Casabeds Casa Med Classic 4 User manual

Casa Med Classic 4 / Classic (FS)
Casa Med Ultra / Ultra (FS)

withDewert® drive system
GB
Nursing Beds

UHYLVHGYHUVLRQ
Casa Med Classic Low
43656 - Patterson Medical 22069 Booklet 11-11.indd 1 11/11/11 11:38:08
C
M
Y
CM
MY
CY
CMY
K
Classic FS - UK only 60601-2-52.pdf 31/5/12 14:08:21
19749GWBE

43656 - Patterson Medical 22069 Booklet 11-11.indd 2 11/11/11 11:38:08

Table of Contents
1 Preface ................................... .2
1.1 Introduction ...........................2
1.2 Information regarding this operating manual. . .2
1.2.1 Symbols used in this operating manual . ..... .2
1.2.2 Information regarding this operating manual. . .2
2 Safety .....................................2
2.1 Safety information . .....................2
2.1.1 Safety information – General. ............. .2
2.1.2 Safety information – Electrical fittings . .......3
2.1.3 Safety information – Nursing personnel, carers
and users ............................ .3
2.1.4 Safety information – Nursing bed assembly . ...3
2.1.5 Safety information – Maintenance and
inspection ............................ .4
2.2 Safety devices/guards . ...................4
2.2.1 Safety devices/guards – Control unit . ....... .4
2.2.2 Safety devices – Head/backrest adjustment
emergency unlocking . ...................4
2.3 Safety measures ........................5
2.3.1 Safety measures – Limitations of use . ....... .5
2.3.2 Safety measures – Gap dimensions and bed rail
spacing .............................. .5
2.3.2A Safety Measures – Mattress Selection . .......5
2.3.3 Safety measures – Locking (disabling) the
handset.............................. .5
2.4 Intended use...........................5
3 Delivery scope.............................. .6
3.1 Transport and storage system . .............6
3.2 Delivery scope – List . ................... .6
4 Assembly/set-up, dismantling, storage ..........7
4.1 Nursing bed – Installation site . .............7
4.2 Nursing bed – Designation of components . ...7
4.3 Nursing bed – Assembly/set-up . ........... .7
4.3.1 Fitting the mattress support . ............. .8
4.3.2 Fitting the actuator motors . ...............9
4.3.3 Connecting the handset and actuator motor for
the foot section........................ .9
4.3.4 Fitting the bed ends (headboard and footboard)10
4.3.5 Connecting the bed end actuator motors . ...11
4.3.6 All control unit connections at a glance. .....11
4.3.7 Fitting the patient lifting pole . ........... .11
4.3.8 Routing the mains cable . ............... .12
4.4 Rechargeable battery (option) . ........... .12
4.4.1 Rechargeable battery – General information . .12
4.4.2 Rechargeable battery – Charging . .........12
4.4.3 Rechargeable battery – Fitting. ........... .12
4.5 Performing a function test. ...............12
4.6 Nursing bed – Dismantling . ............. .13
4.7 Nursing bed – Storage with the transport and
storage system ........................13
5 Handset ...................................13
5.1 Handset – Information on the variants. ..... .13
5.2 Handset – IPROXX......................13
5.3 Handset with magnetic key. . .............15
5.3.1 Handset – Unlocking (enabling). . ........ . .15
5.3.2 Handset – Locking (disabling) . . ...........15
5.3.3 Handset – Nurse mode . . ................15
5.4 Handset with mechanical key . . ...........15
5.4.1 Handset – Lock-out mode . . ............. .15
5.4.2 Handset – Nurse mode . .................15
5.4.3 Handset – Patient mode . . ............. . .15
5.4.4 Handset – Programming mode . . ........ . .15
5.5 Programming the handset. . ............. .16
6 Operation ................................ .16
6.1 Operation – General information. . ........ .16
6.2 Operation – Mains cable, mains plug, wall
socket. ............................. .17
6.3 Operation – Raising/lowering the lower leg
support. . ............................17
6.3.1 Raising the lower leg support . . ...........17
6.3.2 Lowering the lower leg support. . ........ . .17
6.4 Operation – Wheel brakes. . ............. .17
6.5 Operation – Moving the nursing bed. . ..... .18
7 Cleaning and disinfection ....................19
7.1 Nursing bed – Cleaning. . ................19
7.2 Nursing bed – Disinfection . . .............19
8 Maintenance and inspection . . . . . . . . . . . . . . . . . .19
8.1 Maintenance – Daily . . . . . . . . . . . . . . . . . . . .19
8.2 Maintenance – Every six months . . ........ .19
8.3 Maintenance – Safety inspections . . ........19
8.3.1 Testing intervals. . ..................... .19
8.3.2 Safety inspections – Mechanical components .19
8.3.3 Safety inspections – Electrical components . . .20
8.3.4 Safety inspections – Measurement in accordance
with BGV A3. .........................21
9 Trouble Shooting ...........................22
10 Reuse ................................... .22
11 Disposal .................................. .22
12 Appendix..................................23
12.1 Technical data . . .......................23
12.1.1 Technical data – Nursing bed. .............23
12.1.2 Technical data – Drive system . . ...........23
12.1.3 EMC Tables . . ..................... . 24-31
12.2 Name plate . . ........................ .32
12.2.1 Name plate – Nursing bed. ...............32
12.3 Accessories and options . ............... .33
12.4 Spare parts . . ........................ .33
13 Warranty information .......................33
Casa Med Classic (FS) / Casa Med Classic Low / Casa Med Ultra (FS) – 15.09.2011 GB – 1
GB
GB
GB
Casa Med Classic 4 / Classic FS / Casa Med Ultra / Casa Med Ultra FS / Casa Med Low 01.01.2012

* ;C
*(* 8
;;0HB 40;C720A4=DAB8=6143B0A4<0=D502CDA43F8C7
BC0C4>5C740AC C427=820; 5028;8C84B C> ?A>E834 <0G8<D<
;H8=60=3>?4A0C8=62><5>ACDAC74A<>A4C74143B70E4
144=34B86=43C>4=BDA4B8<?;470=3;8=60=3>?4A0C8>=
+74DB4>50CCA02C8E4F>>3342>AB2A40C4B07><4;H0C
<>B?74A4
;0A64=D<14A>5DB45D;0224BB>A84BA>D=3>55>DAA0=64
>5=DAB8=6143B
+74=DAB8=6143B34B2A81438=C78B<0=D0;0A42>=BCAD2C
43C>C745>;;>F8=6BC0=30A3B
s!%%BC0=30A35>A=DAB8=6143B
s!%%BC0=30A35>A7>B?8C0;143B
BC74<>C>ABHBC4<>5C74=DAB8=61433>4B=>C70E40
2>=CA>;BHBC4<F8C702;>2:5A4@D4=2H>5R: I0=38B
<08=;HDB435>A>=;H1A845?4A8>3B>5C8<4 % 
0??;84B8=022>A30=24F8C7%
+78B>?4A0C8=6<0=D0;F8;;50<8;80A8B4H>DF8C7C745D=2
C8>=B>5C74=DAB8=61430=38=0338C8>=34B2A814B
s7>FC>B4CD?C74=DAB8=6143
s7>FC>>?4A0C4C74039DBC<4=C2>=CA>;B
s7>FC>;>>:05C4A0=3<08=C08=C74=DAB8=6143
+74=DAB8=6143E4AB8>=B7>F=8B>=;H8=C4=343C>4G?;08=
7>FC>>?4A0C4C741430=3<0HE0AH5A><H>DA?0AC82
D;0AE4AB8>=
+74<0=D0;70B144=3A0F=D?DB8=68=5>A<0C8>=0E08;0
1;40CC74C8<4>5?A8=C8=6F8C7A460A3C>C7434B86=0=3
>?4A0C8>=>5C74=DAB8=6143
.4A4B4AE4C74A867CC><0:4270=64B3D4C>C427=820;
8<?A>E4<4=CB
!5 H>D 70E4 0=H @D4BC8>=B A460A38=6 C74 =DAB8=6 143
?;40B42>=C02CH>DA0HB 40;C720A4B?4280;8BC340;4AB44
340;4ABC0<?>=C74102:2>E4A
*(+ 8C'

*(+(* !B
+78B >?4A0C8=6 <0=D0; 2>=C08=B C74 5>;;>F8=6 BH<1>;B
F78270A4DB43C>B7>FH>DB?428582A8B:BF74=340;8=6
F8C7C74?A>3D2C>A8=5>A<0C8>=>=7>FC>B8<?;85H70=
3;8=6

7  : ; ;  ; ;
;A>%

7  : ; ;  ; ;
;  >>A 
>%

7 :;;;
>%
*(+(+ 8C'

+7>A>D67;HA403C744=C8A4>?4A0C8=6<0=D0;?A8>AC>B4C
C8=6D?0=3DB8=6C74=DAB8=6143
=BDA4C70C
sC744=C8A4>?4A0C8=6<0=D0;8BA4031H0;;?4AB>=B4=
CADBC43F8C7C74B4CC8=6D?>?4A0C8>=>A<08=C4=0=24
>5C74=DAB8=6143
s0;;?4AB>=B4=CADBC43F8C7C74B4CC8=6D?>?4A0C8>=>A
<08=C4=0=24>5C74=DAB8=6 143 70E4 0224BBC>C78B
>?4A0C8=6<0=D0;0C0;;C8<4B
=H30<064A4BD;C8=65A><=>=>1B4AE0=24>5C78B>?4A
0C8=6<0=D0;8B4G2;D3435A><C74F0AA0=CH
+748;;DBCA0C8>=B2>=C08=438=C78B<0=D0;B7>F4G0<?;4B
>57>FC>70=3;4C740HB 40;C720A4=DAB8=6143B0=3
<0H38554A5A><H>DA?0AC82D;0A<>34;
+ C!
+(* C!C
+(*(* C!CI6

s/ =:>;=$
;;:;
%
s4     : ;   >>%
::# >>$
 %
s  @ ; = #  >
!'(%'%'7C:!;>('%
s4 :>;=
%
s/     :    
>%
s2>  ;  ;
;;; ;
: %
s/ :: $
   :=% /    ;
:=:%
s4 >>:  1%
s/  =   :#   >
=>;=:;
>:%
0B0$43;0BB82*0B0$43;0BB82#>F0B0$43,;CA0*M
6I+


43656 - Patterson Medical 22069 Booklet 11-11.indd 4 11/11/11 11:38:09
* ;C
*(* 8
;;0HB 40;C720A4=DAB8=6143B0A4<0=D502CDA43F8C7
BC0C4>5C740AC C427=820; 5028;8C84B C> ?A>E834 <0G8<D<
;H8=60=3>?4A0C8=62><5>ACDAC74A<>A4C74143B70E4
144=34B86=43C>4=BDA4B8<?;470=3;8=60=3>?4A0C8>=
+74DB4>50CCA02C8E4F>>3342>AB2A40C4B07><4;H0C
<>B?74A4
;0A64=D<14A>5DB45D;0224BB>A84BA>D=3>55>DAA0=64
>5=DAB8=6143B
+74=DAB8=6143B34B2A81438=C78B<0=D0;0A42>=BCAD2C
43C>C745>;;>F8=6BC0=30A3B
s!%%BC0=30A35>A=DAB8=6143B
s!%%BC0=30A35>A7>B?8C0;143B
BC74<>C>ABHBC4<>5C74=DAB8=61433>4B=>C70E40
2>=CA>;BHBC4<F8C702;>2:5A4@D4=2H>5R: I0=38B
<08=;HDB435>A>=;H1A845?4A8>3B>5C8<4 % 
0??;84B8=022>A30=24F8C7%
+78B>?4A0C8=6<0=D0;F8;;50<8;80A8B4H>DF8C7C745D=2
C8>=B>5C74=DAB8=61430=38=0338C8>=34B2A814B
s7>FC>B4CD?C74=DAB8=6143
s7>FC>>?4A0C4C74039DBC<4=C2>=CA>;B
s7>FC>;>>:05C4A0=3<08=C08=C74=DAB8=6143
+74=DAB8=6143E4AB8>=B7>F=8B>=;H8=C4=343C>4G?;08=
7>FC>>?4A0C4C741430=3<0HE0AH5A><H>DA?0AC82
D;0AE4AB8>=
+74<0=D0;70B144=3A0F=D?DB8=68=5>A<0C8>=0E08;0
1;40CC74C8<4>5?A8=C8=6F8C7A460A3C>C7434B86=0=3
>?4A0C8>=>5C74=DAB8=6143
.4A4B4AE4C74A867CC><0:4270=64B3D4C>C427=820;
8<?A>E4<4=CB
!5 H>D 70E4 0=H @D4BC8>=B A460A38=6 C74 =DAB8=6 143
?;40B42>=C02CH>DA0HB 40;C720A4B?4280;8BC340;4AB44
340;4ABC0<?>=C74102:2>E4A
*(+ 8C'

*(+(* !B
+78B >?4A0C8=6 <0=D0; 2>=C08=B C74 5>;;>F8=6 BH<1>;B
F78270A4DB43C>B7>FH>DB?428582A8B:BF74=340;8=6
F8C7C74?A>3D2C>A8=5>A<0C8>=>=7>FC>B8<?;85H70=
3;8=6

7  : ; ;  ; ;
;A>%

7  : ; ;  ; ;
;  >>A 
>%

7 :;;;
>%
*(+(+ 8C'

+7>A>D67;HA403C744=C8A4>?4A0C8=6<0=D0;?A8>AC>B4C
C8=6D?0=3DB8=6C74=DAB8=6143
=BDA4C70C
sC744=C8A4>?4A0C8=6<0=D0;8BA4031H0;;?4AB>=B4=
CADBC43F8C7C74B4CC8=6D?>?4A0C8>=>A<08=C4=0=24
>5C74=DAB8=6143
s0;;?4AB>=B4=CADBC43F8C7C74B4CC8=6D?>?4A0C8>=>A
<08=C4=0=24>5C74=DAB8=6 143 70E4 0224BBC>C78B
>?4A0C8=6<0=D0;0C0;;C8<4B
=H30<064A4BD;C8=65A><=>=>1B4AE0=24>5C78B>?4A
0C8=6<0=D0;8B4G2;D3435A><C74F0AA0=CH
+748;;DBCA0C8>=B2>=C08=438=C78B<0=D0;B7>F4G0<?;4B
>57>FC>70=3;4C740HB 40;C720A4=DAB8=6143B0=3
<0H38554A5A><H>DA?0AC82D;0A<>34;
+ C!
+(* C!C
+(*(* C!CI6

s/ =:>;=$
;;:;
%
s4     : ;   >>%
::# >>$
 %
s  @ ; = #  >
!'(%'%'7C:!;>('%
s4 :>;=
%
s/     :    
>%
s2>  ;  ;
;;; ;
: %
s/ :: $
   :=% /    ;
:=:%
s4 >>:  1%
s/  =   :#   >
=>;=:;
>:%
0B0$43;0BB82*0B0$43;0BB82#>F0B0$43,;CA0*M
6I+


43656 - Patterson Medical 22069 Booklet 11-11.indd 4 11/11/11 11:38:09
Casa Med Classic 4 / Classic FS / Casa Med Ultra / Casa Med Ultra FS / Casa Med Low 01.01.2012
All Casabeds are maufactured with state-of-the-art
technical facilities to provice maximum lying and
operating comfort. Furthermore, the beds have been
designed to ensure simple handling and operattion.
The use of attractive wood decors creates a homely
atmosphere.
The illustrations contained in this manual show examples
of how to handle the Casabeds and may differ from your
particular model.
Only use accessories approved by Drive Medical.
If you have any questions regarding the nursing bed,
please contact your Drive Medical Healthcare specialist
dealer (see dealer stamp on the back cover)

 -87CF;@8B?C;@!>75CB;5>8;CC;@9
!&'&'$&
I 8C-E?1:?A>1@4-@@41<;C1>/-.819-5:?/-.81/-:
:;@.1>A:;B1>C41:9;B5:3@41:A>?5:3.10;>.10
?501@-.81?;>C41:A?5:3/81-:5:31=A5<91:@
I 8C-E?/41/7@41/-.85:32;>/;>>1/@<;?5@5;:5:3.1
2;>1 A?1 <5:/45:3 ;> 75:75:3 ;2 @41 /-.81 9A?@ .1
-B;5010
I 8C-E?05?/;::1/@@419-5:?<8A3.12;>18;:3<1>5;0?
;2:;:A?1
 -87CF;@8B?C;@B;@9A7B@@7>
5B7B@67B
!$'
I ;:;@A?1181/@>5/-89105/-8-<<85-:/1?;:<-@51:@?5:
@41?1:A>?5:3.10?5:B;8B5:35:@>-B-?/A8->;>5:@>-/->
05-//;::1/@5;:
I ;:;@A?1@41:A>?5:3.105:@41B5/5:5@E;2?@>;:3
181/@>;9-3:1@5/ 25180? 2;> 1D-9<81 9-6;> 9105/-8
1=A5<91:@
I 8C-E?<8A3@41:A>?5:3.109-5:?<8A35:@;-?1<-
>-@1C-88?;/71@
I $8A3@419-5:?<8A35:@;C-88?;/71@?@4-@->11-?58E
-//1??5.81-@-88@591?
I %;A@1@419-5:?/-.81@;@41C-88?;/71@5:?A/4-C-E
@4-@@41>15?:;91/4-:5/-8@1:?5;:-:0@419-5:?/-
.81/-::;@.1<5:/41075:710;>>A:;B1>
I $81-?1 ;.?1>B1 @41 >1?<1/@5B1 1=A5<91:@ ;<1>-@5:3
-:0-??19.8E5:?@>A/@5;:?C5@4>13->0@;-:E-005@5;:
-8?-21@E>5?7?@4-@9-E->5?1C41:A?5:3@41:A>?5:3
.105:/;:6A:/@5;:C5@4;@41>1=A5<91:@2E;A4-B1
-:E =A1?@5;:? <81-?1 /;:@-/@ E;A> -E? 1-8@4/->1
?<1/5-85?@01-81>?1101-81>?@-9<;:@41.-/7/;B1>
$&'"$&!$ &)''&%
%$%$$
I *41:@41.105?<8-/105:@;?1>B5/1;>52@41;//A<-:@
5?/4-:310->5?7-??1??91:@9A?@.1/->>510;A@.E
@41/->1>:A>?5:3?@-22
I 88.103-</;:05@5;:?9A?@.1/;:?501>10>18-@5B1@;
@41 ;//A<-:@G? 41-0 -:0 .;0E 0591:?5;:? -:0 -:E
>5?7;21:@>-<91:@9A?@.1501:@52510-:018595:-@10
I 10>-58.A221><-0?->1-B-58-.81-?-:-//1??;>E2>;9
-E? 1-8@4/->1 @; 418< >10A/1 @41 >5?7 ;2 1:@>-<
91:@
I :?A>1@4-@@41.10>-58?->1-8C-E?<>;<1>8E8;/7105:
<8-/1
"$&'"'"'&'$
'%'$'%'$
I 8C-E?8;/705?-.81-884-:0?1@-06A?@91:@2A:/@5;:?
;:@414-:0?1@C45/4/;A80/-A?10-:31>@;@41<-
@51:@?41-8@452-06A?@10/;:?A8@0;/@;>
I 8C-E?@-71-//;A:@;2@41<-@51:@?/;:05@5;:C41:
8;/75:305?-.85:3@41-06A?@91:@;<@5;:?
$'*&'""$''

8C-E?9;B1@41:A>?5:3.10@;@418;C1?@41534@C41:
A:?A<1>B5?10 ;> 2;> @41 <-@51:@ @; 31@ 5: ;> ;A@ ;2 @41
.10
!&'&'$&
I 12;>19;B5:3@41:A>?5:3.1005?/;::1/@@419-5:?
<8A3-:0?1/A>1@419-5:?/-.812>;9.15:3>A:;B1>
I ;:;@A?1@41:A>?5:3.105:?A>>;A:05:3?5:C45/4
28-99-.813-?1?;>B-<;A>?132>;9-:-1?@41@5/?
9-E.1<>1?1:@
$&'''&#'&&'$
I 12;>1-06A?@5:3@41.1041534@1:?A>1@4-@:;@45:3
5?.8;/75:3@412A88-06A?@91:@9;B191:@
I B;50;<1>-@5:3@41-/@A-@;>9;@;>?/;:@5:A;A?8E2;>
9;>1@4-:@C;95:A@1?
!-D59A9/;:@5:A;A?;<1>-@5;:;2@41-/@A-@;>9;
@;>?95:A@1?
!5:59A9<-A?1-2@1>95:A@1?;<1>-@5;:95:
A@1?
I "1B1>A?19;>1@4-:@C;-/@A-@;>9;@;>??59A8@-:1
;A?8E
 -87CF;@8B?C;@B;@94767?4>F
!$ &)'$&&'#")
I :?A>1@4-@-88:A>?5:3.10/;9<;:1:@?->1/;>>1/@8E
-??19.810?11<-31 
I 41/7@4-@-88-06A?@91:@;<@5;:?->15:<1>21/@C;>7
5:3;>01>-2@1>-??19.8E?11<-31 
!$'
I #:8E<1>2;>9-??19.8EC;>7A?5:3[email protected]@;;8?
I #:8E<1>2;>9@41 C;>7 01?/>5.1052E;A->12-9585->
C5@44-:085:3@41>1=A5>10@;;8?
$$*&&$*&
I '41>15?5:/>1-?10>5?7;2@>-<<5:3<5:/45:3;>/>A?4
5:3-@-886;5:@?;2@41:A>?5:3.10-:0-@@41?A<<;>@
<;5:@?;2@419-@@>1???A<<;>@'41>1?<1/@5B14-F->0
<;5:@?;:@41:A>?5:3.10->1501:@52510.E-?@5/71>;:
@41852@9;@;>?-@@411:0?;2@41:A>?5:3.10
I 2@419-@@>1???A<<;>@?1/@5;:?4-B1.11:2;8010A<
?1/A>1@419-3-5:?@A:5:@1:@5;:-8A:2;805:3.E?A5@-
.8191@4;0?
0B0$43;0BB82*0B0$43;0BB82#>F0B0$43,;CA0*M 6I,



43656 - Patterson Medical 22069 Booklet 11-11.indd 5 11/11/11 11:38:10
Casa Med Classic 4 / Classic FS / Casa Med Ultra / Casa Med Ultra FS / Casa Med Low 01.01.2012
Drive Medical
Drive Medical to help reduce the risk of entrapment.

'$
N = '6<57525DD 9CD ;59> C5@1B1D5B %?DC381<D5B 1>75
2B138D
N 09585>*959>%?D6]<<5>45>%5DJCD53;5B1EC45B%5DJ
CD53;4?C5
N 59'6<57525DD5>=9D=?>D95BD5B;;E2?H;1>>5CF?B
;?==5>41CC4955G57E>7DB?DJ75J?75>5=%5DJ
CD53;5BC6?BD75C5DJDG9B4
09585>*959>495C5=1<<41C"125<45B;;E2?H1EC
45B*D5E5B59>859D
 -;5:7B:7;C7;@B;5:C@97@C7@CB;797>@9
&A8C7;>7BC7>>@9
&@7C6:=56*7=68636CC6<??36:7==5636CB67
76?56?06BC6==>CB5B49!?C76B?6?6:?6-49?6==6B
49=6 > 06BC6==>CB 86=OC ?5 5?? ? $?5
3866?<CD6B56?
+(*(. C!CI
 
&=;H0;;>F<08=C4=0=240=38=B?42C8>=F>A:C>14
20AA843>DC1H>AD=34AC74BD?4AE8B8>=0=36D830=24>5
CA08=434G?4AC?4AB>==4;F7>>=C7410B8B>5C748AB?4
280;8BCCA08=8=6:=>F;43640=34G?4A84=248=0338C8>=
C>:=>F;4364>50;;C74A4;4E0=CA46D;0C8>=B0A420?01;4
>54E0;D0C8=6C742>=38C8>=>5C74=DAB8=61430=3>5
A42>6=8B8=60=H?>BB81;445542CB0=370I0A3B
;F0HBA403C74A4;4E0=C270?C4AB>5C78B<0=D0;C7>A
>D67;H145>A420AAH8=6>DC<08=C4=0=240=38=B?42C8>=
F>A:
=H30<064A4BD;C8=65A><=>=>1B4AE0=24>5C78B
>?4A0C8=6<0=D0;0A44G2;D3435A><0=H;8018;8CH>5C74
<0=D502CDA4A
 
s !LWAYSCARRYOUTAFUNCTIONTESTFOLLOWINGMAINTE$
NANCEWORKANDINSPECTIONSSEEPAGE
s 7HENOPERATINGTHEACTUATORMOTORSENSURETHATTHE
NURSINGBEDCABLINGCANNOTBEPINCHEDOVERSTRETCHED
ORKINKED
'$!$!"!
 !
s )MMEDIATELYREMOVEFAULTYDEFECTIVENURSINGBEDS
FROMOPERATIONANDSECURETHEMAGAINSTUNAUTHORISED
USE$ISCONNECTTHEMAINSPLUGFROMTHEWALLSOCKET
s /NLYUSEORIGINALSPAREPARTSFROM$AYS(EALTHCARE
s !LWAYSCARRYOUTTHEPRESCRIBEDMAINTENANCEAND
INSPECTIONWORKATTHESPECIlEDINTERVALSSEE#HAPTER
h-AINTENANCEANDINSPECTIONvFROMPAGE
s $ONOTCARRYOUTANYALTERATIONSTOTHEELECTRICALOR
MECHANICALlTTINGSSUPPLIEDWITHTHENURSINGBED
UNLESSAUTHORISEDTODOSOBYTHEMANUFACTURER
5NAUTHORISEDALTERATIONSLEADTOANYLIABILITYOFTHE
MANUFACTURERBECOMINGNULLANDVOID
s /NLYPERFORMMAINTENANCEANDINSPECTIONWORKUSING
SUITABLETOOLS
s $ONOTOPENELECTRICALCOMPONENTS
+(+ C!
+(+(* C!I
B0=>E4A;>03?A>C42C8>=C742>=CA>;D=8C8=2;D34BC74
5>;;>F8=6B054CH34E824B6D0A3B
s ,IMITSWITCHESTURNOFFTHEACTUATORMOTORSWHEN
THEYREACHTHEIRLIMITPOSITION
s !THERMALSWITCHTURNSOFFTHECONTROLUNITIFITOVER$
HEATS4HECONTROLUNITCANBEOPERATEDAGAINAFTERA
PAUSEOFBETWEENANDMINUTES

s 4HENURSINGBEDISNOTlTTEDWITHASEPARATE%MER$
GENCY3TOPSWITCH
s )NCASESOFEMERGENCYDISCONNECTTHEMAINSPLUG
FROMTHEPOWERSUPPLY
s )FTHENURSINGBEDISlTTEDWITHARECHARGEABLEBAT$
TERYTHEMOVEMENTMAYBECONTINUEDEVENIFTHE
MAINSPLUGISDISCONNECTED)NTHISCASEDISCONNECT
THECABLEOFTHERECHARGEABLEBATTERYFROMTHECON$
TROLUNIT
+(+(+ C!I7BED
 !E
!5C7402CD0C>A<>C>AB7>D;31A40:3>F=C74=DAB8=6
1437403102:A4BC20=14;>F4A43<0=D0;;H1HA4<>E8=6
0@D82:A4;40B450BC4=8=6>=C7402CD0C>A<>C>A
0B0$43;0BB82*0B0$43;0BB82#>F0B0$43,;CA0*M
6I-


43656 - Patterson Medical 22069 Booklet 11-11.indd 6 11/11/11 11:38:13
Casa Med Classic 4 / Classic FS / Casa Med Ultra / Casa Med Ultra FS / Casa Med Low 01.01.2012
Drive Medical

7BEDI5!E
 
 $&
0  = ;  := <
:: >>%
 '4AB>=
)08B4C74<0CCA4BBBD??>AC7403102:A4BCB42C8>=
 '4AB>=
)4<>E4C74@D82:A4;40B450BC4=8=6>=C74;85C10A0B
5>;;>FB
&?4=C741>;CA4C08=4A
'D;;C74@D82:A4;40B41>;C>DC>5C7458GCDA4
 *;>F;H;>F4AC74<0CCA4BBBD??>AC7403102:A4BCB42
C8>=
7BEDI;BE'

 =BDA4C70CC7402CD0C>A<>C>A8B5D=2C8>=8=62>AA42C
;H
 *4C C74 ;85C 10A >= C74 02CD0C>A <>C>A B> C70C C74
@D82:A4;40B41>;C20=148=B4AC430608=
 )458CC74@D82:A4;40B450BC4=8=6
+(, C!
+(,(* C!IC
'0AC82D;0A?0C84=C8;;=4BB4B>A2;8=820;2>=38C8>=B20=;403
C>;8<8C0C8>=B148=68<?>B43>=C74=DAB8=61430??;820
C8>=20?018;8C84B
45>A4 DB8=6 C74 =DAB8=6 143 2>=BD;C C74 B?4280;8BC A4
B?>=B81;45>AC74?0C84=C
D4 C> C748A 34B86= 0HB 40;C720A4 =DAB8=6 143B 0A4
>=;H0??A>E435>A>22D?0=CB>E4AH40AB>5064>A5>A
>22D?0=CBF8C71>3HB8I40=3F4867C4@D8E0;4=CC>0=0E
4A064H40A>;3
0HB 40;C720A4=DAB8=6143B<DBC=>C14DB435>A?4A
B>=BD=34A:61>3HF4867C>AD=34A2<B74867C
>A5>A?4AB>=C70CBD554A5A><B?0B<B>A0A42>=5DB43
+(,(+ C!I6B

$!$ $&$#
##
s9:>#;>
#=::
;;%
s/:>:
 >B   :   
=;>:;%
s:;;>: ;
  1  >   = ; >$
%
s0: >> =
>%
+745>;;>F8=62742:B<DBC14<034>=C74=DAB8=614
3
0=3BD8C01;4?A4E4=C8E4<40BDA4BC0:4=M?0AC82D;0A;H8
=
C7420B4>54GCA4<4;HC78=?0C84=CBM
E3
+70C8C8B=>C?>BB81;45>AC74?0C84=CC>B;8?14CF44
=
C74<0CCA4BB0=3C74143A08;B
;3
&=;HDB4<0CCA4BB4BC70C70E4C74B0<4A42;8=8=6BDA

5024F83C70BC741432<
+(,(, C!IEB
+(,(+4C!I

.74=B4;42C8=60<0CCA4BBC7438BC0=2414CF44=C74
C>?>5C74<0CCA4BBF8C7>DC2><?A4BB8>=C>C74C>?
4364>5C74B834A08;BB7>D;3146A40C4AC70=<<

!$!!$
##
s/  = :   : <

;   #  > '*#  

> '+#>

>>:;>%
s7=$;;: >

;= %0<>
$
;= >%
s6>;

; %
+(- 8
0HB 40;C720A4=DAB8=6143B70E4144=34B86=438=02

2>A30=24F8C7!%%5>A2>=C8=D>DBDB41HC7438B

01;43
0HB 40;C720A4=DAB8=6143B0A434B86=43C>
s0;;4E80C42><?4=B0C45>A038B018;8CH>A8=018;8CH>5?0

C84=CB
s<0:4 C74 F>A:8=6 2>=38C8>=B >5 =DAB8=6 ?4AB>==4
40B84A
0HB 40;C720A4=DAB8=6143B20=0;B>14DB435>AC7438

06=>B8BCA40C<4=C>A>1B4AE0C8>=>5?0C84=CBD=34A<43

820;BD?4AE8B8>=8=022>A30=24F8C7!%%8
=
7><420A4=DAB8=67><4B>AB8<8;0A4=E8A>=<4=CB
+74=DAB8=6143B0A48=C4=3435>ADB48=
s7><4=DAB8=6
s=DAB8=67><4B0=3A47018;8C0C8>=24=CA4B
"
s# 1:

 >>;>'( ;%
s7  :   : ; > 

'-+%
s# 1:

 >>;>'( ;

;>: A?

'( %
s 1 : : ;
>*+=: '+&"

#;>;;;>

;%
0B0$43;0BB82*0B0$43;0BB82#>F0B0$43,;CA0*M 6I.



43656 - Patterson Medical 22069 Booklet 11-11.indd 7 11/11/11 11:38:15
Days Healthcare nursing beds have been designed in
accordance with DIN EN 60601-2-52 for continuous
use by the disabled.
Casa Med Classic 4 / Classic FS / Casa Med Ultra / Casa Med Ultra FS / Casa Med Low 01.01.2012
Due to their design, Casabeds are only approved for
occupants over 12 years of age or for occupants with
body size and weight equivalent to an average 12 year
old.
Casabeds must not be used for persons under 45 kg body
weight or under 150 cm’s height, or for person that suffer
from spasms or are confused.
Casabeds have been designed in accordance with DIN EN
60601-2-52 for continuous use by the disabled.
Casabeds can also be used for the diagnosis, treatment
or observation of patients under medical supervision
in accordance with DIN EN 60601-2-52 in home care,
nursing homes or similar environments.
Due to their design, Casabeds are only approved for
occupants over 12 years of age.
Due to their design, Casabeds are only approved for
occupants over 12 years of age or for occupants with
body size and weight equivalent to an average 12 year
old.
Casabeds must not be used for persons under 45 kg body
weight or under 150 cm’s height, or for person that suffer
from spasms or are confused.
Casabeds are designed to:
Bed rail buffer pads are available as an accessory from
Drive Medical to help reduce the risk of entrapment.
Ensure that the bed rails are always properly locked in
place.
•


JE75<1CC5>
N '1D95>D5>=9D59>5B"jB@5B7BjW5F?>=58B1<C3=
C?<<D5>41C'6<57525DD>938DF5BG5>45>
N 1IC51<D831B5'6<57525DD5>C9>4>EB6nB4955>ED
JE>74EB38'5BC?>5>n25B!18B5>JE75<1CC5>2JG
>EB6nB'5BC?>5>4959>5JE71E6"jB@5B7BjW5E>4
5G938D59>5B4EB38C38>9DD<9385>:]8B975>'5BC?>
5>DC@B5385>?45B41Bn25B<9575>
N 1IC51<D831B5'6<57525DD5>4nB65>>938DF?>'5BC?
>5> E>D5B  ;7 "jB@5B75G938D E>4 E>D5B  3=
"jB@5B7BjW5>938DF?>'5BC?>5>=9DC@1CD9C385>B
;B1>;E>75> C?G95 >938D F?> F5BG9BBD5> '5BC?>5>
?8>5F?B<9575>45@B?65CC9?>5<<5)9C9;?1>1<IC575>EDJD
G5B45>
 ';787B?8@9
 .B@ABC@6'97BFC7?.'-/
==6C6:=656*7=68636CC6D6B56?9?5=:496B@4<C
?576:?6B.B?@BC@=6CC656B>:C56>.B?@BC
?5 '86BFC6> .'-/ G 6:?6B .B?@BC6:?96:C 6B
3?56?
*BP76?-:65:60==CN?5:8<6:C56B':676B?8?9?556B
?497=86?57867P9BC6?':C6?36B-:6>:C56>7
C6==6?56*7=68636CC6368:??6?
6:6B<6??3B6?(N?86=?56B769=6?56?C6:=6?D6?
56?-:6:49?9B6? F$6=C94B6"499N?5=6B:696
$N?5=6BC6>@6=756B,P4<6:C656/>49=86
 7B:49C6B56>7?9>6B9B56.B?@BC?5
'86BFC6>96BG:696?
 ==6&BC?6?C76B?6?
 ==6-:496B96:C49B36?=O6??5':6867=N49696B
?69>6?
$(
525>*951<<5"1BD?>CJE=C@]D5B5>9><175B>45C'6<5
7525DD5C1E6
$(
95229<4E>75>9>495C5B5495>E>7C1><59DE>7J5975>5H5=
@<1B9C38 495 1>4812E>7 =9D 1IC 51<D831B5 '6<57525DD5>
E>4;j>>5>776F?>45=F?B<9575>45>$?45<<12G59385>



!
"

#
$

, !
,(* >!
;;2><?>=4=CB>5C74=DAB8=61430A42>=E4=84=C;H
?02:430=350BC4=43C>0CA0=B?>AC?0;;4C>AC>C74CA0=B
?>AC0=3BC>A064BHBC4<C>5>A<>=4CA0=B?>ACD=8C
45>A42><<4=28=6F8C7C740BB4<1;H>5C74=DAB8=6
1432742:C70CC7434;8E4AH8B2><?;4C4022>A38=6C>C74
;8BCBB?428K438=C745>;;>F8=6
!=C744E4=C>5=>C82401;434542CB>A<8BB8=62><?>=4=CB
?;40B42>=C02CH>DA0HB 40;C720A4B?4280;8BC340;4AB44
340;4ABC0<?>=C74102:2>E4A
'D;;C74?0C84=C;85C8=6?>;4>DC>5C74<>D=C8=6CD14>5
C74CA0=B?>AC0=3BC>A064BHBC4<
)4<>E40;;20A31>0A3?02:068=6
#>>B4=0;;B054CHB2A4FB0=3C0:4>DCC74<0CCA4BB
BD??>ACB42C8>=B
%>C4
"44?0;;20A31>0A3?02:068=65>A?>BB81;4BC>A064>5C74
=DAB8=61430C0;0C4A30C4
%>C4
+748;;DBCA0C8>=B2>=C08=438=C78B<0=D0;B7>F4G0<?;4B
>57>FC>70=3;4C740HB 40;C720A4=DAB8=6143B0=3
<0H38554A5A><H>DA?0AC82D;0A<>34;
,(+ !I
BC
0B0$43;0BB82*0B0$43;0BB82#>F0B0$43,;CA0*M
6I/


43656 - Patterson Medical 22069 Booklet 11-11.indd 8 11/11/11 11:38:16
Casa Med Classic 4 / Classic FS / Casa Med Ultra / Casa Med Ultra FS / Casa Med Low 01.01.2012
Drive Medical specialist dealer (see
of how to handle the Casabeds and may differ from
your particular model.
dealer stamp on the back cover).


5E
- 4CB&4BB&5
-(* ;CBI
 #84645;[274">?5C48;<8CD5=07<4=5\A34=
D5A827C4A
 *48C4=68CC4A
 #84645;[274DWC48;  *48C4=68CC4AB278414A
 $0CA0CI4=70;C4A<8C454BC86D=6BB27A0D14= "0??4=5\A*48C4=68CC4A8=:;AD2:5434A
 *27=4;;E4AB27;DBB1>;I4=P";4<<7414; ! D5A827C4A
 A>=C<8CE>A<>=C84AC4=-4ABC4;;<>C>A4=
 -4ABC4;;<>C>A<8C*C4D4A48=748C5\A">?5C48;E4ABC4;;D=68=:;DB8E4;8=3BC>?54=D=3SD6B8274AD=6
 -4ABC4;;<>C>A5\ADWC48;E4ABC4;;D=6
 0=3B270;C4A8=:;DB8E4$06=4CB27;\BB4;1IF<4270=8B274<*27;\BB4;

 1  C <  >A;= C   /;E A 8;E# 
 ')%
 ::D1>G8=:;DB8E4 0;C4AD=3454BC86D=6BB27A0D14

/==:@:5;:7:D;%
   
43=3>>C*42C8>= 43=3 403*42C8>=
43)08;B
$0CCA4BB*D??>AC
>>C*42C8>=
$0CCA4BB*D??>AC
 403*42C8>=
 $0CCA4BBBD??>AC7403102:A4BC
F8C7<>D=C5>AC74?0C84=C;85C8=6?>;4
*834A08;B
 $0CCA4BBBD??>AC5>>CB42C8>= *834A08;20AA84AB
 $0CCA4BBA4C08=4ABF8C750BC4=8=6B2A4FB
!=B4E4A0;E4AB8>=BC74<0CCA4BBA4C08=4AB0A4
0;A403HF4;343C>C745A0<4
';0BC824=320?B5>AB834A08;B
 (D82:A4;40B41>;CB;0<?8=6;4E4AB !'0C84=C;85C8=6?>;4F8C7BCA0?0=3CA80=6D;0A70=36A8?
 434=3B
F8C7?A40BB4<1;4302CD0C>A<>C>AB
 2CD0C>A<>C>AF8C72>=CA>;D=8C5>A7403102:A4BC039DBC<4=C8=2;D38=63D<<H2>==42C>AB0=3BCA08=
A4;845
 2CD0C>A<>C>A5>A5>>CB42C8>=039DBC<4=C
 0=3B4C8=2;D38=6<06=4C82:4H0=3>A<4270=820;:4H

6ARIOUSHANDSETVERSIONSAREAVAILABLEnDEPENDINGONTHESPECIlCATION
 )4270A6401;410CC4AH>?C8>=8=2;D38=6BD??>AC0=350BC4=8=6B2A4F

4HERECHARGEABLEBATTERYISONLYREQUIREDFORNURSINGBEDSWITH4RENDELENBURGPOSITION
-4B!'&&
-(*BI8
0B0$43;0BB82*0B0$43;0BB82#>F0B0$43,;CA0*M 6I0



43656 - Patterson Medical 22069 Booklet 11-11.indd 9 11/11/11 11:38:17
Casa Med Classic 4 / Classic FS / Casa Med Ultra / Casa Med Ultra FS / Casa Med Low 01.01.2012


@8
8636CC66:?6-C64<56367:?56C
:633:=5?8G6:8C5:6(L656B-C6==7=N496?55:636
?OC:8C6"B6:7=N496
 *8>79747CC847@
$(
N 1CE621E5>45C'6<57525DD5C;1>>F?>59>5B'5BC?>
4EB38756n8BDG5B45>%13845=EC@13;5>45B1E
D59<5G5B45>6nB41CE621E5>31$9>ED5>25>j
D97D
N 95>7125OB538DCL2JGO<9>;CL45C'6<57525DD5C9CD
=9D<93;B938DE>7JEB"?@6C59D565CD75<57D
 ';7978>I5:7?@C;7B7@
 0:6B(CBCG6?9=C6B:?5:69B?86?:>,9
>6?56B':6867=N496?6:?C64<6??576C49B36?
  "LC6:=  56B':6867=N496  >:C56B /?C6B6:C6
?49B?8686?6:?67B6:61?5=69?6?
 &@7C6:= 56B':6867=N4967C64<6?
&"'*$&
38D5>*9541B1E641CC49525G57<9385>+59<545B#9575
6<]385=9D"125<29>45B>2JG=9D45=*9385BE>7C21>4
75C9385BDC9>4C25CD58D"<5==E>4(E5DC3875618B6nB
]>45E>49>75B
>
>
4>
4>



!
!
-(+ BI8
.74=B4;42C8=6C74143B;>20C8>=4=BDA4C70CC74A48B
BD5K284=CB?0245>A0224BBC>C74?0C84=C8=C74143>=
0C;40BC>=4>5C74143BB834B0=3C70CC74A48B0?>F4A
B>2:4C2>=E4=84=C;H;>20C43=40A1H
+748;;DBCA0C8>=B7>FBC74A4@D8A4338<4=B8>=B5>AB4CC8=6
D?C741430=30338C8>=0;B?024A4@D8A435>A0224BBC>
C74?0C84=C
-(, BI4B!'
 
s 4HENURSINGBEDCANBEASSEMBLEDBYONEPERSON
/NCETHECOMPONENTSHAVEBEENUNPACKEDASSEMBLY
TAKESAPPROXMINUTES
s 4HESPECIlCATIONShRIGHTHANDvANDhLEFTHANDvREFER
TOTHENURSINGBEDASSEENFROMTHEFOOTEND
-(,(*
 !=B4ACC745>DA<0CCA4BBA4C08=4AB8=C>C747>;4B
8=C745A0<4>5C74<0CCA4BBBD??>AC0=3B2A4FC867C
 #40=C745>>CB42C8>=>5C74<0CCA4BBBD??>AC
0608=BC0=4<?CHF0;;F8C7C74D=34AB8345028=60F0H
5A><C74F0;;
 8CC747403102:A4BC>=C>C74<0CCA4BBBD??>AC
 $'$
s 4HEREISINCREASEDRISKOFTRAPPINGPINCHINGORCRUSH$
INGATALLJOINTSOFTHENURSINGBEDANDATTHESUPPORT
POINTSOFTHEMATTRESSSUPPORT
s 3ECUREADJUSTABLEJOINTSAGAINSTUNINTENTIONALFOLDING
UPUNFOLDINGBYSUITABLEMETHODS
 !=B4ACCF>2;0<?8=6;4E4AB8=C>C747>;4B0=3B2A4F
C867C=BDA4C70CC742;0<?8=6;4E4AB3>=>C?>8=C
>DCF0A3F74=B2A4F43C867C


0B0$43;0BB82*0B0$43;0BB82#>F0B0$43,;CA0*M
6I1


43656 - Patterson Medical 22069 Booklet 11-11.indd 10 11/11/11 11:38:25
Casa Med Classic 4 / Classic FS / Casa Med Ultra / Casa Med Ultra FS / Casa Med Low 01.01.2012