Costway HW53866 User manual

USER'S MANUAL
Corner Desk
HW53866

1/7
PRODUCT ASSEMBLY
HARDWARE LIST
PARTS LIST
6
8
6
5x35mm
4x30mm
3x12mm
5.8x30mm
Short shelf

2/7
PRODUCT ASSEMBLY
Step 1
Step 2
G
H
G
H
a) Position Shelves (7 & 8) as shown.
b) Apply a small amount of glue into the designated holes for Wood Dowel (A) on (7 ) and insert Wood Dowel (A).
c) Insert double-headed Cam-bolt (E) into the designated hole between the Wood Dowels. Insert (E) until the bolt
head is in the center of the hole.
d) Insert Cam-lock with the “arrow” in-line with the Cam-bolt. Use a Flat-head Screwdriver to turn Cam-lock clockwise
for a quater turn (90 degree) to hold the Cam-bolt head in place. Do not tighten Cam-lock completely at this time.
e) Attach (8) to (7) via the Wood Dowels and Cam-bolt installed on (7).
f) Check for Cam-bolt head to be in center of hole on Panel (8). Install Cam-lock as in Step d) above.
g) Tighten Cam-lock by turning clockwise another quater to a half-turn (until Cam-lock is snug.). Do not over-tighten.
a) Fasten Drawer Plastic Glide (G) to Drawer Back Panel (13) with Screw (H).
(Important: Fasten TOP two screws first, and then BOTTOM two screws.)
b) Assemble Drawer Side Walls (12), Drawer Back Panel (13) and Drawer Bottom Panel (14) by using screw (B).
Tighten all screws completely.
Groove Edge
of Plastic Glide
Important: Groove edge of Plastic Drawer Glide must
level with the top edge of Drawer Back Panel.

3/7
PRODUCT ASSEMBLY
Step 3
Step 4
H
C
Assemble Drawer Front Panel (11) to drawer by using Screw (B). Attach Handle (C) to (11) by using Screw (H).
Tighten all of the screws completely.
a) Position Leg (3) as shown, and insert Wood Dowel (A) in the
designated hole.
b) Attach Leg (3) to Left Apron (15). Loosely tighten with Screw (F).
c) Insert Wood Dowel into designated hole on (15).
d)
Attach Left Side Frame(2) to (15). Loosely tighten with Screw (F).

4/7
PRODUCT ASSEMBLY
Step 5
Step 6
I
Connect Right Side Frame (1) to Right
Apron (4) by using Screw (F).
a) Insert Wood Dowel (A) to designated holes on Leg (3) as shown.
b) Insert Wood Dowel to Right Side Frame (1).
c) Attach Cross Bar (5) to (1) and fasten with Screw (B).
d) Connect the Left Subassembly (15, 2 & Leg 3) to Cross Bar (5)
and Right Apron (4) by means of Wood Dowels inserted in Step a).
e) Fasten (5) to (3) using Screw (B) and (4) to (15) using Screw (F).
A

5/7
PRODUCT ASSEMBLY
Step 7
B B
B B
Note: Please use Screw (B - 4X30mm)
to fix the Top Panel (10).
Step 8
6
F F
a) Place Top Panel (10) bottom-side
up on a surface dose not damage
the exterior finish of (10).
b) Insert Wood Dowel (A) into the
designated holes as shown.
c) With the help of another person,
position and align table frame
assembly from Step 7 to fit into
the Wood Dowels.
d) Identify the 6 pre-drilled screw
hole locations and use Screw (B)
to fasten Table Top (10) to table
frame assembly.
Install Front Frame (6) between Right
Side Frame and Left Side Frame using
Screw (F).
B
B

6/7
PRODUCT ASSEMBLY
Step 9
Step 10
F
F
F
7
8
1 2
a) Identify pre-drilled holes for
Wooden Drawer Glide (9) on
bottom of (10)
b) Position screw holes on (9) over
pre-drilled holes on (10)
c) Use Screw (B) to loosely attach
(9) to (10). Fully tighten Screw
(B) only when both screws are in
place.
a) With the help of another person,
position Shelves (7) & (8)
(completed in Step 1) under and
against Cross Bar (5) and rails of Left
Side Frame (1) and Right Side Frame
(2) as shown.
b) Use Screw (F) to loosely fasten
Shelves (7) & (8) to Cross Bar (5),
and to the rails of Left Side Frame
(1) and Right Side Frame (2).

7/7
PRODUCT ASSEMBLY
Step 11
To insert Drawer:
a) Position drawer directly in front of Front Frame opening.
b) Tilt the drawer upward slightly and slide in the drawer at an angle to allow the Plastic Drawer Glide to connect
into the groove of the Wooden Drawer Glide on the underside of Top Panel.
c) Gently slide in the drawer horizontally.
ASSEMBLY OF THE CORNER DESK IS COMPLETED
Position the Corner Table upright.

TIPS：
Your suggestions and comments for Costway are really important to us!
We sincerely solicit you to go back to our shop and leave a good rating in just a
simple click. It would be quite encouraging if you could kindly do so like below:
February 24, 2018
Great product so far. Fast delivery, easy setup, and working without any issues.
Great products so far
With your inspiring rating, Costway will be more consistent to offer you
EASY SHOPPING EXPERIENCE, GOOD PRODUCTS and EFFICIENT SERVICE!
UNITED STATES
CANADA
UNITED KINGDOM
GERMANY
FRANCE
ITALY
SPAIN
JAPAN
RUSSIA
AUSTRALIA
US office:Fontana
UK office:Ipswich