Coleman 9921B Series User manual

Propane Grill Stoves
INSTRUCTIONS FOR USE
Covered by one or more of the
following U.S. Patents:
D412,808; D450,976; and D469,298.
© 2004 The Coleman Company, Inc.
www.coleman.com
IMPORTANT
Read this manual carefully before assembling, using or servic-
ing these stoves. Keep this manual for future reference. If you
have questions about assembly, operation, servicing or repair
of these stoves, please call Coleman at 1-800-835-3278 or
TDD: 316-832-8707. In Canada call 1-800-387-6161.
Model 9921B Series
ANS Z21.72b-CSA 11.2b (2002) Camp Stove
CERTIFIED
®®

2
Contents
General Safety Information
To Set Up
To Light
To Turn Off
To Clean
To Store
Things You Should Know
Parts List
Warranty
General Safety Information
If you smell gas:
1. Do not attempt to light appliance.
2. Extinguish any open flame.
3. Disconnect from fuel supply.
FOR YOUR SAFETY
Do not store or use gasoline or
other liquids with flammable vapors
in the vicinity of this or any other
appliance.
FOR YOUR SAFETY
This manual contains important information about
the assembly, operation and maintenance of these
propane stoves. General safety information is pre-
sented in these first few pages and is also located
throughout the manual. Particular attention should
be paid to information accompanied by the safety
alert symbol “ DANGER”, “ WARNING”,
“ CAUTION”.
Keep this manual for future reference and to edu-
cate new users of this product.This manual should
be read in conjunction with the labeling on the
product.
Safety precautions are essential when any
mechanical or propane fueled equipment is
involved.These precautions are necessary when
using, storing, and servicing. Using this equipment
with the respect and caution demanded will reduce
the possibilities of personal injury or property
damage.
The following symbols shown below are used
extensively throughout this manual. Always heed
these precautions, as they are essential when
using any mechanical or propane fueled equip-
ment.
CARBON MONOXIDE HAZARD
• This appliance can produce
carbon monoxide which has no
odor.
• Using it in an enclosed space
can kill you.
• Never use this appliance in an
enclosed space such as a camper,
tent, car or home.
DANGER

3
General Safety Information cont.
• EXPLOSION - FIRE HAZARD
• Never store propane near high heat, open flames, pilot lights, direct
sunlight, other ignition sources or where temperatures exceed 120
degrees F (49°C).
• Propane is heavier than air and can accumulate in low places. If you
smell gas, leave the area immediately.
• Never install or remove propane tank while outdoor stove is lighted,
near flame, pilot lights, other ignition sources or while outdoor stove is
hot to touch.
• During operation, this product can be a source of ignition. Never use
the stove in spaces that contain or may contain volatile or airborne com-
bustibles, or products such as gasoline, solvents, paint thinner, dust parti-
cles or unknown chemicals. Minimum clearances from combustible mate-
rials: 12 inches from the sides & 48 inches from the top.
• Do not obstruct the flow of combustion or ventilation air.
Not for home or recreational vehicle use.
WARNING
We cannot foresee every use which may be made of our products.
Check with your local fire safety authority if you have questions
about use.
Other standards govern the use of fuel gases and heat producing prod-
ucts for specific uses.Your local authorities can advise you about these.
• Never refill disposable cylinders.
• Use the preset regulator that came with the stove. Do not attempt to
adjust.
DANGER
DANGER
DANGER indicates an imminently hazardous situation which, if not
avoided, will result in death or serious injury.
WARNING
WARNING indicates a potentially hazardous situation which, if not
avoided, could result in death or serious injury.
CAUTION
CAUTION indicates a potentially hazardous situation which, if not
avoided, may result in minor or moderate personal injury, or property
damage.
Failure to comply with the precautions and instructions provided with
these stoves can result in death, serious bodily injury and property loss or
damage from hazards of fire, explosion, burn, asphyxiation, and/or carbon
monoxide poisoning.
Only persons who can understand and follow the instructions should use
or service these stoves.
If you need assistance or information such as an instruction manual or
labels, contactThe Coleman Company, Inc.
DANGER

4
General Safety Information cont.
• BURN HAZARD
• Never leave stove unattended when hot or in use.
• Keep out of reach of children.
WARNING
CALIFORNIA PROPOSITION 65:
WARNING:This fuel, and byproducts of combustion of this fuel,
contain chemicals known to the state of California to cause cancer,
birth defects, or other reproductive harm.
WARNING
• This product is fueled by propane gas. Propane gas is invisible, odorless,
and flammable. An odorant is normally added to help detect leaks and can
be described as a ”rotten egg” smell.The odorant can fade over time so
leaking gas is not always detectable by smell alone.
• Propane gas is heavier than air and leaking propane will sink to the lowest
level possible. It can ignite by ignition sources including matches, lighters,
sparks or open flames of any kind many feet away from the original leak.
Use only propane gas set up for vapor withdrawal.
• Propane gas should be stored or used in compliance with local ordinances
and codes or with ANSI/NFPA 58. Turn off propane when not in use.
DANGER
• CARBON MONOXIDE HAZARD
• This stove is a combustion appliance. All combustion appliances produce
carbon monoxide (CO) during the combustion process.This product is
designed to produce extremely minute, non-hazardous amounts of CO if
used and maintained in accordance with all warnings and instructions. Do
not block air flow into or out of the stove.
• Carbon Monoxide (CO) poisoning produces flu-like symtoms, watery eyes,
headaches, dizziness, fatigue and possibly death.You can't see it and you
can't smell it. It's an invisible killer. If these symptoms are present during
operation of this product get fresh air immediately!
• For outdoor use only.
• Never use inside house, camper, tent, vehicle or other unventilated or
enclosed areas.This stove consumes air (oxygen). Do not use in unven-
tilated or enclosed areas to avoid endangering your life. • SERVICE SAFETY
• Keep all connections and fittings clean. Inspect propane cylinder and
stove propane connections for damage before attaching.
• During set up, check all connections and fittings for leaks using
soapy water. Never use a flame. Bubbles indicate a leak.Check that
the connection is not cross-threaded and that it is tight. Perform anoth-
er leak check.If there is still a leak, remove the cylinder and contact
Coleman for service or repairs.
• Use as a cooking appliance only. Never alter in any way or use with
any device or part not expressly approved by Coleman.
• Clean stove frequently to avoid grease accumulation and possible
grease fires.
CAUTION

5
To Set Up
DANGER
• CARBON MONOXIDE HAZARD
• For outdoor use only.
• Never use inside house, camper, tent, vehicle or other unventilated or
enclosed areas.This stove consumes air (oxygen). Do not use in unventilated or
enclosed areas to avoid endangering your life.
Note: Use Coleman 16.4 oz dispos-
able propane cylinders.The LP-gas
cylinders(s) used with stoves must
be constructed and marked in
accordance with the specifications
for LP-gas cylinders of the U.S.
Department of Transportation or
Transport Canada, CAN/CSA B339.
■ For outdoor use only.
■ Remove components from carton.
■ Install components as shown.
■ Position WINDGUARDS as
desired.
■ Install DRIP TRAY as shown.
■ Remove plastic cap from top of
propane cylinder and screw
propane cylinder into REGULATOR
hand tight.
■ Make sure VALVES are off.
■ Screw REGULATOR into grill
stove hand tight.
CAUTION
• SERVICE SAFETY
Keep all connections and fittings
clean. Inspect propane cylinder and
stove propane connections for
damage before attaching.
During set up, check all connec-
tions and fittings for leaks using
soapy water. Bubbles indicate a
leak. Never use a flame.

6
To Light
DANGER
• EXPLOSION - FIRE HAZARD
• Propane is heavier than air and can accumulate in low places. If you smell
gas, leave the area immediately.
• Always attach or detach propane source outdoors; never while stove is lighted,
near flame, pilot lights, other ignition sources or while stove is hot to touch.
• This stove is red hot during use and can ignite flammables too close to the
burners. Keep flammables at least 12 inches from the sides and 48 inches from
the top of the stove. Keep gasoline and other flammable liquids and vapors well
away from stove.
INSTA Start ™
Electronic Ignition Model:
■ Set on sturdy, flat surface. For
outdoor use only.
■ Adjust flame with BURNER
VALVE.
■ Flame should be blue with hint of
yellow on tips.
Match Light Model:
■ Set on sturdy, flat surface. For
outdoor use only.
■Hold lighted match near BURN-
ER and open BURNER VALVE. Left
valve controls the grill, right valve
controls the stove.
■ Adjust flame with BURNER
VALVES.
■ Flame should be blue with hint of
yellow on tips.
■ Open BURNER VALVE com-
pletely until it clicks. If burner does
not light with first click, repeat pro-
cedure. Left valve controls the grill;
right valve controls the stove.

To Light cont. To Clean cont.
7
WARNING
• BURN HAZARD
• Never leave stove unattended when hot or in use.
• Keep out of reach of children.
To Turn Off To Clean
■ Close BURNER VALVES firmly. ■ Remove propane cylinder from
REGULATOR and replace plastic
cap on cylinder.
■ Remove REGULATOR from
GRILL STOVE. ■ Wipe clean with soft cloth and mild dish detergent. Do not use
abrasives.
■ GRILL and DRIP TRAY are dish-
washer safe.
■ Be sure grill stove is cool and
PROPANE CYLINDER has been
removed.
■ Lift off GRILL GRATE & POT
SUPPORT.

8
Tips cont.
■ For storage or transport, drip tray
and regulator may be located below
grill.
■ Grill has a nonstick coating.
Use only nonmetallic utensils to
prolong life of nonstick coating.
■ If you desire, aluminum foil
may be used to ease clean up.
■ Be sure to provide hole in foil
for grease.
■ Lid is removable.Tilt forward and lift.
Things You Should Know
To Store
DANGER
• EXPLOSION - FIRE HAZARD
• Never store propane near high
heat, open flames, pilot lights, direct
sunlight, other ignition sources or
where temperatures exceed 120
degrees F (49°C).
• The cylinder must be disconnect-
ed when the lantern is in storage.
Tips
1. It is unsafe and illegal in some places to store or use propane cylinders of
greater than 1.14 kg (2.5 lbs) water capacity (approximately 1 lb. propane) in
occupied enclosures.
2.The usual storage areas for camping and picnic equipment are the base-
ment, attic, or garage.To avoid the accumulation of dust, cobwebs, etc., that
is common in these areas, place your stove in a plastic bag and seal it with a
rubber band.
3. For repair service call one of the numbers on the front cover for location of
your nearest Coleman Service Center. If a service center is not conveniently
located, attach to the product a tag that includes your name, address, day-
time telephone number and description of the problem. Carefully package
the product and send either by UPS or Parcel Post insured with shipping
and insurance prepaid to:
4. If not completely satisfied with the performance of this product, please
call one of the numbers listed on the cover of this manual.
For products purchased in the
United States:
The Coleman Company, Inc.
3600 North Hydraulic
Wichita, KS 67219
For products purchased in Canada:
Sunbeam Corporation (Canada) Limited
5975 Falbourne Street
Mississauga, Ontario
Canada L5R 3V8

Parts List
No. Part No. Description
1 9910A1021 Lid Assembly
2 9921-3161 Pot Support
3 5430A3461 Burner Assy.
4 R430A565T Regulator Assembly
5 R413-149T Control Knob Assy (1 pk) (matchlight)
6 9920A1161 Drip Tray
7 9921-6281 Grill Burner
8 9920B3151 Grill Grate
9
1
4
2
8
5
3
7
6

Warranty
Limited Lifetime Warranty
The Coleman Company, Inc. (“Coleman”) warrants that for the period that you
own this product, it will be free from defects in material and workmanship.
Coleman, at its option, will repair or replace this product or any component of
the product found to be defective during the warranty period. Replacement will
be made with a new or remanufactured product or component. If the product is
no longer available, replacement may be made with a similar product of equal
or greater value.This is your exclusive warranty.
This warranty is valid for the original retail purchaser from the date of initial
retail purchase and is not transferable. Keep the original sales receipt. Proof of
purchase is required to obtain warranty performance. Coleman dealers, service
centers, or retail stores selling Coleman products do not have the right to alter,
modify or in any way change the terms and conditions of this warranty.
This warranty does not cover normal wear of parts or damage resulting from
any of the following: negligent use or misuse of the product, use on improper
voltage or current, use contrary to the operating instructions, disassembly,
repair or alteration by anyone other than Coleman or an authorized service
center. Further, the warranty does not cover Acts of God, such as fire, flood,
hurricanes and tornadoes.
COLEMAN SHALL NOT BE LIABLE FOR ANY INCIDENTAL OR CONSEQUENTIAL
DAMAGES CAUSED BY THE BREACH OF ANY EXPRESS OR IMPLIED WARRANTY
OR CONDITIONS. EXCEPT TO THE EXTENT PROHIBITED BY APPLICABLE LAW,
ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICU-
LAR PURPOSE IS LIMITED IN DURATION TO THE DURATION OF THE ABOVE WAR-
RANTY OR CONDITIONS. SOME STATES, PROVINCES, OR JURISDICTIONS DO
NOT ALLOW THE EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQUEN-
TIAL DAMAGES OR LIMITATIONS ON HOW LONG AN IMPLIED WARRANTY LASTS,
SO THE ABOVE LIMITATIONS OR EXCLUSION MAY NOT APPLY TO YOU. THIS
WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS, AND YOU MAY ALSO HAVE
OTHER RIGHTS THAT VARY FROM STATE TO STATE OR PROVINCE TO PROVINCE
.
HOW TO OBTAIN WARRANTY SERVICE
Take the product to an authorized Coleman service center.You can find the
nearest authorized Coleman service center by calling 1-800-835-3278 or TDD
316-832-8707 in the United States or 1 800 387-6161 in Canada. If a service
center is not conveniently located, attach to the product a tag that includes your
name, address, daytime telephone number and description of the problem.
Include a copy of the original sales receipt. Carefully package the product and
send either by UPS or Parcel Post insured with shipping and insurance pre-
paid to:
For products purchased in the United States:
The Coleman Company, Inc.
3600 North Hydraulic
Wichita, KS 67219
For products purchased in Canada:
Sunbeam Corporation (Canada) Limited
5975 Falbourne Street
Mississauga, Ontario
Canada L5R 3V8
Do not mail products with fuel in tanks, or with disposable propane
cylinders.
DO NOT RETURN THIS PRODUCT TO THE PLACE OF PURCHASE.
If you have any questions regarding this warranty please call
1-800-835-3278 or TDD 316-832-8707 in the United States or
1 800 387-6161 in Canada.
10