Crystal Mountain FIL-W300005 User manual

Installation Instructions
Three stage Filtration System
Part# FIL-W300005
Form 1611003
Crystal Mountain Products, Inc · 1000H Taylor Staon Rd · Gahanna OH 43230
614.454.1618 · www.crystalcoolers.com
© 2016 Crystal Mountain Products Inc.

2
Your FIL-W300005 kit includes a Three Stage Filtraon System with installaon hardware.
Crystal Mountain Products Inc. is not responsible for any damage that may occur during the
installaon of this kit. These instrucons are for informaonal purposes only and the kit
should only be installed by a qualied technician.
Included in this kit:
Three Stage Filtraon Kit Pt# FIL-W300005
6x 1/4” x 1/4” NPT Elbow
6x 1/4” Quick Connect Locking Clip Pt# POU-A300001
2x Filter Mounng Clips Pt# POU-A300003
2x Mounng Screws Pt# FAS-W300001
2x Installaon Tubing Pt# POU-A300004
Installation Instructions: Three Stage Filtration System
FIL-W300005

3
Release handle locaon
1. Unpack both the Crystal Pro Water Dispenser and the ltraon kit. Remove the lter access
door on the Crystal Pro by pulling on the release handle located just below the drip tray.
2. Install the lter mounng clips with the screws supplied in the lter kit. For best results use
the mounng holes on the lter mounng plate as shown below.
Installation Instructions: Three Stage Filtration System
FIL-W300005

4
Installation Instructions: Three Stage Filtration System
FIL-W300005
3. Assemble the elbow ngs included with your kit. Be careful not to over ghten these
ngs. Note that the pre-lter and the post carbon lter ngs are 90⁰ from each other
as shown below. This will help to prevent side loading on the ng during the product
water connecon step of these instrucons.
4. Your Crystal Pro is supplied with enough product water tubing for this installaon. Cut the
zip e and uncoil the tubing. Find the midpoint of the tubing and cut for the lter connec-
on. Be sure to use the proper tubing cuer when making this cut and ensure that the
tubing is free of ash and cut square before using.
CAUTION: All connecons must have the supplied locking clips installed

5
Installation Instructions: Three Stage Filtration System
FIL-W300005
5. Aer all tubing, ngs, connecons, and ow direcons are veried on the lter kit, inspect
for damage before aaching the product water tubing to the lter kit as shown below. Be
sure to follow the inlet and outlet direcon as outlined in these instrucons. Install lter set
to the lter clips inside the Crystal Pro as shown below.
Your Crystal Pro Water Dispenser is supplied with a electronic leak detector. If excess water has
accumulated around the base, the leak detector will need to be completely dried before proper
operaon. The sensor is located just in front of the right front compressor foot.
A pressure regulator must be installed for this installaon with a set point no higher then 65
PSIG Place cooler in service by connecng water supply and electrical supply as outlined in the
Crystal Pro installaon instrucons, check for leaks and replace lter access door by pushing it
down and back into place.

6
Crystal Mountain Products, Inc · 1000H Taylor Staon Rd · Gahanna OH 43230
614.454.1618 · www.crystalcoolers.com
Form 1611003 © 2016 Crystal Mountain Products Inc.
FILTER AND RO MEMBRANE
LIMITED WARRANTY
Subject to the condions and limitaons described below, Crystal Mountain warrants the lter cartridges to
be free from defects in material and workmanship at the me of installaon when used within the operang
specicaons listed in the lter “Installaon and Service Guide”.
RO MEMBRANE WARRANTY
Membranes carry a twelve (12) month pro-rated warranty as follows: Credit 1/12th of the replacement cost
for each unused month provided the system is installed and maintained according to factory instrucons and
the unit is operated within the specicaons listed in the lter “Installaon and Service Guide”.
CONDITIONS OF FILTER WARRANTY
The above warranty will not apply to the lters or RO membranes that are damaged because of neglect,
misuse, alteraon, accident, misapplicaon, physical damage, fouling and/or scaling of membranes by miner-
als, bacterial aack, sediment, or damage caused by re, acts of God, freezing, or hot water.
If the lters/membrane are altered by anyone other than Crystal Mountain the warranty is void. Crystal
Mountain assumes no warranty liability in connecon with the Reverse Osmosis or Filtraon system other
than specied herein. Crystal Mountain will not be liable for any consequenal damages of any kind or na-
ture due to use of Crystal Mountain products.
Installation Instructions: Three Stage Filtration System
FIL-W300005