COMPANION PB01 User manual

Part No. PB01
PORTABLE PIZZA OVEN
INSTRUCTION MANUAL
IMPORTANT
Read these instructions
for use carefully.
Familiarise yourself
with the appliance
before connecting it
to its gas container.
Keep these instructions
for future reference.
AS 2658:2008
Cert. GSCS20258
SAI Global

GENERAL WARNINGS
• This appliance shall only be used with the regulator supplied with the appliance
and can be connected to a non-refillable 468g disposable propane cartridge
certified to DOT-39, UN1075 or using an AGA or SAIGlobal certified LP Gas hose
to POL or 3/8” LH cylinder certified to AS 2469.
• This appliance is to be stored in a dry and well ventilated location free from
direct sunlight. Do not store when still connected to the cartridge. Make sure
that the cartridge is disconnected and is stored in a well ventilated area, free
from direct sunlight, heat and ignition sources. If being stored indoors, ensure
that the location complies with the standard AS/NZS1596.
• This appliance must be inspected regularly for correct operation and for any
wear and tear that could result in a gas leak or incorrect operation. If any
symptoms or incorrect operation are observed contact customer service and
present the appliance to an Authorised Service Agent for repair.
DANGER!
• During operation all surfaces will be extremely hot and should not be touched
or handled.
• Do not use the appliance if it has a leak, worn, deteriorated or damaged seals.
• Handle with care even after brief use.
• It may be hazardous to attempt to fit other types of gas containers or cartridges.
• Use only in well ventilated areas.
• OUTDOOR USE ONLY – The appliance must be used outdoors only and is to
be operated no closer than 1000mm from the sides and 1000mm from above
all combustible surfaces, fabrics and flammable materials. Must only be used
on solid and stable horizontal surfaces made from non-combustible or non-
flammable materials and should be protected from direct drafts and in a well
ventilated place.
• Do not use adaptors or modify appliance to fit other connectors or cylinders.
• Children must be supervised by an adult at all times.
• Never leave appliance unattended when operating.
• Use as a cooking appliance only, is not to be used as heater or modified for any
other reason.
• To be used with propane (LP Gas) only.
CARBON MONOXIDE HAZARD
• This appliance produces carbon monoxide which has no odour. Using the appliance
in enclosed spaces, such as caravan, car, boat or mobile home could cause DEATH.
IMPORTANT
• Keep away from children at all times.
• Take care the openings at the side and rear of the appliance are not obstructed,
or that air flow is restricted by placing items or other appliances close to or
adjacent to openings.
• Do not build this appliance into a cavity or enclosure.
• This appliance is not designed to be used indoors or marine applications and/or
in areas that maybe subject to wind, rain or salt air.
• Surfaces of the appliance will become hot during operation, please take care
when handling or moving the appliance.
• Appliance is to be used on a stable, level, flat non-flammable surface, the
appliance should be protected from direct drafts and in a well ventilated place.
• If you smell gas, immediately turn the appliance off and move to a well
ventilated area outside, keeping well away from sources of heat such as naked
flames and pilot lights.
• Do not attempt to move or relocate the appliance when it is operating,
extinguish the burner and allow to cool, disengage the gas cartridge then
move the appliance.
• During operation if the appliance produces an unusual smell, gas can be smelt
or the flame can be seen outside of the covered burner section in the base of the
appliance, turn the unit off and locate in a well ventilated area. Do not repair or
remove covers - take the appliance to an Authorised Service Agent.
CHECKING FOR GAS LEAKS
• Check that all connections are tight and that the gas connection has been
tightened before you turn the appliance on.
• NEVER check for leaks with a flame or pilot light.
• Using soapy water, coat all connections, if bubbles appear turn the gas control
off and retighten the connection before re-testing.
• Inspect the appliance regularly for signs of wear, leaks or incorrect operation.
If symptoms such as flaring of the burners, issues with lighting, damage to
connections or leaks from seals or gas controls are identified, do not attempt to
repair, return to your authorised stockist for service and maintenance.
• To check if gas remains in the cartridge, disconnect from the appliance and hold
in a vertical position then shake from side to side, if there is a sound or feel of
liquid movement inside, the cartridge contains gas.
• When changing gas cartridges ensure this is conducted outside in a well
ventilated location free from people, animals and ignition sources such as
naked flames, pilot lights and electrical equipment with heaters or elements.
SAFETY INSTRUCTIONS
This appliance must only be used
in an above ground open air
situation with natural ventilation,
without stagnant areas, where
gas leakage is rapidly dispersed
by wind and natural convection.
Any enclosure in which the
appliance is used should comply
with one of the following:
(A) An enclosure with walls on
all sides, but with no
overhead cover.
(B) Within a partial enclosure
that includes an overhead
cover and no more than
two walls.
1

(C) Within a partial enclosure
that includes an overhead
cover and more than two
walls, the following must
apply:
(1) At least 25% of the total
wall area is completely open.
(2) 30% or more in total of the
remaining wall side, back
and front wall areas is open
and unrestricted.
(3) In the case of balconies,
20% or more of the total
wall area must remain open
and unrestricted.
OPERATING THE APPLIANCE
1. Thermometer
2. Oven Control/Ignition Knob
3. Oven Shelf
4. Pizza Stone
5. Oven Rack
6. Pre Heat Cover
7. Gas Connection
8. Propane
BOM Cartridge
(sold separately)
9. Regulator
ASSEMBLY
• Remove all protective packaging from the appliance
and parts.
• Insert the Oven Rack
• Fit Oven Shelf, ensuring the cutouts shown fit over the
screws on the opening of the oven
• Insert the Pizza Stone, ensuring the raised walls are at
sides and rear
CONNECTION
Your oven is designed to connect directly to a gas cartridge
using the specially designed LP gas regulator supplied
with the appliance.
• Check that the control knob is in the “off” position (turned
fully clockwise.)
• Take the regulator and attach to the gas inlet on the rear
of the appliance, tighten using fingers.
• Attach gas cartridge to regulator.
• Check connections for leaks with soapy water, if a leak
is detected, retighten all connections and then retest.
LIGHTING OVEN
• Make sure the Control Knob is set to the “OFF” position.
• Depress and turn the Control Knob anti-clockwise until a
“click” sound is heard, check that the burner is now alight
if so hold the ignition knob in for 10 to 15 seconds then
release.
• If the burner does not stay alight, turn the Control Knob
to the “OFF” position and wait for 5 minutes before
attempting to relight the burner.
ADJUSTING TEMPERATURE*
• Turn the Control Knob in an anti-clockwise direction
to achieve a higher temperature and in a clockwise
direction for a lower temperature.
• The thermometer on the roof of the appliance provides
an indication of the internal temperature (not the
temperature of the cooking stone).
* When heating the oven, locate the pre-heat cover to close
off the oven and then remove after 5-10 minutes or when
oven has reached the desired temperature. Do not replace
until the oven has cooled after cooking.
TURNING THE APPLIANCE OFF
Turn the control knob clockwise to the “OFF” position.
1
1
2
2
7
8
1
2
3
4
5
6
9

Distributed by
Companion Brands
Bundoora Victoria 3083
www.companionbrands.com.au
Spare Part List
1PB01-01S Pizza Stone
2PB01-02S Thermometer
3PB01-03S Control Knob
4PB01-04S Regulator
5PB01-05S Legs
6PB01-06S Piezo
7 PB01-07S Thermo Coupler
8PB01-08S Pre-Heat Cover
9MH9BX-01S LP Gas Hose
Code PB01
Description Portable Pizza Oven
Size* 660 x 433 x 405mm
Weight* 18kg
*Excluding Regulator and Gas Cartridge
Gas Jet
Oven: 1.32mm
Consumption
Inlet Pressure: 2.75kPa
Oven : 20Mj/hr
414g/hr
A selection of spare parts and components are available
for your appliance to ensure years of operation:
WARRANTY
Our goods come with guarantees that cannot be excluded under the Australian
Consumer Law. You are entitled to a replacement or refund for a major failure and
compensation for any other reasonably foreseeable loss or damage. You are also
entitled to have the goods repaired or replaced if goods fail to be of acceptable
quality and the failure does not amount to a major failure.
For warranty and technical
support please visit
www.companionbrands.com.au
or call 1300 555 197
TECHNICAL DETAILS & SPARE PARTS CARE AND CLEANING INSTRUCTIONS
• Ensure that the appliance is not operating and is cool to touch –
internal and external surfaces.
• Do not remove any panels from the appliance.
• The cooking stone can be easily removed for cleaning. Clean using warm soapy
water with a mild detergent (do not use bleach).
• Never place the cooking stone in water when hot: the sudden change in
temperature will damage the stone.
• Clean external surfaces using warm, soapy water with a mild detergent
(do not use bleach).
• DO NOT submerge the appliance in a sink or bowl.
• DO NOT use abrasive cleaners or bleach.
COOKING TIPS
• Allow the oven to warm the stone before cooking the pizza. A hotter stone
produces a crispier crust.
• Sprinkle some semolina or polenta on the cooking stone to protect against dough
sticking to the stone.
• The stone will discolour and stain over time without affecting performance, but
any lumps of dough or topping should be removed or cleaned off.
• Never reach into the oven to remove the pizza by hand - the stone and oven will
be extremely hot. Instead, use a wooden or steel paddle. Avoid plastic utensils
which may melt onto the stone.