Dyna-Glo DGH353CRP User manual

Français p.
Español p.
052821
3-BURNER LP GAS GRILL
WITH SEARPLUS™ BURNER
Model #DGH353CRP/DGH353CRP-D
Questions, problems, missing parts?
Before returning to your retailer,
call our customer service
department at 1-877-447-4768,
8:00 a.m. – 4:30 p.m., CST,
Monday – Friday or e-mail us at
[email protected]
Français p. 29
Español p. 57

2
Table Of Contents
Assembler/Installer: This manual contains important information necessary for the proper
assembly and safe use of this appliance. Read and follow all warnings and instructions before
assembling and using this appliance. Leave these instructions with the consumer.
Consumer/User: Follow all warnings and instructions when using this appliance.
Retain these instructions for future reference.
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. Open lid.
4. If odor continues, keep away from
the appliance and immediately call your
local fire department.
1. Do not store or use gasoline or other
flammable liquids or vapors in the
vicinity of this or any other appliance.
2. An LP (liquid propane) cylinder not
connected for use shall not be stored
in the vicinity of this or any other
appliance.
3. This grill is for outdoor use only and
shall not be used in a building, garage,
under overhangs or any other enclosed
area.
4. Do not leave a lit grill unattended.
Keep children and pets away from the
grill at all times.
DANGER WARNING
Safety Information............................................................................................................................... 3
Package Contents ............................................................................................................................... 5
Hardware Contents ............................................................................................................................. 6
Preparation........................................................................................................................................... 6
Assembly Instructions........................................................................................................................ 7
Operation Instructions...................................................................................................................... 15
Care and Maintenance...................................................................................................................... 20
Troubleshooting ................................................................................................................................ 23
Limited Warranty ............................................................................................................................... 24
Replacement Parts List .................................................................................................................... 25

3
Please read and understand this entire manual before attempting to assemble, operate or install the
product. If you have any questions regarding the product, please call customer service at: 1-877-447-
4768, 8:00 a.m. – 4:30 p.m., CST, Monday – Friday.
DANGER
CAUTION
Safety Information
• Do not use in an explosive atmosphere. Keep grill area clear and free from combustible
materials, gasoline and other ammable vapors and liquids.
• Never use charcoal or lighter uid with the grill.
• Do not use gasoline, kerosene or alcohol for lighting.
• The LP gas cylinder used with this appliance must be:
(a) Constructed and marked in accordance with the Specications for LP-Gas Cylinders
of the U.S. Department of Transportation (D.O.T.) or the National Standard of Canada,
CAN/CSA-B339, Cylinders, Spheres and Tubes for Transportation of Dangerous Goods;
and Commission, as applicable; and
(b) Provided with a listed overlling prevention device.
(c) Provided with a cylinder connection device compatible with the connector for outdoor
cooking appliances. This grill is not intended to be used in or installed on recreational
vehicles and/or boats.
• Never keep a lled container in a hot car or car trunk. Heat will cause the gas pressure to
increase, which may open the relief valve and allow gas to escape.
• Always open grill lid slowly and carefully as heat and steam trapped within the grill can burn
you severely.
WARNING: FUELS USED IN LIQUEFIED PROPANE GAS
APPLIANCES, AND THE PRODUCTS OF COMBUSTION OF SUCH
FUELS, CAN EXPOSE YOU TO CHEMICALS INCLUDING BENZENE,
WHICH IS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER AND CAUSE BIRTH DEFECTS OR OTHER REPRODUCTIVE
HARM. For more information go to: www.P65Warnings.ca.gov.

4
• Do not place the grill under overhead
combustible construction or awnings.
Minimum clearance from sides and back
of unit to combustible construction, 36
inches (914.4mm) from sides and back.
NOTE: The installation must conform with
local codes or, in the absence of local
codes, with either the National Fuel Gas
Code, ANSI Z223.1/NFPA 54, Natural
Gas and Propane Installation Code, CSA
B149.1, or Propane Storage and Handling
Code, B149.2.
• Do not store or use gasoline or other ammable liquids or vapors in the vicinity of this or any
other appliance.
• An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance.
• This grill is for use with propane gas only (propane cylinder not included).
• Never attempt to attach this grill to the self-contained propane system of a boat, camper
trailer, motor home or house.
• Do not attempt to move the grill while it is lit or when it is hot. The casters should be locked
when not moving the grill.
• Do not use the grill unless it is completely assembled and all parts are securely fastened and
tightened.
• Keep all combustible items and surfaces at least 36 inches (91.44 cm) away from the grill at all times.
• Do not touch metal parts of grill until it has completely cooled (about 45 minutes) to avoid
burns, unless you are wearing protective gear (pot holders, gloves, BBQ mittens, etc.).
• Do not alter this grill in any manner.
• Clean and inspect the hose before each use. If there is evidence of abrasion, wear, cuts, or
leaks, the hose must be replaced prior to operating the appliance. The replacement hose
assembly will be that which is specied by the manufacturer.
• Move gas hoses as far away as possible from hot surfaces and dripping hot grease.
• Keep the grill’s valve compartment, burners and circulating air passages clean. Inspect the grill
before each use. Do not obstruct the ow of gas or ventilation air.
• The use of alcohol, prescription or non-prescription drugs may impair the operator’s ability to
properly assemble or safely operate the grill.
• Do not leave a lit grill unattended. Keep children and pets away from the grill at all times.
• Do not place this grill on any type of tabletop surface. The grill should be placed on a at and
level surface.
• Do not use the grill in high winds.
36in
914.4mm
36in
914.4mm
WARNING
Safety Information
CAUTION
36in
914.4mm
36in
914.4mm

5
Package Contents
PART DESCRIPTION QTY.
ALid Handle Assembly 1
BTemperature Gauge 1
CTemperature Gauge Bezel 1
DGrill Body Assembly 1
EControl Knob 2
FGrease Cup Holder 1
GGrease Cup 1
HWarming Rack 1
ICooking Grate 2
JHeat Tent For Main Burner 2
KSide Table 2
LControl Knob For Sear Burner 1
MHeat Tent For Sear Burner 1
NTank Heat Shield 1
OLeft Leg Assembly 1
J
I
C
B
A
D
K
F
M
N
Q
G
O
RZ
L
P
T
SU
A1
X
Y
W
V
C1
B1
E
PART DESCRIPTION QTY.
PLeg End Cap 2
QSide Exclusion Bar 1
RTank Brace 1
SCart Rear Support 1
TCart Front Panel - Upper 1
UCylinder Exclusion 1
VCart Front Panel - Lower 1
WAxle 1
XWheel 2
YRight Leg Assembly 1
ZTank Retention Fixed Wire 2
A1 Smoker Box Rear Support 1
B1 Smoker Box Front Support 1
C1 Smoker Box Assembly 1
H
K

6
THIS UNIT IS HEAVY. Two people required for safe assembly.
Two people required for safe assembly. Some parts may contain sharp edges.
Wear protective gloves if necessary. Read and follow all safety statements,
warnings, assembly instructions and use and care instructions before attempting
to assemble and use.
Hardware Contents
Preparation
CC
AA BB DD
M6x16
Screw
M8 Nut
2X 20X 2X
2X
2X
2X
M6 Wing
Nut
M6 Plain
Washer
FF GG
M6 Spring
Washer
EE
M8
Wrench
Before beginning assembly of product, make sure all parts are present. Compare parts with package
contents list on previous page and hardware contents above. If any part is missing or damaged, do not
attempt to assemble the product. Contact customer service for replacement parts.
Estimated Assembly Time: 50 minutes with 2 people.
Tools Required for Assembly and Leak Testing (not included): Phillips screwdriver, Spray bottle
CAUTION
M4x10
Screw
4X
HH
2X
St4 8x10
Screw
M5x14
Screw
16X
I I

7
1
2
Assembly – Left Leg
Assembly – Right Leg
Assembly Instructions
AA
2X
BB
2X
O
P
AA
W
BB
Y
X

8
3
4
Assembly – Cart Front Panels
Assembly – Back Exclusion Bar and Cart Rear Support
DD
2X
DD
5 Threads U
S
II
8X
Y
II
V
O
T
II
II
4X
II

9
5
6Assembly – Handle, Knobs, and Temperature Gauge
Assembly – Tank Brace and Side Exclusion Bar
EE
2X
FF
2X
GG
2X
DD
Z
R
Q
R
Rear shown,
same for front
DD
4X
II
2X
NII
D
GG
L
EE
FF
B
A
E
C

10
7Assembly – Grill Body to Base
DD
4X
NOTE: Fully tighten all nuts from front panel and back brace screws at this time.
CAUTION:
2 people required
for safe assembly.
O
DD
Y
D
DD

11
8Assembly – Side Tables
DD
10X
DD
DD
II
5 Threads
Rear shown,
same for front
K
DD
K
9Assembly – Hose Fitting
I I
2X
D

12
10 Assembly – Optional Smoker Box
11
A1
HH
4X
HH
C1
B1
Assembly – Heat Tents
J
M

13
12 Assembly – Rack and Cooking Grates
13 Assembly – Grease Cup
H
F
G
I

14
14 Assembly – Propane Cylinder
R

25
Replacement Parts List
1
2
3
4
5
6
7
8
910
11 12
13
14
18
16
19
21
20
17
22
30
35
45
41
34
40
46
42
48
4447
38
44
43
44
44
39
24
23
25
27
29
15
26
28
36
32
33
31
37
13
44
43
18
17

26
For replacement parts, call our customer service department at 1-877-447-4768, 8:00 a.m. – 4:30 p.m.,
CST, Monday – Friday.
Part Description Part #
1Temperature gauge assembly 70-02-264
2Temperature gauge bezel 70-01-906
3Badge 70-10-540
4Lid handle welding 70-02-157
5Warming rack 70-01-633
6Cooking grate 70-01-634
7Heat tent for main burner 70-02-158
8Heat tent for SearPLUSTM burner 70-02-159
9Main burner with cotter pin 70-02-582
10 SearPLUSTM burner with cotter pin 70-02-062
11 Main burner sparker 70-01-283
12 SearPLUSTM burner sparker 70-02-063
13 Side table 70-02-160
14 Left leg assembly 70-02-161
15 Leg end cap 70-02-584
16 Lid assembly 70-02-162
17 Lid pivot pin-with cotter pin 70-01-641
18 Lid Bumper 70-01-176
19 Cooking grate bracket 70-01-642
20 Firebox assembly with heat shield 70-02-163
21 Main valves and manifold assembly 70-02-164
22 Main control panel assembly 70-02-165
23 Grease cup 70-01-650
24 Control knob bezel for main burner 70-01-920
25 SearPLUSTM control knob bezel 70-02-418
26 Control knob for main burner 70-01-921
27 Grease cup holder 70-01-651
28 Control knob for SearPLUSTM burner 70-01-923
29 Match holder with chain 70-01-204
30 Cylinder exclusion 70-02-555
31 Cart rear support 70-02-166
32 Cart front panel-upper 70-02-549
33 Cart front panel-Lower 70-02-167
34 Cylinder heat shield 70-02-168
35 Tank retention xed wire 70-02-541
36 Tank brace 70-02-433
37 Side exclusion bar 70-02-435
Replacement Parts List

27
38 Corrugated hose assembly 70-01-645
39 Connector 70-02-110
40 Connector xing plate 70-02-268
41 Regulator and Hose Assembly 70-01-647
42 Right leg assembly 70-02-169
43 Wheel 70-01-659
44 Axle 70-01-658
45 Smoker box rear support with hardware 70-02-086
46 Smoker box lid with hardware 70-01-929
47 Smoker box body with hardware 70-01-930
48 Smoker box front support with hardware 70-02-085
n/a Hardware pack 70-09-578
REPLACEMENT PARTS LIST – CONTINUED