Cisco ONS 15454 Manual

Cisco ONS 15454 Hardware Installation Guide
First Published: 2016-11-26
Last Modified: 2019-10-04
Americas Headquarters
Cisco Systems, Inc.
170 West Tasman Drive
San Jose, CA 95134-1706
USA
http://www.cisco.com
Tel: [phone]
800 553-NETS (6387)
Fax: [phone]

©2019 Cisco Systems, Inc. All rights reserved.

CONTENTS
Preface xvii
PREFACE
Revision History xviii
Document Objectives xxiii
Audience xxiii
Related Documentation xxiii
Document Conventions xxiii
Obtaining Optical Networking Information xxix
Where to Find Safety and Warning Information xxix
Obtaining Documentation, Obtaining Support, and Security Guidelines xxix
Overview 1
CHAPTER 1
Compliance Standards 1
Cisco ONS 15454 ANSI 1
Cisco ONS 15454 ETSI 2
Cisco ONS 15454 M2 Shelf 2
Cisco ONS 15454 M6 Shelf 4
Preparing to Install the ONS 15454 (ANSI and ETSI), ONS 15454 M2 and ONS 15454 M6 Shelf 7
CHAPTER 2
Important Safety Recommendations 7
Required Tools and Equipment 9
Cisco Supplied Materials 9
User Supplied Materials 11
Ordering Solutions for ONS 15454 M2 and ONS 15454 M6 15
Card Slot Requirements 15
ONS 15454 15
ONS 15454 M2 18
Cisco ONS 15454 Hardware Installation Guide
iii

ONS 15454 M6 19
Card Replacement 19
NTP-G305 Unpack and Inspect the ONS 15454, ONS 15454 M2, and ONS 15454 M6 Shelves 20
DLP-G676 Unpack and Verify the ONS 15454, ONS 15454 M2, and ONS 15454 M6 Shelves 20
DLP-G677 Inspect the ONS 15454, ONS 15454 M2, and ONS 15454 M6 Shelves 21
Installing the ONS 15454 M12 (ANSI and ETSI) Shelf 23
CHAPTER 3
ONS 15454 ANSI Rack Installation 24
Reversible Mounting Bracket 25
Mounting a Single Node 26
Mounting Multiple Nodes 26
ONS 15454 ANSI Bay Assembly 26
ONS 15454 ETSI Rack Installation 27
Mounting a Single Node 28
Mounting Multiple Nodes 29
NTP-G306 Install the ONS 15454 Shelf 31
DLP-G3 Reverse the Mounting Bracket to Fit a 19-inch (482.6-mm) Rack (ANSI Only) 33
DLP-G4 Install the External Brackets and Air Filter (ANSI Only) 34
DLP-G678 Mount the ONS 15454 Shelf in a Rack (One Person) 36
DLP-G679 Mount the ONS 15454 Shelf in a Rack (Two People) 37
DLP-G680 Mount Multiple ONS 15454 Shelf Assemblies in a Rack 39
DLP-G8 Install the Air Ramp 42
Front Door 45
ONS 15454 ANSI Backplane Covers 53
Lower Backplane Cover 54
Rear Cover 54
Alarm Interface Panel 56
Alarm Interface Panel Replacement 56
NTP-G3 Open and Remove the Front Door 56
DLP-G9 Open the Front Cabinet Compartment (Door) 57
DLP-G10 Remove the Front Door 58
NTP-G4 Open and Remove the FMEC Cover (ETSI Only) 60
DLP-G11 Open the FMEC Cover 61
DLP-G12 Remove the FMEC Cover 62
Cisco ONS 15454 Hardware Installation Guide
iv
Contents

NTP-G5 Remove the Backplane Covers (ANSI Only) 63
DLP-G13 Remove the Lower Backplane Cover 64
DLP-G14 Remove the Backplane Sheet Metal Cover 65
ONS 15454 ETSI Front Mount Electrical Connection 65
NTP-G6 Install the MIC-A/P and MIC-T/C/P FMECs (ETSI Only) 66
Power and Ground Description 67
NTP-G7 Install the Power and Ground 68
DLP-G17 Connect Office Power to the ONS 15454 ETSI 70
DLP-G18 Connect Office Power to the ONS 15454 ANSI 71
DLP-G19 Turn On and Verify Office Power 74
Shelf Voltage and Temperature 75
NTP-G230 View Shelf Voltage and Temperature 76
Fan-Tray Assembly 76
Fan-tray Units for ONS 15454 Cards 78
Fan Speed 81
Fan Failure 81
Air Filter 82
NTP-G8 Install the Fan-Tray Assembly 82
ONS 15454 ANSI Alarm Expansion Panel 85
NTP-G9 Install the Alarm Expansion Panel (ANSI Only) 91
ONS 15454 ANSI Alarm, Timing, LAN, and Craft Pin Connections 94
Alarm Contact Connections 97
Timing Connections 98
LAN Connections 98
TL1 Craft Interface Installation 99
NTP-G10 Attach Wires to Alarm, Timing, LAN, and Craft Pin Connections 100
DLP-G20 Install Alarm Wires on the MIC-A/P (ETSI Only) 101
DLP-G21 Install Timing Wires on the MIC-C/T/P (ETSI Only) 104
DLP-G22 Install LAN Wires on the MIC-C/T/P (ETSI Only) 105
DLP-G23 Install Alarm Wires on the Backplane (ANSI Only) 106
DLP-G24 Install Timing Wires on the Backplane (ANSI Only) 109
DLP-G25 Install LAN Wires on the Backplane (ANSI Only) 110
DLP-G26 Install the TL1 Craft Interface Wires (ANSI Only) 111
NTP-G11 Install an External Wire-Wrap Panel on the AEP (ANSI Only) 112
Cisco ONS 15454 Hardware Installation Guide
v
Contents

NTP-G12 Install and Close the FMEC Cover (ETSI Only) 117
NTP-G13 Install the Rear Cover (ANSI Only) 118
Typical DWDM Rack Layouts 120
NTP-G14 Install DWDM Equipment 123
DLP-G27 Install the DCU Shelf 123
DLP-G28 Install the Fiber Patch-Panel Tray 124
DLP-G29 Install the Fiber-Storage Tray 125
DLP-G371 Install the Ethernet Adapter Panel 126
DLP-G352 Install the Y-Cable Module Tray 126
DLP-G30 Install the FlexLayer Shelf 127
DLP-G31 Install the FlexLayer Modules 128
DLP-G32 Install the Y-Cable Protection Modules in the FlexLayer Shelf 129
DLP-G377 Install the Y-Cable Protection Modules in the Y-Cable Module Tray 130
NTP-G15 Install the Common Control Cards 131
DLP-G33 Install the TCC2, TCC2P, or TCC3 Card 132
DLP-G34 Install the AIC-I Card 135
DLP-G309 Install the MS-ISC-100T Card 136
Multishelf Management 137
Multishelf LAN Topologies 137
ONS 15454 Multishelf Node and Subtending Shelves 138
ONS 15454 Multishelf Node and Subtending Shelves—Upgrade 138
NTP-G301 Connect the ONS 15454 Multishelf Node and Subtending Shelves to an MS-ISC-100T
Card 138
NTP-G304 Configure the MS-ISC-100T Card for a ONS 15454 Multishelf Node for Non-Default Public
and Private VLAN IDs 141
NTP-G307 Perform the ONS 15454 Shelf Installation Acceptance Test 143
DLP-G35 Inspect the Shelf Installation and Connections 145
DLP-G36 Measure Voltage 146
NTP-G295 Connect the ONS 15454 Multishelf Node and Subtending Shelves to a Catalyst 2950 or
Catalyst 3560 146
NTP-G296 Upgrade the ONS 15454 Multishelf with MS-ISC Card Configuration Using the Catalyst
3560 148
NTP-G297 Upgrade the ONS 15454 Multishelf with Catalyst 2950 Configuration Using the Catalyst
3560 150
Cisco ONS 15454 Hardware Installation Guide
vi
Contents

NTP-G298 Configure a Cisco Catalyst 2950 or Catalyst 3560 (Active and Standby) for a ONS 15454
Multishelf Node 152
Ethernet Adapter Panel 154
Filler and Blank Cards 156
Cable Routing and Management 157
Fiber Management 158
Fiber Management Using the Patch-Panel Trays 160
Standard and Deep Patch-Panel Trays (32-Channel) 160
40-Channel Patch-Panel Tray 161
Mesh Patch-Panel Tray 162
Install PP-Mesh 163
Install PP-Mesh on an ANSI 19" Configuration 164
Install PP-Mesh on an ANSI 23" Configuration 167
Install PP-Mesh on an ETSI Configuration 171
Fiber Management Using the Y-Cable Module Tray 173
Fiber Management Using the Fiber-Storage Tray 173
Fiber Management Using the Optional ANSI Tie-Down Bar 175
Installing the ONS 15454 M2 Shelf 177
CHAPTER 4
Installing the ONS 15454 M2 Shelf 177
ANSI Rack Installation 177
Mounting Brackets 178
Mounting a Single Node 179
ETSI Rack Installation 179
Mounting a Single Node 180
Wall Mounting the ONS 15454 M2 Shelf 180
Desktop Mounting the ONS 15454 M2 Shelf 181
Air Deflector 181
Air Plenum 181
Air Plenum Rack and Cabinet Compatibility 182
NTP-G343 Install the Air Plenum in ONS 15454 M2 Shelf 183
DLP-G763 Install Air Plenum for ONS 15454 M2 Shelf in ANSI 19-inch Configuration 185
DLP-G764 Install Air Plenum in ONS 15454 M2 Shelf for ANSI 23-inch Configuration 187
DLP-G765 Install Air Plenum for ONS 15454 M2 Shelf in ETSI Configuration 191
Cisco ONS 15454 Hardware Installation Guide
vii
Contents

NTP-G266 Install the ONS 15454 M2 Shelf 194
DLP-G582 Mounting the 19-inch Brackets on the ONS 15454 M2 Shelf for ANSI Rack
Configuration 197
DLP-G583 Mounting the 23-inch Brackets on the ONS 15454 M2 Shelf for ANSI Rack
Configuration 198
DLP-G584 Mounting the Bracket with Air Deflectors (Front-to-Back) on the ONS 15454 M2
Shelf for ANSI Rack Configuration 199
DLP-G585 Mounting the Brackets on the ONS 1545 M2 Shelf for ETSI Rack Configuration 202
DLP-G586 Mounting the Air Deflectors (Front-to-Front) on the ONS 15454 M2 Shelf for ETSI
Rack Configuration 203
DLP-G587 Mounting the Bracket with Air Deflectors (Front-to-Back) on the ONS 15454 M2
Shelf for ETSI Rack Configuration 205
DLP-G588 Mounting the Bracket with Air Deflectors (Front-to-Top) on the ONS 15454 M2 Shelf
for ETSI Rack Configuration 208
DLP-G589 Mount the ONS 15454 M2 Shelf on a Rack (One Person) 209
DLP-G590 Mount the ONS 15454 M2 Shelf on the Wall 211
DLP-G591 Mount the ONS 15454 M2 Shelf on the Desktop 214
Front Door 215
NTP-G269 Install the Standard Door of the ONS 15454 M2 Shelf 216
NTP-G270 Open and Remove the Standard Door of the ONS 15454 M2 Shelf 218
DLP-G594 Open the Standard Door of the ONS 15454 M2 Shelf 219
DLP-G595 Remove the Standard Door of the ONS 15454 M2 Shelf 220
NTP-G343 Install the Deep-Front Panel of the ONS 15454 M2 Shelf 222
NTP-G331 Remove the Deep-Front Panel of the ONS 15454 M2 Shelf 226
Power Modules 228
AC Power Module 229
DC Power Module 230
NTP-G267 Install the Power Module in the ONS 15454 M2 Shelf 230
DLP-G592 Install the AC Power Module in the ONS 15454 M2 Shelf 231
DLP-G593 Install the DC Power Module in the ONS 15454 M2 Shelf 233
Fan-Tray Assembly 234
Fan Speed 235
Fan Failure 235
NTP-G268 Install the Fan-Tray Assembly in the ONS 15454 M2 Shelf 235
Power and Ground Description 237
Cisco ONS 15454 Hardware Installation Guide
viii
Contents

ANSI Power and Ground 238
ETSI Power and Ground 238
NTP-G271 Install the Power and Ground to the ONS 15454 M2 Shelf 239
DLP-G596 Connect Office Power (AC) to the ONS 15454 M2 Shelf 241
DLP-G597 Connect Office Power (DC) to the ONS 15454 M2 Shelf (ANSI Only) 244
DLP-G598 Connect Office Power (DC) to the ONS 15454 M2 Shelf (ETSI Only) 249
DLP-G599 Turn On and Verify AC Office Power on the ONS 15454 M2 Shelf 251
DLP-G600 Turn On and Verify DC Office Power on the ONS 15454 M2 Shelf 252
NTP-G291 Attach Wires to Timing, LAN, and Craft Pin Connections in ONS 15454 M2 254
DLP-G292 Install Timing Wires in ONS 15454 M2 - ANSI 255
DLP-G293 Install Timing Wires in ONS 15454 M2 - ETSI 257
DLP-G294 Install LAN Wires in ONS 15454 M2 261
NTP-G313 Install and Configure the TNC, TNCE, TSC, or TSCE Card 261
DLP-G604 Install the TNC, TNCE, TSC, or TSCE Card 262
DLP-G605 Provision PPM and Port for the TNC and TNCE Cards 265
DLP-G606 Configure UDC and VoIP for the TNC and TNCE Cards 266
NTP-G275 Perform the ONS 15454 M2 Shelf Installation Acceptance Test 267
DLP-G601 Inspect the ONS 15454 M2 Shelf Installation and Connections 268
DLP-G602 Measure DC Voltage on the ONS 15454 M2 Shelf 268
Filler and Blank Cards 269
Air Filter 270
Shelf Voltage and Temperature 270
Installing the ONS 15454 M6 Shelf 271
CHAPTER 5
ANSI Rack Installation 272
Reversible Mounting Bracket 273
Mounting a Single Shelf 273
Mounting Multiple Nodes 274
ETSI Rack Installation 274
Mounting a Single Node 275
Mounting Multiple Nodes 276
Air Deflector 276
Air Plenum 276
Air Plenum Rack and Cabinet Compatibility 278
Cisco ONS 15454 Hardware Installation Guide
ix
Contents

NTP-G344 Install the Air Plenum in ONS 15454 M6 Shelf 279
DLP-G766 Install Air Plenum for ONS 15454 M6 Shelf in ANSI 19-inch Cabinet 280
DLP-G767 Install Air Plenum in ONS 15454 M6 Shelf for ANSI 23-inch Configuration 284
DLP-G768 Install Pre-assembled Air Plenums in ANSI 23-inch Configuration 287
DLP-G769 Install Air Plenum for ONS 15454 M6 Shelf in ETSI Configuration 289
Air Flow Performance of ONS 15454 M6 293
NTP-G252 Install the ONS 15454 M6 Shelf 294
DLP-G674 Verify the ONS 15454 M6 Shelf for AC Power Module Installation 297
DLP-G675 Verify the ONS 15454 M6 Shelf for DC Power Module Installation 298
DLP-G560 Mounting the Reversible Brackets on the ONS 15454 M6 Shelf for ANSI Rack
Configuration 299
DLP-G561 Mounting the Bracket with Air Deflectors (Front-to-Back) on the ONS 15454 M6 Shelf
for ANSI Rack Configuration 302
DLP-G562 Mounting the Brackets on the ONS 15454 M6 Shelf for ETSI Rack Configuration 304
DLP-G563 Mounting the Air Deflectors (Front-to-Front) on the ONS 15454 M6 Shelf for ETSI Rack
Configuration 306
DLP-G564 Mounting the Bracket with Air Deflectors (Front-to-Back) on the ONS 15454 M6 Shelf
for ETSI Rack Configuration 307
DLP-G565 Mounting the Bracket with Air Deflectors (Front-to-Top) on the ONS 15454 M6 Shelf
for ETSI Rack Configuration 309
DLP-G821 Mounting the Bracket with Air Deflectors (Front-to-Side) on the ONS 15454 M6 Shelf
for ETSI Rack Configuration 313
DLP-G566 Mount the ONS 15454 M6 Shelf on a Rack (One Person) 315
DLP-G567 Mount the ONS 15454 M6 Shelf on a Rack (Two People) 317
DLP-G568 Mount Multiple ONS 15454 M6 Shelves on a Rack 318
Front Door 320
NTP-G258 Install the Standard Door of the ONS 15454 M6 Shelf 323
NTP-G259 Open and Remove the Standard Door of the ONS 15454 M6 Shelf 327
DLP-G576 Open the Standard Door of the ONS 15454 M6 Shelf 328
DLP-G577 Remove the Standard Door of the ONS 15454 M6 Shelf 330
NTP-G327 Install the Deep-Front Panel of the ONS 15454 M6 Shelf 332
NTP-G329 Remove the Deep-Front Panel of the ONS 15454 M6 Shelf 339
External Connection Units 342
ECU 342
ECU2 343
Cisco ONS 15454 Hardware Installation Guide
x
Contents