CMA Dishmachines MODEL GL-C Specification sheet

PRIME
DETERGENT
CONCENTRATION
PRIME
SANITIZER
CONCENTRATION
PRIME
RINSE
CONCENTRATION
FLUSH
OFF
ON
HEATER THERMOSTAT
GL-C FRONT VIEW
GW-100 FRONT VIEW
12-2014
POWER BLOCK
1
POWER SWITCH
5
6
THERMOMETER
DRAIN CONNECTION
3
GL-C/220V
GW-100/110V
Carousel
Glasswasher
Quick Setup
Instructions
LEVELING LEGS
4
1
STEP
Connect the drain hose to the FLOOR DRAIN. If
floor drain is not available connect to the wall. Floor
drain must have a (1 inch) air gap between the drain
hose and the floor drain.
Adjust heater thermostat to 140F.
Connect water lines (hot 140F/160F) and (cold
75F) to water solenoid valves.
Flip power "on-off/flush" switch to "ON" position.
Wash tank will automatically fill.
Connect L1 and L2 (N) leads to the power block
and one ground.
4
STEP
PRIME
RINSE
CONCENTRATION
FLUSH
OFF
ON
Level dishmachine by adjusting leveling legs.
Dishmachine must be level front and back to
ensure proper performance.
GROUND
L2 (N)
L1
2
STEP
5
STEP
6
STEP
140
3
STEP
FLOOR
DRAIN
1"AIR GAP
WALL
DRAIN
WARNING: Electrical and plumbing
connections need to be made by a
licensed service person and comply
with all Federal, State and Local
Health, Electrical, Plumbing and
Safety codes.
6
800-854-6417
DISHMACHINES
HOT WATER
INLET 2
COLD WATER
INLET 2

PRIME
DETERGENT
CONCENTRATION
PRIME
SANITIZER
CONCENTRATION
PRIME
RINSE
CONCENTRATION
FLUSH
OFF
ON
10
STEP
PRIME
DETERGENT
CONCENTRATION
PRIME
SANITIZER
CONCENTRATION
PRIME
RINSE
CONCENTRATION
FLUSH
OFF
ON
GL-C FRONT VIEW
7-2012
Insert tube stiffener with chemical tubing into
corresponding chemical dispensers.
Adjust auto-fill timer to set water level. Push each of the chemical prime buttons and
hold until the chemical feed tubes are full.
Start conveyor by flipping rocker switch to
"ON" position.
8
STEP
BLUE RED WHITE
CHEMICAL
STORAGE AREA
TUBE
STIFFENER
ROCKER
SWITCH
8
10
CHEMICAL
TUBING 8
OVERFLOW
DRAIN TUBE
PRIMER
PUSH BUTTONS
AUTO FILL TIMER
7
9
7
STEP
6
54
10
1
9
3
2
8
7
INPUT
INIT.
MAX
MIN
LOAD
3
2
1
72
3/4"
PRIME
DETERGENT
CONCENTRATION
PRIME
SANITIZER
CONCENTRATION
PRIME
RINSE
CONCENTRATION
9
STEP
WARNING: Electrical and plumbing
connections need to be made by a
licensed service person and comply with
all Federal, State and Local Health,
Electrical, Plumbing and Safety codes.
800-854-6417
DISHMACHINES
Available Option: Drain tray and waste
collector. (Recommended)
DRAIN TRAY AND
WASTE COLLECTOR
GL-C/220V
GW-100/110V
Carousel
Glasswasher
Quick Setup
Instructions
12-2014