CMA Dishmachines GW-100 Manual

PRIME
DETERGENT
CONCENTRATION
PRIME
SANITIZER
CONCENTRATION
PRIME
RINSE
CONCENTRATION
FLUSH
OFF
ON
11-2017
GW-100 Carousel
Glasswasher
Quick Setup
Instructions
1
STEP
Connect the drain hose to the FLOOR DRAIN. If
floor drain is not available connect to the wall. Floor
drain must have a (1 inch) air gap between the drain
hose and the floor drain.
Adjust heater thermostat to 140F.
Connect water lines (hot 140F/160F) and (cold
75F) to water solenoid valves.
Flip power "on-off/flush" switch to "ON" position.
Wash tank will automatically fill.
Connect L1 and L2 leads to the power block and
ground wire to ground lug.
4
STEP
PRIME
RINSE
CONCENTRATION
FLUSH
OFF
ON
Level dishmachine by adjusting leveling legs.
Dishmachine must be level front and back to
ensure proper performance.
GROUND
L2 (N)
L1
HOT WATER
INLET 2
COLD WATER
INLET 2
2
STEP
5
STEP
6
STEP
140
3
STEP
FLOOR
DRAIN
1"AIR GAP
WALL
DRAIN
WARNING: Electrical and plumbing
connections need to be made by a
licensed service person and comply
with all Federal, State and Local
Health, Electrical, Plumbing and
Safety codes.
HEATER THERMOSTAT
POWER BLOCK
1
POWER SWITCH
5
6
THERMOMETER
DRAIN CONNECTION
3
LEVELING LEGS
4
6
PN: 1013039

PRIME
DETERGENT
CONCENTRATION
PRIME
SANITIZER
CONCENTRATION
PRIME
RINSE
CONCENTRATION
FLUSH
OFF
ON
PRIME
DETERGENT
CONCENTRATION
PRIME
SANITIZER
CONCENTRATION
PRIME
RINSE
CONCENTRATION
FLUSH
OFF
ON
11-2017
10
STEP
Start conveyor by flipping rocker switch to
"ON" position.
Insert tube stiffener with chemical tubing into
corresponding chemical dispensers.
8
STEP
BLUE RED WHITE
Push each of the chemical prime buttons
and hold until the chemical feed tubes are full.
PRIME
DETERGENT
CONCENTRATION
PRIME
SANITIZER
CONCENTRATION
PRIME
RINSE
CONCENTRATION
9
STEP
WARNING: Electrical and plumbing
connections need to be made by a
licensed service person and comply
with all Federal, State and Local
Health, Electrical, Plumbing and
Safety codes.
GW-100 Carousel
Glasswasher
Quick Setup
Instructions
AUTO FILL TIMER
7
OVERFLOW
DRAIN TUBE
PRIMER
PUSH BUTTONS
9
ROCKER
SWITCH 10
CHEMICAL
STORAGE AREA
8
TUBE
STIFFENER
CHEMICAL
TUBING 8
Adjust auto-fill timer to 10 seconds to set
water level.
7
STEP
6
54
10
1
9
3
2
8
7
INPUT
INIT.
MAX
MIN
LOAD
3
2
1
72
The Spirit of Excellence
an Ali Group Company
an Ali Group Company
PN: 10130.39