EdgeStar IP210SS User manual

IMPORTANTSAFETYINSTRUCTIONS…………………………………………………1
PREPARINGYOURICEMAKERFORUSE
IMPORTANTSAFETYTIPS.……………………………………………………………….2
GETTINGTOKNOWYOURUNIT… …… …… …… …… …… …… …… …… …… …… …… …… …… …… …… …… …… …… …… …… …. .. .3 3
OPERATINGPROCEDURES&MAINTENANCE
UNPACKINGYOURICEMAKER..………….…………………………………………...4
CONNECTINGYOURICEMAKER……………….……….……………………………..4
CLEANINGANDMAINTAINING YOURICEMAKER….……………………………….4
USINGYOURICEMAKER……………….……..………………………………………...5
TROUBLESHOOTING..……………………….……………………………………………6
TECHNICALSPECIFICATIONS& CIRCUITDIAGRAM…..……………..….………..8
WARRANTY…………………………..……….………………………………………….…9
9

Yoursafetyandthesafetyofothersareveryimportant.Yoursafetyandthesafetyofothersareveryimportant.
Wehaveprovidedmanyimportantsafetymessagesinthismanualandonyourappliance.Wehaveprovidedmanyimportantsafetymessagesinthismanualandonyourappliance.
Alwaysreadandobeyallsafetymessages.Alwaysreadandobeyallsafetymessages.
Thisisthesafetyalertsymbol:Thisisthesafetyalertsymbol:
!
All safety messages will follow the safety alert symbol and the word “DANGER” or
“WARNING”.
All safety messages will follow the safety alert symbol and the word “DANGER” or
“WARNING”.
DANGER
!
WARNINGING
!
Thesewordsmean:Thesewordsmean:
Youcanbekilledorseriouslyinjuredifyoudon’timmediatelyYoucanbekilledorseriouslyinjuredifyoudon’timmediatelyfollowinstructions.
All safety messages will tell you what the potential hazard is, tell you how to reduce the
chanceofinjury,andtellyouwhatcanhappeniftheinstructionsarenotfollowed.
1

IMPORTANTSAFETYTIPS
Whenusing electrical appliances, basicsafetyprecautions shouldbefollowed to reducethe
risk of fire, electric shock, and/or injury to persons or property. Read all instructions before
usinganyappliance.
Donotoperatethisoranyotherappliancewithadamagedcord.
Connecttoproperlypolarizedoutletsonly.Nootherapplianceshouldbepluggedintothe
sameoutlet.Besurethattheplugisfullyinsertedintothereceptacle.
Donotruncordovercarpetingorotherheatinsulators.Donotcoverthecord.Keepcord
awayfromtrafficareas,anddonotsubmergeinwater.
We donot recommend the useof an extensioncord, as it may overheat and become a
firerisk.Ifyoumustuseanextensioncord,useacordofNo.14AWGminimumsizeand
ratedfornolessthan1875watts.
Unplugtheicemakerbeforecleaningitormakingrepairs.
Exercisecautionandusereasonablesupervisionwhenapplianceisusednearchildren.
Donotcleanyouricemakerwithflammablefluids.Thefumescancreateafirehazardor
explosion.
Donottipover.
Iftheicemakerisbroughtinfromoutsideinwintertime,giveitafewhourstowarmupto
roomtemperaturebeforepluggingitin.
2

1.Cover:Featuresatransparentwindowforinteriorvisibility.
2.Iceshovel.
3.Control Panel:Easytouse,withtouchcontrols.
A.Icefulllight.
B.Icesizeindicators:Small,Medium,andLarge.
C.Icesizeselectorbutton.
D.Addwaterlight:whenlit,addwater.
2
B
A
1
6
3
C
D
E
F
5
E.Powerindicator.
F.Powerbutton.
4.Foot
5.Waterdraincap:Fordrainingwaterfromwaterreservoir.
6.Airvent.
Note:Icescoopnotshown.
4
3

UNPACKINGYOURICEMAKER
1. Remove the exterior and interior packaging. Check that ice basket and ice scoop is
included.Ifanypartsaremissing,pleasecontactcustomerservice.
1. Remove the exterior and interior packaging. Check that ice basket and ice scoop is
included.Ifanypartsaremissing,pleasecontactcustomerservice.
2. Cleantheinteriorwithlukewarmwaterandasoftcloth.Takeouttheicebasketandclean
it.
2. Cleantheinteriorwithlukewarmwaterandasoftcloth.Takeouttheicebasketandclean
it.
3. Findalocationforyouricemakerthatisprotectedfromdirectsunlightandothersources
ofheat(e.g.,stove,furnace,radiator).Placetheicemakeronalevelsurface.Makersure
thatthereisatleast5inchesofspacebetweenthebackandsidesofyouricemakerand
thewall.
3. Findalocationforyouricemakerthatisprotectedfromdirectsunlightandothersources
ofheat(e.g.,stove,furnace,radiator).Placetheicemakeronalevelsurface.Makersure
thatthereisatleast5inchesofspacebetweenthebackandsidesofyouricemakerand
thewall.
4. Allowonehourfortherefrigerantfluidtosettlebeforepluggingicemakerin.4. Allowonehourfortherefrigerantfluidtosettlebeforepluggingicemakerin.
5. Theappliancemustbepositionedsothattheplugisaccessible.5. Theappliancemustbepositionedsothattheplugisaccessible.
CONNECTINGYOURICEMAKER
DANGERDANGER
!
* Improper use of the grounded plug can result in the risk of electrical shock. If the
powercordisdamagedpleasecallcustomerservice.
* Improper use of the grounded plug can result in the risk of electrical shock. If the
powercordisdamagedpleasecallcustomerservice.
1. Thisunitshouldbeproperlygroundedforyoursafety.Thepowercordofthisapplianceis
equipped with a threeprong plug which mates with standard three prong wall outlets to
minimizethepossibilityofelectricshock.
1. Thisunitshouldbeproperlygroundedforyoursafety.Thepowercordofthisapplianceis
equipped with a threeprong plug which mates with standard three prong wall outlets to
minimizethepossibilityofelectricshock.
2. Plug your appliance into an exclusive, properly installed, grounded wall outlet. Do not
underanycircumstances,cutorremovethethird(ground)prongfromthepowercord.Any
questions concerning power and/or grounding should be directed toward a certified
electrician.
2. Plug your appliance into an exclusive, properly installed, grounded wall outlet. Do not
underanycircumstances,cutorremovethethird(ground)prongfromthepowercord.Any
questions concerning power and/or grounding should be directed toward a certified
electrician.
3. This appliance requires a standard 110~120 volt, 60Hz electrical outlet with threeprong
ground.
3. This appliance requires a standard 110~120 volt, 60Hz electrical outlet with threeprong
ground.
CLEANINGANDMAINTAININGYOURICEMAKER
Beforeusingyouricemaker,itisstronglyrecommendedtocleanitthoroughly.Beforeusingyouricemaker,itisstronglyrecommendedtocleanitthoroughly.
1. Takeouttheicebasket.1. Takeouttheicebasket.
2. Cleantheinteriorwithdiluteddetergent,warmwaterandasoftcloth.2. Cleantheinteriorwithdiluteddetergent,warmwaterandasoftcloth.
3. The outside of the ice maker should be cleaned regularly with a mild detergent solution
andwarmwater.
3. The outside of the ice maker should be cleaned regularly with a mild detergent solution
andwarmwater.
4. Drytheinteriorandexteriorwithasoftcloth.4. Drytheinteriorandexteriorwithasoftcloth.
5. Whenthemachineisnotinuse,openthewaterdraincap tocompletelydrainthewater
reservoir.
5. Whenthemachineisnotinuse,openthewaterdraincap tocompletelydrainthewater
reservoir.
4

1. Selectthesizeoftheicecubebypressingthe“Select”button.Iftheroomtemperatureis
lowerthan60°F,itisbesttoselectthesmallormediumicesize,otherwisetheicecubes
mightsticktogether.
2. Openthecover,removetheicebasketandpourwaterintotank.
Keepwaterlevelbelowthelevelmark.
3. Press“Power”onthecontrolpaneltobegintheicemakingcycle.
4. The ice making cycle lasts 6 to 15 minutes, depending on the size of the ice cubes
selected.
5. Whiletheice makerison,verifythewaterlevelperiodically.Ifthewater levelistoolow,
theicemakerwillstopautomatically,andthe“Water”indicatorwillturnon.
Pressthe“Power”button,filltheunitwithwater,andpress“Power”again.
Allowtherefrigerantinsidethecompressoratleast3minutestosettlebeforerestarting.
6. Theicemakerautomaticallystopsworkingwhentheicebasketisfull.
7. Changethe water in thewaterreservoir every24 hourstoensurea reasonablehygiene
level.
Iftheicemakerwillnotbeusedforanextendedperiodoftime,youshoulddrainthewater
fromthereservoirandwipeouttheinsideoftheunit.
5

Issue Solution
Nopowertotheunit. Checktomakesurethepowercordisplugged
in
Checkthecontrolpanelforanylightsorifthere
isanymovementwithanycomponentsofthe
unitsuchastheicecaseorwaterpump.Ifthere
isnolightornomovement,contactEdgeStar
support.
Only the power and/or ice cube size lights
are on, unit is not working and does not
respond to buttons pushed on the control
panel.
Whentheicemakerispluggedin,thepower
lightmayblinkuntilyoupushthepowerbutton
toturnontheunit.
Ifyoupushthepowerbutton,buttheunitdoes
notrespond,thentheprobablecauseisafaulty
controlpanel,andneedstobereplaced.
ContactEdgeStarsupport.
Afterpushingthepowerbuttonandmaking
ice cube selections, the ice maker does
nothing.
ContactEdgeStarsupport.
Icecasemovesbackandforthbutdoesnot
stopinthewaterfillposition.
ContactEdgeStarsupport.
Unit goes through the ice making process,
but no ice is produced, or ice cubes are
verysmall.
Checktoseeiftheicemakerisbeingusedin
properambienttemperature.Ifunitisrunina
roomthatisparticularlyhotattimes,suchas
kitchenorlaundryrooms,Pleasemovetheunit
toadifferent,coolerroomandtryagain.
Ificemakerisbeingusedinproperambient
temperatures,thenchecktoseeifthefanonthe
sideoftheunitisworkingduringthecycle.Ifnot,
thenthefanneedstobereplacedasitisnot
drawingtheheatoffthecoils.ContactEdgeStar
support.
CompressormakesaknockingnoiseMakesuretheunitissittinglevel
Iftheunitissittinglevel,thencontactEdgeStar
support
Whentheunittriestodumptheice,theice
caseandshoveljam.
Theicecasehingesortheiceshovelplastic
tabs(onoldermodels)arebrokenandneedto
bereplaced.
TROUBLESHOOTING
6

The icemaker has a funny smell or theice
that is being produced has anunappealing
taste.
Clean the machine out with a mild soapy
solutionandasoftcloth
Addatablespoonofvinegartothewaterinthe
reservoir and then run a few batches of
ice. Afterremovingthevinegariceandwater,
run a few more cycles with regular water.
Remove this water and ice. The machine
should then be free of a bad smell and you
shouldbeabletoproducebettertastingice.
The“addwater”lightisoneventhoughthe
machineisfullofwater.
Your water may not have enough impurities
(distilled, reverse osmosis [RO], purified, etc.)
in it. Add a pinch of salt to the distilled water.
This will add impurities to the water which will
allowthemachinetodetectthewater.
Thewateruptakefiltermaybeclogged(atthe
bottom of the lower water reservoir). Using a
flatheadscrewdrivertopryitout,cleanthefilter
andreplace.
Icemakerfreezesonebigblockofice
insteadofindividualcubes.
If the ambient temperature in the room is less
than 60 degrees, use only the small and
mediumicecubesizesettings.
If the ambient temperature in the room is
normal,thecompressormaybefaulty.Contact
EdgeStarsupport
Theunitisleaking. If there is a steady drip coming from the
machine, the drain plug may be loose or a
hose may have been damaged. If the drain
plug is securely attached, contact EdgeStar
support
Ifthemachineisleakingwhenwaterispoured
intothelowerwaterreservoir,ahosemayhave
becomedislodged.ContactEdgeStarsupport.
The evaporator coils are not freezing/The
evaporator coils are not releasing the ice/Only
halfoftheevaporatorcoilsarefreezing.
ContactEdgeStarsupport
7

ThisEdgeStarproductiswarrantedtobefreefromdefectiveworkmanshipandmaterialsfor
thefirstyearfollowingthedateoforiginalpurchase.Replacementpartswillbesuppliedfreeof
chargeforthefirstyearfollowingthedateoforiginalpurchase.Laborwillbeperformedfreeof
chargeforthefirst90daysfollowingthedateoforiginalpurchase.
WHATISCOVERED
Thiswarrantyappliestotheoriginalpurchaseronly,andonlycoversdefectsinworkmanship
experienced during operation of the product under normal service, maintenance, and usage
conditions.Thiswarrantyappliestothepurchaseanduseofthisproductinresidentialsettings
withintheUnitedStatesofAmerica.
WHATISNOTCOVERED
Thefollowinglimitationsapplytothecoverageofthiswarranty:
Optional accessories, attachments, and appearance items are excluded from warranty
coverage,asisshippingdamage,andanydamagecausedbyimpropervoltageoranyother
misuse,includingabnormalservice,handling,orusage.
Thiswarrantydoesnotcovernormalwearandtearonpartsorreplacementofpartsdesigned
tobereplaced,e.g.filters,etc.
Thiswarrantydoesnotcoverservicetripstodeliver,pickup,repair,orinstalltheproduct,orto
instructinproperusageoftheproduct.
Damages or operating problems resulting from abuse, operation outside environmental
specifications,usescontrarytoinstructionsprovidedintheowner’smanual,accidents,vermin,
fire,flood,improperinstallation,unauthorizedservice,actsofGod,unauthorizedinstallationor
modification,orcommercialuseareexcludedfromwarrantycoverage.
Damageorlossofitemsstoredinsidetheapplianceareexcludedfromwarrantycoverage.
This warranty does not cover labor incurred 91 days or more after the date of original
purchase.
ThiswarrantydoesnotcoveruseofEdgeStarproductsincommercialsettings.
DESCRIPTIONOFWARRANTYSERVICE
All defective product components covered by this warranty will be repaired or replaced, at
EdgeStar’s option, free of charge on a mailin basis to EdgeStar’s authorized repair facility
duringthefirst90daysfromthedateoforiginalpurchase.
All defective product components covered by this warranty will be repaired or replaced, at
EdgeStar’s option, on a mailin basis to EdgeStar’s authorized repair facility during the time
periodbeginningonthe91
st dayfromthedateoforiginalpurchaseandendingoneyearfrom
thedateoforiginalpurchase.Duringthistimeperiod,partswillbesuppliedfreeofcharge,but
laborchargeswillapply.
Allreplacementpartsandunitswillbenew,remanufacturered,orrefurbished.
All products and components replaced by EdgeStar under warranty service become the
9

propertyofEdgeStar.
OBTAININGWARRANTYSERVICE
Contact EdgeStar for troubleshooting assistance and warranty service authorization at
18663195473.Pleasehaveyourorderreceiptavailabletoconfirmthedateofpurchase.
Once an EdgeStar authorized representative has confirmed that your product is eligible for
warrantyservice,theproductmustbereturnedtoanEdgeStarauthorizedrepairfacility.
The purchaser is solely responsible for prepaying all shipping related costs to and from the
repairfacility.
EdgeStar is not responsible for damage resulting from shipper mishandling or improper
packaging.
Donotreturndefectiveproducttotheplaceofpurchase.
THIS WARRANTY IS IN LIEU OF ANY OTHER WARRANTY, EXPRESS OR IMPLIED,
INCLUDING WITHOUT LIMITATION, ANY WARRANTY OF MERCHANTABILITY OR
FITNESSFORAPARTICULARPURPOSE.TOTHEEXTENTANYIMPLIEDWARRANTYIS
REQUIREDBYLAW,ITISLIMITEDINDURATIONTOTHEEXPRESSWARRANTYPERIOD
ABOVE. NEITHER THE MANUFACTURER NOR ITS DISTRIBUTORS SHALL BE LIABLE
FORANYINCIDENTAL,CONSEQUENTIAL,INDIRECT,SPECIAL,ORPUNITIVEDAMAGES
OF ANY NATURE, INCLUDING WITHOUT LIMITATION, LOST REVENUES OR PROFITS,
OR ANY OTHER DAMAGE WHETHER BASED IN CONTRACT, TORT, OR OTHERWISE.
SOMESTATESDONOTALLOWTHEEXCLUSIONOFINCIDENTALORCONSEQUENTIAL
DAMAGES, SO THE ABOVE EXCLUSION MAY NOT APPLY TO YOU. THIS WARRANTY
GIVES YOU SPECIFIC LEGAL RIGHTS. YOU MAY HAVE OTHER RIGHTS THAT VARY
FROMSTATETOSTATE.