Camp Chef MS40A User manual

Dear Valued Consumer:
Logan Outdoor Products, LLC d/b/a Camp Chef, in cooperation with the U.S. Consumer Product Safety Commission (CPSC), is
sending you the enclosed replacement regulator for your Camp Stove Model MS40A with component gas regulators date coded
“1923” through “2030”. Our records indicate that you are an owner of one of these affected camp stoves.
Description: This recall involves portable Camp Stove Models MS40A with component gas regulators date coded “1923” through
“2030”. The Model name is located on the manufacturers label on the stove. The gas regulator date code is engraved on the
regulator.
Hazard: An internal part of the gas regulator component may have a burr that may wear or tear a hole in the seal causing gas to
leak out of the top of the regulator and potentially catch fire.
Instructions: Please destroy and discard the regulator included with your stove and replace with the included regulator. See
below instructions for destroying the original regulator.
Warning: Read and follow all instructions in the product instruction manual included with the stove for removing and
assembling the gas regulator to the stove and fuel supply and performing the required leak tests prior to igniting the stove.
Regulator Removal Instructions:
1. Turn all valves on the stove to the off position by turning clockwise to a full stop and make sure all flames are extinguished.
ON
OFF

2. Turn the valve on the propane cylinder clockwise to turn off and remove regulator from propane cylinder by turning the fitting
counter-clockwise.
3. Remove regulator from stove by turning threaded fitting attaching to the stove counter-clockwise.
MS40A Regulator Disposal Instructions: Please destroy and discard of the original regulator by cutting the rubber gas hose
from regulator and disposing of both pieces.
WARNING
• Do not use appliance until leak checked. Leak check should be performed using a 50/50 mixture of mild soap and water. Do
not use household cleaning agents. Use a paint brush to brush soapy solution onto all indicated areas.
• If you cannot stop a gas leak, immediately close LP tank valve and call LP gas supplier or your fire department!
WARNING
Appliance must be leak checked outdoors in well-ventilated area, away from ignition sources such as gas fired or electrical
appliances. During leak test, keep appliance away from open flames or sparks.

Regulator Installation and setup:
1. Turn all valves to the off position
ON
OFF
2. Attach new hose and regulator to the stove as shown. Align the hose to the fuel tube on the stove and push on. Screw on the
outer threaded sleeve in a clockwise direction until tight.
3. Attach hose to cylinder valve by turning clockwise.
4. Open cylinder valve.
5. Perform leak check on hose to stove, and hose to cylinder connections with soapy water. Bubbles indicate a leak. Check that
the connection is tight. Perform another leak check. If there is still a leak, remove the cylinder and contact the manufacturer
for service and repair. 1-800-650-2433.
LEAK TEST
LEAK TEST

If you have any questions please call Camp Chef customer service toll-free [phone] from 9:00 AM to 5:00 PM Mountain
Time, Monday through Friday, or send an email to [email protected].
As always, we appreciate your continued support and business.
Thank you,
Camp Chef