Dwyer Instruments 1207A User manual

DWYER 1207A
QUICK REFERENCE GUIDE
ANALYZER FEATURES AND KEYPAD
ON / OFF
Turns the analyzer ON / OFF
PUMP / CAL PRESSURE
Turns the pump ON / OFF
Press for 2+ seconds to zero
the pressure sensor
PRINT / BACKLIGHT
Press to print “live” or “frozen”
data. Press again to abort.
Press for 2+ seconds to switch
backlight & torch ON / OFF
LINE SELECT / FREEZE
Press to select active line on
display as indicated by LED’s
Press for 2 seconds to “HOLD”
Press longer to “LOG”
Test Equipment Depot - 800.517.8431 - 99 Washington Street Melrose, MA 02176
TestEquipmentDepot.com

BEFORE USING ANY ANALYZER CHECK THAT:
- Calibration date has not expired
- Particle filter is not dirty inside
- Water trap and flue probe hose are empty of water
- Water trap is fitted correctly to the analyzer including the drain plug
- Flue probe hose is connected properly to the flue gas inlet
- Flue probe temperature plug is connected into T1 connection
Please read the Safety Warnings in the User Manual
USING THE ANALYZER
With the flue probe in fresh air at the same temperature as the boiler inlet air
press . The analyzer will auto-calibrate for 20 to 30 seconds and then a
set of readings will be displayed. In fresh air the O
2
reading should be
20.9% + 0.1% and the CO reading should be zero. Check the battery status
by selecting “Bat” on the rotary switch and select the correct fuel via the
“menu” – See Using the Menu.
Insert the tip of the probe into the center of the flue. After approximately 60
seconds the readings should stabilize. A printout can be produced if required
by pressing .
SETTING UP THE DISPLAY
Any four parameters can be displayed simultaneously. Press to move
the line select LED to the line you wish to change, then use the rotary switch
to select the new parameter you require. To change other lines just repeat
the procedure.

DER 1207A REPORTS




 
 
 
 

 

  
 (@ 

  
  
 
 V 
  

 

  
    
 V 
  





 V 
  
 
 





 

 
 
 
 
 
 
















 
  
  
  
  



 
  
  
  
  

 
  






 








 
Stock No: 187 45-2
Test Equipment Depot - 800.517.8431 - 99 Washington Street Melrose, MA 02176
TestEquipmentDepot.com