Coleman INSTASTART 9966 Series User manual

SHEET 1 OF 1
Wichita, Kansas USA 67219
The Coleman Company, Inc.
COMPOSITE- NO
CRITICAL DIMENSION
cm3
REV.
MATERIAL:
SEE NOTES
SEE NOTES
1:1 24-SEP-14
Black
Program: InDesign CS6
Christine Z.
INSTRUCTION MANUAL
Daniel Y.
01
4010038506
SCALE:
NAME:
DATE: DRAWN BY: APPROVED BY: REVISION
FINISH
SPEC.:
DATE NAME ECN NO. MODIFICATIONS
grams
g/cm3
This drawing contains proprietary information and trade secrets of The Coleman Company, Inc.
Unauthorized use or copying is prohibited.
METRIC
[INCH]
CHECKING IS COMPULSORY
VOLUME 01 24-SEP-14 Christine Z. 20041626NEW
MASS
DENSITY
GENERAL TOLERANCES
EXCEPT AS NOTED
0 TO 6mm = ±0.1
>6 TO 30mm = ±0.2
>30 TO 80mm = ±0.3
>80 TO 180mm = ±0.4
>180mm = ±0.5
ANGULAR = ± 3°
PAR T
NO.:
DO NOT PRINT THIS PAGE
Printing Notes:
Material: 80 GSM Bond Paper or 50# Bond Paper White
Ink: Black
Resolution: 150 DPI or above
Printing method: Offset Printing
Binding: Saddle Stitch
Folded size: 4 x 8.5 in (W x H)

IMPORTANT
Read this manual carefully before assembling, using or servicing
these stoves. Keep this manual for future reference. If you have
questions about assembly, operation, servicing or repair of
these stoves, please call Coleman at 1-800-835-3278 or TDD:
1-316-832-8707. In Canada call 1-800-387-6161.
IMPORTANT
Lisez attentivement ce manuel avant d’assembler, d’utiliser ou
de réparer le réchaud et gardez-le pour référence ultérieure.
Pour toute question en ce qui concerne l’assemblage, le
fonctionnement, l’entretien ou la réparation, appelez Coleman
au 1-800-835-3278 ou ATS 1-316-832-8707 aux États-Unis et au
1-800-387-6161 au Canada.
Propane Stoves
Réchauds à propane
Instructions for use
Notice d’emploi
© 2014 The Coleman Company, Inc.
www.coleman.com
9966 Series
Camp Stove
Poêle de camping
INSTASTART™ Electronic Ignition
Allumage électronique
* Griddles are only available on certain models.
* Les plaques chauffantes ne sont disponibles
qu’avec certains modèles.

English-1
If you smell gas:
1. Do not attempt to
light appliance.
2. Extinguish any
open flame.
3. Disconnect from
fuel supply.
FOR YOUR
SAFETY
Do not store or use
gasoline or other liquids
with flammable vapors
in the vicinity of this or
any other appliance.
FOR YOUR
SAFETY
CARBON MONOXIDE
HAZARD
• This appliance can
produce carbon
monoxide which has
no odor.
• Using it in an enclosed
space can kill you.
• Never use this
appliance in an
enclosed space such as
a camper, tent, car or
home.
DANGER WARNING
WARNING indicates a potentially hazardous
situation which, if not avoided, could result
in death or serious injury.
DANGER
DANGER indicates an imminently hazardous
situation which, if not avoided, will result in
death or serious injury.
This manual contains important information
about the assembly, operation and maintenance
of this outdoor propane appliance. General
safety information is presented on this page and
is also located throughout these instructions.
Particular attention should be paid to
information accompanied by
the safety alert symbol “ DANGER”,
“ WARNING”, “ CAUTION”.
Keep this manual for future reference
and to educate new users of this product. This
manual should be read in conjunction with the
labeling on the product.
Safety precautions are essential when any
mechanical or propane fueled equipment is
involved. These precautions are necessary
when using, storing, and servicing. Using
this equipment with the respect and caution
demanded will reduce the possibilities of personal
injury or property damage.
The following symbols shown below are used
extensively throughout these instructions. Always
heed these precautions, as they are essential
when using any mechanical or propane
fueled equipment.
CALIFORNIA PROPOSITION 65:
WARNING: This fuel, and by products of
combustion of this fuel, contain chemicals
known to the state of California to cause cancer,
birth defects, or other reproductive harm.
CAUTION
CAUTION indicates a potentially hazardous
situation which, if not avoided, may result in
minor or moderate personal injury, or
property damage.
Failure to comply with the precautions and
instructions provided with these stoves can
result in death, serious bodily injury and
property loss or damage from hazards of fire,
explosion, burn, asphyxiation, and/or carbon
monoxide poisoning.
Only persons who can understand and follow
the instructions should use or service
these stoves.
If you need assistance or information such
as an instruction manual or labels, contact
The Coleman Company, Inc.
DANGER

English-2
• This product is fueled by propane gas.
Propane gas is invisible, odorless, and
flammable. An odorant is normally added
to help detect leaks and can be described
as a ”rotten egg” smell. The odorant can
fade over time so leaking gas is not always
detectable by smell alone.
• Propane gas is heavier than air and leaking
propane will sink to the lowest level possible.
It can ignite by ignition sources including
matches, lighters, sparks or open flames of
any kind many feet away from the original
leak. Use only propane gas set up for
vapor withdrawal.
• Propane gas should be stored or used in
compliance with local ordinances and codes
or with ANSI/NFPA 58. Turn off propane when
not in use.
WARNING
DANGER
• EXPLOSION - FIRE HAZARD
• Never store propane near high heat, open
flames, pilot lights, direct sunlight, other
ignition sources or where temperatures
exceed 120 °F (49 °C).
• Propane is heavier than air and can
accumulate in low places. If you smell gas,
leave the area immediately.
• Never install or remove propane tank while
outdoor stove is lighted, near flame, pilot
lights, other ignition sources or while outdoor
stove is hot to touch.
• During lighting and operation, this product
can be a source of ignition. Never use
the stove in spaces that contain or may
contain volatile or airborne combustibles,
or products such as gasoline, solvents,
paint thinner, dust particles or unknown
chemicals. Minimum clearances from
combustible materials: 12 inches from the
sides and 48 inches from the top.
• Provide adequate clearances around air
openings into the combustion chamber.
WARNING
Not for home or recreational vehicle use.
We cannot foresee every use which may be
made of our products.
Check with your local fire safety authority if
you have questions about use.
Other standards govern the use of fuel gases
and heat producing products for specific
uses. Your local authorities can advise you
about these.
• Never refill disposable cylinders.
• Use the preset regulator that came with
the stove. Do not attempt to adjust.
• Use only Coleman®accessories or parts.
During stove set-up, check all fittings
for leaks using soapy water. Never use
a flame.
WARNING
• BURN HAZARD
• Never leave stove unattended when
hot or in use.
• Keep out of reach of children.
DANGER
• CARBON MONOXIDE HAZARD
• This stove is a combustion appliance. All
combustion appliances produce carbon
monoxide (CO) during the combustion
process. This product is designed to
produce extremely minute, non-hazardous
amounts of CO if used and maintained
in accordance with all warnings and
instructions. Do not block air flow into or out
of the stove.
• Carbon Monoxide (CO) poisoning produces
flu-like symptoms, watery eyes, headaches,
dizziness, fatigue and possibly death.
You can’t see it and you can’t smell it. It’s
an invisible killer. If these symptoms are
present during operation of this product get
fresh air immediately!
• For outdoor use only.
• Never use inside house, camper, tent,
vehicle or other unventilated or enclosed
areas. This stove consumes air (oxygen).
Do not use in unventilated or enclosed
areas to avoid endangering your life.
CAUTION
• SERVICE SAFETY
• Keep all connections and fittings clean.
Inspect propane cylinder and stove propane
connections for damage before attaching.
• During set up, check all connections and
fittings for leaks using soapy water. Never
use a flame. Bubbles indicate a leak. Check
that the connection is not cross-threaded
and that it is tight. Perform another leak
check. If there is still a leak, remove the
cylinder and contact Coleman for service
or repairs.
• Use as a cooking appliance only. Never
alter in any way or use with any device or
part not expressly approved by Coleman.
• Clean stove frequently to avoid grease
accumulation and possible grease fires.

English-3
To Set Up
Technical
Characteristics
Input: 12,000 BTU/H
Category: Pressure regulated propane
Fuel: 16.4 oz. disposable propane cylinders
Regulator: 5430
DANGER
• CARBON MONOXIDE HAZARD
• For outdoor use only.
• Never use inside house, camper, tent,
vehicle or other unventilated or enclosed
areas. This stove consumes air (oxygen). Do
not use in unventilated or enclosed areas to
avoid endangering your life.
NOTE: Use Coleman®16.4 oz. disposable
propane cylinders. The LP-gas cylinder(s)
used with stoves must be constructed and
marked in accordance with the specifications
for LP-gas cylinders of the U.S. Department of
Transportation or Transport Canada,
CAN/CSA B339.
■Remove components from carton. (Fig. 1)
■Assemble Lid Stopper to stove. (Fig. 3)
Fig. 2
■To open the lid, move the handle slightly
to the “ ” location. Pull the latch hook
panel out and push it upwards right
above the handle to release. (Fig. 2)
Fig. 1
Regulator
Wind Shield
Pan Support
Stove
■Control Knob Identification (Fig. 6)
Fig. 4
Fig. 5
■Install Wind Shield Pan Support as shown
(Fig. 4). Please place cooking pot / pan
directly on the the Pan Supports.
■OPTIONALally, you may install the
griddles as shown. (Fig. 5)
Fig. 3
Lid stopper
■NOTE: The handle can’t be pulled
down fully.
■NOTE: Don’t use griddle without
Wind Shield Pan Support .
Fig. 6
Right
Burner
Valve
Igniter
Button
Left
Burner
Valve
NOTE TO PREVENT DAMAGE WHICH
WILL VOID THE WARRANTY:
• Do not use pots, pans, ovens, etc., on this
griddle surface.
• Do not use this griddle on a campfire or
other open fire.
• Use this griddle only on the Coleman®
stove for which it was designed.
OPTIONAL
OPTIONAL
OPTIONAL
Griddle
* Griddles are only available on certain models.

English-4
Fig. 11
■Propane cylinder correctly installed.
(Fig. 10)
■Never operate stove with propane
cylinder in an inverted position. (Fig. 11)
Fig. 8 Fig. 9
■Screw regulator into stove hand tight.
(Fig. 8)
■Remove plastic cap from top of propane
bottle and screw propane bottle into
regulator hand tight. (Fig. 9)
Fig. 10
WARNING
• Perform leak test outdoors.
• Extinguish all open flames.
• NEVER leak test when smoking.
• Do not use the outdoor stove until
connection has been leak tested and does
not leak.
Leak Check
WARNING
• BURN HAZARD
• Never leave stove unattended when
hot or in use.
• Keep out of reach of children.
To Light
DANGER
• EXPLOSION - FIRE HAZARD
• Propane is heavier than air and can
accumulate in low places. If you smell gas,
leave the area immediately.
• Always attach or detach propane source
outdoors; never while stove is lighted, near
flame, pilot lights, other ignition sources or
while stove is hot to touch.
• This stove is red hot during use and can
ignite flammables too close to the burners.
Keep flammables at least 12 inches from
the sides and 48 inches from the top of the
stove. Keep gasoline and other flammable
liquids and vapors well away from stove.
• The stove must not be exposed to
flammable vapors or liquids during lighting.
CAUTION
• SERVICE SAFETY
• Keep all connections and fittings clean.
Inspect propane cylinder and stove propane
connections for damage before attaching.
• During set up, check all connections and
fittings for leaks using soapy water. Bubbles
indicate a leak. Never use a flame.
■Close both burner valves firmly. (Fig. 7)
Fig. 7
OPTIONAL

INSTASTART™
Electronic Ignition Stoves
■Set on sturdy, flat surface. For outdoor
use only.
■Open burner valve and repeatedly push
igniter button until burner ignites. (Fig. 12)
■Repeat for both burners.
Note: If the igniter still fails to light stove,
use match to light burner. If the stove is
wet the igniter may not spark.
Fig. 12
Match Lighting
■Set on sturdy, flat surface. For outdoor
use only.
■Hold lighted match near burner and open
burner valve. (Fig. 13)
■Repeat for both burners.
Fig. 13
English-5
To Turn Off
■Adjust flame with burner valves.
(Fig. 14). Flame should be blue with a
hint of yellow on tips.
■Close the burner valves firmly. (Fig. 15)
Fig. 15
To Clean
■Make sure stove is cool.
■Move stove away from flame (including
pilot lights) and other ignition sources.
■Remove propane cylinder from
regulator and replace protective cap on
cylinder. (Fig. 16)
■Remove regulator from stove. (Fig. 17)
• MAINTENANCE
• Keep stove area clear and free from
combustible materials, gasoline and other
flammable vapors and liquids.
• Do not obstruct the flow of combustion and
ventilation air.
• A good flame should be blue with minimal
yellow tip. Some yellow tips on flames are
acceptable as long as no carbon or soot
deposits appear.
• Wipe clean with soft cloth and mild dish
detergent. Do not use abrasives. (Fig. 18)
Fig. 18
Fig. 17
Fig. 14
Fig. 16
■Make sure stove and griddle are cool.
■Wipe clean with soft cloth and mild
dish detergent. Do not use abrasives
on the non-stick griddle surface.
Cleaning the Griddle
* Griddles are only available on certain models.

English-6
Things You Should Know
1. It is unsafe and illegal in some places to
store or use propane cylinders of greater
than 1.14 kg (2.5 lbs) water capacity
(approximately 1 lb. propane) in
occupied enclosures.
2. The usual storage areas for camping and
picnic equipment are the basement, attic, or
garage. To avoid the accumulation of dust,
cobwebs, etc., that is common in these
areas, place your stove in a plastic bag and
seal it with a rubber band.
3. If not completely satisfied with the
performance of this product, please call one
of the numbers listed on the cover of
this manual.
www.coleman.com
DANGER
• EXPLOSION - FIRE HAZARD
• Never store propane near high heat, open
flames, pilot lights, direct sunlight, other
ignition sources or where temperatures
exceed 120 degrees F (49 °C).
• The cylinder must be disconnected when
the stove is in storage.
To Store
■For storage or transport, the regulator
may be located between the Wind Shield
Pan Support . (Fig. 19)
■Place the griddle on the Wind Shield
Pan Support .
Fig. 19
Fig. 20
■Secure the lid latch.
■To carry the stove, firmly grasp the stove
by the handle. (Fig. 20)
* Griddles are only available on certain models.
OPTIONAL

English-7
Warranty
Parts List
ACCESSARIES
Limited Three Year Warranty
The Coleman Company, Inc. (“Coleman”) warrants that
for a period of three (3) years from the date of original retail
purchase, this product will be free from defects in material and
workmanship. Coleman, at its OPTIONAL, will repair or replace
this product or any component of the product found to be
defective during the warranty period. Replacement will be made
with a new or remanufactured product or component. If the
product is no longer available, replacement may be made with a
similar product of equal or greater value. This is your
exclusive warranty.
This warranty is valid for the original retail purchaser from the
date of initial retail purchase and is not transferable. Keep the
original sales receipt. Proof of purchase is required to obtain
warranty performance. Coleman dealers, service centers, or
retail stores selling Coleman
®
products do not have the right to
alter, modify or in any way change the terms and conditions of
this warranty.
What This Warranty Does Not Cover
This warranty does not cover normal wear of parts, parts
that are not genuine Coleman
®
parts, or damage resulting from
any of the following: negligent use or misuse of the product;
commercial use of the product; use contrary to the operating
instructions; disassembly, repair or alteration by anyone other
than Coleman or an authorized service center. Further, the
warranty does not cover Acts of God, such as fire, flood,
hurricanes and tornadoes. Warranty void if damage to the
product results from the use of a part other than a genuine
Coleman
®
part.
COLEMAN SHALL NOT BE LIABLE FOR DEFECTS THAT
ARE CAUSED BY THE USE OF UNAUTHORIZED PARTS OR
SERVICE. COLEMAN SHALL NOT BE LIABLE FOR ANY
INCIDENTAL OR CONSEQUENTIAL DAMAGES CAUSED BY
THE BREACH OF ANY EXPRESS OR IMPLIED WARRANTY
OR CONDITIONS. EXCEPT TO THE EXTENT PROHIBITED BY
APPLICABLE LAW, ANY IMPLIED WARRANTY OF
MERCHANTABILITY OR FITNESS FOR A PARTICULAR
PURPOSE IS LIMITED IN DURATION TO THE DURATION
OF THE ABOVE WARRANTY OR CONDITIONS. SOME
STATES, PROVINCES, OR JURISDICTIONS DO NOT ALLOW
THE EXCLUSION OR LIMITATION OF INCIDENTAL OR
CONSEQUENTIAL DAMAGES OR LIMITATIONS ON HOW
LONG AN IMPLIED WARRANTY LASTS, SO THE ABOVE
LIMITATIONS OR EXCLUSION MAY NOT APPLY TO YOU.
THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS, AND
YOU MAY ALSO HAVE OTHER RIGHTS THAT VARY FROM
STATE TO STATE OR PROVINCE TO PROVINCE.
How to Obtain Warranty Service
Your product must be under warranty in order to obtain
warranty service. If your product is defective and is within your
warranty period, contact us at 1-800-835-3278
(TDD 1-316-832-8707) in order to receive a return authorization.
Do not return product to Coleman without authorization.
You will be directed to attach a tag to the product that
includes your name, address, daytime telephone number and
description of the problem. Include a copy of the original sales
receipt. Carefully package the product and send insured
by UPS, FedEx Ground or Parcel Post with shipping and
insurance prepaid to:
For products purchased in the United States:
The Coleman Company, Inc.
3600 North Hydraulic
Wichita, KS 67219 U.S.A.
For products purchased in Canada:
Sunbeam Corporation (Canada) Limited
DBA Jarden Consumer Solutions
20B Hereford Street
Brampton, ON L6Y 0M1
The cost of transporting the product to Coleman for warranty
service is the responsibility of the purchaser.
Do not mail products with fuel in tanks, or with disposable
propane cylinders.
DO NOT RETURN THIS PRODUCT TO THE PLACE OF
PURCHASE.
If you have any questions regarding this warranty please call
1-800-835-3278 or TDD 1-316-832-8707 in the United States or
1-800-387-6161 in Canada.
No. Part Number Description
Replacement Parts:
1. 5010002508 Wind Shield Pan Support
- Hyperflame
2.
R430B565T Regulator Assembly
3. 5010002509 Handle Assy - 9966 Models
4. 5010002507 Knob - 9966 Models
No. Part Number Description
5. 2000017528 Griddle
1
5
34
2
OPTIONAL

Français-1
Que faire si vous sentez
une odeur de gaz :
1. Ne pas tenter d’allumer
d’appareils.
2. Éteindre toute flamme.
3. Couper l’alimentation
en gaz à la source.
POUR VOTRE
SÉCURITÉ
Ne pas entreposer ni
utiliser d’essence ni
d’autres vapeurs ou
liquides inflammables à
proximité de cet appareil
ou de tout autre appareil.
POUR VOTRE
SÉCURITÉ
MONOXYDE DE
CARBONE
• Cet appareil peut
produire du monoxyde de
carbone, un gaz inodore.
• L’utilisation de cet
appareil dans des
espaces clos peut
entraîner la mort.
• Ne jamais utiliser cet
appareil dans un epace
clos comme un véhicule
de camping, une tente,
une automobile ou
une maison.
DANGER
Ce manuel contient des renseignements
importants quant à l’assemblage, au
fonctionnement et à l’entretien de cet appareil
à propane destiné au plein air. De nombreux
renseignements de sécurité sont fournis tout au
début du manuel puis un peu partout dans le
reste du manuel. Faites tout parti-culièrement
attention lorsque vous voyez les symboles
suivants:
DANGER, AVERTISSEMENT et
ATTENTION.
Gardez ce manuel pour le consulter au besoin et
pour apprendre aux nouveaux utilisateurs à em-
ployer l’appareil. Le manuel devrait être compulsé
de concert avec les étiquettes apposées sur
le produit.
Des précautions de sécurité sont indispensables
en présence de tout appareil mécanique ou à gaz
propane. Des précautions sont nécessaires pour
l’utilisation, le rangement et l’entretien. Utiliser
cet appareil avec tous les soins qui lui sont dus
réduira les risques de blessures corporelles ou de
dommages matériels.
Les symboles illustrés ci-après sont
régulièrement employés dans le manuel. Tenez
compte de ces précautions impératives lors de
l’utilisation de tout appareil mécanique ou à
gaz propane.