Caterlite CK686-A User manual

Model
CK686-A
Coffee/Spice
Grinder
Instruction manual
CK686-A_A5_v1_20190809.indb 1 2019/8/9 16:22

2
AU Telephone Helpline: 1300225960
Safety Tips
• Position on a flat, stable surface.
• A service agent/qualified technician should carry out
installation and any repairs if required. Do not remove any
components on this product.
• Consult Local and National Standards to comply with the
following:
- Health and Safety at Work Legislation
- Fire Precautions
- Wiring Regulations
- Building Regulations
• DO NOT immerse the appliance in water, or use jet/pressure
washers to clean the appliance
• Do not use the appliance for anything other than its intended
use.
• Always switch off and disconnect the power supply to the
appliance when not in use.
• Do not let cord hang over edge of table or hot surface.
• Not suitable for outdoor use.
• Keep fingers away from moving parts.
• Do not remove cover until blade has completely stopped.
• Do not attempt to operate without the cover in place.
• This appliance must only be used in accordance with these
instructions and by persons competent to do so.
• Keep all packaging away from children. Dispose of the
packaging in accordance to the regulations of local authorities.
• If the power cord is damaged, it must be replaced by a
Caterlite agent or a recommended qualified technician in order
to avoid a hazard.
CK686-A_A5_v1_20190809.indb 2 2019/8/9 16:23

3
AU
Telephone Helpline: 1300225960
• This appliance is not intended for use by persons (including
children) with reduced physical, sensory or mental capabilities,
or lack of experience and knowledge, unless they have
been given supervision or instruction concerning use of the
appliance by a person responsible for their safety.
• Children should be supervised to ensure that they do not play
with the appliance.
• Do not use if damaged.
• Caterlite recommends that this appliance should be periodically
tested (at least annually) by a Competent Person. Testing
should include, but not be limited to: Visual Inspection,
Polarity Test, Earth Continuity, Insulation Continuity and
Functional Testing.
Introduction
Please take a few moments to carefully read through this manual. Correct maintenance and operation of
this machine will provide the best possible performance from your Caterlite product.
Pack Contents
The following is included:
• Caterlite Coffee/Spice Grinder
• Instruction manual
Caterlite prides itself on quality and service, ensuring that at the time of packaging the contents are
supplied fully functional and free of damage.
Should you find any damage as a result of transit, please contact your Caterlite dealer immediately.
CK686-A_A5_v1_20190809.indb 3 2019/8/9 16:23

4
AU Telephone Helpline: 1300225960
Know your Spice/Coffee
Grinder
Power Switch
Transparent Cover
Grinding Bowl
(Containing blade)
Motor Base
Before Use
• Carefully unpack your coffee grinder and
remove all packing materials.
• To remove any dust that may have
accumulated during packaging, wipe the
grinding bowl, blades with a damp lint-free
cloth or sponge. Use extreme care as the
blades are sharp.
• The transparent cover can be immersed in
water for cleaning, dry thoroughly.
Caution: Never immerse the
motor base in water for cleaning
and do not fill the grinding bowl
with water for cleaning.
Operation
1. Place the grinder on a flat surface.
2. Assemble the grinding bowl into the motor
base, and then turn the bowl clockwise until a
click sound is heard. When disassembling, turn
the bowl anti-clockwise to detach it.
3. Pour dry spices or coffee beans into the
grinding bowl, it must be noted the quantity of
should not exceed 60g.
4. Attach the transparent cover and plug into the
power outlet.
5. Press and hold the power switch, the appliance
will start operating. Release the power switch,
the appliance will stop operating.
NOTE: Do not operate this
appliance continuously for
more than 30 seconds. Allow
appliance to cool down for 3
minute between two continuous
cycles.
6. View the consistency of ground product
through the transparent cover.
IMPORTANT: If necessary to
remove the cover to check
the consistency of the coffee
grounds, it must be noted you
should never remove the cover
until blades come to a complete
stop.
7. Once the desired grind is obtained, release
power switch and unplug the power cord from
the outlet.
Grinding Tips
This grinder can only grind dry, brittle foods. It
will not grind anything moist, extremely hard, or
gummy such as whole ginger, chocolate, sesame
seeds or nutmeg. Never use the grinder to chop
ice cubes.
Spices, freshly ground peppercorns etc. may have
a strong aroma and a taste that may affect the
flavour of coffee beans ground afterward. You may
want to purchase a separate grinder if you plan to
grind coffee and spices.
CK686-A_A5_v1_20190809.indb 4 2019/8/9 16:23

5
AU
Telephone Helpline: 1300225960
Cleaning, Care & Maintenance
Warning:
Be sure to unplug this appliance before cleaning.
To protect against electrical shock, do not immerse cord, plug or motor base in
water or liquid.
After each use, always make sure plug is disconnected from the mains power
supply.
• Wash cover with water and mild detergent. The cover is not dishwasher-safe. Rinse thoroughly and
dry.
• Never immerse motor base or filling water into the grinding bowl.
• Wipe the grinding bowl, blades with a lint-free cloth. Extreme care should be exercised as the
blades are sharp.
Troubleshooting
If your Caterlite appliance develops a fault, please check the following table before making a call to the
Helpline.
Fault Probable Cause Solution
The unit is not working No power Make sure the machine is plugged in
correctly.
Check power supply
Plug and lead are damaged Call Caterlite agent or qualified technician
Internal wiring fault Call Caterlite agent or qualified technician
Fuse in the plug has blown Replace the plug fuse
Cover not located correctly Make sure cover located correctly
Technical Specifications
Model Voltage Power Current Dimensions
h x w x d mm Weight (kg)
CK686-A 220-240V~
50/60Hz 180-220W 0.9A 209 x 123 x 124 1.02 kg
CK686-A_A5_v1_20190809.indb 5 2019/8/9 16:23

6
AU Telephone Helpline: 1300225960
Electrical Wiring
The plug is to be connected to a suitable mains socket.
This appliance is wired as follows:
• Live wire (coloured brown) to terminal marked L
• Neutral wire (coloured blue) to terminal marked N
If in doubt consult a qualified electrician.
Electrical isolation points must be kept clear of any obstructions. In the event of any emergency
disconnection being required they must be readily accessible.
Compliance
The product must not be disposed of as household waste. To help prevent possible harm to human
health and/or the environment, the product must be disposed of in an approved and environmentally safe
recycling process. For further information on how to dispose of this product correctly, contact the product
supplier, or the local authority responsible for waste disposal in your area.
Caterlite parts have undergone strict product testing in order to comply with regulatory
standards and specifications set by international, independent, and federal authorities.
Caterlite products have been approved to carry the following symbol:
All rights reserved. No part of these instructions may be produced or transmitted in any form or by any means, electronic,
mechanical, photocopying, recording or otherwise, without the prior written permission of Caterlite.
Every effort is made to ensure all details are correct at the time of going to press, however, Caterlite reserves the right to
change specifications without notice.
CK686-A_A5_v1_20190809.indb 6 2019/8/9 16:23

DECLARATION OF CONFORMITY
Equipment Type
Coffee/Spice Grinder
Model
CK686-A
Legislation
Electrical Safety
Electromagnetic Compatibility
Standards
IEC 60335.1:2010+A1:2013 +A2:2016
IEC 60335.2.14:2016
EN55014-1:2017
EN55014-2:2015
EN61000-3-2:2014
EN61000-3-3:2013
Producer Name
Caterlite
Producer Address
15 Badgally Road,
Campbelltown,
NSW 2560
I, the undersigned, hereby declare that the equipment specified above conforms to the above Legislation and Standard(s).
Date
22nd May 2019
Signature
Full Name
Ashley Hooper
Position
Technical & Quality Manager/ Responsible Supplier
CK686-A_A5_v1_20190809.indb 7 2019/8/9 16:23

CK686-A_A5_v1_20190809
CK686-A_A5_v1_20190809.indb 8 2019/8/9 16:23