Core 40080 User manual
STITCH LINE
10 x 10 INSTANT CANOPY WITH SUN WALL
1
Extend Shelter Frame
CAUTION: Avoid pinch points when opening or closing the shelter frame.
• Expand and spread out SHELTER FRAME halfway.
(continued on other side)
Model No. 40080
Secure Canopy to Frame
• Locate HOOK & LOOP FASTENERS along the seam of the underside of the
CANOPY; then wrap around METAL BRACKET to secure.
• Repeat for remaining 3 sides of the shelter CANOPY.
Two people can easily setup this shelter in minutes. Raising Roof Support Brackets
• To finish expanding the frame, grasp the LEG POLE and push up on the
ROOF SUPPORT BRACKET until the GRAY BUTTON “clicks” into locked
position.
• Repeat for remaining 3 ROOF SUPPORT BRACKETS to fully raise the
ROOF PEAK.
3
Telescoping Steel Frame Legs
• Place foot on the LEG FOOT; then grasp and extend the TELESCOPING
LEG POLE until the LOCKING BUTTON “clicks” into locked position.
• Repeat for remaining 3 LEG POLES.
NOTE: When telescoping the legs, the LOCKING BUTTON will lock in the
lowest setting first. Push in the LOCKING BUTTON and extend the leg
further to desired shelter height.
4
Contents & Repair Parts:
Joint Endcap (2”)
#90685
Bracket Joint (1”) #91153
2
Attach Canopy
• Unfold CANOPY then drape over SHELTER FRAME with corners position-
ed over SHELTER LEGS.
• Locate HOOK & LOOP FASTENER on underside of the corner of the
CANOPY; then attach to material located at the top of the STEEL SHELTER
LEG.
• Repeat for remaining 3 corners of the CANOPY.
Shelter Leg
#91154
Center Hub #90682
Apex Support Pole
#90679
Upper Roof Pole #90681
Roof Joint #90683
Lower Roof Pole
#90680
STEEL SHELTER FRAME
Not Pictured:
Sun Wall #40104
Stakes #90674
Canopy Top #91499
Carry Bag #91500
Bracket Pole 40”
#90676A
Apex Joint #90684
STEEL SHELTER LEGS
CANOPY
UNDERSIDE
OF CANOPY
HOOK & LOOP
FASTENERS
STEEL
SHELTER LEG
GRAY
BUTTON
SUPPORT
BRACKET
ROOF PEAK
HOOK & LOOP
FASTENER
METAL BRACKET
3-Stage Height
Adjustability
LOW
HIGH
MEDIUM
LOCKING
BUTTON
LEG FOOT
5
Secure Canopy to Frame (continued)
• Position the shelter in its final position before securing with stakes and
guylines.
5
6
Attach Sun Wall
NOTE: The Sun Wall may be attached to any of the 4 sides of the Instant
Canopy.
• Clip J-HOOK located at each top corner of the Sun Wall onto the METAL
LOOP at the top of the LEG POLES. (Detail 1)
• Wrap J-HOOK and D-RING on STRAPS located at top of Sun Wall
around TOP FRAME to secure. (Detail 2)
• Wrap J-HOOK and D-RING on STRAPS located along one side of the
Sun Wall around LEG POLE to secure. (Detail 3)
• Clip one of the two J-HOOKS located near the bottom edge of the Sun
Wall into the hole in the lower LEG POLE. Use the lower J-HOOK (A)
when the LEG POLE is fully extended and J-HOOK (B) for lower LEG
POLE height setting. (Detail 4)
• Repeat above steps to secure other side of the Sun Wall.
• Place METAL STAKE through the WEB STRAP located at each bottom
corner and center of the Sun Wall then drive in to secure. (Detail 5)
12
3
A
B
4
5
Outside
Bracket
Pole
#90676B
IMPORTANT:
THE ORIGINAL FIRE RETARDANT AND WATER-REPELLENT PROTEC-
TIVE COATINGS MAY BE COMPROMISED IF SPRAYS OR OTHER CHEMI-
CAL TREATMENTS ARE USED ON THE SHELTER. FABRIC HAS BEEN
FACTORY TREATED. IT IS HIGHLY WATER-REPELLENT; HOWEVER, IT IS NOT
WATERPROOF. ALL SHELTERS CAN EXPERIENCE SEAM LEAKAGE DURING
WET WEATHER. IF YOU WANT ADDITIONAL MOISTURE PROTECTION, TRY
A SEAM SEALING COMPOUND ONLY; STRICTLY FOLLOW THE MANUFAC-
TURER’S DIRECTIONS. IT IS RECOMMENDED THAT YOU SEAL THE SHELTER
DURING THE INITIAL SETUP AS WELL AS PRIOR TO EACH CAMPING SEA-
SON. SEAM SEALER COMPOUNDS CAN BE PURCHASED AT YOUR LOCAL
CAMPING PRODUCTS OUTLET. FOR MISSING PARTS CALL 1-888-775-5628.
PLEASE DO NOT RETURN THIS PRODUCT TO THE RETAIL STORE.
Elevate LLC
Overland Park, KS 66221
Made in China • Printed in China
STITCH LINE
WARNING: Keep clear of overhead power lines.
• Do not set up your shelter under trees because of potential lightning strikes or
falling tree limbs in inclement weather.
• Secure with all stakes and guylines provided to prevent property damage or
personal injury.
• Never store shelter, even for a short period of time, without drying it thorough-
ly and brushing off caked dirt. Do not pack stakes inside your shelter. Use a
separate storage bag.
• STAKES SHOULD BE REMOVED BY PULLING ON THE STAKE ITSELF. NEVER
PULL ON THE SHELTER TO REMOVE STAKE.
• Do not leave your shelter set-up for weeks at a time. Be aware that exposure to
ultraviolet rays from the sun can seriously damage material and/or cause it to
become discolored.
WARNINGS & CAUTIONS:
WARNING: KEEP ALL FLAME AND HEAT SOURCES AWAY FROM THIS
SHELTER FABRIC
This shelter is made of flame-resistant fabric, which meets CPAI-84 specifica-
tions. IT IS NOT FIRE-PROOF. The fabric will burn if left in continuous contact
with any flame source. The application of any foreign substance to the product
fabric may render the flame-resistant properties ineffective.
DO NOT use fuel burning devices inside or near shelter materials.
DO NOT permit children to light matches, operate burning appliances or handle
any flame sources in or near the shelter.
• Do not smoke, use matches, candles or open flames of any kind in or near
the shelter.
• Do not refuel lanterns, stoves or heaters inside shelter.
• Do not cook inside shelter.
• Do not store flammable liquids inside shelter.
FREQUENTLY ASKED QUESTIONS:
• Are replacement parts available? Yes, please call Customer Service at
1-888-775-5628 for replacement parts. All parts can be replaced.
• Why are my shelter legs not locking into place? Be sure that the large gray
buttons are secure. Extend pole further if it is not locked. It will “click” into
place.
• How do I clean my canopy top and sun wall? Clean the canopy top and sun
wall with a soft sponge, mild soap and tepid water. Be sure to scrub gently
and remove all soap. Let dry in sunlight.
• Why is it difficult to extend the roof assembly on my frame? Be sure to
stretch the frame out fully and lock the roof assembly into place before rais-
ing the shelter legs.
• When should I attach the canopy fabric? Attach the canopy fabric after the
frame is expanded, before extending the roof assembly or shelter legs.
NOTE:
For long-term storage: Remove the CANOPY & store separately.
For short-term storage (1-2 weeks): It is acceptable to leave the CANOPY
attached to STEEL SHELTER FRAME.
Follow the previous steps and illustra-
tions on other side of this tag in the reverse order:
• Disconnect canopy CLIPS from 4 LEG POLES.
• Push the LOCKING BUTTONS and telescope down the 4 LEG POLES.
• Push the 4 GRAY BUTTONS to release the ROOF SUPPORT BRACKET.
• Fold CANOPY and put back into the bag.
• Fold up SHELTER FRAME and place into bag.
Storing the Shelter
• Remove stakes and place in their storage bag.
• All stakes must be placed in their own storage bag before placing in
carrying case to prevent damage to the shelter fabric.
• Store in a clean, dry area.
TAKE DOWN INSTRUCTIONS:
To Secure Shelter
• Locate FOOT at the bottom of each SHELTER LEG POLE (4 total).
• Slide STAKE through HOLE at each location.
• Locate GUYLINES attached to the shelter and unroll.
• Slide STAKE through loop at each location, extend out and drive in to secure.
NOTE: Extend four corner GUYLINES out at a 45º angle from shelter.
• Tighten GUYLINES as needed by adjusting the SLIDER up the cord.
7
FOOT
SLIDER
CORE®Equipment and Elevate LLC warrants for a period of one year from the original
date of purchase, this product against any defects in materials or workmanship. At its
discretion, CORE®Equipment may provide replacement parts to original purchaser. Original
receipt or proof of purchase as well as proof of defect in the form of a photograph or video
is required. CORE®Equipment will not be responsible for shipping costs incurred outside
the continental USA. Warranty is valid for the original purchaser one year from the date of
purchase and is not transferable.
This warranty does not cover any product purchased through unauthorized dealers/
distributors and/or unauthorized resellers on online auction websites. CORE®uses
approved and authorized distributors to furnish quality products, and CORE®provides
warranty coverage only on products purchased from those distributors. If the product was
purchased from an unauthorized reseller, this warranty does not apply. Unauthorized resell-
ers may sell products that are used, defective, counterfeit, or which may not be designed
for use in that specific country. To determine whether the seller of a CORE®Equipment
product is one that has been approved and authorized by Elevate LLC owner of the CORE®
1-888-775-5628.
This 1-Year Limited Warranty does NOT cover normal wear and tear, abuse or misuse of
this product including damage from inclement conditions, such as wind, rain or hail. In
case of inclement weather, remove all valuables and persons and seek appropriate shelter.
Under no circumstances will CORE®Equipment or Elevate LLC be liable or responsible
for any incidental or consequential damages. This product is designed and intended for
recreational use only. Prolonged exposure to UV rays will cause any fabric to fade and
deteriorate and is NOT covered by this 1-Year Limited Warranty. All replacement products
or parts will assume the remaining warranty of the original product. This warranty gives
you specific legal rights. You may also have other rights which vary from state to state. To
obtain Warranty Service: Call Toll Free 1-888-775-5628 for warranty service, repair parts
or product questions. Monday - Friday, 8:00 a.m. - 5:00 p.m. Central Time.
NOTICE: DO NOT RETURN PRODUCT TO RETAIL STORE.
1-YEAR LIMITED WARRANTY:
GUYLINE
Other Core Tent manuals
