäíèòå åìèñèè çà òîçè
äâèãàòåë å EM (flîäèôèêàöèè íà äâèãàòåëèòå).
Ãîëÿìà íàäìîðñêà âèñî÷èíà
fi˜è íàäìî˜ñêè âèñî…èíè íàä 5000 ôóòà (1524 ìåò˜à), áåíçèí ñ ìèíèìàëíî
îêòàíîâî …èñëî 85/85 AKI (89 RON), å ï˜èåìëèâ. Çà äà îñòàíå ñúâìåñòèì ñ
èçèñêâàíèÉòà çà íèâîòî íà åìèñèèòå, ñå íàëàãà íàñò˜îéêà íà äâèãàòåëÉâ
ñúîòâåòñòâèå ñ ãîëÉìàòà íàäìî˜ñêà âèñî…èíà. ˆàáîòàòà áåç òàêàâà íàñò˜îéêà ùå
äîâåäå äî ïîíè¥àâàíå íà òåõíè…åñêèòå ïîêàçàòåëè, ïîâèàâàíå íà
êîíñóìàöèÉòà íà ãî˜èâî è óâåëè…åíè â˜åäíè åìèñèè. ‹àï˜àâåòå ñï˜àâêà ï˜è
‡ïúëíîìîùåí ï˜åäñòàâèòåë íà Briggs & Stratton çà ñâåäåíèÉîòíîñíî íàñò˜îéêàòà
çà ãîëÉìà íàäìî˜ñêà âèñî…èíà.
‹å ñå ï˜åïî˜ú…âà ˜àáîòà íà äâèãàòåëÉñ ˜åãóëè˜àù êîìïëåêò çà ãîëÉìà
íàäìî˜ñêà âèñî…èíà ï˜è âèñî…èíè ïîä 2500 ôóòà (762 ìåò˜à).
Êàê ñå íàëèâà ìàñëî - Ôèãóðà 3
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
Ãîðèâîòî è íåãîâèòå ïàðè ñà èçêëþ÷èòåëíî îãíåîïàñíè è
èçáóõëèâè.
Ïîæàð èëè âçðèâ ìîãàò äà ïðè÷èíÿò ñåðèîçíè îáãàðÿíèÿ èëè
ñìúðò.
Ïðè äîëèâàíå íà ãîðèâî
‚¤çêë˚…åòå äâèãàòåëÉè ãî îñòàâåòå äà ñå îõëàäè íàé-ìàëêî 2 ìèíóòè,
ï˜åäè äà ñâàëèòå êàïà…êàòà íà ˜åçå˜âîà˜à çà ãî˜èâî.
‚fiúëíåòå ˜åçå˜âîà˜à çà ãî˜èâî íà îòê˜èòî èëè â äîá˜å âåíòèëè˜àíî
ïîìåùåíèå.
‚íå ï˜åïúëâàéòå ˜åçå˜âîà˜à çà ãî˜èâî. Çà äà ïîçâîëèòå ˜àçè˜åíèå íà
áåíçèíà, íå ïúëíåòå íàä äîëíàòà îñíîâà íà ãú˜ëîâèíàòà çà íàëèâàíå íà
ãî˜èâî.
‚Ęú¥òå ãî˜èâîòî äàëå… îò èñê˜è, îòê˜èòè ïëàìúöè, ñèãíàëíè ëàìïè,
òîïëèíà è ä˜óãè çàïàëèòåëíè èçòî…íèöè.
‚fi˜îâå˜Éâàéòå …åñòî ãî˜èâîï˜îâîäèòå, ˜åçå˜âîà˜à, êàïà…êàòà è
ñúåäèíåíèÉòà çà ïóêíàòèíè èëè òå…îâå. Çàìåíåòå ãè, àêî å íåîáõîäèìî.
‚æêî ãî˜èâîòî ñå ˜àçëåå, èç…àêàéòå äîêàòî òî ñå èçïà˜è, ï˜åäè äà
ñòà˜òè˜àòå äâèãàòåëÉ.
1. fiî…èñòåòå ï˜îñò˜àíñòâîòî îêîëî êàïà…êàòà íà ˜åçå˜âîà˜à çà ãî˜èâî îò
ì˜úñîòèÉè íàñëîÉâàíèÉ. Ñâàëåòå êàïà…êàòà (A)(·èãó˜à3).
2. ‹àïúëíåòå ˜åçå˜âîà˜à çà ãî˜èâî (B) ñ ãî˜èâî. Çà äà ïîçâîëèòå ˜àçè˜åíèå íà
ãî˜èâîòî, íå ïúëíåòå íàä äîëíàòà îñíîâà íà ãú˜ëîâèíàòà çà íàëèâàíå íà
ãî˜èâî (C).
3. fiîñòàâåòå îá˜àòíî êàïà…êàòà.
Êàê ñå ñòàðòèðà äâèãàòåëÿ - Ôèãóðà 4
Áúðçîòî ïðèòåãëÿíå íà ïóñêîâîòî âúæå (îáðàòåí óäàð)
ïðèäúðïâà ðúêàòà êúì äâèãàòåëÿ ïî-áúðçî, îòêîëêîòî âèå
ìîæåòå äà ÿ îòäðúïíåòå.
Òîâà ìîæå äà ïðè÷èíè ñ÷óïåíè êîñòè, ôðàêòóðè, êîíòóçèè è
íàâÿõâàíèÿ.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
‚fi˜è ñòà˜òè˜àíå íà äâèãàòåëÉ, èçòåãëåòå âíèìàòåëíî âú¥åòî íà ˜ú…íèÉ
ñòà˜òå˜, äîêàòî óñåòèòå ñúï˜îòèâëåíèå, à ñëåä òîâà ä˜úïíåòå ˜Éçêî, çà
äà èçáåãíåòå îá˜àòíèÉóäà˜.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
Ãîðèâîòî è íåãîâèòå ïàðè ñà èçêëþ÷èòåëíî îãíåîïàñíè è
èçáóõëèâè.
Ïîæàð èëè âçðèâ ìîãàò äà ïðè÷èíÿò ñåðèîçíè îáãàðÿíèÿ èëè
ñìúðò.
Ïðè ñòàðòèðàíå íà äâèãàòåëÿ
‚‡âå˜åòå ñå, …å çàïàëèòåëíàòà ñâåù, óìîçàãëóèòåëÉ, êàïà…êàòà íà
˜åçå˜âîà˜à çà ãî˜èâî è âúçäóíèÉôèëòú˜ (àêî èìà òàêèâà) ñà íà
ìÉñòîòî ñè è ñà îáåçîïàñåíè.
‚‹å ˜àçâú˜òàéòå äâèãàòåëÉñ èçâàäåíà çàïàëèòåëíà ñâåù.
‚æêî äâèãàòåëÉò ñå çàäàâè, ïîñòàâåòå ñìóêà…à (àêî èìà òàêúâ) íà ïîçèöèÉ
OPEN/RUN, ï˜èäâè¥åòå ˜ú…íàòà ãàç (àêî èìà òàêàâà) íà ïîçèöèÉFAST è
˜àçâú˜òàéòå, äîêàòî äâèãàòåëÉò ñòà˜òè˜à.
14 BRIGGSandSTRATTON.COM
Äâèãàòåëèòå èçïóñêàò âúãëåðîäåí îêèñ, êîéòî å îòðîâåí ãàç, áåç
ìèðèñ è öâÿò.
Âäèøâàíåòî íà âúãëåðîäåí îêèñ ìîæå äà ïðè÷èíè ãàäåíå,
ïðèïàäúê èëè ñìúðò.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
‚Ñòà˜òè˜àéòå è ˜àáîòåòå ñ äâèãàòåëÉíàâúí.
‚‹å ñòà˜òè˜àéòå è íå ˜àáîòåòå ñ äâèãàòåëÉâ çàòâî˜åíî ïîìåùåíèå, äî˜è è
ï˜è îòâî˜åíè â˜àòè èëè ï˜îçî˜öè.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ: ‹àñòîÉùèÉò äâèãàòåë ñå äîñòàâÉîò Briggs & Stratton áåç
ìàñëî. fi˜åäè äà ñòà˜òè˜àòå äâèãàòåëÉñå óâå˜åòå, …å ñòå íàëåëè ìàñëî â íåãî
ñïî˜åä èíñò˜óêöèèòå â òîâà ˜úêîâîäñòâî. æêî ãî ñòà˜òè˜àòå áåç ìàñëî, òîé ùå ñå
ïîâ˜åäè, áåç äà áúäå âúçìî¥íî äà ñå ˜åìîíòè˜à è áåç ïîê˜èòèå îò ãà˜àíöèÉòà.
Çàáåëåæêà: Ñúî˜ú¥åíèåòî ìî¥å äà èìà óñò˜îéñòâà çà äèñòàíöèîííî óï˜àâëåíèå.
‹àï˜àâåòå ñï˜àâêà â ˆúêîâîäñòâîòî çà ˜àáîòà îòíîñíî ˜àçïîëî¥åíèåòî è
˜àáîòàòà ñ óñò˜îéñòâàòà çà äèñòàíöèîííî óï˜àâëåíèå.
1. fi˜îâå˜åòå íèâîòî íà ìàñëîòî. ‹àï˜àâåòå ñï˜àâêà â ˜àçäåëà Êàê ñå
ïðîâåðÿâà/íàëèâà ìàñëî.
2. ‡âå˜åòå ñå, …å çàäâè¥âàùèòå óï˜àâëåíèÉíà îáî˜óäâàíåòî, àêî èìà òàêèâà,
ñà èçêë˚…åíè.
3. fi˜åìåñòåòå ê˜àí…åòî çà èçêë˚…âàíå ïîäàâàíåòî íà ãî˜èâî (E) íà ïîçèöèÉon
(Öêë.).
4. fi˜åìåñòåòå ëîñòà íà ñìóêà…à (À) íà çàòâî˜åíà ïîçèöèÉ(·èãó˜à 4).
Çàáåëåæêà: ›áèêíîâåíî èçïîëçâàíåòî íà ñìóêà… íå å íåîáõîäèìî ï˜è
ïîâòî˜íî ñòà˜òè˜àíå íà òîïúë äâèãàòåë.
5. fi˜åìåñòåòå ëîñòà íà ˜ú…íàòà ãàç (B), àêî èìà òàêàâà, íà áú˜çè îáî˜îòè .
ˆàáîòåòå ñ äâèãàòåëÉï˜è ˜ú…íà ãàç íà áú˜çè îáî˜îòè.
6. fi˜è äâèãàòåëè, ñíàáäåíè ñúñ ñòîï êë˚…(C), ïîñòàâåòå êë˚…à íà ïîçèöèÉon
(âêë.).
7. Çä˜àâî ä˜ú¥òå ˜úêîõâàòêàòà íà âú¥åòî íà ñòà˜òå˜à (D). ¤çòåãëåòå áàâíî
˜úêîõâàòêàòà íà âú¥åòî íà ñòà˜òå˜à, äîêàòî ïî…óâñòâàòå ñúï˜îòèâëåíèå,
ñëåä êîåòî ãî ä˜úïíåòå ˜Éçêî.
Çàáåëåæêà: æêî äâèãàòåëÉò íå ñòà˜òè˜à ñëåä ïîâòà˜Éùè ñå îïèòè, èäåòå íà
èíòå˜íåò àä˜åñ BRIGGSandSTRATTON.COM èëè ñå îáàäåòå íà
1-800-233-3723 (â ÑæÂ).
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ: Ÿú˜çîòî îòòåãëÉíå íà âú¥åòî íà ñòà˜òå˜à
(îá˜àòåí óäà˜) ùå ï˜èòåãëè öÉëàòà âè ˜úêà êúì äâèãàòåëÉïî-áú˜çî,
îòêîëêîòî âèå ìî¥åòå äà Éîòòåãëèòå. ‚îâà áè ìîãëî äà äîâåäå äî ñ…óïåíè
êîñòè, ô˜àêòó˜è, íàâÉõâàíèÉè êîíòóçèè. fi˜è ñòà˜òè˜àíå íà äâèãàòåëÉ
èçòåãëåòå áàâíî âú¥åòî íà ñòà˜òå˜à, äîêàòî ïî…óâñòâàòå ñúï˜îòèâëåíèå,
ñëåä êîåòî ãî ä˜úïíåòå ˜Éçêî, çà äà èçáåãíåòå îá˜àòíèÉóäà˜.
8. Âîì äâèãàòåëÉò çàã˜åå, ïîñòàâåòå ëîñòà íà ñìóêà…à (A)íà
˜àáîòíà ïîçèöèÉ.
Êàê äà ñïðåòå äâèãàòåëÿ - Ôèãóðà 4
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
Ãîðèâîòî è íåãîâèòå ïàðè ñà èçêëþ÷èòåëíî îãíåîïàñíè è
èçáóõëèâè.
Ïîæàð èëè âçðèâ ìîãàò äà ïðè÷èíÿò ñåðèîçíè îáãàðÿíèÿ èëè
ñìúðò.
‚‹å çàïóâàéòå êàìå˜àòà íà êà˜áó˜àòî˜à, çà äà ñï˜åòå äâèãàòåëÉ.
1. fi˜åìåñòåòå ñòîï êë˚…à (C) äî ïîçèöèÉstop.
èëè
fi˜åìåñòåòå ëîñòà çà ˜ú…íàòà ãàç (B), àêî èìà òàêúâ, íà slow (áàâíè îáî˜îòè)
à ïîñëå íà stop ïîçèöèÉ.
2. fi˜åìåñòåòå ê˜àí…åòî çà èçêë˚…âàíå ïîäàâàíåòî íà ãî˜èâî (E) íà ïîçèöèÉoff
(¤çêë.).
Òåõíè÷åñêî îáñëóæâàíå
‹èå âè ï˜åïî˜ú…âàìå äà ïîñåòèòå ›òî˜èçè˜àí ñå˜âèçåí ï˜åäñòàâèòåë íà Briggs &
Stratton çà âñè…êè îïå˜àöèè ïî òåõíè…åñêîòî è ñå˜âèçíîòî îáñëó¥âàíå íà
äâèãàòåëÉè ˜åçå˜âíèòå …àñòè.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ: Öñè…êè êîìïîíåíòè, èçïîëçâàíè ï˜è ï˜îèçâîäñòâîòî íà
òîçè äâèãàòåë, ò˜Éáâà äà áúäàò íà ìÉñòîòî ñè çà ï˜àâèëíàòà ìó ˜àáîòà.
Êîíòðîë íà åìèñèèòå
Ïîääðúæêàòà, ñìÿíàòà èëè ðåìîíòúò íà óñòðîéñòâàòà çà êîíòðîë íà
âðåäíèòå åìèñèè ìîãàò äà áúäàò èçâúðøâàíè îò âñåêè ðåìîíòåí öåõ èëè
òåõíèê, ðåìîíòèðàùè äâèãàòåëè, êîèòî íå ñå èçïîëçâàò çà òðàíñïîðòíè öåëè.
Öñå ïàê, çà äà ïîëó…èòå ÄáåçïëàòíîÄîáñëó¥âàíå íà óñò˜îéñòâàòà çà êîíò˜îë íà
â˜åäíèòå åìèñèè, ˜àáîòàòà ò˜Éáâà äà áúäå èçâú˜åíà îò óïúëíîìîùåí çàâîäñêè
ï˜åäñòàâèòåë. ‹àï˜àâåòå ñï˜àâêà â øà˜àíöèÉòà îòíîñíî â˜åäíèòå åìèñèè.
Ñëó÷àéíî èñêðåíå ìîæå äà äîâåäå äî ïîæàð èëè ïîðàçÿâàíå îò
åëåêòðè÷åñêè òîê.
Íåâîëíî ñòàðòèðàíå ìîæå äà äîâåäå äî çàõâàùàíå, òðàâìàòè÷íà
àìïóòàöèÿ èëè äî ðàíÿâàíå.
Îïàñíîñò îò ïîæàð
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
Ïðåäè èçâúðøâàíå íà ðåãóëèðîâêè è ïîïðàâêè:
‚›òêà…åòå êàáåëà íà çàïàëèòåëíàòà ñâåù è ãî ä˜ú¥òå äàëå… îò íåÉ.
‚›òêà…åòå ìèíóñ-êëåìàòà íà àêóìóëàòî˜à (ñàìî ï˜è äâèãàòåëè ñ
åëåêò˜è…åñêè ñòà˜òå˜).
‚¤çïîëçâàéòå ñàìî ïîäõîäÉùè èíñò˜óìåíòè.
‚‹å çàñòîïî˜Éâàéòå ñ ˜åãóëè˜àùàòà ï˜ó¥èíà, ëîñòîâèòå ñèñòåìè èëè ñ
ä˜óãè…àñòè,çàäàïîâèèòå îáî˜îòèòå íà äâèãàòåëÉ.
‚ˆåçå˜âíèòå …àñòè ò˜Éáâà äà áúäàò ñúñ ñúùàòà êîíñò˜óêöèÉèäàñå
ìîíòè˜àò â ñúùîòî ïîëî¥åíèå, êàêòî î˜èãèíàëíèòå …àñòè. ˝àñòè îò ä˜óã
ï˜îèçâîäèòåë ìî¥å äà íå ˜àáîòÉò äîá˜å, ìî¥å äà ïîâ˜åäÉòàã˜åãàòàèëè
äà äîâåäàò äî íà˜àíÉâàíå.
‚‹å óä˜Ééòå ìàõîâèêà ñ …óê èëè òâú˜ä ï˜åäìåò, çàùîòî òîé ìî¥å äà ñå
ñò˜îè ïî â˜åìå íà ˜àáîòà.
Ïðè èçïðîáâàíå çà èñêðà:
‚¤çïîëçâàéòå îäîá˜åí òèï òåñòå˜ çà ñâåùè.
‚‹å ï˜àâåòå ï˜îâå˜êà çà èñê˜à ï˜è èçâàäåíà çàïàëèòåëíà ñâåù.
Ãðàôèê çà òåõíè÷åñêî îáñëóæâàíå
Ñëåä ïúðâèòå 5 ÷àñà
‚Äà ñå ñìåíÉìàñëîòî
Íà âñåêè 8 ÷àñà èëè åæåäíåâíî
‚Äà ñå ï˜îâå˜Éâà íèâîòî íà ìàñëîòî â äâèãàòåëÉ
‚Äà ñå ïî…èñòâàò ïîâú˜õíîñòèòå îêîëî óìîçàãëóèòåëÉè óï˜àâëåíèÉòà.
‚fiî…èñòåòå çàùèòíèÉêàïàê çà ï˜úñòèòå
Íà âñåêè 25 ÷àñà èëè åæåãîäíî
‚Äà ñå ïî…èñòâà âúçäóíèÉôèëòú˜ *
‚Äà ñå ïî…èñòâà ï˜åäôèëòú˜à *
Íà âñåêè 50 ÷àñà èëè åæåãîäíî
‚Äà ñå ñìåíÉìàñëîòî íà äâèãàòåëÉ
‚Äà ñå ï˜åãëå¥äàò óìîçàãëóèòåëÉè èñê˜îãàñèòåëÉ
Íà âñåêè 100 ÷àñà
‚Ñìåíåòå ìàñëîòî â çúáíèɘåäóêòî˜ (àêî èìà òàêúâ)
Åæåãîäíî
‚Äà ñå ñìåíÉâúçäóíèÉôèëòú˜.
‚Äà ñå ñìåíè ï˜åäôèëòú˜à
‚Äà ñå ñìåíÉçàïàëèòåëíàòà ñâåù
‚Äà ñå ïî…èñòè âúçäóíàòà îõëàäèòåëíà ñèñòåìà *
*fi˜è íàëè…èå íà çàï˜àåíîñò èëè íîñåùè ñå â îêîëíîòî ï˜îñò˜àíñòâî
îòëîìêè, äà ñå ïî…èñòâà ïî-…åñòî.
15
bg
Ðåãóëèðàíå íà êàðáóðàòîðà
‹èêîãà íå ï˜àâåòå íàñò˜îéêè íà êà˜áó˜àòî˜à. ÿà˜áó˜àòî˜úò å ˜åãóëè˜àí â
çàâîäà, çà äà ˜àáîòè åôåêòèâíî ï˜è ïîâå…åòî óñëîâèÉ.Öñå ïàê, àêî ñå íàëàãàò
íàñò˜îéêè, çà ñå˜âèçíî îáñëó¥âàíå ñå îáú˜íåòå êúì íÉêîé ‡ïúëíîìîùåí
ï˜åäñòàâèòåë íà Briggs & Stratton.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ: fi˜îèçâîäèòåëÉò íà îáî˜óäâàíåòî, íà êîåòî òîçè äâèãàòåë
ùå áúäå ìîíòè˜àí, îï˜åäåëÉìàêñèìàëíèòå îáî˜îòè, ï˜è êîèòî òîé ùå ˜àáîòè. Íå
íàäâèøàâàéòå òåçè îáî˜îòè.
Êàê ñå ñìåíÿ çàïàëèòåëíàòà ñâåù - Ôèãóðà 5
fi˜îâå˜Éâàéòå ìå¥äèíàòà (A, ·èãó˜à 5) ñ ïîìîùòà íà êàëèáú˜ çà òåë (B). æêî å
íåîáõîäèìî, ˜åãóëè˜àéòå ìå¥äèíàòà. flîíòè˜àéòå è çàòåãíåòå ñâåùòà ñ
ï˜åïî˜ú…âàíèÉâú˜òÉù ìîìåíò. Çà ˜åãóëè˜àíå íà ìå¥äèíàòà èëè îòíîñíî
âú˜òÉùèÉìîìåíò çà çàòÉãàíå, íàï˜àâåòå ñï˜àâêà â ˜àçäåë Òåõíè÷åñêè äàííè.
Çàáåëåæêà: ‹à íÉêîè ìåñòà, ìåñòíèÉò çàêîí èçèñêâà óïîò˜åáà íà ˜åçèñòî˜íà
ñâåù, çà äà ñå ïîäòèñíàò ˜àäèîñìóùåíèÉòà. æêî íàñòîÉùèÉò äâèãàòåë å
ôàá˜è…íî îáî˜óäâàí ñ ˜åçèñòî˜íà ñâåù, èçïîëçâàéòå ñúùèÉòèï ñâåù çà ñìÉíà.
Ïðîâåðÿâàéòå øóìîçàãëóøèòåëÿ è
èñêðîãàñèòåëÿ - Ôèãóðà 6
Ðàáîòåùèòå äâèãàòåëè îòäåëÿò òîïëèíà. ×àñòèòå íà äâèãàòåëèòå,
îñîáåíî øóìîçàãëóøèòåëÿ, ñòàâàò èçêëþ÷èòåëíî ãîðåùè.
Ïðè äîïèð ìîæå äà ïîëó÷èòå ñåðèîçíî èçãàðÿíå.
Ãîðèìèòå îòïàäúöè, êàòî ëèñòà, òðåâè, õðàñòàëàê è äðóãè, ìîãàò
äà ñå çàïàëÿò.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
‚›ñòàâåòå óìîçàãëóèòåëÉ, öèëèíäú˜à íà äâèãàòåëÉè ˜åá˜àòà äà ñå
îõëàäÉò, ï˜åäè äà ãè äîêîñâàòå.
‚›òñò˜àíåòå íàò˜óïàíèòå îòëîìêè îêîëî óìîçàãëóèòåëÉè öèëèíäú˜à.
‚¤çïîëçâàíåòî èëè ˜àáîòàòà ñ äâèãàòåëÉ, ïî çàëåñåíè ñ ãî˜è, õ˜àñòè èëè ñ
ò˜åâè ïëîùè, ñïî˜åä fi˜àâèëíèêà íà ÿàëèôî˜íèÉçà îáùåñòâåíèòå
˜åñó˜ñè, ˆàçäåë 4442, ï˜åäñòàâëÉâà íà˜óåíèå, îñâåí àêî äâèãàòåëÉò
íå å ñíàáäåí ñ èñê˜îãàñèòåë, ïîääú˜¥àí â åôèêàñíî ˜àáîòíî ñúñòîÉíèå,
êàêòî å îï˜åäåëåíî â ˆàçäåë 4442. Öä˜óãèòå ùàòè è ôåäå˜àëíè
˚˜èñäèêöèè ìî¥å äà èìà ïîäîáíè çàêîíè. Ñâú˜¥åòå ñå ñ ï˜îèçâîäèòåëÉ,
ï˜îäàâà…à íà ä˜åáíî èëè äèñò˜èáóòî˜à íà î˜èãèíàëíîòî ñúî˜ú¥åíèå, çà
äà ïîëó…èòå èñê˜îãàñèòåë, ï˜îåêòè˜àí çà ìîíòè˜àíàòà íà òîçè äâèãàòåë
èçïóñêàòåëíà ñèñòåìà.
›òñò˜àíåòå íàò˜óïàíèòå îòëîìêè îò ï˜îñò˜àíñòâàòà îêîëî óìîçàãëóèòåëÉè
öèëèíäú˜à. fi˜îâå˜åòå óìîçàãëóèòåëÉ(A, ·èãó˜à 6) çà ïóêíàòèíè, êî˜îçèÉèëè
ä˜óãà ïîâ˜åäà. Äåìîíòè˜àéòå èñê˜îãàñèòåëÉ(B), (àêî èìà òàêúâ) è ãî ï˜îâå˜åòå
çà ïîâ˜åäà èëè çàïóâàíå ñúñ ñà¥äè. æêî îòê˜èåòå ïîâ˜åäà, ìîíòè˜àéòå
˜åçå˜âíèòå …àñòè, ï˜åäè äà çàïî…íåòå ˜àáîòà.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ: ˆåçå˜âíèòå …àñòè ò˜Éáâà äà áúäàò ñúñ
ñúùàòà êîíñò˜óêöèÉè äà ñå ìîíòè˜àò â ñúùîòî ïîëî¥åíèå, êàêòî
î˜èãèíàëíèòå …àñòè. ˝àñòè îò ä˜óã ï˜îèçâîäèòåë ìî¥å äà íå ˜àáîòÉò äîá˜å,
ìî¥å äà ïîâ˜åäÉò àã˜åãàòà èëè äà äîâåäàò äî íà˜àíÉâàíå.
Êàê ñå ñìåíÿâà ìàñëîòî - Ôèãóðà 7 8
›ò˜àáîòèëîòî ìàñëî å îïàñåí îòïàäú…åí ï˜îäóêò è ò˜Éáâà äà ñå ñêëàäè˜à ïî
ïîäõîäÉù íà…èí. ‹å ãî èçõâú˜ëÉéòå ñ äîìàêèíñêèòå îòïàäúöè. fi˜îâå˜åòå
ñúâìåñòíî ñ îáùèíñêèòå âëàñòè, çà îáñëó¥âàù öåíòú˜ èëè çà ï˜åäñòàâèòåë íà
èíñòàëàöèè çà áåçîïàñíî äåïîíè˜àíå/˜åöèêëè˜àíå íà îò˜àáîòèëîòî ìàñëî.
Èçòî÷åòå îòðàáîòèëîòî ìàñëî
1. fi˜è èçêë˚…åí, íî âñå îùå òîïúë äâèãàòåë, îòêà…åòå êàáåëà íà çàïàëèòåëíàòà
ñâåù (A) è ãî ä˜ú¥òå íà ˜àçñòîÉíèå îò ñâåùòà (·èãó˜à 7).
2. Ñâàëåòå ï˜îáêàòà çà èçòî…âàíå íà ìàñëîòî (B, ·èãó˜à 8). ¤çòî…åòå ìàñëîòî â
ïîäõîäÉù çà öåëòà ñúä.
Çàáåëåæêà: ÖñÉêà îò ïîêàçàíèòå ï˜îáêè çà èçòî…âàíå íà ìàñëîòî (C)ìî¥åäà
áúäå ìîíòè˜àíà íà äâèãàòåëÉ.
3. Ñëåä êàòî ìàñëîòî å èçòî…åíî, ïîñòàâåòå è çàòåãíåòå ï˜îáêàòà.
Íàëèâàíå íà ìàñëî
‚ˆàçïîëî¥åòå õî˜èçîíòàëíî äâèãàòåëÉ.
‚fiî…èñòåòå ìÉñòîòî îêîëî îòâî˜à çà íàëèâàíå íà ìàñëî îò âñè…êè îòëîìêè.
‚‹àï˜àâåòå ñï˜àâêà â ˜àçäåë Òåõíè÷åñêè äàííè îòíîñíî âìåñòèìîñòòà çà
ìàñëîòî.
1. Ñâàëåòå íèâîïîêààçàòåëÉ(D) è ãî èçáú˜åòå ñ …èñò ïëàò.
2. ‹àëåéòå âíèìàòåëíî ìàñëî â äâèãàòåëÉï˜åç îòâî˜à çà íàëèâàíå (E).
‹àïúëíåòå äî òî…êàòà íà ï˜åëèâàíå.
3. fiîñòàâåòå íèâîïîêàçàòåëÉ,íîíå ãî çàòÉãàéòå. Ñâàëåòå ãî è ï˜îâå˜åòå
íèâîòî íà ìàñëîòî. ‚î ò˜Éáâà äà äîñòèãà äî ìà˜êè˜îâêàòà FULL (F)íà
íèâîïîêàçàòåëÉ.
4. flîíòè˜àéòå è çàòåãíåòå íèâîïîêàçàòåëÉ.
Êàê äà ñå îáñëóæâà âúçäóøíèÿ ôèëòúð - Ôèãóðà 9
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
Ãîðèâîòî è íåãîâèòå ïàðè ñà èçêëþ÷èòåëíî îãíåîïàñíè è
èçáóõëèâè.
Ïîæàð èëè âçðèâ ìîãàò äà ïðè÷èíÿò ñåðèîçíè îáãàðÿíèÿ èëè
ñìúðò.
‚‹èêîãà íå ñòà˜òè˜àéòå è íå ˜àáîòåòå ñ äâèãàòåëÉï˜è îòñò˜àíåí êîìïëåêò
íà âúçäóíèÉôèëòú˜ (àêî èìà òàêúâ) èëè ï˜è îòñò˜àíåí âúçäóåí
ôèëòú˜ (àêî èìà òàêúâ).
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ: ‹å èçïîëçâàéòå ñãúñòåí âúçäóõ èëè ˜àçòâî˜èòåëè, çà äà
ïî…èñòâàòå ôèëòú˜à. ÑãúñòåíèÉò âúçäóõ ìî¥å äà ïîâ˜åäè ôèëòú˜à, à
˜àçòâî˜èòåëèòå ãî ˜àçòâà˜Éò.
Ñèñòåìàòà íà âúçäóíèÉôèëòú˜ èçïîëçâà ôèëòú˜ îò íàãúíàò ôèëòú˜åí
ìàòå˜èàë ñ ï˜åäôèëòú˜ ïî îïöèÉ.fi˜åäôèëòú˜úò ìî¥å äà áúäå ï˜îìèâàí è
ïîëçâàí ïîâòî˜íî.
1. Ñâàëåòå ôèêñàòî˜à (A) è êàïàêà (B).
2. Äåìîíòè˜àéòå ôèêñàòî˜à (C)èôèëòú˜à(D).
3. Äåìîíòè˜àéòå ï˜åäôèëòú˜à (E),àêî èìà òàêúâ, îò ôèëòú˜à. Çà äà ïî…èñòèòå
íàñëîÉâàíèÉòà, ëåêî ïî…óêâàéòå ôèëòú˜à âú˜õó òâú˜äà ïîâú˜õíîñò. æêî
ôèëòú˜úò å ï˜åêîìå˜íî çàìú˜ñåí, çàìåíåòå ãî ñ íîâ.
4. fi˜îìèéòå ï˜åäôèëòú˜à âúâ âîäåí ˜àçòâî˜ íà ïî…èñòâàù ï˜åïà˜àò. ›ñòàâåòå
ãî äîá˜å äà ñå èçñóèíàâúçäóõ.Íå ñìàçâàéòå ï˜åäôèëòú˜à.
5. flîíòè˜àéòå ñóõèÉï˜åäôèëòú˜ êúì ôèëòú˜à.
6. flîíòè˜àéòå ôèëòú˜à è ï˜åäôèëòú˜à â îñíîâàòà (F)èâú˜õóïèëêàòà (G).
‡âå˜åòå ñå, …å ôèëòú˜à ïàñâà ïëúòíî â îñíîâàòà. Çàê˜åïåòå ôèëòú˜à ñúñ
ñêîáàòà (C).
7. fiîñòàâåòå êàïàêà íà âúçäóíèÉôèëòú˜ è ãî çàê˜åïåòå ñúñ ôèêñàòî˜à (A).
‡âå˜åòå ñå, …å ôèêñàòî˜úò å çàòåãíàò.
Êàê ñå ñìåíÿâà ìàñëîòî çà ïðåäàâêèòå - Ôèãóðà 10
æêî äâèãàòåëÉò âè å îáî˜óäâàí ñúñ çúáåí ˜åäóêòî˜, äà ñå îáñëó¥âà êàêòî
ñëåäâà.
1. Ñâàëåòå ï˜îáêàòà çà ïúëíåíå íà ìàñëî (B) è ï˜îáêàòà çà èçìå˜âàíå íà íèâîòî
ìó (C).
2. Ñâàëåòå ï˜îáêàòà (A, ·èãó˜à 10) îò îòâî˜à çà èçòî…âàíå íà ìàñëîòî è ãî
èçòî…åòå â ïîäõîäÉù êîíòåéíå˜.
3. fiîñòàâåòå è çàòåãíåòå ï˜îáêàòà çà ìàñëîòî.
4. Çà äà íàïúëíèòå îòíîâî ñ ìàñëî, âíèìàòåëíî íàëåéòå ìàñëîòî çà ï˜åäàâêè â
îòâî˜à çà íàëèâàíå (íàï˜àâåòå ñï˜àâêà â ˜àçäåë Òåõíè÷åñêè äàííè).
fi˜îäúë¥àâàéòå äà íàëèâàòå, äîêàòî ìàñëîòî ï˜îòå…å èçâúí îòâî˜à çà
ï˜îâå˜êà íà íèâîòî ìó.
5. fiîñòàâåòå è çàòåãíåòå ï˜îáêàòà íà îòâî˜à çà ìå˜åíå íà íèâîòî ìàñëîòî.
6. fiîñòàâåòå è çàòåãíåòå ï˜îáêàòà íà îòâî˜à çà ïúëíåíå ñ ìàñëî.
Âàæíî: fi˜îáêàòà íà îòâî˜à çà ïúëíåíå ñ ìàñëî èìà âåíòèëàöèîíåí îòâî˜ (D)
èò˜Éáâà äà áúäå ìîíòè˜àíà íà âú˜õà íà êàïàêà íà ï˜åäàâàòåëíàòà êóòèÉ,
êàêòî å ïîêàçàíî.
Êàê ñå ïî÷èñòâà âúçäóøíî-îõëàäèòåëíàòà
ñèñòåìà - Ôèãóðà 11
Ðàáîòåùèòå äâèãàòåëè îòäåëÿò òîïëèíà. ×àñòèòå íà äâèãàòåëèòå,
îñîáåíî øóìîçàãëóøèòåëÿ, ñòàâàò èçêëþ÷èòåëíî ãîðåùè.
Ïðè äîïèð ìîæå äà ïîëó÷èòå ñåðèîçíî èçãàðÿíå.
Ãîðèìèòå îòïàäúöè, êàòî ëèñòà, òðåâè, õðàñòàëàê è äðóãè, ìîãàò
äà ñå çàïàëÿò.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
‚›ñòàâåòå óìîçàãëóèòåëÉ,öèëèíäú˜àíàäâèãàòåëÉè ˜åá˜àòà äà ñå
îõëàäÉò, ï˜åäè äà ãè äîêîñâàòå.
‚›òñò˜àíåòå íàò˜óïàíèòå îòëîìêè îêîëî óìîçàãëóèòåëÉè öèëèíäú˜à.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ: ‹å èçïîëçâàéòå âîäà, çà äà ïî…èñòâàòå äâèãàòåëÉ.Öîäàòà
ìî¥å äà çàìú˜ñè ãî˜èâíàòà ñèñòåìà. ¤çïîëçâàéòå …åòêà èëè ñóõ ïëàò, çà äà ãî
ïî…èñòèòå.
‚îâà å äâèãàòåë ñ âúçäóíî îõëà¥äàíå. ‹å…èñòîòèèòå è íàñëîÉâàíèÉòà ìîãàò äà
îã˜àíè…àò âúçäóíèÉïîòîê è äà ï˜è…èíÉò ï˜åã˜Éâàíåòî ìó, êîåòî âîäè äî
íàìàëÉâàíå íà ïîêàçàòåëèòå è ï˜îäúë¥èòåëíîñòòà íà ¥èâîòà ìó.
¤çïîëçâàéòå …åòêà èëè ñóõ ïëàò, çà äà îòñò˜àíèòå íàñëîÉâàíèÉòà îò
ï˜åäïàçèòåëÉíà ï˜úñòèòå (A) (·èãó˜à 11). fiàçåòå …èñòè ëîñòîâàòà ñèñòåìà,
ï˜ó¥èíèòå è óï˜àâëåíèÉòà (B). fiàçåòå ï˜îñò˜àíñòâîòî îêîëî è çàä
óìîçàãëóèòåëÉ(C) ñâîáîäíî îò âñÉêàêâè çàïàëèìè íàñëîÉâàíèÉ.
16 BRIGGSandSTRATTON.COM
Ñêëàäèðàíå
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
Ãîðèâîòî è íåãîâèòå ïàðè ñà èçêëþ÷èòåëíî îãíåîïàñíè è
èçáóõëèâè.
Ïîæàð èëè âçðèâ ìîãàò äà ïðè÷èíÿò ñåðèîçíè îáãàðÿíèÿ èëè
ñìúðò.
Ïðè ñêëàäèðàíå íà ãîðèâî èëè íà ìàøèíà ñ ãîðèâî â ðåçåðâîàðà
‚Ñêëàäè˜àéòå äàëå… îò ïåùè, ïå…êè, âîäîíàã˜åâàòåëè èëè ä˜óãè
åëåêò˜è…åñêè ï˜èáî˜è, êîèòî èìàò ñèãíàëíè ëàìïè èëè ä˜óãè çàïàëèòåëíè
èçòî…íèöè, çàùîòî òå ìîãàò äà âúçïëàìåíÉò èçïà˜åíèÉòà îò ãî˜èâîòî.
Ãîðèâíà ñèñòåìà
øî˜èâîòî îñòà˜Éâà ñëåä ñêëàäè˜àíå çà ïîâå…å îò 30 äíè. ›ñòà˜Éëîòî ãî˜èâî âîäè
äî îá˜àçóâàíå íà êèñåëèííè è ñìîëåñòè îòëî¥åíèÉâ ãî˜èâíàòà ñèñòåìà èëè ïî
îñíîâíèòå …àñòè íà êà˜áó˜àòî˜à. Çà äà çàïàçèòå ãî˜èâîòî ñâå¥î, èçïîëçâàéòå
ñòàáèëèçàòî˜à çà ãî˜èâî FRESH START®íà Briggs & Stratton, êîéòî å äîñòúïåí
ïîä ôî˜ìàòà òå…íà äîáàâêà èëè ôëàêîí çà êàïêîâî ïîäàâàíå.
æêî ñå äîáàâÉñòàáèëèçàòî˜à çà ãî˜èâîòî ñúãëàñíî èíñò˜óêöèèòå, íÉìà íó¥äà
áåíçèíúò äà ñå èçòî…âà. ›ñòàâåòå äâèãàòåëÉò äà ˜àáîòè îêîëî 2 ìèíóòè, çà äà
öè˜êóëè˜à ñòàáèëèçàòî˜úò â ãî˜èâíàòà ñèñòåìà. ‚îãàâà äâèãàòåëÉò è ãî˜èâîòî
ìîãàòäàñåñúõ˜àíÉâàò äî 24 ìåñåöà.
æêî áåíçèíúò â äâèãàòåëÉíå å áèë îá˜àáîòâàí ñúñ ñòàáèëèçàòî˜, òîé ò˜Éáâà äà
áúäå èçòî…åí â ïîäõîäÉù çà öåëòà ñúä. ›ñòàâåòå äâèãàòåëÉò äà ˜àáîòè, äîêàòî
ñï˜å ïî˜àäè èç…å˜ïâàíå íà ãî˜èâîòî. Çà äà ïîääú˜¥àòå ñâå¥åñòòà íà ãî˜èâîòî
ï˜è ñêëàäè˜àíåòî ìó, ï˜åïî˜ú…âàìå èçïîëçâàíåòî íà ñòàáèëèçàòî˜.
Ìàñëîòî íà äâèãàòåëÿ
Äîêàòî äâèãàòåëÉò å âñå îùå òîïúë ñìåíåòå ìàñëîòî.
Îòêðèâàíå è îòñòðàíÿâàíå íà íåèçïðàâíîñòè
‹ó¥äàåòå ëè ñå îò ïîìîù? fiîñåòåòå BRIGGSandSTRATTON.COM èëè ñå îáàäåòå
íà 1-800-233-3723.
Òåõíè÷åñêè äàííè
Ñïåöèôèêàöèè çà äâèãàòåëÿ
flîäåë 83100
ˆàáîòåí îáåì 7,74 in3(127 cm3)
Öúò˜ååí äèàìåòú˜ íà öèëèíäú˜à 2,441 in (62 mm)
ˆàáîòåí õîä íà áóòàëîòî 1,654 in (42 mm)
Öìåñòèìîñò íà äâèãàòåëÉçà ìàñëî 18 -- 20 oz (0,54 -- 0,59 L)
Ñïåöèôèêàöèè íà çúáíèÿ ðåäóêòîð (àêî èìà òàêúâ)
Öèä ìàñëî êàòî çà çúáíèɘåäóêòî˜ 80W-90
Öìåñòèìîñò íà çúáíèɘåäóêòî˜ çà ìàñëî 4 oz (0,12 L)
Ðåãóëèðîâú÷íè äàííè *
flîäåë 83100
¤ñê˜îâà ìå¥äèíà íà çàïàëèòåëíàòà ñâåù 0,030 in (0,76 mm)
Öú˜òÉù ìîìåíò çà çàòÉãàíå íà çàïàëèòåëíàòà
ñâåù
180 lb-in (20 Nm)
Öúçäóíà ìå¥äèíà ìå¥äó ˜îòî˜à è ñòàòî˜à 0,006 - 0,010 in (0,15 - 0,25 mm)
flå¥äèíà íà ñìóêàòåëíèÉêëàïàí 0,005 - 0,007 in (0,13 - 0,18 mm)
flå¥äèíà íà èçïóñêàòåëíèÉêëàïàí 0,005 - 0,007 in (0,13 - 0,18 mm)
*flîùíîñòòà íà äâèãàòåëÉíàìàëÉâà ñ 3,5% íà âñåêè 1000 ôóòà (300 ìåò˜à) íàä
ìî˜ñêîòî íèâî è ñ 1% çà âñåêè 10flF(5,6flC) íàä 77flF(25flC). ÄâèãàòåëÉòùå
˜àáîòè çàäîâîëèòåëíî ï˜è íàêëîí äî 15fl. ‹àï˜àâåòå ñï˜àâêà â ˆúêîâîäñòâîòî çà
˜àáîòà ñ îáî˜óäâàíåòî çà áåçîïàñíèòå ã˜àíèöè çà ˜àáîòà íà íàêëîíè.
Îáèêíîâåíè ÷àñòè çà ïîääðúæêà
Ñåðâèçíà ÷àñò Íîìåð íà ÷àñòòà
›âàëåí âúçäóåí ôèëòú˜ 797258
øî˜èâíà äîáàâêà 5041, 5058
Çàïàëèòåëíà ñâåù 797235
ÿë˚… çà ñâåù 89838, 5023
¤ñê˜îâ òåñòå˜ 19368
n‹èå âè ï˜åïî˜ú…âàìå äà ïîñåòèòå íÉêîé îò ‡ïúëíîìîùåíèòå ï˜åäñòàâèòåëè
íà Briggs & Stratton çà âñè…êè îïå˜àöèè ïî òåõíè…åñêîòî è ñå˜âèçíîòî îáñëó¥âàíå
íà äâèãàòåëÉè ˜åçå˜âíèòå …àñòè.
17
bg
ÃÀÐÀÍÖÈÎÍÍÀ ÏÎËÈÖÀ ÍÀ ÑÎÁÑÒÂÅÍÈÊÀ ÍÀ ÄÂÈÃÀÒÅË BRIGGS & STRATTON Ñåïòåìâðè 2009 ã.
ÿî˜ïî˜àöèÉBriggs & Stratton ùå ˜åìîíòè˜à èëè çàìåíè áåçïëàòíî âñÉêà …àñò (âñè…êè …àñòè) íà äâèãàòåë, êîèòî ñà ïîâ˜åäåíè, ïî˜àäè äåôåêòåí ìàòå˜èàë èëè
ï˜îèçâîäñòâî, èëè ïî˜àäè äâåòå. ‚˜àíñïî˜òíèòå ˜àçõîäè íà èçï˜àòåíèòå çà ˜åìîíò èëè ñìÉíà …àñòè ïî òàçè ãà˜àíöèÉñå ïîåìàò îò êóïóâà…à. ‚àçè ãà˜àíöèÉå
âàëèäíà çà îï˜åäåëåíèÉñ˜îê è å ï˜åäìåò íà óñëîâèÉòà, ôèêñè˜àíè ïî-äîëó. Çà îáñëó¥âàíå ïî ãà˜àíöèÉòà ñå îáú˜íåòå êúì íàé-áëèçêèɇïúëíîìîùåí
ñå˜âèçåí ï˜åäñòàâèòåë, êîéòî ìî¥å äà îòê˜èåòå â íàèÉóêàçàòåë íà àä˜åñ BRIGGSandSTRATTON.com, èëè êàòî ñå îáàäèòå íà òåëåôîí
1-800-233-3723, èëè êàòî å ïîñî…åíî â «Œúëòèòå ñò˜àíèöè».
Íÿìà äðóãà ñïåöèàëíà ãàðàíöèÿ. Ïîäðàçáèðàùèòå ñå ãàðàíöèè, âêëþ÷èòåëíî òåçè çà ãîäíîñòòà çà ïðîäàæáà èëè çà íÿêàêâà ñïåöèàëíà öåë, ñà
îãðàíè÷åíè äî åäíà ãîäèíà îò äàòàòà íà êóïóâàíå èëè äî ñðîêà, ðàçðåøåí ïî çàêîí. Âñè÷êè äðóãè ñâúðçàíè (ïî ïîäðàçáèðàíå) ãàðàíöèè ñå
èçêëþ÷âàò. Îòãîâîðíîñò çà ñëó÷àéíè èëè ïîñëåäâàùè ùåòè ñå èçêëþ÷âà â ñòåïåí, ðàçðåøåíà ïî çàêîí. ‹Éêîè ùàòè èëè ñò˜àíè íå ïîçâîëÉâàò
îã˜àíè…åíèÉçà â˜åìåò˜àåíåòî íà ïîä˜àçáè˜àùàòà ñå ãà˜àíöèÉ,àíÉêîè ùàòè èëè ñò˜àíè íå ïîçâîëÉâàò èçêë˚…âàíåòî èëè îã˜àíè…àâàíåòî íà ñëó…àéíè èëè
ïîñëåäâàùè ùåòè, òàêà …å å âúçìî¥íî ãî˜íîòî îã˜àíè…åíèå è èçêë˚…åíèå äà íå âà¥è çà âàñ. ‚àçè ãà˜àíöèÉâè äàâà ñïåöèôè…íè çàêîíîâè ï˜àâà, à âèå
ìî¥åòå äà èìàòå è ä˜óãè òàêèâà, êîèòî ñå èçìåíÉò â åäèí èëè ä˜óã ùàò, èëè â åäíà èëè ä˜óãà ñò˜àíà.
ÎÃÐÀÍÈ×ÅÍÀ ÃÀÐÀÍÖÈß
ÑÒÀÍÄÀÐÒÍÈ ÃÀÐÀÍÖÈÎÍÍÈ ÓÑËÎÂÈß *
Ìàðêà/Âèä ïðîäóêò Çà ïîëçâàíå çà ñîáñòâåíè íóæäè Çà ïîëçâàíå çà ïðîìèøëåíè íóæäè
Vanguardt2 ãîäèíè 2 ãîäèíè
Extended Life Seriest, I/C®, IntektI/C®,IntektPro;
Professional Series ñ …óãóíåíà ˜èçà Dura-Boret;
850 Series ñ …óãóíåíà ˜èçà Dura-Boret;
Snow Series MAXtñ …óãóíåíà ˜èçà Dura-Boret
Öñè…êè ä˜óãè äâèãàòåëè íà Briggs & Stratton èìàò …óãóíåíà ˜èçà Dura-Boret
2 ãîäèíè 1 ãîäèíà
Öñè…êè ä˜óãè äâèãàòåëè íà Briggs & Stratton 2 ãîäèíè 90 äíè
*‚åçè ñà íàèòå ñòàíäà˜òíè ãà˜àíöèîííè óñëîâèÉ, íî å âúçìî¥íî ñëó…àéíî äà èìà äîïúëíèòåëíî ãà˜àíöèîííî ïîê˜èòèå, êîåòî íå å áèëî îï˜åäåëåíî êúì
ìîìåíòà íà ïóáëèêóâàíåòî. Çà ñïèñúêà ñ òåêóùèòå ãà˜àíöèîííè óñëîâèÉçà âàèÉäâèãàòåë ïîñåòåòå àä˜åñà íè â ¤íòå˜íåò BRIGGSandSTRATTON.COM
èëè ñå îáú˜íåòå êúì ‡ïúëíîìîùåí ñå˜âèçåí ï˜åäñòàâèòåë íà Briggs & Stratton.
Äâèãàòåëè, ìîíòè˜àíè íà äîìàåí ãåíå˜àòî˜ çà åëåêò˜îåíå˜ãèÉñà ãà˜àíòè˜àíè ñàìî ïî êëàóçàòà ÄÇà ïîò˜åáèòåëñêî ïîëçâàíåÄ. ‹àñòîÉùàòà ãà˜àíöèÉíå
å âàëèäíà çà äâèãàòåëè, ìîíòè˜àíè íà îáî˜óäâàíå, ïîëçâàíî êàòî ïú˜âè…íà ìîùíîñò, âìåñòî öåíò˜àëíîòî çàõ˜àíâàíå. Äâèãàòåëè, èçïîëçâàíè çà
ñúñòåçàíèÿ, çà òúðãîâñêè öåëè èëè çà îòäàâàíå ïîä íàåì, íå ñà ïîêðèòè îò ãàðàíöèÿòà.
øà˜àíöèîííèÉò ïå˜èîä çàïî…âà îò äàòàòà íà êóïóâàíå îò ïú˜âèÉïîò˜åáèòåë íà ä˜åáíî èëè îò ê˜àéíèÉïîò˜åáèòåë çà ï˜îìèëåíè íó¥äè è ï˜îäúë¥àâà çà ïå˜èîäà,
ïîñî…åí â òàáëèöàòà ãî˜å. ÄÇà ïîëçâàíå çà ñîáñòâåíè íó¥äèÄîçíà…àâà ëè…íî èçïîëçâàíå â äîìàêèíñòâî îò ïîò˜åáèòåë íà ä˜åáíî. ÄÇà ïîëçâàíå çà ï˜îìèëåíè íó¥äèÄ
îçíà…àâà âñè…êè ä˜óãè óïîò˜åáè, âêë˚…èòåëíî òú˜ãîâñêà óïîò˜åáà, êàêòî è òàêàâà, ôî˜ìè˜àùà äîõîä èëè îòäàâàíå ïîä íàåì. Ñëåä êàòî âåäíú¥ äâèãàòåëÉò å áèë
ïîëçâàí çà ï˜îìèëåíè íó¥äè, ïî-íàòàòúê òîé ùå áúäå ñ…èòàí êàòî äâèãàòåë çà ï˜îìèëåíè íó¥äè çà öåëèòå íà òàçè ãà˜àíöèÉ.
Íå å íåîáõîäèìà ðåãèñòðàöèÿ íà ãàðàíöèÿòà, çà äà ñå ïîëó÷è ãàðàíöèîííî îáñëóæâàíå çà ïðîäóêòèòå Briggs & Strstton. Ïàçåòå çà äîêàçàòåëñòâî êâèòàíöèÿòà
îò ïîêóïêàòà. Àêî íå îñèãóðèòå äîêàçàòåëñòâî çà íà÷àëíàòà äàòà íà êóïóâàíå, ïðè ïîèñêâàíå íà ãàðàíöèîííî îáñëóæâàíå, äàòàòà íà ïðîèçâîäñòâî íî
ïðîäóêòà ùå áúäå èçïîëçâàíà çà îïðåäåëÿíå íà ãàðàíöèîííèÿ ïåðèîä.
Îòíîñíî âàøàòà ãàðàíöèÿ
Briggs & Stratton ï˜èåìàò ñ ãîòîâíîñò ãà˜àíöèîííèɘåìîíò è ñå èçâèíÉâàò çà
ï˜è…èíåíîòî âè íåóäîáñòâî. Öñåêè ‡ïúëíîìîùåí ñå˜âèçåí ï˜åäñòàâèòåë ìî¥å äà
èçâú˜âà ãà˜àíöèîííè ˜åìîíòè. fiîâå…åòî ãà˜àíöèîííè ˜åìîíòè ñå ï˜îâå¥äàò
˜óòèííî, íî ïîíÉêîãà å âúçìî¥íî èñêàíèÉòà çà ãà˜àíöèîííî îáñëó¥âàíå äà íå
áúäàò ñúîòâåòñòâàùè.
æêîêóïóâà…úòíååñúãëàñåíñ˜ååíèåòî íà Ñå˜âèçíèÉï˜åäñòàâèòåë, ùå ñå
íàï˜àâè ï˜îó…âàíå, çà äà ñå óñòàíîâè äàëè ãà˜àíöèÉòà ñå ï˜èçíàâà. ¤çèñêâàéòå
îò Ñå˜âèçíèÉï˜åäñòàâèòåë äà ï˜åäîñòàâè çà ï˜åãëåä âñè…êè äîïúëíèòåëíè
ôàêòè íà ñâîÉäèñò˜èáóòî˜ èëè íà çàâîäà. æêî äèñò˜èáóòî˜úò èëè çàâîäúò ˜åè,
…å òîâà èñêàíå å îï˜àâäàíî, êóïóâà…úò ùå áúäå íàïúëíî îáåçùåòåí çà
äåôåêòíèòå …àñòè. Çà äà ñå èçáåãíå íåäî˜àçóìåíèåòî, êîåòî ìî¥å äà âúçíèêíå
ìå¥äó êóïóâà…à è ï˜åäñòàâèòåëÉ, ïî-äîëó ñà èçá˜îåíè íÉêîè îò ï˜è…èíèòå çà
ïîâ˜åäà â äâèãàòåëÉ, êîèòî ãà˜àíöèÉòà íå ïîê˜èâà.
Íîðìàëíî èçíîñâàíå: Äâèãàòåëèòå, êàêòî âñè…êè ìåõàíè…íè óñò˜îéñòâà, ñå
íó¥äàÉò îò ïå˜èîäè…íà çàìÉíà íà …àñòè è îáñëó¥âàíå, çà äà ˜àáîòÉò äîá˜å.
øà˜àíöèÉòà íå ïîê˜èâà ˜åìîíòà, êîãàòî ï˜è íî˜ìàëíî èçíîñâàíå äàäåíà …àñò èëè
äâèãàòåëÉò ñà èç…å˜ïàëè ¥èâîòà ñè. øà˜àíöèÉòà íå ñå ï˜èëàãà, àêî â äâèãàòåëÉñå
ñëó…è ïîâ˜åäà, ïî˜àäè íåï˜àâèëíî ïîëçâàíå èëè îòñúñòâèå íà ˜óòèííà
ïîää˜ú¥êà, ò˜àíñïî˜òè˜àíå, ìàíèïóëè˜àíå, ñúõ˜àíÉâàíå èëè íåï˜àâèëåí
ìîíòà¥. Ñúùî òàêà, ãà˜àíöèÉòà ñå ãóáè, àêî ñå˜èéíèÉò íîìå˜ íà äâèãàòåëÉå
îòñò˜àíåí èëè ïî íåãî ñà ï˜àâåíè ï˜îìåíè.
Íåïðàâèëíî ïîääúðæàíå: Œèâîòúò íà äàäåí äâèãàòåë çàâèñè îò óñëîâèÉòà, ï˜è
êîèòî ˜àáîòè è îò ã˜è¥èòå, êîèòî ïîëó…àâà. ‹Éêîè ï˜èëî¥åíèÉ, êàòî
êóëòèâàòî˜è, ïîìïè, è ˜îòàöèîííè êîñà…êè, ìíîãî …åñòî ñå èçïîëçâàò â ï˜àíà è
çàìú˜ñåíà ñ˜åäà, êîåòî ìî¥å äà äîâåäå äî ï˜åäâà˜èòåëíîòî èì èçíîñâàíå.
‚àêîâà èçíîñâàíå íå ñå ïîê˜èâà îò ãà˜àíöèÉòà, êîãàòî ñå äúë¥è íà ì˜úñîòèÉ,
ï˜àõ, àá˜àçèâ çà ïî…èñòâàíå íà ñâåùòà èëè ä˜óãè àá˜àçèâíè ìàòå˜èàëè,
ïîïàäíàëè â äâèãàòåëÉïî˜àäè íåêà…åñòâåíî ïîääú˜¥àíå.
Òàçè ãàðàíöèÿ ïîêðèâà ñàìî óïîòðåáåí â äâèãàòåëÿ äåôåêòåí ìàòåðèàë
è/èëè èçðàáîòêà, à íå çàìÿíàòà èëè âúçñòàíîâÿâàíåòî íà ìàøèíàòà, êúì
êîÿòî äâèãàòåëÿò ìîæå äà áúäå ìîíòèðàí. Ãàðàíöèÿòà íå ïîêðèâà è
ïîèñêàíè ðåìîíòè ïîðàäè:
1Ïðîáëåìè, ïðè÷èíåíè îò ÷àñòè, êîèòî íå ñà îðèãèíàëíè ÷àñòè íà Briggs &
Stratton.
2 ‡ñò˜îéñòâà çà óï˜àâëåíèå íà ìàèíàòà èëè ñúî˜ú¥åíèÉ, êîèòî ï˜å…àò íà
ñòà˜òè˜àíåòî íà äâèãàòåëÉ, âîäÉò äî íåçàäîâîëèòåëíàòà ìó ˜àáîòà èëè
ñêúñÉâàò ¥èâîòà ìó. (ÿîíñóëòè˜àéòå ñå ñ ï˜îèçâîäèòåëÉíà óñò˜îéñòâàòà.)
3 ‚å…àùè êà˜áó˜àòî˜è, çàä˜úñòåíè ãî˜èâíè ò˜úáè, áëîêè˜àíè êëàïàíè èëè
ä˜óãè ïîâ˜åäè, ï˜è…èíåíè îò óïîò˜åáàòà íà çàìú˜ñåíî èëè îñòà˜Éëî ãî˜èâî.
4˝àñòè, êîèòî ñà íàä˜àíè èëè ñ…óïåíè, çàùîòî äâèãàòåëÉò å ˜àáîòèë ñ
íåäîñòàòú…íî èëè çàìú˜ñåíî ìàñëî, èëè ñ ìàñëî ñ íåïîäõîäÉùî êà…åñòâî
(ï˜îâå˜Éâàéòå è äîëèâàéòå, êîãàòî å íåîáõîäèìî è ãî ñìåíÉâàéòå íà
ï˜åïî˜ú…âàíèòå èíòå˜âàëè îò â˜åìå.) æâà˜èéíîòî óñò˜îéñòâî OIL GARD
ìî¥å äà íå ñï˜å ˜àáîòåùèÉäâèãàòåë. æêî íèâîòî íà ìàñëîòî íå ñå ïîääú˜¥à
òî…íî, äâèãàòåëÉò ìî¥å äà ñå ïîâ˜åäè.
5 ˆåìîíò èëè ˜åãóëè˜àíå íà ìîíòè˜àíè …àñòè èëè àã˜åãàòè êàòî ñúåäèíèòåëè,
ï˜åäàâàòåëíè ìåõàíèçìè, äèñòàíöèîííè óï˜àâëåíèÉèä˜.,êîèòîíåñà
ï˜îèçâåäåíè îò Briggs & Stratton.
6fiîâ˜åäà èëè èçíîñâàíå íà …àñòè, ï˜è…èíåíè îò íå…èñòîòèÉ, ïîïàäíàëà â
äâèãàòåëÉ, ïî˜àäè íåêà…åñòâåíî ïîääú˜¥àíå íà âúçäóíèÉôèëòú˜,
íåêà…åñòâåí ïîâòî˜åí ìîíòॠèëè îò èçïîëçâàíå íà íåî˜èãèíàëíè åëåìåíòè
çà ôèëòú˜à. ‹à ï˜åïî˜ú…âàíèòå èíòå˜âàëè îò â˜åìå ïî…èñòâàéòå è/èëè
ñìåíÉâàéòå ôèëòú˜à, êàêòî å ïîñî…åíî â ˆúêîâîäñòâîòî çà ˜àáîòà.
7˝àñòè, ïîâ˜åäåíè îò ï˜åâèåíà ñêî˜îñò èëè ï˜åã˜Éâàíå, ï˜è…èíåíè îò ò˜åâè,
ïà˜…åòà èëè ì˜úñîòèÉ,êîÉòî çàïóâà èëè çàä˜úñòâà îõëàäèòåëíèòå ˜åá˜à è
êàìå˜àòà íà ìàõîâèêà, èëè ïîâ˜åäà ïî˜àäè ˜àáîòà íà äâèãàòåëÉâ çàòâî˜åíî
ï˜îñò˜àíñòâî áåç äîñòàòú…íî ï˜îâåò˜Éâàíå. fiî…èñòâàéòå äâèãàòåëÉîò
ïîïàäíàëè ïà˜…åòà íà ï˜åïî˜ú…âàíèòå èíòå˜âàëè îò â˜åìå, êàêòî å ïîñî…åíî
â ˆúêîâîäñòâîòî çà ˜àáîòà.
8˝àñòè íà äâèãàòåëÉèëè ìàèíàòà, ñ…óïåíè îò ï˜åêîìå˜íà âèá˜àöèÉ,
äúë¥àùà ñå íà õëàáàâ ìîíòॠíà äâèãàòåëÉ, õëàáàâè ˜å¥åùè íî¥îâå,
õëàáàâè ïëàñòèíè è õëàáàâè èëè çëå áàëàíñè˜àíè ˜àáîòíè êîëåëà, íà
íåäîá˜î êóïëè˜àíå íà ìàèíàòà êúì êîëåí…àòèÉâàë íà äâèãàòåëÉ,íà
ñâ˜úõâèñîêè îáî˜îòè èëè ä˜óãà çëîóïîò˜åáà ï˜è ˜àáîòà.
9 ›ãúíàò èëè ñ…óïåí êîëåí…àò âàë âñëåäñòâèå íà óäà˜ â òâú˜ä ï˜åäìåò íà
˜å¥åùèÉíî¥ íà ˜îòàöèîííàòà ïîëåâà êîñà…êà èëè îò ï˜åêîìå˜íî íàòÉãàíå
íà ò˜àïåöîâèäíèɘåìúê.
10 ˆóòèííà íàñò˜îéêà è ˜åãóëè˜îâêà íà äâèãàòåëÉ.
11 fiîâ˜åäà íà äâèãàòåëÉèëè íà íåãîâ åëåìåíò, ò.å. ãî˜èâíà êàìå˜à, êëàïàíè,
êëàïàííè ëåãëà, êëàïàííè âîäà…è, èëè èçãî˜åëè íàìîòêè íà ñòà˜òå˜à ïî˜àäè
èçïîëçâàíåòî íà àëòå˜íàòèâíè ãî˜èâà êàòî íàôòà, ï˜è˜îäåí ãàç, áåíçèíè ñ
ï˜îìåíåíè êà…åñòâà è ò.í.
Ãàðàíöèîííîòî îáñëóæâàíå å äîñòúïíî åäèíñòâåíî ÷ðåç Óïúëíîìîùåíèòå
ñåðâèçíè ïðåäñòàâèòåëè íà Êîðïîðàöèÿ Briggs & Stratton. Íàìåðåòå
íàé-áëèçêèÿ Óïúëíîìîùåí ñåðâèçåí ïðåäñòàâèòåë â íàøàòà óêàçàòåëíà êàðòà
çà ïðåäñòàâèòåëèòå íà àäðåñ BRIGGSandSTRATTON.com, èëè êàòî ñå îáàäèòå
íà òåë. 1-800-233-3723, èëè êàêòî å ïîñî÷åíî â ‘Æúëòèòå ñòðàíèöè’.
18 BRIGGSandSTRATTON.COM
Všeobecné informace
Tato pøíruèka obsahuje bezpeènostní informace nezbytné pro to, abyste vìdìli, jaká
nebezpeèí a rizika souvisí s motory a jak se jim vyhnout. Obsahuje i pokyny, jak øádnì
motor používat a jak se nìj starat. Vzhledem k tomu, že korporace Briggs & Stratton
nemusí nutnì vìdìt, jaké zaøízení bude tento motor pohánìt, je dùležité, abyste si
pøeèetli a pochopili tyto pokyny a pokyny pro zaøízení, které tento motor pohání.
Uschovejte tyto pokyny pro budoucí použití.
Potøebujete-li náhradní díly nebo technickou pomoc, zapište dolù model motoru, typové a
kódové èíslo a datum nákupu. Tato naleznete na svém motoru (viz kapitola Funkce a
ovládací prvky).
Datum nákupu:
Model motoru:
DD/MM/RRRR
Model: Kód:Typ:
Informace o jmenovitém výkonu motoru
Hrubý výkon jednotlivých modelù benzínových motorù je uvádìn v souladu s normou
J1940 pro postup pøi stanovování výkonu a krouticího momentu u malých motorù (Small
Engine Power & Torque Rating Procedure) vydané asociací SAE (Society of Automotive
Engineers) a výkon byl získán a pøepoèten v souladu s normou SAE J1995 (revize
2002-05). Hodnoty krouticího momentu byly získány pøi 3060 RPM (ot./min.) a hodnoty
výkonu v koních byly získány pøi 3600 RPM (ot./min.) Skuteèný hrubý výkon motoru
bude nižší, což je ovlivnìno mimo jiné provozními podmínkami prostøedí a rozdíly mezi
jednotlivými vyrobenými kusy motorù. Z dùvodu široké škály produktù, do nichž se naše
motory umísGují a rùzných vnìjších faktorù vztahujících se k provozu zaøízení, nemusí
benzínový motor pøi použití v konkrétním druhu zaøízení dosahovat hrubého výkonu
(skuteèného výkonu „na místì instalace” nebo èistého výkonu). Tento rozdíl je zpùsoben
mnoha faktory, mezi nìž patøí použité pøíslušenství (jako je napøíklad vzduchový filtr,
výfuk, plnìní, chlazení, karburátor, palivové èerpadlo atd.), omezení využití, provozní
podmínky prostøedí (teplota, vlhkost, nadmoøská výška) a rozdíly mezi jednotlivými
vyrobenými kusy motoru V dùsledku výrobních a kapacitních omezení mùže spoleènost
Briggs & Stratton nahradit motor této série motorem o vyšším výkonu.
Bezpeènost obsluhy
Výbuch
Toxické výparyPohyblivé èásti
Úraz elektrickým
proudem
Horký povrch
Zpìtný ráz
Požár
Uzávìr paliva
Ètìte návod
Sytiè
Olej
Palivo
Zapnuto/Vypnuto
Stop
Používejte
ochranu zraku
Pomalu
Rychle
BEZPEÈNOSTNÍ A KONTROLNÍ SYMBOLY
Nebezpeèná chemikálie Omrzliny
Symbol bezpeènostního upozornìní oznaèuje bezpeènostní informace týkající se
rizik, která mohou zpùsobit úraz. Signální slovo (NEBEZPEÈÍ, UPOZORNÌNÍ nebo
VÝSTRAHA) se používá spolu s varovným symbolem pro vyznaèení pravdìpodobnosti a
potenciální vážnosti úrazu. Mimo to mùže být pro oznaèení druhu nebezpeèí použit symbol
nebezpeèí.
NEBEZPEÈÍ oznaèuje ohrožení, které, není-li eliminováno, zpùsobí smrt
nebo vážný úraz.
VAROVÁNÍ oznaèuje ohrožení, které, není-li eliminováno, mùže zpùsobit
smrt nebo vážný úraz.
POZOR oznaèuje ohrožení, které, není-li eliminováno, mùže zpùsobit lehký,
nebo støednì tìžký úraz.
POZNÁMKA oznaèuje situaci, v níž by mohlo dojít k poškození produktu.
VAROVÁNÍ
Nìkteré souèásti tohoto produktu a související pøíslušenství obsahují chemické
látky, o nichž je ve státì Kalifornie známo, že zpùsobují rakovinu, poškození plodu
èi jiné poruchy reprodukce. Po manipulaci si umyjte ruce.
VAROVÁNÍ
Výfukové plyny tohoto výrobku obsahují chemikálie, o nichž je ve státì Kalifornie
známo, že zpùsobují rakovinu, poškození plodu èi jiné poruchy reprodukce.
VAROVÁNÍ
Briggs & Stratton neschvaluje ani nepovoluje použití tìchto motorù na tøíkolových
terénních vozidlech (ATV), motocyklech, zábavních/rekreaèních motokárách,
letadlech nebo vozidlech urèených pro sportovní soutìže. Takové použití tìchto
motorù by mohlo vést ke škodám na majetku, vážnému zranìní (vèetnì ochrnutí)
nebo i ke smrtelnému úrazu.
POZNÁMKA: Tento motor je dodáván firmou Briggs & Stratton bez oleje. Pøed
spuštìním motoru zkontrolujte hladinu oleje. Pokud spustíte motor bez oleje, mùže dojít
k jeho neopravitelnému poškození, na které se nebude vztahovat záruka.
VAROVÁNÍ
Palivo a jeho páry jsou vysoce hoølavé a výbušné.
Požár nebo výbuch mùže zpùsobit vážné popáleniny nebo i smrt
Když doplòujete palivo
‚Vypnìte motor a pøed sejmutím uzávìru palivové nádrže jej nechte nejménì 2
minuty chladnout.
‚Nádrž plòte venku nebo v dobøe vìtraném prostoru.
‚Palivovou nádrž nepøeplòujte. Kvùli tepelné roztažnosti paliva naplòte nádrž
jen po spodní okraj hrdla.
‚Chraòte palivo pøed jiskrami, otevøeným ohnìm, vìèným plamínkem, teplem
a jinými zdroji zapálení.
‚Kontrolujte palivové potrubí, nádrž a uzávìr a všechny spoje na tìsnost a
praskliny. V pøípadì potøeby proveïte výmìnu.
‚Jestliže rozlijete palivo, poèkejte, až se odpaøí a teprve potom spusGte motor.
Pøi spouštìní motoru
‚Zkontrolujte, zda jsou na svém místì svíèky, tlumiè výfuku, víèko palivové
nádrže a vzduchový filtr (je-li jím motor vybaven), a zda jsou dobøe zajištìny.
‚Neotáèejte motorem pøi odstranìné svíèce.
‚Pøi pøeplavení motoru nastavte sytiè (je-li k dispozici) do polohy OPEN/RUN
(chod) a škrtící klapku do polohy FAST (rychle) a protáèejte motor, dokud
nenaskoèí.
Pøi obsluze zaøízení
‚Nenaklánìjte motor ani zaøízení do polohy, která by zpùsobila únik paliva.
‚Motor se nesmí zastavovat zahlcením karburátoru.
‚Nespouštìjte ani neprovozujte motor s odmontovanou sestavou vzduchového
filtru (je-li jím motor vybaven) nebo s vyjmutým vzduchovým filtrem (je-li jím
motor vybaven).
Pøi výmìnì oleje
‚když vypouštíte olej z horní plnící olejové trubky, musí být palivová nádrž
prázdná, protože jinak mùže palivo unikat z nádrže a zpùsobit požár nebo
explozi.
Pøi pøepravì zaøízení
‚Zaøízení pøepravujte s PRÁZDNOU palivovou nádrží nebo zavøeným palivovým
kohoutem.
Pøi skladování paliva nebo zaøízení s palivem v nádrži
‚Uložte oddìlenì od pecí, kamen, ohøívaèù vody èi jiných zaøízení, která mají
vìèný plamínek nebo od jiných zdrojù zapálení. Mohou zažehnout výpary z
paliva.
19
cs
Spouštìní motoru je doprovázené jiskøením.
Jiskøení mùže zažehnout pøítomné hoølavé plyny.
Výsledkem mùže být požár nebo výbuch.
VAROVÁNÍ
‚Nespouštìjte motor, uniká-li v prostoru zemní plyn nebo propan-butan (LPG).
‚Nepoužívejte stlaèené startovací kapaliny, jejich páry jsou hoølavé.
Motory produkují oxid uhelnatý, což je bezbarvý jedovatý plyn bez
zápachu.
Vdechování oxidu uhelnatého mùže zpùsobit nevolnost, mdloby až
smrt.
VAROVÁNÍ
‚Spouštìjte a provozujte motor venku.
‚Nespouštìjte ani neprovozujte motor v uzavøeném prostoru, i když jsou
otevøená okna i dveøe.
Rychlé zatažení (zpìtné ”kopnutí”) lanka spouštìèe pøitáhne ruku a
paži k motoru rychleji, než ho staèíte pustit.
Je tu nebezpeèí zlomeniny, odøení nebo natažení šlach.
VAROVÁNÍ
‚Pøi startování motoru táhnìte za lanko spouštìèe pomalu, dokud neucítíte odpor
a pak rychle zatáhnìte, abyste zabránili zpìtnému kopnutí.
‚Pøed spuštìním motoru zbavte motor veškerého vnìjšího vybavení/zátìže.
‚Pøímo spøažené souèásti zaøízení, napø. nože, obìžná kola, øemenice, ozubená
kola atd., musí být bezpeènì upevnìny.
Otáèivé èásti se mohou dostat do styku nebo zachytit ruce, nohy,
vlasy, odìv èi výstroj.
Mùže dojít k tìžkým tržným ranám až amputacím konèetin.
VAROVÁNÍ
‚Provozujte zaøízení pouze s upevnìnými ochrannými kryty.
‚Nepøibližujte ruce a nohy k rotujícím èástem.
‚Sepnìte si dlouhé vlasy a sejmìte šperky.
‚Nenoste volnì vlající odìv, volnì visící stahovací tkalouny a šòùry, jež mohou
být zachyceny.
Provozem motorù se vytváøí teplo. Díly motoru, zejména tlumiè
výfuku, jsou za provozu extrémnì horké.
Ve styku s nimi mohou vzniknout vážné popáleniny.
Hoølavý materiál, jako je listí, tráva, roští atd., mùže vzplanout.
VAROVÁNÍ
‚Pøed manipulací nechejte tlumiè výfuku, válec a žebra motoru vychladnout.
‚Odstraòujte hoølavé neèistoty, hromadící se v prostoru tlumièe a válce.
‚Pøi použití zaøízení na zalesnìném, travnatém nebo køovím porostlém pozemku
bez lapaèe jisker nainstalovaného ve výfukovém systému a udržovaného v
øádném funkèním stavu porušujete ustanovení paragrafu 4442 Zákona o
veøejných zdrojích státu Kalifornie. Jiné státy nebo federální jurisdikce mohou
mít podobné zákony. Chcete-li zakoupit lapaè jisker vhodný pro výfukový
systém nainstalovaný na tomto motoru, kontaktujte výrobce pùvodního zaøízení,
prodejce nebo dodavatele.
Neúmyslné jiskøení mùže zpùsobit požár nebo úraz elektrickým
proudem.
Neúmyslné spuštìní motoru mùže zpùsobit zachycení, amputaci
konèetiny nebo tržné rány.
Riziko požáru
VAROVÁNÍ
Pøed provádìním seøizování nebo oprav:
‚Odpojte kabel od zapalovací svíèky a uložte jej dále od zapalovací svíèky.
‚Odpojte kabel od záporného vývodu akumulátoru (jen pokud je motor vybaven
elektrickým spouštìèem).
‚Používejte pouze správné nástroje.
‚Otáèky motoru se nesmí zvyšovat úpravami pružin regulátoru, táhel a ostatních
dílù.
‚Náhradní díly musí mít stejné provedení jako pùvodní díly a musí být
nainstalovány ve stejné poloze. Jiné díly nemusí poskytovat požadovaný výkon,
mohou poškodit zaøízení nebo zpùsobit zranìní.
‚Na setrvaèník netluète kladivem nebo tvrdým pøedmìtem, protože hrozí rozpad
setrvaèníku pøi dalším provozu.
Pøi zkoušení svíèky:
‚Použijte schválenou zkoušeèku zapalovacích svíèek
‚Nezkoušejte jiskru zapalování pøi vyjmuté svíèce.
20 BRIGGSandSTRATTON.COM
Funkce a ovládací prvky
Abyste se seznámili s umístìním rùzných funkcí a ovládacích prvkù, porovnávejte
ilustrace 1s motorem.
A. Identifikace motoru
Model Typ Kód
B. Zapalovací svíèka
C. Vzduchový filtr
D. Sytiè
E. RukojeGlanka spouštìèe
F. Palec svíèky
G. Ovladaè škrtící klapky (volitelný)
H. Spínaè (volitelný)
I. Palivová nádrž a víèko
J. Vypouštìcí zátka oleje
K. Plnicí hrdlo oleje
L. Tlumiè výfuku
Kryt tlumièe (volitelný)
Jiskrojem (volitelný)
M. Jednotka redukèního pøevodu (volitelný)
N. Uzávìr paliva
Fungování
Objem oleje (viz èást Specifikace)
Doporuèené oleje
Nejlepší výkonnosti dosáhnete, budete-li používat doporuèené oleje používat znaèky
Briggs & Stratton s potvrzenou zárukou. Ostatní vysoce jakostní detergentní oleje jsou
pøijatelné, jestliže jsou klasifikovány minimálnì pro SF, SG, SH, SJ. Nepoužívejte
zvláštní aditiva.
Venkovní teploty urèují správnou viskozitu oleje pro motor. Pro oèekávaný rozsah
venkovní teploty vyberte nejlepší viskozitu pomocí tabulky.
SAE 30
10W-30
Syntetický olej 5W-30
5W-30
°F°C
*Používání oleje SAE 30 pøi teplotách nižších než 4°C(40°F) zpùsobuje obtížné
startování.
** Použití oleje 10W-30 pøi teplotách nad 27°C(80°F) mùže zpùsobit zvýšenou
spotøebu oleje. V tomto pøípadì kontrolujte èastìji stav oleje.
Postup kontroly/pøidání oleje — obrázek 2
Pøed doplnìním nebo kontrolou oleje
‚Motor dejte do vodorovné polohy.
‚Vyèistìte prostor pro doplòování oleje od neèistot.
1. Vyjmìte mìrku (A) a otøete ji èistým hadøíkem.
2. VraGte zpìt mìrku, ale nezašroubujte ji. Hladina oleje by mìla být na znaèce FULL
(B)namìrce.
3. Nalévejte olej pomalu do plnicího otvoru v motoru (C). Dolijte olej až po okraj, ale
nepøelijte jej.
4. Zasuòte mìrku zpìt a utáhnìte ji.
Doporuèení týkající se benzínu
Palivo musí splòovat následující požadavky:
‚Používejte èistý, èerstvý bezolovnatý benzín.
‚Minimálnì 87 oktanù/87 AKI (91 RON). V pøípadì, že používáte stroj ve vyšších
nadmoøských výškách, viz níže.
‚Pøijatelný je benzín obsahující do 10 % ethanolu (smìsi benzínu s alkoholem)
nebo do 15 % MTBE (methyl-tercio-butyl-ether).
POZOR: Nepoužívejte neschválené benzíny, jako napøíklad E85. Nepøidávejte do
benzínu olej ani neupravujte motor pro provoz s alternativními palivy. Došlo by k
poškození souèástí motoru a ztrátì záruky na motor.
Do paliva pøidávejte stabilizátor paliva, abyste zabránili tvorbì pryskyøièných usazenin v
palivové soustavì. Viz Skladování. Všechna paliva nejsou stejná. Pokud se objeví
problémy se spouštìním nebo výkonností motoru, zmìòte dodavatele paliva nebo
znaèku. Tento motor je úøednì schválen jako benzínový motor. Systém øízení emisí
tohoto motoru je EM (Engine Modifications).
Vyšší nadmoøské výšky
Ve výškách nad 1 524 m (5 000 stop) je pøípustný minimálnì 85oktanový/85 AKI (89
RON) benzín. Aby byly dodrženy emisní limity, musí být motor pro vyšší nadmoøské
výšky seøízen. Provoz bez tohoto seøízení zpùsobí sníženou výkonnost, zvýšenou
spotøebu paliva a zvýšené emise. Informace o seøízení pro vyšší nadmoøské výšky
získáte u autorizovaného prodejce znaèky Briggs & Stratton.
Provoz motoru pøí nadmoøských výškách pod 762 m (2 500 stop) s pøestavbou pro vyšší
nadmoøské výšky se nedoporuèuje.
Postup doplnìní paliva — obrázek 3
VAROVÁNÍ
Palivo a jeho páry jsou vysoce hoølavé a výbušné.
Požár nebo výbuch mùže zpùsobit vážné popáleniny nebo i smrt
Když doplòujete palivo
‚Vypnìte motor a pøed sejmutím uzávìru palivové nádrže jej nechte nejménì 2
minuty chladnout.
‚Nádrž plòte venku nebo v dobøe vìtraném prostoru.
‚Palivovou nádrž nepøeplòujte. Kvùli tepelné roztažnosti paliva naplòte nádrž
jen po spodní okraj hrdla.
‚Chraòte palivo pøed jiskrami, otevøeným ohnìm, vìèným plamínkem, teplem
a jinými zdroji zapálení.
‚Kontrolujte palivové potrubí, nádrž a uzávìr a všechny spoje na tìsnost a
praskliny. V pøípadì potøeby proveïte výmìnu.
‚Jestliže rozlijete palivo, poèkejte, až se odpaøí a teprve potom spusGte motor.
1. Odstraòte z oblasti kolem uzávìru palivové nádrže. Sejmìte uzávìr palivové nádrže
(A) (obrázek 3).
2. Naplòte palivovou nádrž (B) benzínem. Kvùli tepelné roztažnosti benzínu dbejte na
to, aby pøi plnìní hladina nepøesáhla spodní èást hrdla palivové nádrže (C).
3. Nasaïte uzávìr palivové nádrže.
Jak spustit motor — obrázek 4
Rychlé zatažení (zpìtné ”kopnutí”) lanka spouštìèe pøitáhne ruku a
paži k motoru rychleji, než ho staèíte pustit.
Je tu nebezpeèí zlomeniny, odøení nebo natažení šlach.
VAROVÁNÍ
‚Pøi startování motoru táhnìte za lanko spouštìèe pomalu, dokud neucítíte odpor
a pak rychle zatáhnìte, abyste zabránili zpìtnému kopnutí.
VAROVÁNÍ
Palivo a jeho páry jsou vysoce hoølavé a výbušné.
Požár nebo výbuch mùže zpùsobit vážné popáleniny nebo i smrt
Pøi spouštìní motoru
‚Zkontrolujte, zda jsou na svém místì svíèky, tlumiè výfuku, víèko palivové
nádrže a vzduchový filtr (je-li jím motor vybaven), a zda jsou dobøe zajištìny.
‚Neotáèejte motorem pøi odstranìné svíèce.
‚Pøi pøeplavení motoru nastavte sytiè (je-li k dispozici) do polohy OPEN/RUN
(chod) a škrtící klapku do polohy FAST (rychle) a protáèejte motor, dokud
nenaskoèí.
Motory produkují oxid uhelnatý, což je bezbarvý jedovatý plyn bez
zápachu.
Vdechování oxidu uhelnatého mùže zpùsobit nevolnost, mdloby až
smrt.
VAROVÁNÍ
‚Spouštìjte a provozujte motor venku.
‚Nespouštìjte ani neprovozujte motor v uzavøeném prostoru, i když jsou
otevøená okna i dveøe.
Other manuals for 83100
3
Table of contents
Languages:
Other Briggs & Stratton Engine manuals
Briggs & Stratton
Briggs & Stratton 217900 Series Setup guide
Briggs & Stratton
Briggs & Stratton 99700 Series User manual
Briggs & Stratton
Briggs & Stratton 217700 Series Setup guide
Briggs & Stratton
Briggs & Stratton 150000 HORIZONTAL SERIES User manual
Briggs & Stratton
Briggs & Stratton Classic 100000 Series User manual
Briggs & Stratton
Briggs & Stratton 550 series User manual
Briggs & Stratton
Briggs & Stratton Extended Life Series User manual
Briggs & Stratton
Briggs & Stratton 90000 series User manual
Briggs & Stratton
Briggs & Stratton 31F700 Series Setup guide
Briggs & Stratton
Briggs & Stratton 19D Operating instructions
Briggs & Stratton
Briggs & Stratton Vanguard 540000 Series User manual
Briggs & Stratton
Briggs & Stratton 310000 VERTICAL SERIES User manual
Briggs & Stratton
Briggs & Stratton 11000B User manual
Briggs & Stratton
Briggs & Stratton 400000 Professional Series User manual
Briggs & Stratton
Briggs & Stratton 210000 Series User manual
Briggs & Stratton
Briggs & Stratton 405700, 406700, 407700, 445700 User manual
Briggs & Stratton
Briggs & Stratton 128800 Series Setup guide
Briggs & Stratton
Briggs & Stratton 310000 VERTICAL SERIES User manual
Briggs & Stratton
Briggs & Stratton Vanguard 540000 Series User manual
Briggs & Stratton
Briggs & Stratton 210000 Intek User manual
Popular Engine manuals by other brands
Zenith
Zenith NA428 Operator's manual
Nice
Nice Neomat A Series Instructions and warnings for the fitter
Novarossi
Novarossi MEPHISTO.21 GT5 instructions
Generac Power Systems
Generac Power Systems 0H0923PMNL parts manual
VTS Medical Systems
VTS Medical Systems 7-1-0005-0082 manual
Yanmar
Yanmar 6HA2M-WHT Operation manual
