Ducati 999S User manual

1
E
DUCATI999/999S
Owner’s manual

2
E

3
E
Hearty welcome among Ducati fans! Please accept our
best compliments for choosing a Ducati motorcycle. We
think you will ride your Ducati motorcycle for long
journeys as well as short daily trips. Ducati Motor Holding
s.p.a wishes you smooth and enjoyable riding.
We are steadily doing our best to improve our “Technical
Assistance” service. For this reason, we recommend you
to strictly follow the indications given in this manual,
especially for motorcycle running-in. In this way, your
Ducati motorbike will surely give you unforgettable
emotions.
For any servicing or suggestions you might need, please
contact our authorized service centres.
Enjoy your ride!
Note
Ducati Motor Holding S.p.A. declines any liability
whatsoever for any mistakes incurred in drawing up this
manual. The information contained herein is valid at the
time of going to print. Ducati Motor Holding S.p.A.
reserves the right to make any changes required by the
future development of the above-mentioned products.
For your safety, as well as to preserve the warranty,
reliability and worth of your motorcycle, use original
Ducati spare parts only.
Warning
This manual forms an integral part of the
motorcycle and - if a transfer of title occurs - must always
be handed over to the new owner.

4
E
TABLE OF CONTENTS
General 6
Warranty 6
Symbols 6
Useful information for safe riding 7
Carrying the max load allowed 8
Identification data 9
Controls 10
Position of motorcycle controls 10
Instrument panel 11
LCD - main functions 12
LCD - how to set/display parameters 14
The immobilizer system 20
Keys 20
Code card 21
Procedure to disable immobilizer engine block through
throttle twistgrip 22
Duplicate keys 23
Ignition switch and steering lock 24
Left switch 25
Clutch lever 26
Cold start lever 27
Right switch 28
Throttle twistgrip 28
Front brake lever 29
Rear brake pedal 30
Gear change pedal 30
Adjusting the gear change and rear brake pegs 31
Gear change pedal adjustment 32
Rear brake pedal adjustment 33
Main components and devices 34
Location 34
Tank filler plug 35
Seat/fuel tank adjustment 36
Seat catch and helmet hook 37
Side stand 39
Steering damper 40
Front fork adjusters 41
Shock absorber adjusters 43
Changing motorcycle track alignment 45
Directions for use 47
Running-in recommendations 47
Pre-ride checks 49
Starting the engine 50
Moving off 52
Braking 52
Stopping the motorcycle 53
Parking 53
Refueling 54
Tool kit and accessories 55

5
E
Main maintenance operations 56
Removing the fairing 56
Checking and topping up the coolant level 59
Checking brake and clutch fluid level 61
Checking brake pads for wear 62
Lubricating cables and joints 63
Throttle cable tension adjustment 64
Charging the battery 65
Adjusting steering head angle (999) 67
Adjusting steering head angle (999S) 69
Chain tension inspection 70
Chain lubrication 70
Changing the high and low beam bulbs 71
Changing the parking light bulb 73
Front turn indicators 74
Rear turn indicators 74
Stop light 75
Number plate light 75
Beam setting 76
Rear view mirror adjustment 77
Tubeless tyres 78
Checking engine oil level 80
Cleaning and replacing the spark plugs 82
Cleaning the motorcycle 83
Storing the bike away 84
Important notes 84
Technical data 85
Overall dimensions 85
Weights 85
Top-ups 86
Engine 87
Timing system 87
Performance data 88
Spark plugs 88
Brakes 88
Transmission 89
Frame 90
Wheels 90
Tyres 90
Suspensions 91
Exhaust system 91
Available colours 91
Electric system 92
For United States of America version only 96
Routine maintenance record 105

6
E
GENERAL
Warranty
In your own interest, and in order to guarantee product
reliability, you are strongly advised to refer to a Ducati
Dealer or Authorized Workshop for any servicing
requiring particular technical expertise. Our highly skilled
staff have access to the implements required to perform
any servicing job at best, using Ducati original spare parts
only as the best guarantee for full interchangeability,
smooth running and long life.
All Ducati motorcycles come with a “Warranty Card”.
However, warranty does not apply to the motorcycles
used in competitions. No motorcycle part may be
tampered with, altered, or replaced with parts other than
original Ducati spare parts during the warranty period, or
the warranty will be automatically invalidated.
Symbols
Ducati Motor Holding S.p.A. advises you to read this
manual carefully so as to become familiar with your
motorcycle. In case of any doubts, please call a Ducati
Dealer or Authorized Workshop. The information
contained herein will prove useful on your trips - and
Ducati Motor Holding S.p.A. wishes you smooth,
enjoyable riding - and will help you keep the performance
of your motorcycle unchanged for a long time.
Warning
Failure to comply with these instructions may put
you at risk and lead to severe injury or death.
Important
Possibility of damaging the motorcycle and/or its
components.
Note
Additional information concerning the job being
carried out.
The terms right and left are referred to the motorcycle
viewed from the riding position.

7
E
Useful information for safe riding
Warning
Read this section before riding your motorcycle.
Accidents are frequently due to inexperience. Always
make sure you have your licence with you when riding;
you need a valid licence to be entitled to ride your
motorcycle.
Do not lend your motorcycle to inexperienced riders or
who do not hold a valid licence.
Both rider and pillion passenger must always wear a
safety helmet.
Wear proper clothing, with no loose items or accessories
that may become tangled in the controls or limit your
zone of vision.
Never start or run the engine indoors. Exhaust gases are
poisonous and may lead to loss of consciousness or even
death within a short time.
Both rider and pillion passenger should keep their feet on
the footpegs when the motorcycle is in motion.
Always hold the handlebars firmly with both hands so
you will be ready for sudden changes of direction or in
the road surface. The pillion passenger should always
hold on to the suitable belt on the rear seat with both
hands.
Ride within the law and observe national and local rules.
Always respect speed limits where these are posted.
However, always adjust your speed to the visibility, road
and traffic conditions you are riding in.
Always signal your intention to turn or pull to the next
lane in good time using the suitable turn indicators.
Be sure you are clearly visible and do not ride within the
blind spot of vehicles ahead.
Be very careful when tackling road junctions, or when
riding in the areas near exits from private grounds, car
parks or on slip roads to access motorways.
Always turn off the engine when refueling.
Be extremely careful not to spill fuel on the engine or on
the exhaust pipe when refueling.
Do not smoke when refueling.
While refueling, you may inhale noxious fuel vapors.
Should any fuel drops be spilled on your skin or clothing,
immediately wash with soap and water and change your
clothing.
Always remove the key when you leave your motorcycle
unattended.
The engine, exhaust pipes, and mufflers stay hot for a
long time.
Warning
The exhaust system might be hot, even after
engine is switched off; pay particular attention not to
touch exhaust system with any body part and do not park
the vehicle next to inflammable material (wood, leaves
etc.).
Park your motorcycle where no one is likely to hit it and
use the side stand.
Never park on uneven or soft ground or your motorcycle
may fall over.

8
E
Carrying the maximum load allowed
Your motorcycle is designed for long-distance riding,
carrying the maximum load allowed in full safety.
Even weight distribution is critical to preserving safety
features and avoiding trouble when performing sudden
manoeuvres or riding on bumpy roads.
Information about carrying capacity
The total weight of the motorcycle in running order
including rider, pillion passenger, luggage and additional
accessories should not exceed 375 Kg.
Arrange your luggage or heavy accessories in the lowest
possible position and close to motorcycle centre.
Be sure to secure the luggage to the supports provided
on the motorcycle as firmly as possible. Improperly
secured luggage may affect stability.
Never fix bulky or heavy objects to the handlebar or to
the front mud guard as this would affect stability and
cause danger.
Do not insert any objects you may need to carry into the
gaps of the frame as these may foul moving parts.
Make sure the tyres are inflated to the proper pressure
indicated at page 78 and that they are in good condition.

9
E
Identification data
All Ducati motorcycles have two identification numbers,
for frame (fig. 1.1 and fig. 1.2) and engine (fig. 2).
Frame number
Engine number
Note
These numbers identify the motorcycle model and
are required when ordering spare parts.
fig. 2
fig. 1.1
fig. 1.2
999
999S

10
E
CONTROLS
Warning
This section details the position and function of all
the controls you need to drive your motorcycle. Be sure
to read this information carefully before you use the
controls.
Position of motorcycle controls (fig. 3)
1) Instrument panel.
2) Key-operated ignition switch and steering lock.
3) Left switch.
4) Clutch lever.
5) Cold start control.
6) Right switch.
7) Throttle twistgrip.
8) Front brake lever.
9) Gear change pedal.
10) Rear brake pedal.
fig. 3
18
7
6
2
10
9
5
3
4